fuse CHEVROLET EXPRESS CARGO 2021 User Guide

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
206 Vehicle Care
{Danger
Fuses and circuit breakers are marked
with their ampere rating. Do not exceed
the specified amperage rating when
replacing fuses and circuit breakers. Use
of an oversized fuse or circuit breaker can
result in a vehicle fire. You and others
could be seriously injured or killed.
{Warning
Installation or use of fuses that do not
meet GM’s original fuse specifications is
dangerous. The fuses could fail, and result
in a fire. You or others could be injured
or killed, and the vehicle could be
damaged.See
Accessories and Modifications 0178 and
General Information 0178.
To check a fuse, look at the silver-colored
band inside the fuse. If the band is broken
or melted, replace the fuse. Be sure to
replace a bad fuse with a new one of the
identical size and rating.
Fuses of the same amperage can be
temporarily borrowed from another fuse
location, if a fuse goes out. Replace the fuse
as soon as possible.
Engine Compartment Fuse Block
The fuse block is in the engine compartment
on the driver side of the vehicle.
Vehicles with Upfitter Content
See www.gmupfitter.com for upfitter
provisions and best practices.
Caution
Spilling liquid on any electrical
component on the vehicle may damage
it. Always keep the covers on any
electrical component.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
Vehicle Care 207
The vehicle may not be equipped with all of
the fuses, relays, and features shown.Fuses Usage
1 ABS motor
2 ABS module
3 Right trailer stoplamp/ Turn signal lamp
4 –
5 –
6 Fuel system control module/Ignition
7 Body control module 5
8 Body control module 7
9 Body control module 4
10 Instrument cluster 11 Trailer wiring
12 –
13 Interior rear vision camera module
14 Windshield washer
16 Horn 17 Transmission

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
208 Vehicle Care
FusesUsage
18 A/C
19 Engine control module battery
20 Left stop/turn cutaway lamp
21 Left stop/turn trailer lamp
22 Right stop/turn cutaway lamp
23 NOX Sensor (Diesel only)
24 Fuel pump 25 Auxiliary power outlet
26 Body control module 3 27 Special equipment option
28 Airbag
29 Steering wheel sensor
30 Engine control module ignition
31 Transmission control module Ignition Fuses
Usage
32 Transmission control module 1 battery
33 Rear parking aid module
34 NOX Sensor (Diesel only)
35 Fuel heater control module (Diesel only)
36 Fuel system control module battery
41 Transmission control module 2, battery
signal
42 Trailer wiring
43 Electro viscous fan clutch (Diesel only)
44 Starter solenoid 45 Engine control module, powertrain signal 2
46 DC-AC inverter 47 –
51 Left high-beam headlamp Fuses
Usage
52 Right high-beam headlamp
53 Left low-beam headlamp
54 Right low-beam headlamp
55 Wipers
56 Canister vent solenoid
58 Body control module 2
59 Body control module 1 61 Engine oil solenoid/ Crankcase vent heater
(Diesel only)
62 O2 sensor 2
63 –
64 Mass airflow/ Canister vent
65 Ignition coils/injectors - odd
66 Daytime running lamps 2
67 Daytime running lamps 1

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
Vehicle Care 209
FusesUsage
68 Auxiliary stoplamps
69 External power for trailer
70 Upfitter stoplamps 71 Fuel heater/FlexFuel sensor
72 Body control module 6
73 Lighter/Data link connector
74 Front blower 75 Engine control module
76 Soot sensors (Diesel only)
77 O2 sensor 1
78 Engine control module/ Powertrain signal 1
79 Ignition coils/injectors - even Relays
Usage
15 Run/Crank
37 NOX Sensor (Diesel only)
38 Fuel pump
39 Crank
40 A/C compressor 48 Electro viscous fan clutch (Diesel only)
49 Powertrain 50 –
57 –
60 – Auxiliary Fuse Block
This component is near the fuse block in the
engine compartment
Fuses Usage
MR-1 Upfitter 1
MR-2 Upfitter 2
MR-3 Upfitter power control
Relays Usage
MR Rel 1 Upfitter 1
MR Rel 2 Upfitter 2

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
210 Vehicle Care
Mega Fuse Holder
FuseUsage
1 Starter motor
Floor Console Fuse Block
The floor console fuse block is under the driver seat.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
Vehicle Care 211
The vehicle may not be equipped with all of
the fuses, relays, and features shown.Mini-Fuses Usage
F1 –
F2 Steering wheel sensor
F3 Auxiliary parking lamps
F4 Front parking lamps F5 Trailer parking lamps
F6 Upfitter/Parking lamps F7 Right rear parking lamp
F8 Left rear parking lamp
F9 Exterior rear mirror switch/ Door
lock-unlock control
upfitter/Front camera
module
F10 Airbag/Automatic occupant sensing
F11 –/OnStar
F12 –
F13 HVAC 2
F14 HVAC 1 F15 Reflected LED display Mini-Fuses Usage
F16 Upfitter aux 1/Gas ambulance
F17 Heated outside mirrors
F18 Rear window defogger
F19 Compass
F20 Radio/Chime/SiriusXM satellite radio
F21 Remote function actuator/Tire pressure
monitor
F22 Ignition switch/Discrete logic ignition sensor
F23 Instrument cluster
F24 –
F25 HVAC control
F26 Auxiliary/Trailer reverse lamps
F27 Reverse tail lamps
F28 Upfitter 2/Reading lamps/Ambulance
F29 Rear blower
F30 Upfitter/Courtesy lamps Mini-Fuses Usage
F31 Front door lock
F32 Rear door lock
F33 Cargo door unlock
F34 Front passenger door unlock
F35 Rear passenger door unlock
F36 Driver door unlock F37 –
F38 –
Relays Usage K1 Run
K2 –
K3 Parking lamps
K4 Upfitter 2 K5 Rear window defogger
K6 Retained accessory power

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
Index 287
CompartmentsStorage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Compass . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67
Connected Services Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . 283
Diagnostics . . . . . . . . . . . . . . . . . . . . . . . . . . . . 284
Navigation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 282
Connections Connected Services . . . . . . . . . . . . . . . . . . . . 283
Control Traction and Electronic Stability . . . . . . . 147
Control of a Vehicle . . . . . . . . . . . . . . . . . . . . . . 127
Convex Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Coolant Engine Temperature Gauge . . . . . . . . . . . . . 73
Cooling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 119, 122
Cooling System . . . . . . . . . . . . . . . . . . . . . . . . . . . 191
Courtesy Transportation Program . . . . . . . . 270
Cruise Control . . . . . . . . . . . . . . . . . . . . . . . . . . . 149
Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
Customer Assistance . . . . . . . . . . . . . . . . . . . . . 267
Offices . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 267
Text Telephone (TTY) Users . . . . . . . . . . . . 267
Customer Information Publications Ordering Information . . . . . 273
Customer Satisfaction Procedure . . . . . . . . . 265
Cybersecurity . . . . . . . . . . . . . . . . . . . . . . . . . . . . 275D
Damage Repair, Collision . . . . . . . . . . . . . . . . . . 271
Danger, Warning, and Caution . . . . . . . . . . . . . .2
Data Collection Infotainment System . . . . . . . . . . . . . . . . . . 276
OnStar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 276
Data Recorders, Event . . . . . . . . . . . . . . . . . . . 275
Daytime Running Lamps (DRL) . . . . . . . . . . . . .91
Defensive Driving . . . . . . . . . . . . . . . . . . . . . . . . 126
Delayed Locking . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Devices Auxiliary . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 108
Diagnostics Connected Services . . . . . . . . . . . . . . . . . . . . 284
Distracted Driving . . . . . . . . . . . . . . . . . . . . . . . . 126
Dome Lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94
Door Cargo Door Relocking . . . . . . . . . . . . . . . . . . . . 11
Delayed Locking . . . . . . . . . . . . . . . . . . . . . . . . . 12
Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Power Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Rear Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Side . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Sliding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Drive Belt Routing, Engine . . . . . . . . . . . . . . . 264
Driver Assistance Systems . . . . . . . . . . . . . . . 150
Driver Information Center (DIC) . . . . . . . . . . . .81 Driving
Better Fuel Economy . . . . . . . . . . . . . . . . . . . 126
Characteristics and Towing Tips . . . . . . . . 160
Defensive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 126
Hill and Mountain Roads . . . . . . . . . . . . . . 130
If the Vehicle is Stuck . . . . . . . . . . . . . . . . . . 131
Impaired . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 127
Loss of Control . . . . . . . . . . . . . . . . . . . . . . . . 128
Off-Road Recovery . . . . . . . . . . . . . . . . . . . . . 128
Vehicle Load Limits . . . . . . . . . . . . . . . . . . . . 132
Wet Roads . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 129
Winter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 130
E
Electrical Equipment, Add-On . . . . . . . . . . . . 176
Electrical SystemEngine Compartment Fuse Block . . . . . . . 206
Floor Console Fuse Block . . . . . . . . . . . . . . . 210
Fuses and Circuit Breakers . . . . . . . . . . . . . 205
Overload . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 205
Emergency
OnStar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 278
Engine Air Cleaner/Filter . . . . . . . . . . . . . . . . . . . . . . 189
Check Light (Malfunction Indicator) . . . . . 76
Compartment Overview . . . . . . . . . . . . . . . . . 181
Coolant Heater . . . . . . . . . . . . . . . . . . . . . . . . 139

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
288 Index
Engine (cont'd)Coolant Temperature Gauge . . . . . . . . . . . . 73
Cooling System . . . . . . . . . . . . . . . . . . . . . . . . . 191
Drive Belt Routing . . . . . . . . . . . . . . . . . . . . . 264
Exhaust . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 141
Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 195
Oil Life System . . . . . . . . . . . . . . . . . . . . . . . . 186
Oil Pressure Gauge . . . . . . . . . . . . . . . . . . . . . 72
Oil Pressure Light . . . . . . . . . . . . . . . . . . . . . . . 80
Overheating . . . . . . . . . . . . . . . . . . . . . . . . . . . 194
Power Messages . . . . . . . . . . . . . . . . . . . . . . . . 85
Running While Parked . . . . . . . . . . . . . . . . . 142
Starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 137
Enhanced Technology Glass . . . . . . . . . . . . . . . . 21
Entry Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94
Equipment, Towing . . . . . . . . . . . . . . . . . . . . . . . 172
Event Data Recorders . . . . . . . . . . . . . . . . . . . . 275
Exit Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94
Extender, Seat Belt . . . . . . . . . . . . . . . . . . . . . . . .35
Exterior Lamp Controls . . . . . . . . . . . . . . . . . . . . 90
Exterior Lamps Off Reminder . . . . . . . . . . . . . 90
Exterior Lighting Battery Saver . . . . . . . . . . . 95
F
Fan Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 195
Fast Idle System . . . . . . . . . . . . . . . . . . . . . . . . . .138 Filter,
Engine Air Cleaner . . . . . . . . . . . . . . . . . . . . . 189
Fixed Mast Antenna . . . . . . . . . . . . . . . . . . . . . 103
Flash-to-Pass . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .91
Flashers, Hazard Warning . . . . . . . . . . . . . . . . . 92
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 227 Changing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 229
Floor Mats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 248
Fluid Automatic Transmission . . . . . . . . . . 186, 189
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 197
Power Steering . . . . . . . . . . . . . . . . . . . . . . . . 196
Washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 196
Folding Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . .19
Forward Collision Alert (FCA) System . . . . .154
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 273
Front Seats Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Front Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Front Turn Signal Bulb Replacement . . . . . . . . . . . . . . . . . . . . . . 202
Fuel Additives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 158
Economy, Driving for Better . . . . . . . . . . . 126
Filling a Portable Fuel Container . . . . . . . 160 Fuel (cont'd)
Filling the Tank . . . . . . . . . . . . . . . . . . . . . . . . 158
Foreign Countries . . . . . . . . . . . . . . . . . . . . . . 158
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
Low Fuel Warning Light . . . . . . . . . . . . . . . . 80
Prohibited Fuels . . . . . . . . . . . . . . . . . . . . . . . 158
Recommended . . . . . . . . . . . . . . . . . . . . . . . . . 158
Top Tier . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 157
Full-Size Spare Tire . . . . . . . . . . . . . . . . . . . . . . . 236
Fuses Engine Compartment Fuse Block . . . . . . . 206
Floor Console Fuse Block . . . . . . . . . . . . . . . 210
Fuses and Circuit Breakers . . . . . . . . . . . . . 205
G
GaugesEngine Coolant Temperature . . . . . . . . . . . . 73
Engine Oil Pressure . . . . . . . . . . . . . . . . . . . . . 72
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Speedometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Trip Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Voltmeter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73
Warning Lights and Indicators . . . . . . . . . . 70
General Information Service and Maintenance . . . . . . . . . . . . . . 250
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 160