air condition CHEVROLET LOW CAB FORWARD 2017 Owner's Guide

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
376 Service and Maintenance
one side, unusual sounds when
braking, increased brake pedal
travel or harder pedal. The front and
rear brakes are attached to an auto
adjuster mechanism. If there are no
defects, as the pedal travel is
properly maintained, adjustments
are not necessary. Check regularly
that the brake fluid reservoir
(left-hand side of the instrument
panel) or HBB reservoir (5500HD,
5500XD models: left side behind the
cab) is properly filled and check for
fluid leaks. Any of these conditions
could indicate the need for brake
system inspection and/or service.
G: Exhaust System :Be alert for
any changes in the sound of the
exhaust system or any smell of
fumes. These are signs the system
may be leaking. Have it checked
and/or repaired at once. (Refer to
"Engine Exhaust Emissions Caution
(Carbon Monoxide)" under Engine
Exhaust 0178).
H: Windshield Wipers and
Washers : Check operation and
condition of the wiper blades. Check
the flow of the washer spray. I: Defroster :
Turn the outlet
selector knob to "Defroster" and the
fan speed control knob to the fully
clockwise position. Then check the
airflow from the ducts at the inside
base of the windshield.
J: Rearview Mirrors and Sun
Visors : Check that friction joints
hold mirrors and sun visors in place.
K: Horn : Sound the horn, now and
then, to be sure it works.
L: Lap-Shoulder Belts : Check the
seat belt system (including webbing,
buckles, latch plates and anchors)
for proper operation, and for
damage.
M: Seat Adjusters : When
adjusting the driver's manual seat,
be sure the seat adjusters latch by
pushing the seat forward and
backward. Do not attempt to adjust
the seat when the vehicle is in
motion.
N: Lamps : Check panel lighting,
warning lamps, indicator lamps and
interior lamps. On the outside,
check: license plate lamps, side
marker lamps, reflectors on outside mirrors, headlamps, parking lamps,
identification and clearance lamps,
taillights, brake lamps, turn signals,
cornering lamps, backup lamps and
hazard warning flashers. Have
headlamp aim checked immediately
if beams seem improperly aimed.
O: Glass, Mirrors, Lights and/or
Reflectors Condition :
Look for
broken, scratched, dirty or damaged
glass, mirrors, lamps or reflectors
that could reduce the view or
visibility, or cause injury. Replace,
clean or repair promptly.
P: Door Latches : Check that doors
close, latch and lock tightly. Check
for broken, damaged or missing
parts that might prevent tight
latching.
Q :Tilt Cab (Driving Position) : Be
sure the tilt lever is down and
locked.
R: Fluid Leaks : Check for fuel,
water, oil or other fluid leaks by
looking at the surface beneath the
vehicle after it has been parked for
a while. If you notice diesel fumes or
fluid at any time, have the cause
found and corrected at once.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
396 Technical Data
Engine Drive Belt Routing
Fan Belt and Air Conditioning
Compressor Belt
See theMaintenance Schedule
0 345.
3.0L L4 Engine (IZ3)
No. Name
1 Fan Pulley
2 Tension pulley
3 A/C compressor
4 A/C belt
5 Crank pulley
6 Idler No.
Name
7 Alternator
8 Fan belt
If your air conditioning system is
functioning properly, it is not
necessary to remove and replace
the refrigerant or compressor oil.
6.0L V8 Engine (L96)
No. Name
1 Fan belt idler pulley
2 Alternator
3 Vacuum pulley
4 Power steering pump pulley No.
Name
5 Cooling fan pulley
6 Crank pulley
7 A/C belt
8 A/C compressor
9 Fan belt
10 Fan belt tensioner
5.2L L4 Engine (I1B)
No. Name
1 Fan belt
2 Fan pulley
3 A/C belt

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Technical Data 397
No.Name
4 A/C compressor
5 Tension pulley
6 Crank pulley
7 Alternator
If your air conditioning system is
functioning properly, it is not
necessary to remove and replace
the refrigerant or compressor oil.
. A V-ribbed belt is used for the
fan belt. This type of belt
requires the tension to be
adjusted more accurately than is
required with the conventional V
belt. Inappropriate tension could
cause the belt to make noise or
break. When the fan belt is
damaged, electricity is not
properly generated or becomes
a cause of engine overheating.
You must check the tension of
the fan belt carefully.
. Use dealer-certified genuine
parts when changing the
fan belt. .
Have the vehicle inspected and
serviced at your dealer.
. The air conditioning drive belt,
if equipped, must be adjusted
after fan belt adjustment. If the
belt is not adjusted properly, the
A/C belt may experience
excessive tension, and possible
premature failure.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Index 407
IndexA
About Driving the Vehicle . . . . . . . . . 3
Accessories andModifications . . . . . . . . . . . . . . . . . . 245
Add-On Electrical Equipment . . . 241
Additional Maintenance
and Care . . . . . . . . . . . . . . . . . . . . . . 375
Adjustments Seat, Initial Drive . . . . . . . . . . . . . . . 44
Agreements
Trademarks and License . . . . . 125
Air Cleaner/Filter, Engine . . . . . . . 263
Air Conditioning . . . . . . . . . . . . . . . . 126
Air Filter, Passenger Compartment . . . . . . . . . . . . . . . . . 130
Air Vents . . . . . . . . . . . . . . . . . . . . . . . 129
AM-FM Radio . . . . . . . . . . . . . . . . . . . 108
Antenna Fixed Mast . . . . . . . . . . . . . . . . . . . .113
Antilock Brake System (ABS) . . . 217 Warning Light . . . . . . . . . . . . . . . . . . . 87
Appearance Care Exterior . . . . . . . . . . . . . . . . . . . . . . . 334
Interior . . . . . . . . . . . . . . . . . . . . . . . . 340
Ashtrays . . . . . . . . . . . . . . . . . . . . . . . . . 75
Assistance Program, Roadside . . . . . . . . . . . . . . . . . . . . . . 400 Audio Players
CD . . . . . . . . . . . . . . . . . . . . . . . . . . . .114
Automatic Transmission . . . . . . . . . . . . . . . . . 204
Transmission Fluid . . . . . . . . . . . 260
Automatic Transmission Selector Lever . . . . . . . . . . . . . . . . 214
Shift Lock Control Function
Check . . . . . . . . . . . . . . . . . . . . . . . 285
Automatic Transmission Fluid Temperature Warning Light . . . . . 88
Automatic Transmission Overdrive Off . . . . . . . . . . . . . . . . . . 215
Auxiliary Devices . . . . . . . . . . . . . . . . . . . . . . . 124
Axle, Rear . . . . . . . . . . . . . . . . . . . . . . 283
B
Battery . . . . . . . . . . . . . . . . . . . . . . . . . 281
Battery - North America . . . . . . . . . 326
Battery Warning Light . . . . . . . . . . . . 83
Biodiesel . . . . . . . . . . . . . . . . . . . . . . . 233
Blade Replacement, Wiper . . . . . 286
Brake
Exhaust . . . . . . . . . . . . . . . . . . . . . . 222
System Warning Light . . . . . . . . . . 84
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . 275 Antilock . . . . . . . . . . . . . . . . . . . . . . . 217
Exhaust Light . . . . . . . . . . . . . . . . . . . 88

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
408 Index
Brakes (cont'd)Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 280
Parking . . . . . . . . . . . . . . . . . . . . . . . 221
Braking . . . . . . . . . . . . . . . . . . . . . . . . . 137
Break-In, New Vehicle . . . . . . . . . . 162
Bulb Replacement
Headlamp Aiming . . . . . . . . . . . . . 288
Headlamps . . . . . . . . . . . . . . . . . . . 288
Headlamps and Front TurnSignal . . . . . . . . . . . . . . . . . . . . . . . 291
Interior Lamps . . . . . . . . . . . . . . . . 298
License Plate Lamps . . . . . . . . . 297
Roofmarker Lamps . . . . . . . . . . . 295
Sidemarker Lamps . . . . . . . . . . . 295
Taillamps, Turn Signal, Stoplamps, and Back-up
Lamps . . . . . . . . . . . . . . . . . . . . . . 297
Buzzers, Warning . . . . . . . . . . . . . . . 101
C
Cab Tilting . . . . . . . . . . . . . . . . . . . . . . 247
California
Perchlorate MaterialsRequirements . . . . . . . . . . . . . . . 245
California Proposition 65 Warning . . . . . . . . . . . . . . . 245, 326
Capacities and Specifications . . . . . . . . . . . . . . . . . 389 Carbon Monoxide
Engine Exhaust . . . . . . . . . . . . . . . 178
Winter Driving . . . . . . . . . . . . . . . . 145
Cargo Lamp . . . . . . . . . . . . . . . . . . . . 107
Caution, Danger, and Warning . . . . 3
CD Player . . . . . . . . . . . . . . . . . . . . . . 114
Check Engine Light (MalfunctionIndicator) . . . . . . . . . . . . . . . . . . . . . . 84
Child Restraints Infants and Young Children . . . . . 57
Systems . . . . . . . . . . . . . . . . . . . . . . . . 57
Cigarette Lighter . . . . . . . . . . . . . . . . . 74
Cleaning Exterior Care . . . . . . . . . . . . . . . . . 334
Interior Care . . . . . . . . . . . . . . . . . . 340
Climate Control Systems . . . . . . . 126 Air Conditioning . . . . . . . . . . . . . . 126
Heating . . . . . . . . . . . . . . . . . . . . . . . 126
Cluster, Instrument . . . . . . . . . . . . . . 77
Cold Weather Operation . . . . . . . . 235
Collision Damage Repair . . . . . . . 401
Compartments Storage . . . . . . . . . . . . . . . . . . . . . . . . . 60
Control of a Vehicle . . . . . . . . . . . . . 133
Coolant
Engine . . . . . . . . . . . . . . . . . . . . . . . . 263
Engine Temperature Gauge . . . . 82 Cooling . . . . . . . . . . . . . . . . . . . . . . . . . 126
Cornering Lamps . . . . . . . . . . . . . . . 106
Cover
Engine . . . . . . . . . . . . . . . . . . . . . . . . 250
Covers Winter . . . . . . . . . . . . . . . . . . . . . . . . 172
Cruise Control . . . . . . . . . . . . . 224, 227
Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92
Cupholders . . . . . . . . . . . . . . . . . . . . . . 62
Customer Assistance . . . . . . . . . . . 399 Offices . . . . . . . . . . . . . . . . . . . . . . . . 399
Text Telephone (TTY)
Users . . . . . . . . . . . . . . . . . . . . . . . 399
Customer Information Service PublicationsOrdering Information . . . . . . . . 403
Customer Satisfaction Procedure . . . . . . . . . . . . . . . . . . . . . 398
D
Damage Repair, Collision . . . . . . . 401
Danger, Warning, and Caution . . . . 3
Daytime Running Lamps (DRL)Indicator Light . . . . . . . . . . . . . . . . . . 92
Devices Auxiliary . . . . . . . . . . . . . . . . . . . . . . 124
Diesel Engine Engine Alarm andAutomatic Shutdown . . . . . . . . 174