air filter CHEVROLET LOW CAB FORWARD 2018 Owner's Guide

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
314 Service and Maintenance
12. Engine Coolant :Inspect the
engine coolant every 12 months.
Replace the engine coolant every
24 months, drain the engine coolant
by opening the drain plug at the
bottom of the radiator core, flush
and refill the engine cooling system
with a new engine coolant. Refer to
"Preparing Engine Coolant" in
Engine Coolant 0231. Have the
Engine Coolant replaced by your
authorized dealer.
13. Exhaust System : Check the
complete exhaust system every
16 000 km (10,000 miles). Check
body areas near the exhaust
system. Look for broken, damaged,
missing, or out-of-position parts.
Also inspect for open seams, holes,
loose connections, or other
conditions which could cause heat
build-up at the rear body floor pan,
or could let exhaust fumes seep into
the passenger compartment. Dust
or water in the cabin may indicate a
leak in that area. Required repairs
should be made at once. 14. DPF (Clean Filter) :
Clean the
filter every 160 000 km
(100,000 miles) or 3,000 hours
whichever occurs first.
15. DPF (Pressure Difference
Sensor 0 Point Adjustment) :
Adjust the sensor every 160 000 km
(100,000 miles) or 3,000 hours
whichever occurs first.
16. DPF (Pressure Difference
Sensor Hose) : Inspect the sensor
hose every 160 000 km
(100,000 miles) or 3,000 hours
whichever occurs first. Replace the
sensor hose every 400 000 km
(250,000 miles).
17. Fuel Line System : Inspect the
fuel tank, cap and lines for damage
which could cause leakage every
16 000 km (10,000 miles). Inspect
fuel cap for correct sealing ability
and indications of physical damage.
Replace any damaged or
malfunctioning parts.
18. Brake Lining and Pad for
Wear : Check drum brake lining and
disc brake pad for wear or cracks
every 16 000 km (10,000 miles).
Check brakes (including parking brake) more often if operating
conditions or driving habits result in
frequent braking.
Front disc brakes have built-in wear
noise indicators which are designed
to make a high pitched squeal or
cricket-like warning sound when the
brake pads are worn to the point
where new pads are needed.
When the truck is in motion, the
sound may be constant or it may
come and go. Pressing the brake
pedal firmly may cause the sound
to stop.
Have the brake linings or the brake
pads replaced by your authorized
dealer as soon as possible after the
warning first becomes evident.
Failure to do so can result in
expensive damage to the brake
system or a serious accident.
19. Brake Drum and Rotor for
Wear and Damage :
Check brake
drums (rear and parking) and rotors
(front) for wear or damage every
32 000 km (20,000 miles) or
12 months whichever occurs first.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
316 Service and Maintenance
33. Leaf Spring U-bolt Torque :
Tighten the U-Bolt nuts to the
specified torque after the first
1 040 km (650 miles), thereafter
every 16 000 km (10,000 miles).Model Leaf spring U-bolt nut tightening torque
Front Rear
4500HD 127 Y
(94 lb·ft) 177
Y
(131 lb·ft)
4500XD 196 Y
(145lb·ft) 177
Y
(131 lb·ft)
5500HD, 5500XD 196
Y
(145lb·ft) 284
Y
(209 lb·ft)
34. Wheel Nut Torque : Check tires
for excessive or abnormal wear,
or damage. Also check tire inflation
pressures and adjust.
Be sure wheels are not bent or
cracked and that wheel nuts have
been tightened to the specified
torque after the first 1,040 km
(650 miles) and then every
10 400 km (6,500 miles). Note that
there are left and right hand
threads. Wheel nut tightening torque
500Y(362 lb·ft)
35. King Pin : Lubricate the grease
fitting on the king pins every
12 months or 16 000 km
(10,000 miles) whichever occurs
first.
36. Wheel Hub Bearing Grease :
Clean and repack front wheel
bearings every 24 months or
48 000 km (30,000 miles) whichever
occurs first.
37. Air Conditioner Blower
Filter : The air conditioner blower
filter should be removed and
cleaned once a month.
38. Exhaust Injector : Clean the
exhaust injector every 176,000 km
(110,000 miles).
39. DEF Supply Pump Filter
Element : Replace the DEF supply
pump filter element every
192 000 km (120,000 miles) or
24 months whichever occurs first. 40. Starter :
The color displayed by
the starter indicator light will change
from green to amber when the
number of times remaining is 0 or
below and the screen is selected.
When the indicator light (amber)
comes on, have the vehicle
inspected/serviced at the nearest
dealer.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
Service and Maintenance 329
5.2L Diesel
PartGM Part Number
Engine Air Cleaner 98177271
Engine Oil Filter 98298404
Fuel Filter: Engine Side 98147525
Fuel Filter: Chassis Side 98037481
Replacement Fasteners
During vehicle maintenance, any
fasteners used to replace older
ones must have the same
measurements and strength as
those removed, whether metric or
customary. Fasteners taken from
the vehicle should be saved for
reuse in the same location when
possible. Where a fastener cannot
be used again, take care to choose
a replacement that matches the old
one. For information and help, see
your dealer.{Warning
This vehicle is primarily
dimensioned in the metric system.
Most fasteners are metric and
many are very close in dimension
to well-known customary
fasteners in the inch system.
Mismatched or incorrect fasteners
can result in damage to the
vehicle or possibly personal
injury.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
Index 351
IndexA
Accessories and Modifica-tions . . . . . . . . . . . . . . . . . . . . . . . . . . 218
Add-On Electrical Equipment . . . 215
Additional Maintenance and Care . . . . . . . . . . . . . . . . . . . . . . 323
Adjustments Seat, Initial Drive . . . . . . . . . . . . . . . 38
Agreements Trademarks and License . . . . . .114
Air Cleaner/Filter, Engine . . . . . . . 231
Air Conditioning . . . . . . . . . . . . . . . . 115
Air Filter, Passenger Com- partment . . . . . . . . . . . . . . . . . . . . . . 119
Air Vents . . . . . . . . . . . . . . . . . . . . . . . 118
AM-FM Radio . . . . . . . . . . . . . . . . . . . . 97
Antenna Fixed Mast . . . . . . . . . . . . . . . . . . . 102
Antilock Brake System (ABS) . . . 196
Warning Light . . . . . . . . . . . . . . . . . . . 77
Appearance Care Exterior . . . . . . . . . . . . . . . . . . . . . . . 293
Interior . . . . . . . . . . . . . . . . . . . . . . . . 299
Ashtrays . . . . . . . . . . . . . . . . . . . . . . . . . 68
Assistance Program,
Roadside . . . . . . . . . . . . . . . . . . . . . . 344
Audio Players CD . . . . . . . . . . . . . . . . . . . . . . . . . . . 103 Automatic
Transmission . . . . . . . . . . . . . . . . . 185
Transmission Fluid . . . . . . . . . . . 229
Automatic Transmission Selector Lever . . . . . . . . . . . . . . . . 194
Shift Lock Control FunctionCheck . . . . . . . . . . . . . . . . . . . . . . . 251
Automatic Transmission Fluid Temperature Warning Light . . . . . 78
Automatic Transmission Overdrive Off . . . . . . . . . . . . . . . . . . 195
Auxiliary Devices . . . . . . . . . . . . . . . . . . . . . . . .113
Axle, Rear . . . . . . . . . . . . . . . . . . . . . . 249
B
Battery . . . . . . . . . . . . . . . . . . . . . . . . . 247
Battery - North America . . . . . . . . . 287
Battery Warning Light . . . . . . . . . . . . 73
Biodiesel . . . . . . . . . . . . . . . . . . . . . . . 207
Blade Replacement, Wiper . . . . . 252
Brake Exhaust . . . . . . . . . . . . . . . . . . . . . . 201
System Warning Light . . . . . . . . . . 75
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . 242 Antilock . . . . . . . . . . . . . . . . . . . . . . . 196
Exhaust Light . . . . . . . . . . . . . . . . . . . 78
Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 246
Parking . . . . . . . . . . . . . . . . . . . . . . . 200

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
Index 353
Diesel Exhaust Fluid (DEF)Warning Light . . . . . . . . . . . . . . . . . . 80
Diesel Particulate Filter . . . . . . . . . 161
Distracted Driving . . . . . . . . . . . . . . . 122
Dome Lamps . . . . . . . . . . . . . . . . . . . . 96
Door Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Power Locks . . . . . . . . . . . . . . . . . . . . 33
Drive Belt Routing, Engine . . . . . . 341
Driver Behavior . . . . . . . . . . . . . . . . . 122
Driver Information Cen- ter (DIC) . . . . . . . . . . . . . . . . . . . . . . . 82
Driving Emergencies . . . . . . . . . . . . 137, 146
For Better Fuel Economy . . . . . . . 23
Hill and Mountain Roads . . . . . . 132
If the Vehicle is Stuck . . . . . . . . . 136
Wet Roads . . . . . . . . . . . . . . . . . . . 132
Winter . . . . . . . . . . . . . . . . . . . . . . . . 133
E
Electrical Equipment,Add-On . . . . . . . . . . . . . . . . . . . . . . . 215
Electrical System Overload . . . . . . . . . . . . . . . . . . . . . 264
Emergencies . . . . . . . . . . . . . . 137, 146
Engine
Air Cleaner/Filter . . . . . . . . . . . . . 231 Engine (cont'd)
Alarm and Automatic
Shutdown . . . . . . . . . . . . . . . . . . . 155
Check Light (Malfunction In-
dicator) . . . . . . . . . . . . . . . . . . . . . . . . 74
Checks Before Operating . . . . . 156
Compartment Overview . . . . . . . 222
Coolant . . . . . . . . . . . . . . . . . . . . . . . 231
Coolant Temperature Gauge . . . . 72
Cover . . . . . . . . . . . . . . . . . . . . . . . . . 222
Drive Belt Routing . . . . . . . . . . . . 341
Exhaust . . . . . . . . . . . . . . . . . . . . . . 159
Heater . . . . . . . . . . . . . . . . . . . . . . . . 154
High Idle System . . . . . . . . . . . . . 155
Oil Pressure Light . . . . . . . . . . . . . . 79
Overheating . . . . . . . . . . . . . . . . . . 237
Reduced Power Light . . . . . . . . . . . 81
Running While Parked . . . . . . . . 160
Shutdown Warning Light . . . . . . . . 80
Engine Oil Level Indicator Light . . . . . . . . . . . . 80
Engines Diesel Fuel . . . . . . . . . . . . . . . . . . . 206
Exhaust Brake . . . . . . . . . . . . . . . . . . 201
Exhaust Brake Light . . . . . . . . . . . . . 78
Exhaust Fluid Diesel . . . . . . . . . . . . . . . . . . . . . . . . 170
Extender, Seat Belt . . . . . . . . . . . . . . 49 Exterior Lamp Controls . . . . . . . . . . 92
F
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 161
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 248
Filter, Engine Air Cleaner . . . . . . . . . . . 231
Fixed Mast Antenna . . . . . . . . . . . . 102
Flash-to-Pass . . . . . . . . . . . . . . . . . . . . 93
Flashers, Hazard Warning . . . . . . . 94
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 287
Fluid Automatic Transmission . . . . . . 229
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 246
Diesel Exhaust . . . . . . . . . . . . . . . . . 24
Power Steering . . . . . . . . . . . . . . . 240
Washer . . . . . . . . . . . . . . . . . . . . . . . 241
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 348
Front Seat Position Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 38
Fuel Biodiesel . . . . . . . . . . . . . . . . . . . . . 207
Cold Weather Operation . . . . . . 209
Diesel Engines . . . . . . . . . . . . . . . 206
Economy Driving . . . . . . . . . . . . . . . 23
Filling the Tank . . . . . . . . . . . . . . . 213
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 248
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . 72

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
Index 355
Lights (cont'd)Automatic Transmission
Fluid Temperature . . . . . . . . . . . . . 78
Battery Warning . . . . . . . . . . . . . . . . 73
Brake System Warning . . . . . . . . . 75
Check Engine (Malfunction
Indicator) . . . . . . . . . . . . . . . . . . . . . . 74
Cruise Control . . . . . . . . . . . . . . . . . . 82
Daytime Running Lamps (DRL) . . . . . . . . . . . . . . . . . . 82
Diesel Exhaust Fluid (DEF) . . . . . 80
Engine Oil Level Indicator . . . . . . 80
Engine Oil Pressure . . . . . . . . . . . . 79
Engine Shutdown Warning . . . . . 80
Exhaust Brake . . . . . . . . . . . . . . . . . . 78
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 93
High-Beam On . . . . . . . . . . . . . . . . . . 81
High/Low Beam Changer . . . . . . . 93
Idle Shutdown . . . . . . . . . . . . . . . . . . 81
Overdrive Off . . . . . . . . . . . . . . . . . . . 79
Reduced Engine Power . . . . . . . . 81
Seat Belt Reminders . . . . . . . . . . . . 73
Service Transmission Warning . . . . . . . . . . . . . . . . . . . . . . . 78
Service Vehicle Soon . . . . . . . . . . . 74
Wait to Start . . . . . . . . . . . . . . . . . . . . 79
Loading the Vehicle . . . . . . . . . . . . . . 58 Locks
Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Power Door . . . . . . . . . . . . . . . . . . . . . 33
M
Maintenance and CareAdditional . . . . . . . . . . . . . . . . . . . . . 323
Maintenance Schedule . . . . . . . . . 303 Recommended Fluids andLubricants . . . . . . . . . . . . . . . . . . . 326
Malfunction Indicator Lamp . . . . . . 74
Messages Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 86
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . 33 Heated . . . . . . . . . . . . . . . . . . . . . . . . . 34
N
New Vehicle Break-In . . . . . . . . . . . 147
Noise Control System . . . . . . . . . . 250
O
Odometer . . . . . . . . . . . . . . . . . . . . . . . . 71Trip . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Oil Engine . . . . . . . . . . . . . . . . . . . . . . . . 223
Pressure Light . . . . . . . . . . . . . . . . . . 79
Online Owner Center . . . . . . . . . . . 343
Operating Temperature . . . . . . . . . 153
Ordering Service Publications . . . . . . . . . . 347 Outlets
Power . . . . . . . . . . . . . . . . . . . . . . . . . . 67
Overdrive Off . . . . . . . . . . . . . . . . . . . 195
Overdrive Off Light . . . . . . . . . . . . . . 79
Overheating, Engine . . . . . . . . . . . . 237
Owner Checks and Services . . . . 317
P
Parking Brake . . . . . . . . . . . . . . . . . . . . . . . . . 200
Over Things That Burn . . . . . . . 157
Passenger Compartment Air
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 119
Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . 148
Perchlorate Materials Re- quirements, California . . . . . . . . . 218
Port
USB . . . . . . . . . . . . . . . . . . . . . . . . . . .110
Power Door Locks . . . . . . . . . . . . . . . . . . . . . 33
Outlets . . . . . . . . . . . . . . . . . . . . . . . . . 67
Reduced Engine Light . . . . . . . . . . 81
Steering Fluid . . . . . . . . . . . . . . . . . 240
Windows . . . . . . . . . . . . . . . . . . . . . . . 35
Power Take-Off (PTO) . . . . . . . . . . 215
Pregnancy, Using Seat Belts . . . . 47
Privacy Vehicle Data Recording . . . . . . . 349