steering wheel CHEVROLET KODIAK 2008 Owner's Guide

(12)= Check steering system:
•Look for damaged, loose, or missing parts. Inspect
the steering linkage relay rod and tie rod ends for
looseness or lack of lubricant. Also look for parts
showing signs of wear or lack of lubrication. Replace
parts as needed. Also check steering gear mounting
bolts, pitman arm nut, gear housing upper cover and
side cover attaching bolts, steering column mounting
bolts and cardan joint clamp bolts; tighten if
necessary. See the service manual.
•Inspect power steering hoses, tubes, and fittings for
leaks. Hoses and lines must not be twisted, kinked,
or tightly bent. Make sure clips, clamps, supporting
tubes, and hoses are in place and properly secured.
•Check steering gear for leakage around pitman shaft
and housing. If leakage is evident (lubricant oozing
out, not just oily film), leak should be corrected
immediately.
(13)= Check front and rear suspension. Look for
damaged, loose, or missing parts or parts showing signs
of wear or lack of lubrication. Replace parts as needed.
(14)= Adjust tire pressures as indicated on the
Certification or Tire Information label for optimum tire
life. SeeTires on page 5-82for further details. Check
tires for excessive or abnormal wear or damage. Also
check for damaged wheels. Replace wheels and/or tires
as needed.(15)= Check spring-to-axle U-bolts and shackle bolts
for proper torque. See the service manual for torque
sequence and specifications. When parts are replaced,
the torque must be checked and adjusted more often
during the first 6,000 miles (10 000 km). Check torque at
500 miles (800 km) and 2,000 miles (3 000 km) after
first use of parts.
(16)= Check complete exhaust system, including DPF
pressure lines, and cab areas near the exhaust system
for broken, damaged, missing, or out-of-position parts.
Also inspect for open seams, holes, loose connections, or
other conditions which could let exhaust fumes seep into
the driver compartment. Needed repairs should be made
at once. To help maintain system integrity, replace
exhaust pipes whenever a new muffler is put on.
(17)= Check all gasoline engine drive belts for cracks,
fraying, and wear. Replace as needed.
(18)= Adjust valve lash. Incorrect valve clearance will
result in increased engine noise and reduced engine
output.
(19)= With the engine off and below normal operating
temperature, check to see that the thermostatically
controlled engine cooling fan can be rotated by hand on
viscous-operated drives. Replace as needed.
(20)= Check shields and underhood insulation for
damage or looseness. Adjust or replace as needed.
6-22

Automatic Transmission Shift Indicator
Check
Check that the indicator points to the gear chosen.
Steering Check
Be alert for any changes in steering action, abnormal
front tire wear or steering wheel position. An inspection
or service is needed when the steering wheel is harder
to turn or has too much free play, or if there are strange
sounds when turning or parking.
Brake System Check
Be alert to the low air warning light or tone alarm, or
changes in braking action, such as repeated pulling to
one side, unusual sounds when braking or increased
brake pedal travel. Make sure air brake system
reservoirs are drained daily with full system air pressure,
and check system for leaks. Any of these conditions
could indicate the need for brake system inspection
and/or service.
Engine Cooling System Service
Inspect the hoses and have them replaced if they are
cracked, swollen, or deteriorated. Inspect all pipes,
fittings, and clamps; replace as needed. Clean the
outside of the radiator and air conditioning condenser.
To help ensure proper operation, a pressure test of the
cooling system and pressure cap is recommended at
least once a year.
Exhaust System Inspection
Be alert for any changes in the sound of the exhaust
system or any smell of fumes. These are signs the
system may be leaking. Have it checked and/or repaired
at once. SeeEngine Exhaust on page 2-45and
Running the Vehicle While Parked on page 2-50.
Check to be sure that mud or dirt is not caked on the
exhaust system, especially in the area of the diesel
particulate filter and tailpipe. Clean the area as needed.
SeeDiesel Particulate Filter (Diesel Engine) on
page 2-46.
At high mileages, the DPF becomes loaded with ash.
This is normal. When the amount of ash loading is high,
see your dealer/retailer for DPF cleaning or replacement.
6-28

Exhaust Brake Indicator Light...........................3-40
Exhaust Restrictor...........................................2-22
Extender, Safety Belt.......................................1-28
Exterior Lamps...............................................3-14
F
Filter
Engine Air Cleaner......................................5-39
Filter Minder Gage..........................................3-45
Finish Damage...............................................5-99
Fixed Mast Antenna........................................3-58
Flashers, Hazard Warning.................................. 3-6
Flat Tire........................................................5-92
Fluid.............................................................5-43
Power Steering...........................................5-54
Windshield Washer......................................5-55
Four-Wheel Drive....................................2-32, 5-73
Front Axle......................................................5-74
Front Wheel Bearings with Oil-Filled Hubs..........5-81
Fuel............................................................... 5-7
Additives...................................................... 5-8
Change Filter Warning Light..........................3-44
Diesel Engine Fuel........................................ 5-9
Filling a Portable Fuel Container....................5-21
Filling the Tank...........................................5-20
Filter..........................................................5-78
Filter Replacement.......................................5-18
Fuels in Foreign Countries............................5-19Fuel (cont.)
Gage.........................................................3-43
Gasoline Octane........................................... 5-7
Gasoline Specifications.................................. 5-7
Primary Filter and Water Separator................5-79
Running Out of...........................................2-50
Running Out of Fuel....................................5-17
Secondary Filter and Water Separator/
Heater....................................................5-80
Very Cold Weather Operation........................5-12
Water in Fuel..............................................5-12
Water in Warning Light.................................3-44
What Fuel to Use.......................................... 5-9
Fuses
Fuses and Circuit Breakers.........................5-103
Instrument Panel Fuse Block.......................5-103
Underhood Fuse Block...............................5-106
Windshield Wiper.......................................5-102
G
Gage
Air Pressure...............................................3-46
Check Gages Warning Light..........................3-42
Engine Coolant Temperature.........................3-35
Filter Minder...............................................3-45
Fuel..........................................................3-43
Hourmeter..................................................3-46
Oil Pressure...............................................3-37
5

Specifications, Capacities...............................5-109
Speedometer..................................................3-26
Split Bench Seat.............................................. 1-6
Starting Diesel Engine.....................................2-14
Starting the Gasoline Engine............................2-12
Steering.......................................................... 4-9
Steering Wheel, Tilt Wheel................................. 3-7
Storage Areas................................................2-53
Center Console Storage Area........................2-53
Stuck in Sand, Mud, Ice, or Snow.....................4-19
Sun Visors...................................................... 2-9
Suspension, Air..............................................2-44
Switchbanks, Instrument Panel..........................3-18
T
Tachometer....................................................3-26
Theft-Deterrent, Radio.....................................3-57
Tilt Wheel........................................................ 3-7
Time, Setting..................................................3-48
Tires.............................................................5-82
Aluminum or Chrome-Plated Wheels,
Cleaning.................................................5-98
Buying New Tires........................................5-85
Cleaning....................................................5-99
Dual Tire Operation.....................................5-84
If a Tire Goes Flat.......................................5-92
Inflation - Tire Pressure................................5-82
Tightening the Wheel Nuts............................5-86Tires (cont.)
Wheel Alignment and Tire Balance.................5-86
Wheel Loading............................................5-83
Wheel Replacement.....................................5-90
When It Is Time for New Tires......................5-84
Tow Hooks.....................................................4-20
Towing
Your Vehicle...............................................4-24
Traction
Control System (TCS).................................... 4-8
Trailer
Connections................................................4-26
Trailer Brake Hand Control Valve........................ 4-6
Transmission
Fluid, Automatic...........................................5-43
Fluid, Manual..............................................5-43
Service Warning Light..................................3-31
Temperature Gage.......................................3-39
Transmission Operation, Automatic....................2-29
Transmission Operation, Manual........................2-30
Trip Odometer................................................3-26
Turn and Lane-Change Signals.......................... 3-8
Turn Signal/Multifunction Lever........................... 3-7
Two-Speed Rear Axle......................................2-27
U
Using this Manual................................................ ii
11