service schedule CHEVROLET KODIAK 2008 User Guide

Other Service Items
Fuel Filter
Fuel Filter/Pressure Regulator
(Gasoline Engines)
The steel fuel filter/pressure regulator is located near
the engine compartment on the driver’s side frame rail.
If your vehicle has a rear steel fuel tank, the fuel
filter/pressure regulator is located near the rear fuel tank,
on the driver’s side frame rail. SeeScheduled
Maintenance on page 6-5for recommended service
intervals.
If your vehicle is equipped with the optional Davco
spin-on type filter, it is located on the driver’s side
frame rail.
Fuel Filter (Diesel Engines)
If you have a diesel engine, your fuel filter is located in
the engine compartment on the driver’s side of the
vehicle, or along the driver’s side frame rail. See “Fuel
Filter Replacement” earlier in this section for further
information.
Also seeScheduled Maintenance on page 6-5for
recommended service intervals.
5-78

{CAUTION:
If wheel studs are damaged, they can break.
If all the studs on a wheel broke, the wheel
could come off and cause a crash. If any stud
is damaged because of a loose-running wheel,
it could be that all of the studs are damaged.
To be sure, replace all studs on the wheel.
If the stud holes in a wheel have become
larger, the wheel could collapse in operation.
Replace any wheel if its stud holes have
become larger or distorted in any way. Inspect
hubs and hub-piloted wheels for damage.
Because of loose running wheels, piloting pad
damage may occur and require replacement of
the entire hub, for proper centering of the
wheels. When replacing studs, hubs, wheel
nuts or wheels, be sure to use GM original
equipment parts.
{CAUTION:
Rust or dirt on a wheel, or on the parts to
which it is fastened, can make wheel nuts
become loose after a time. The wheel
could come off and cause a crash. When
you change a wheel, remove any rust or
dirt from places where the wheel attaches
to the vehicle. In an emergency, you can
use a cloth or a paper towel to do this;
but be sure to use a scraper or wire brush
later, if you need to, to get all the rust or
dirt off.
How Often to Check
Wheel tightness is so important you should have a
technician check nut tightness on all wheels with
a torque wrench after your first 100 miles (160 km), and
then 1,000 miles (1 600 km) after that. Be sure to
repeat this service whenever you have a tire removed or
serviced. SeeScheduled Maintenance on page 6-5for
further information.
5-89

Maintenance Schedule......................................6-2
Introduction...................................................6-2
Maintenance Requirements..............................6-2
Your Vehicle and the Environment....................6-2
How This Section is Organized.........................6-3
Part A: Scheduled Maintenance Services...........6-4
Using the Maintenance Schedule......................6-4
Scheduled Maintenance Supplements................6-4Scheduled Maintenance...................................6-5
Part B: Owner Checks and Services................6-26
At Each Fuel Fill..........................................6-26
At Least Twice a Year...................................6-27
At Least Once a Year...................................6-30
Part C: Recommended Fluids and Lubricants. . . .6-31
Part D: Maintenance Record..........................6-33
Section 6 Maintenance Schedule
6-1

How This Section is Organized
This maintenance schedule is divided into four parts:
“Part A: Scheduled Maintenance Services”explains
what to have done and how often. Some of these
services can be complex, so unless you are technically
qualified and have the necessary equipment, you
should let your dealer/retailer do these jobs.
Your dealer/retailer has trained and supported service
people that will perform the work using genuine parts.
{CAUTION:
Performing maintenance work on a vehicle can
be dangerous. In trying to do some jobs, you
can be seriously injured. Do your own
maintenance work only if you have the required
know-how and the proper tools and equipment
for the job. If you have any doubt, have a
qualied technician do the work. SeeDoing
Your Own Service Work on page 5-6.
If you want to purchase service information, seeService
Publications Ordering Information on page 7-10.“Part B: Owner Checks and Services”tells you what
should be checked and when. It also explains what
you can easily do to keep your vehicle in good condition.
“Part C: Recommended Fluids and Lubricants”
lists some recommended products necessary to help
keep your vehicle properly maintained. These products,
or their equivalents, should be used whether you do the
work yourself or have it done.
“Part D: Maintenance Record”is a place for you to
record and keep track of the maintenance performed on
your vehicle. Keep your maintenance receipts. They
may be needed to qualify your vehicle for warranty
repairs.
6-3

Part A: Scheduled Maintenance
Services
In this part are scheduled maintenance services which
are to be performed at the mileage intervals specified.
Using the Maintenance Schedule
We want to help keep your vehicle in good working
condition. But we do not know exactly how you will drive
it. You might drive very short distances only a few times
a week. Or you might drive long distances all the
time in very hot, dusty weather. You might use your
vehicle in making deliveries or in many other ways.
Because of all the different ways people use their
vehicles, maintenance needs vary. You might need
more frequent checks and replacements. So please read
the following and note how you drive. If you have any
questions on how to keep your vehicle in good condition,
see your dealer/retailer.
This part tells you the maintenance services you should
have done and when to schedule them.
When you go to your dealer/retailer for your service
needs, you will know that trained and supported service
people will perform the work using genuine parts.The proper fluids and lubricants to use are listed in
Part C. Make sure whoever services your vehicle uses
these. All parts should be replaced and all necessary
repairs done before you or anyone else drives the
vehicle.
This schedule is for vehicles that:
•carry passengers and cargo within recommended
limits. You will find limits on your vehicle’s
Certification or Tire Information label. SeeLoading
Your Vehicle on page 4-21.
•are driven on reasonable road surfaces within legal
driving limits.
•use the recommended fuel. SeeGasoline Octane
on page 5-7for gasoline engine vehicles orWhat
Fuel to Use on page 5-9for diesel engine vehicles.
Scheduled Maintenance
Supplements
If your vehicle has a Caterpillar®diesel engine, your
owner manual is supplemented by the Caterpillar®
Diesel Engine Operation & Maintenance Manual. If your
vehicle has an Allison Transmission®, your owner
manual is supplemented by an Allison Transmission®
Operator’s Manual. Always refer to these manuals
for related maintenance services.
6-4

Scheduled Maintenance
The services shown in this schedule up to 100,000 miles
(166 000 km) should be repeated after 100,000 miles
(166 000 km) at the same intervals for the life of
this vehicle. The services shown after 100,000 miles
(166 000 km) should be repeated at the same miles (km)
after those intervals for the life of this vehicle.
Gasoline engine vehicles and some DURAMAX
®diesel
and Isuzu diesel engine vehicles have a computer
that lets you know when to change the engine oil. This
is not based on mileage, but on engine operation and
engine temperature. When the computer has calculated
that the oil needs changing, the Engine Oil Life System
will indicate that a change is necessary. SeeEngine Oil
Life System (Gasoline Engine) on page 5-36orEngine
Oil Life System (DURAMAX
®/Isuzu Diesel Engines) on
page 5-37orEngine Oil Life System (Caterpillar®Diesel
Engine) on page 5-39.
The “Footnotes” at the end of this Maintenance
Schedule further explain maintenance services.
SeeService Publications Ordering Information on
page 7-10.
100 Miles (160 km)
❑Wheel stud nut service.(36)
1,000 Miles (1 600 km)
❑Wheel stud nut service.(36)
❑Rear axle air shift motor service.(10)
7,500 Miles (12 000 km)
❑Gasoline Engine Only: Check engine oil life system.
If engine oil and filter are changed, reset system.
See “Engine Oil (Gasoline Engine)” in the
Index.(2) (8)
❑Check fluid levels (or every 3 months, whichever
occurs first).(1) (5)
❑Chassis lubrication service (or every 6 months,
whichever occurs first).(11)
❑Spring-to-axle U-bolts and shackle bolts service.(15)
❑Wheels and tires service.(14)
❑Hydraulic brake service (or every 6 months,
whichever occurs first).(6) (36)
❑Parking brake service (or every 6 months, whichever
occurs first).(21)
❑Air brake service (or every 6 months, whichever
occurs first).(32)
❑Air brake automatic slack adjuster service (or every
500 hours, whichever occurs first).(33)
❑Check air brake relay valve operation and check for
leaks (or every month, or every 300 hours, whichever
occurs first).
6-5

Part D: Maintenance Record
After the scheduled services are performed, record the date, odometer reading and who performed the service, and
any additional information from “Owner Checks and Services” on the following record pages. Also, you should
retain all maintenance receipts.
DateMiles/km Or
HoursServiced By Maintenance Record
6-33

Service Publications Ordering
Information
Service Manuals
Service Manuals have the diagnosis and repair
information on engines, transmission, axle suspension,
brakes, electrical, steering, body, etc.
Service Bulletins
Service Bulletins’ give additional technical service
information needed to knowledgeably service
General Motors cars and trucks. Each bulletin contains
instructions to assist in the diagnosis and service of
your vehicle.
Owner Information
Owner publications are written specifically for owners
and intended to provide basic operational information
about the vehicle. The owner manual includes the
Maintenance Schedule for all models.
In-Portfolio: Includes a Portfolio, Owner Manual, and
Warranty Booklet.
RETAIL SELL PRICE: $35.00 (U.S.) plus processing fee
Without Portfolio: Owner Manual only.
RETAIL SELL PRICE: $25.00 (U.S.) plus processing fee
Current and Past Model Order Forms
Technical Service Bulletins and Manuals are available
for current and past model GM vehicles. To request
an order form, specify year and model name of
the vehicle.
ORDER TOLL FREE: 1-800-551-4123
Monday-Friday 8:00 AM - 6:00 PM
Eastern Time
For Credit Card Orders Only
(VISA-MasterCard-Discover), visit Helm, Inc. on the
World Wide Web at: www.helminc.com
Or you can write to:
Helm, Incorporated
P.O. Box 07130
Detroit, MI 48207
Prices are subject to change without notice and without
incurring obligation. Allow ample time for delivery.
Note to Canadian Customers: All listed prices are
quoted in U.S. funds. Canadian residents are to make
checks payable in U.S. funds.
7-10

M
Maintenance, Replacement Parts.....................5-115
Maintenance Schedule
At Each Fuel Fill.........................................6-25
At Least Once a Year..................................6-29
At Least Twice a Year..................................6-26
How This Section is Organized....................... 6-2
Introduction.................................................. 6-2
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-3
Part B - Owner Checks and Services.............6-25
Part C - Recommended Fluids and
Lubricants...............................................6-30
Part D - Maintenance Record........................6-32
Scheduled Maintenance................................. 6-4
Scheduled Maintenance Supplements............... 6-4
Using.......................................................... 6-3
Your Vehicle and the Environment................... 6-2
Malfunction Indicator Light................................3-36
Manual Transmission
Fluid..........................................................5-43
Operation...................................................2-30
Manual, Using..................................................... ii
Manual Windows.............................................. 2-8
Marker Lamps................................................3-16
Mirrors
Manual Rearview Mirror................................2-51
Outside Convex Mirrors................................2-52
Outside Heated Mirrors................................2-52Mirrors (cont.)
Outside Manual Mirrors................................2-51
Outside Power Mirrors..................................2-51
N
Navigation System, Privacy..............................7-12
New Vehicle Break-In......................................2-10
Noise Control System, Tampering......................5-75
O
Odometer......................................................3-26
Odometer, Trip...............................................3-26
Off-Road Recovery..........................................4-11
Oil
Change Engine Oil Light...............................3-38
Engine...............................5-23, 5-24, 5-28, 5-32
Low Oil Level Light......................................3-38
Pressure Gage............................................3-37
Oil, Engine Oil Life System..............5-36, 5-37, 5-39
Older Children, Restraints................................1-28
OnStar, Privacy..............................................7-12
Other Service Items
Front Wheel Bearings with Oil-Filled Hubs.......5-81
Primary Fuel Filter and Water Separator.........5-79
Secondary Fuel Filter and Water
Separator/Heater......................................5-80
Other Warning Devices...................................... 3-6
8

Outlet Adjustment............................................3-23
Outlets
Accessory Power.........................................3-19
Outside
Convex Mirrors............................................2-52
Heated Mirrors............................................2-52
Manual Mirrors............................................2-51
Power Mirrors.............................................2-51
Overspeed Warning Light.................................3-39
P
Paint, Damage...............................................5-99
Park Brake............................................2-38, 2-41
Parking.........................................................2-37
Brake Burnish Procedure..............................2-43
Over Things That Burn.................................2-44
Two-Speed Rear Axle..................................2-27
Part A - Scheduled Maintenance Services............ 6-3
Part B - Owner Checks and Services................6-25
Part C - Recommended Fluids and Lubricants....6-30
Part D - Maintenance Record...........................6-32
Passing.........................................................4-11
Perchlorate Materials Requirements, California...... 5-5
Power
Door Locks.................................................. 2-7
Electrical System.......................................5-103
Reduced Engine Light..................................3-41Power (cont.)
Steering Fluid.............................................5-54
Windows...................................................... 2-9
Power Take-Off Light.......................................3-42
Power Take-Off (PTO).....................................2-32
Privacy..........................................................7-11
Event Data Recorders..................................7-11
Navigation System.......................................7-12
OnStar.......................................................7-12
Radio Frequency Identification.......................7-12R
Radio Frequency Identification (RFID), Privacy....7-12
Radios..........................................................3-47
Radio(s)........................................................3-48
Radios
Reception...................................................3-58
Setting the Clock.........................................3-48
Theft-Deterrent............................................3-57
Range Inhibit Warning Indicator........................3-32
Reading Lamps..............................................3-17
Rear Axle......................................................5-72
Differential Lock Control................................. 4-7
Shift Motor.................................................5-73
Rear Heating System......................................3-24
Rear Seat Operation.......................................1-10
Rearview Mirrors.............................................2-51
9