instrument panel CHEVROLET LOW CAB FORWARD 2017 Owner's Guide

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
276 Vehicle Care
Follow the recommendations for
brake checks in the Maintenance
Schedule.
GM replacement brake lining
material is recommended for this
vehicle to maintain the balance
between front and rear brake
performance. GM replacement
brake parts have been carefully
selected to provide the proper brake
balance for purposes of both
stopping distance and controllability
over the full range of operating
conditions. Installation of front or
rear brake lining material with
performance different from that of
the replacement parts
recommended for this vehicle can
change the intended brake balance
of this vehicle.
Checking the Brake Electric
Vacuum Pump (4500HD/
4500XD Series)
1. Turn the engine control switchto the "ON" position (do not
start the engine), and press the
brake pedal several times. 2. Check for the noisy sound of
the electric vacuum pump
inside the instrument panel at
the same time as vacuum
warning buzzer sound, and
check that the brake low
vacuum warning light
comes on.
3. Then, start the engine. The main vacuum pump driven by
the engine will start running.
If the electric vacuum pump
operation (noisy sound) and
the vacuum warning buzzer
stop, and the brake low
vacuum warning light goes off
thereafter, the operation is
normal.
4. If you cannot hear the noisy sound or the noisy sound stays
on all the time, have the
vehicle inspected by the
nearest dealer immediately.Hydraulic Brake Booster (HBB)
The 5500HD, 5500XD models are
equipped with a HBB system. HBB
is a brake booster device that utilizes hydraulic pressure from the
HBB pump integral with the power
steering pump.
If the brake booster warning light
comes on or a warning buzzer
continues to sound, there may be a
problem with the HBB.
If this warning light comes on while
driving, immediately stop your
vehicle at a safe place well clear of
traffic and promptly contact the
nearest dealer for inspection.
Hydraulic brake booster (HBB)
characteristics
In the 5500HD, 5500XD models, an
unusual sound from under the
instrument panel may be heard from
the hydraulic system while brakes
are used. It does not mean trouble.
It is not a sign of malfunction.
If you pump the brakes with the
engine off, a squeaking sound can
be heard. This comes from the
auxiliary accumulator. It is not a
malfunction. With the engine
running, a similar sound can be
heard during sudden braking.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
280 Vehicle Care
hose and pipe do not interfere with
any chassis part or wheel, and that
their joints are not leaking and are
free of any type of damage. Check
the right front brake hose and pipe
in the same way. The rear left and
right brake hoses and pipes should
also be checked in the same
manner.
Disc Brakes and Drum Brakes
If the brake pads and shoe linings
wear out beyond their usable limit,
not only will the brake performance
be impaired, but brake components
could also fail.
{Warning
Do not drive with brake pads and
shoe linings worn out beyond the
limit. Excessively worn brake
pads and shoe linings may cause
breakdown of brake components
and poor braking performance.
You and others could be seriously
injured.
Caution
The pad has an embedded wear
indicator. A squeaking noise from
the indicator means that the pad
is approaching the usable limit.
If the squeaking noise from the
indicator can be heard, contact
the nearest dealer for inspection
or replacement.
Brake Fluid
Checking the Brake Fluid
Level
Remove the inspection cover (1) on
the left- hand side of the instrument
panel by turning it with your fingers.
Check that the fluid level in the
reservoir is between the "MAX" and
"ADD" lines.
If the fluid surface cannot easily be
seen, rock the vehicle gently.
Adding Brake Fluid
If the level of brake fluid has
dropped below the "ADD" line,
remove the cap (2) and add fluid.
Take care to avoid filling beyond the
"MAX" line.
Tighten the cap securely after the
fluid has been added.
When adding brake fluid to the tank,
take care to prevent dirt and water
from entering it. Any dirt or water in
the system could cause the vehicle
to lose braking functions.
Inspect and change brake fluid
according to the Maintenance
Schedule.
Use the recommended brake fluid
when adding brake fluid.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Vehicle Care 299
The Location of Fuses and Relays
The fuses (3) and relays (2) are
located in the lower part of the
instrument panel in the center and
in the left rear of the cab.
The cover (1) must be opened in
order to carry out inspection and
replacement. In addition, the
cover (1) of the relay box at the left
rear of the cab must also be opened
at this time.
If you should spill water or a
beverage on the cover, wipe it off
before opening the cover.
The area around the cover may get
warm when the vehicle is being
driven, but this is not abnormal.Replacing Fuses
1. Before replacing fuses, firmly apply the parking brake, move
the selector lever to the
P (Park) position, and turn the
engine control switch to the
LOCK position.
2. The fuse puller is stored in the fuse box inside the cab. Place
the fuse puller on the fuse and
pull it out.
3. If the fuse appears asshown (2), the fuse is blown.
Replace with a spare fuse (1).
Spare fuses are stored in the
fuse box inside the cab.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
354 Service and Maintenance
How to check: This operation could
be difficult and you may choose to
have this done at your dealer
Service Department.
1. Turn the engine control switch to
the "ON" position (not to start the
engine), and press the brake pedal
several times.
2. Check for the noisy sound of the
electric vacuum pump inside the
instrument panel at the same time
as vacuum warning buzzer sound,
and check that the brake low
vacuum warning light comes on.
3. Then, after you start the engine,
the main vacuum pump driven by
the engine will start running. If the
electric vacuum pump operation
(noisy sound) and the vacuum
warning buzzer stop, and the brake
low vacuum warning light goes off
thereafter, the operation is normal.
4. If you cannot hear the noisy
sound of the electric vacuum pump,
check the electrical wiring and
repair as necessary. If it cannot be
repaired, replace the electric
vacuum pump.20. BRAKE FLUID :
Check the fluid
in the brake fluid reservoir every
12 000 km (7,500 miles) and replace
fluid every 48 000 km
(30,000 miles).
21. BRAKE LINE AND HOSES :
Check lines and hoses for proper
hook-up, binding, leaks, cracks,
chafing, etc. every 48 000 km
(30,000 miles). Any questionable
parts should be replaced or repaired
at once. When rubbing or wear is
noted on lines or hoses, the cause
must be corrected at once.
22. HYDRAULIC UNIT : Change
every 10 years.
23. DIFFERENTIAL GEAR OIL :
Replace lubricant every 48 000 km
(30,000 miles) or every 24 months.
Check lubricant level every
12 000 km (7,500 miles) or every
12 months, and add lubricant to
within 0 to 10 mm (0 to 0.4 inch) of
the bottom edge of the filler hole if
necessary. 24. POWER STEERING FLUID :
Replace power steering fluid every
24 months or 60 000 km
(37,500 miles), whichever occurs
first.
25. STEERING WHEEL FREE
PLAY :
Check steering wheel free
play after the first 1 040 km
(650 miles) and then every
10 400 km (6,500 miles).
Steering wheel free play
10-50 mm (0.39-1.97 in)
26. STEERING GEAR BOX
TORQUE : Retighten the fixing bolts
of the steering gear box to the
specified torque every 48 000 km
(30,000 miles). Specified tightening
torque.
Steering gear box tightening torque
102 Y(75 lb·ft)
27. DRIVESHAFT FLANGE
TORQUE : Check the fixing bolts of
driveshaft flange for looseness or
damage first 12 000 km
(7,500 miles). Retighten the fixing

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
376 Service and Maintenance
one side, unusual sounds when
braking, increased brake pedal
travel or harder pedal. The front and
rear brakes are attached to an auto
adjuster mechanism. If there are no
defects, as the pedal travel is
properly maintained, adjustments
are not necessary. Check regularly
that the brake fluid reservoir
(left-hand side of the instrument
panel) or HBB reservoir (5500HD,
5500XD models: left side behind the
cab) is properly filled and check for
fluid leaks. Any of these conditions
could indicate the need for brake
system inspection and/or service.
G: Exhaust System :Be alert for
any changes in the sound of the
exhaust system or any smell of
fumes. These are signs the system
may be leaking. Have it checked
and/or repaired at once. (Refer to
"Engine Exhaust Emissions Caution
(Carbon Monoxide)" under Engine
Exhaust 0178).
H: Windshield Wipers and
Washers : Check operation and
condition of the wiper blades. Check
the flow of the washer spray. I: Defroster :
Turn the outlet
selector knob to "Defroster" and the
fan speed control knob to the fully
clockwise position. Then check the
airflow from the ducts at the inside
base of the windshield.
J: Rearview Mirrors and Sun
Visors : Check that friction joints
hold mirrors and sun visors in place.
K: Horn : Sound the horn, now and
then, to be sure it works.
L: Lap-Shoulder Belts : Check the
seat belt system (including webbing,
buckles, latch plates and anchors)
for proper operation, and for
damage.
M: Seat Adjusters : When
adjusting the driver's manual seat,
be sure the seat adjusters latch by
pushing the seat forward and
backward. Do not attempt to adjust
the seat when the vehicle is in
motion.
N: Lamps : Check panel lighting,
warning lamps, indicator lamps and
interior lamps. On the outside,
check: license plate lamps, side
marker lamps, reflectors on outside mirrors, headlamps, parking lamps,
identification and clearance lamps,
taillights, brake lamps, turn signals,
cornering lamps, backup lamps and
hazard warning flashers. Have
headlamp aim checked immediately
if beams seem improperly aimed.
O: Glass, Mirrors, Lights and/or
Reflectors Condition :
Look for
broken, scratched, dirty or damaged
glass, mirrors, lamps or reflectors
that could reduce the view or
visibility, or cause injury. Replace,
clean or repair promptly.
P: Door Latches : Check that doors
close, latch and lock tightly. Check
for broken, damaged or missing
parts that might prevent tight
latching.
Q :Tilt Cab (Driving Position) : Be
sure the tilt lever is down and
locked.
R: Fluid Leaks : Check for fuel,
water, oil or other fluid leaks by
looking at the surface beneath the
vehicle after it has been parked for
a while. If you notice diesel fumes or
fluid at any time, have the cause
found and corrected at once.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
410 Index
Fuel (cont'd)Economy Driving . . . . . . . . . . . . . . . 29
Filling the Tank . . . . . . . . . . . . . . . 240
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 282
Foreign Countries . . . . . . . . . . . . 232
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . 81
Running out of Fuel . . . . . . . . . . . 238
Water in Fuel . . . . . . . . . . . . . . . . . 236
Fuel for Diesel Engines . . . . . . . . . 232
G
Gauges
Diesel Exhaust Fluid (DEF) . . . . . 83
Engine Coolant Temperature . . . 82
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
Odometer . . . . . . . . . . . . . . . . . . . . . . . 80
Speedometer . . . . . . . . . . . . . . . . . . . 80
Tachometer . . . . . . . . . . . . . . . . . . . . . 81
Trip Odometer . . . . . . . . . . . . . . . . . . 80
Warning Lights andIndicators . . . . . . . . . . . . . . . . . . . . . 76
General Information Vehicle Care . . . . . . . . . . . . . . . . . . 245
Getting In and Out of the
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 35
Glove Box . . . . . . . . . . . . . . . . . . . . . . . 61
GM Mobility Reimbursement Program . . . . . . . . . . . . . . . . . . . . . . . 400
H
Hazard Warning Flashers . . . . . . . 105
Headlamps
Aiming . . . . . . . . . . . . . . . . . . . . . . . . 288
Bulb Replacement . . . . . . . 288, 291
Daytime Running Lamps(DRL) Indicator Light . . . . . . . . . . 92
Flash-to-Pass . . . . . . . . . . . . . . . . . 104
High-Beam On Light . . . . . . . . . . . . 92
High/Low Beam Changer . . . . . 104
Heated Mirrors . . . . . . . . . . . . . . . . . . . 40
Heater Engine . . . . . . . . . . . . . . . . . . . . . . . . 173
Heating . . . . . . . . . . . . . . . . . . . . . . . . . 126
High Idle System . . . . . . . . . . . . . . . 174
High-Beam On Light . . . . . . . . . . . . . 92
Hill and Mountain Roads . . . . . . . . 144
Hooks Shopping Bag . . . . . . . . . . . . . . . . . . 64
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
HVAC . . . . . . . . . . . . . . . . . . . . . . . . . . . 126
I
Idle Shutdown . . . . . . . . . . . . . . . . . . 174
Ignition Positions . . . . . . . . . . . . . . . 163
Infants and Young Children, Restraints . . . . . . . . . . . . . . . . . . . . . . 57
Information on Loading the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 64 Instrument Cluster . . . . . . . . . . . . . . . 77
Instrument Panel
Storage Area . . . . . . . . . . . . . . . . . . . 61
Introduction . . . . . . . . . . . . . . . . . . . . . . . 2
J
Jump Starting - North America . . . . . . . . . . . . . . . . . . . . . . . 326
K
Keyless EntryRemote (RKE) System . . . . . . . . . 32
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
L
Lamps
Cargo . . . . . . . . . . . . . . . . . . . . . . . . . 107
Cornering . . . . . . . . . . . . . . . . . . . . . 106
Dome . . . . . . . . . . . . . . . . . . . . . . . . . 107
Exterior Controls . . . . . . . . . . . . . . 103
Interior . . . . . . . . . . . . . . . . . . . . . . . . 298
License Plate . . . . . . . . . . . . . . . . . 297
Malfunction Indicator (CheckEngine) . . . . . . . . . . . . . . . . . . . . . . . 84
Roofmarker . . . . . . . . . . . . . . . . . . . 295
Sidemarker . . . . . . . . . . . . . . . . . . . 295
Lap Belt . . . . . . . . . . . . . . . . . . . . . . . . . 53
Lighter, Cigarette . . . . . . . . . . . . . . . . 74
Lighting Illumination Control . . . . . . . . . . . 106

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Index 413
Storage Areas (cont'd)Information on Loading the
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . 64
Instrument Panel . . . . . . . . . . . . . . . 61
Storage Compartments . . . . . . . . . . 60
Stuck Vehicle . . . . . . . . . . . . . . . . . . . 148
Sun Visors . . . . . . . . . . . . . . . . . . . . . . . 43
System Noise Control . . . . . . . . . . . . . . . . . 284
T
Tachometer . . . . . . . . . . . . . . . . . . . . . . 81
TaillampsBulb Replacement . . . . . . . . . . . . 297
Temperature, Operating . . . . . . . . 172
Text Telephone (TTY) Users . . . . 399
Three-Point Seat Belt . . . . . . . . . . . . 51
Tires If a Tire Goes Flat . . . . . . . . . . . . 326
Pressure . . . . . . . . . . . . . . . . . . . . . . 322
Rotation . . . . . . . . . . . . . . . . . . . . . . 323
Tires and Wheels . . . . . . . . . . . . . . . 308
Towing Vehicle . . . . . . . . . . . . . . . . . . . . . . . 332
Trademarks and License Agreements . . . . . . . . . . . . . . . . . . . 125
Transmission Automatic . . . . . . . . . . . . . . . . . . . . . 204
Fluid, Automatic . . . . . . . . . . . . . . 260 Transmission (cont'd)
Overdrive Off, Automatic . . . . . . 215
Service Warning Light . . . . . . . . . . 88
Trip Odometer . . . . . . . . . . . . . . . . . . . 80
Turn and Lane-Change
Signals . . . . . . . . . . . . . . . . . . . . . . . . 105
Turn Signal Bulb Replacement . . . . . . . . . . . . 297
U
USB Port . . . . . . . . . . . . . . . . . . . . . . . 121
Using This Manual . . . . . . . . . . . . . . . . 3
V
VehicleControl . . . . . . . . . . . . . . . . . . . . . . . 133
Getting In and Out . . . . . . . . . . . . . . 35
Identification Number (VIN) . . . 383
Messages . . . . . . . . . . . . . . . . . . . . . . 97
Security . . . . . . . . . . . . . . . . . . . . . . . . 39
Service Soon Light . . . . . . . . . . . . . 84
Starting and Stopping . . . . 165, 168
Towing . . . . . . . . . . . . . . . . . . . . . . . . 332
Vehicle Care
Tire Pressure . . . . . . . . . . . . . . . . . 322
Vehicle Data Recording and Privacy . . . . . . . . . . . . . . . . . . . . . . . . 405
Ventilation, Air . . . . . . . . . . . . . . . . . . 129
Visors . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
W
Wait to Start Light . . . . . . . . . . . . . . . 89
Warning Brake System Light . . . . . . . . . . . . . 84
Caution and Danger . . . . . . . . . . . . . 3
Warning Buzzers . . . . . . . . . . . . . . . 101
Warning Lights, Gauges, and Indicators . . . . . . . . . . . . . . . . . . . . . . 76
Warnings Hazard Flashers . . . . . . . . . . . . . . 105
Washer Fluid . . . . . . . . . . . . . . . . . . . 274
Water in Fuel . . . . . . . . . . . . . . . . . . . 236
Wheels and Tires . . . . . . . . . . . . . . . 308
Windows Power . . . . . . . . . . . . . . . . . . . . . . . . . . 41
Windshield Wiper/Washer . . . . . . . . . . . . . . . . . . 73
Winter Driving . . . . . . . . . . . . . . . . . . . . . . . . 145
Winter Cover . . . . . . . . . . . . . . . . . . . 172
Wiper Blade Replacement . . . . . . 286