washer fluid CHEVROLET LOW CAB FORWARD 2017 User Guide

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Vehicle Care 275
Use a high quality premixed solvent
available at most dealers or service
stations.
Avoid hard water when mixing
windshield washer solvents. Hard
water contaminants may plug
orifices in the washer system and
reduce performance.
Do not use radiator antifreeze in the
windshield washer; it could cause
cab paint damage.
In cold weather, warm the
windshield with the defrosters
before using the washer, to help
prevent icing that may block the
driver's vision.Refilling Windshield Washer
Fluid
1. The windshield washer fluidtank (1) is located under the
instrument panel on the
passenger side.
2. Open the cap (2) and fill the tank with windshield washer
fluid.
Upon factory shipment, new
vehicles contain only tap water in
the washer fluid tank. Adjust the
concentration of the fluid to suit your
own usage. Follow the instructions provided with
the windshield washer fluid
regarding the ratio for mixing with
tap water.
Poor quality products, engine
coolant, and soapy water must not
be used. Failure to observe this
precaution can result in nozzle
blockage or damage to painted
surfaces.
The washer should never be used
while the tank is empty. Operating
the washer with the tank empty can
result in motor damage.Brakes
For the most effective braking and
for maximum life from brake system
components, follow these
suggestions:
.
Keep any obstructions from
interfering with brake pedal
travel.
. Keep tires properly inflated.
Improperly inflated tires can
reduce the efficiency of the
brakes.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Service and Maintenance 369
2. Checks performed at theengine
.Fan belt looseness and
damage
. Engine oil level
. Engine coolant level
. Power steering fluid level
3. Checks performed from the driver's seat
.Brake fluid level
. Brake pedal free play
. Operation of meters,
gauges and warning/
indicator lights
. Engine startability,
abnormal noise and color of
exhaust gases
. Parking brake lever stroke
. Windshield washer fluid
spray condition and
windshield wiper
effectiveness
. Windshield washer fluid
level .
Steering wheel position and
free play
. Operation of horn and turn
signal lights
. Door lock operation
4. Checks performed during a walk around the vehicle
.Illumination, flashing,
contamination, damage and
obstruction of lights
. Contamination, damage ad
obstruction of windows,
mirrors and reflectors
. Leaf spring damage
. Oil, engine coolant, fuel,
brake fluid and power
steering fluid leaks
. Water separator
5. Checking wheels and tires .Air pressure
. Cracks and other damage
. Abnormal wear
. Tread depth
. Mounting condition of all
wheel nuts 6. Checks performed after the
engine startup
.Oil, engine coolant, fuel,
brake fluid and power
steering fluid leaks
. Inspect the exhaust system,
checking that the tailpipe is
clear
7. Checks performed while driving the vehicle
.Brake effectiveness
. Engine abnormal noises
Keep the Floor Around the Driver
Seat Clean and Tidy
{Warning
It is extremely dangerous to have
empty cans, empty bottles,
or other items rolling around on
the floor because they could get
trapped under the brake pedal
and prevent brake application.
For proper pedal operation, it is
also essential to lay floor mats (Continued)

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
376 Service and Maintenance
one side, unusual sounds when
braking, increased brake pedal
travel or harder pedal. The front and
rear brakes are attached to an auto
adjuster mechanism. If there are no
defects, as the pedal travel is
properly maintained, adjustments
are not necessary. Check regularly
that the brake fluid reservoir
(left-hand side of the instrument
panel) or HBB reservoir (5500HD,
5500XD models: left side behind the
cab) is properly filled and check for
fluid leaks. Any of these conditions
could indicate the need for brake
system inspection and/or service.
G: Exhaust System :Be alert for
any changes in the sound of the
exhaust system or any smell of
fumes. These are signs the system
may be leaking. Have it checked
and/or repaired at once. (Refer to
"Engine Exhaust Emissions Caution
(Carbon Monoxide)" under Engine
Exhaust 0178).
H: Windshield Wipers and
Washers : Check operation and
condition of the wiper blades. Check
the flow of the washer spray. I: Defroster :
Turn the outlet
selector knob to "Defroster" and the
fan speed control knob to the fully
clockwise position. Then check the
airflow from the ducts at the inside
base of the windshield.
J: Rearview Mirrors and Sun
Visors : Check that friction joints
hold mirrors and sun visors in place.
K: Horn : Sound the horn, now and
then, to be sure it works.
L: Lap-Shoulder Belts : Check the
seat belt system (including webbing,
buckles, latch plates and anchors)
for proper operation, and for
damage.
M: Seat Adjusters : When
adjusting the driver's manual seat,
be sure the seat adjusters latch by
pushing the seat forward and
backward. Do not attempt to adjust
the seat when the vehicle is in
motion.
N: Lamps : Check panel lighting,
warning lamps, indicator lamps and
interior lamps. On the outside,
check: license plate lamps, side
marker lamps, reflectors on outside mirrors, headlamps, parking lamps,
identification and clearance lamps,
taillights, brake lamps, turn signals,
cornering lamps, backup lamps and
hazard warning flashers. Have
headlamp aim checked immediately
if beams seem improperly aimed.
O: Glass, Mirrors, Lights and/or
Reflectors Condition :
Look for
broken, scratched, dirty or damaged
glass, mirrors, lamps or reflectors
that could reduce the view or
visibility, or cause injury. Replace,
clean or repair promptly.
P: Door Latches : Check that doors
close, latch and lock tightly. Check
for broken, damaged or missing
parts that might prevent tight
latching.
Q :Tilt Cab (Driving Position) : Be
sure the tilt lever is down and
locked.
R: Fluid Leaks : Check for fuel,
water, oil or other fluid leaks by
looking at the surface beneath the
vehicle after it has been parked for
a while. If you notice diesel fumes or
fluid at any time, have the cause
found and corrected at once.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Service and Maintenance 379
UsageFluid/Lubricant
Engine Coolant (Diesel Engine) 50/50 mixture of clean, drinkable water and GM extended life coolant. (GM Part No. 12378560) SeeEngine Coolant0263.
Engine Coolant (Gasoline Engine) 50/50 mixture of clean, drinkable water and use only DEX-COOL
®coolant.
See Engine Coolant 0263.
Engine Oil (Diesel Engine) Engine oils with the letters CK-4 are required for your vehicle. The CK-4 designation can appear either alone or in combination with other American
Petroleum Institute (API) designations, such as API CK-4/SL. These letters
show API levels of quality. To determine the preferred viscosity for your
vehicle's diesel engine, seeEngine Oil (Gasoline)0257 orEngine Oil
(Diesel) 0251.
Engine Oil (Gasoline Engine) Engine oil meeting the dexos1™ specification of the proper SAE viscosity
grade. ACDelco dexos1 Synthetic Blend is recommended.
See Engine Oil (Gasoline) 0257 orEngine Oil (Diesel) 0251.
Hydraulic Brake Booster (If
Equipped) DEXRON
®-VI Automatic Transmission Fluid.
Power Steerig Fluid DEXRON
®-VI Automatic Transmission Fluid.
Rear Axle Multi purpose gear oil SAE80W-90 GL-5, SAE90 GL-5
Rear Axle
(Limited slip differential (LSD)) Multi purpose gear oil SAE80W-90 GL-5, SAE90 GL-5 for limited slip
differential together with limited slip differential lubricant additive (GM
Part No. 88900330) or equivalent.
Windshield Washer Solvent Automotive windshield washer fluid that meets regional freeze protection requirements.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Index 409
Diesel Engine (cont'd)High Idle System . . . . . . . . . . . . . 174
Diesel Exhaust Fluid . . . . . . . . 30, 189
Diesel Exhaust Fluid (DEF) Gauge . . . . . . . . . . . . . . . . . . . . . . . . . 83
Diesel Exhaust Fluid (DEF) Warning Light . . . . . . . . . . . . . . . . . . 90
Diesel Particulate Filter . . . . . . . . . 180
Distracted Driving . . . . . . . . . . . . . . . 133
Dome Lamps . . . . . . . . . . . . . . . . . . . 107
Door Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
Power Locks . . . . . . . . . . . . . . . . . . . . 39
Drive Belt Routing, Engine . . . . . . 396
Driver Behavior . . . . . . . . . . . . . . . . . 133
Driver Information
Center (DIC) . . . . . . . . . . . . . . . . . . . 93
Driving
Emergencies . . . . . . . . . . . . 148, 161
For Better Fuel Economy . . . . . . . 29
Hill and Mountain Roads . . . . . . 144
If the Vehicle is Stuck . . . . . . . . . 148
Wet Roads . . . . . . . . . . . . . . . . . . . 143
Winter . . . . . . . . . . . . . . . . . . . . . . . . 145
Driving the Vehicle . . . . . . . . . . . . . . . . 3
E
Electrical Equipment, Add-On . . . . . . . . . . . . . . . . . . . . . . . 241 Electrical System
Overload . . . . . . . . . . . . . . . . . . . . . 298
Emergencies . . . . . . . . . . . . . . 148, 161
Engine Air Cleaner/Filter . . . . . . . . . . . . . 263
Alarm and AutomaticShutdown . . . . . . . . . . . . . . . . . . . 174
Check Light (Malfunction Indicator) . . . . . . . . . . . . . . . . . . . . . . 84
Checks Before Operating . . . . . 175
Compartment Overview . . . . . . . 249
Coolant . . . . . . . . . . . . . . . . . . . . . . . 263
Coolant Temperature Gauge . . . . 82
Cover . . . . . . . . . . . . . . . . . . . . . . . . . 250
Drive Belt Routing . . . . . . . . . . . . 396
Exhaust . . . . . . . . . . . . . . . . . . . . . . 178
Heater . . . . . . . . . . . . . . . . . . . . . . . . 173
High Idle System . . . . . . . . . . . . . 174
Oil Pressure Light . . . . . . . . . . . . . . 89
Overheating . . . . . . . . . . . . . . . . . . 269
Reduced Power Light . . . . . . . . . . . 91
Running While Parked . . . . . . . . 179
Shutdown Warning Light . . . . . . . . 91
Engine Oil Level Indicator Light . . . . . . . . . . . . 90
Engines Diesel Fuel . . . . . . . . . . . . . . . . . . . 232
Exhaust Brake . . . . . . . . . . . . . . . . . . 222 Exhaust Brake Light . . . . . . . . . . . . . 88
Exhaust Fluid
Diesel . . . . . . . . . . . . . . . . . . . . . . . . 189
Extender, Seat Belt . . . . . . . . . . . . . . 55
Exterior Lamp Controls . . . . . . . . . 103
F
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 180 Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 282
Filter, Engine Air Cleaner . . . . . . . . . . . 263
Fixed Mast Antenna . . . . . . . . . . . . 113
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 104
Flashers, Hazard Warning . . . . . . 105
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 326
Fluid Automatic Transmission . . . . . . 260
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 280
Diesel Exhaust . . . . . . . . . . . . . . . . . 30
Power Steering . . . . . . . . . . . . . . . 273
Washer . . . . . . . . . . . . . . . . . . . . . . . 274
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 404
Front Seat Position Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 44
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 231
Biodiesel . . . . . . . . . . . . . . . . . . . . . 233
Cold Weather Operation . . . . . . 235
Diesel Engines . . . . . . . . . . . . . . . 232

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Index 413
Storage Areas (cont'd)Information on Loading the
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . 64
Instrument Panel . . . . . . . . . . . . . . . 61
Storage Compartments . . . . . . . . . . 60
Stuck Vehicle . . . . . . . . . . . . . . . . . . . 148
Sun Visors . . . . . . . . . . . . . . . . . . . . . . . 43
System Noise Control . . . . . . . . . . . . . . . . . 284
T
Tachometer . . . . . . . . . . . . . . . . . . . . . . 81
TaillampsBulb Replacement . . . . . . . . . . . . 297
Temperature, Operating . . . . . . . . 172
Text Telephone (TTY) Users . . . . 399
Three-Point Seat Belt . . . . . . . . . . . . 51
Tires If a Tire Goes Flat . . . . . . . . . . . . 326
Pressure . . . . . . . . . . . . . . . . . . . . . . 322
Rotation . . . . . . . . . . . . . . . . . . . . . . 323
Tires and Wheels . . . . . . . . . . . . . . . 308
Towing Vehicle . . . . . . . . . . . . . . . . . . . . . . . 332
Trademarks and License Agreements . . . . . . . . . . . . . . . . . . . 125
Transmission Automatic . . . . . . . . . . . . . . . . . . . . . 204
Fluid, Automatic . . . . . . . . . . . . . . 260 Transmission (cont'd)
Overdrive Off, Automatic . . . . . . 215
Service Warning Light . . . . . . . . . . 88
Trip Odometer . . . . . . . . . . . . . . . . . . . 80
Turn and Lane-Change
Signals . . . . . . . . . . . . . . . . . . . . . . . . 105
Turn Signal Bulb Replacement . . . . . . . . . . . . 297
U
USB Port . . . . . . . . . . . . . . . . . . . . . . . 121
Using This Manual . . . . . . . . . . . . . . . . 3
V
VehicleControl . . . . . . . . . . . . . . . . . . . . . . . 133
Getting In and Out . . . . . . . . . . . . . . 35
Identification Number (VIN) . . . 383
Messages . . . . . . . . . . . . . . . . . . . . . . 97
Security . . . . . . . . . . . . . . . . . . . . . . . . 39
Service Soon Light . . . . . . . . . . . . . 84
Starting and Stopping . . . . 165, 168
Towing . . . . . . . . . . . . . . . . . . . . . . . . 332
Vehicle Care
Tire Pressure . . . . . . . . . . . . . . . . . 322
Vehicle Data Recording and Privacy . . . . . . . . . . . . . . . . . . . . . . . . 405
Ventilation, Air . . . . . . . . . . . . . . . . . . 129
Visors . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
W
Wait to Start Light . . . . . . . . . . . . . . . 89
Warning Brake System Light . . . . . . . . . . . . . 84
Caution and Danger . . . . . . . . . . . . . 3
Warning Buzzers . . . . . . . . . . . . . . . 101
Warning Lights, Gauges, and Indicators . . . . . . . . . . . . . . . . . . . . . . 76
Warnings Hazard Flashers . . . . . . . . . . . . . . 105
Washer Fluid . . . . . . . . . . . . . . . . . . . 274
Water in Fuel . . . . . . . . . . . . . . . . . . . 236
Wheels and Tires . . . . . . . . . . . . . . . 308
Windows Power . . . . . . . . . . . . . . . . . . . . . . . . . . 41
Windshield Wiper/Washer . . . . . . . . . . . . . . . . . . 73
Winter Driving . . . . . . . . . . . . . . . . . . . . . . . . 145
Winter Cover . . . . . . . . . . . . . . . . . . . 172
Wiper Blade Replacement . . . . . . 286