oil temperature CHEVROLET LOW CAB FORWARD 2019 Owner's Guide

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
Service and Maintenance 329
.Frequent short trips of less than
16 kilometers (10 miles) in sub-
freezing temperatures
. Frequent and extended low-
speed engine operation (door-
to- door deliveries, stop- and- go
traffic, etc.)
. Driving on unpaved roads with
heavy dust
. Towing a trailer
Power Take Off (PTO) and
Extended Idle Use
When the vehicle is used with the
PTO equipment or used in a way
that requires extended idle time,
one hour of use shall be deemed
the same as 33 miles. See Driver
Information Center (DIC) 082 for
hourmeter.
Preventive Maintenance
As any mechanical device operates,
a certain amount of wear occurs.
The amount of wear depends on
certain variables –type and method
of operation and the schedule of
maintenance. These variables may be emphasized as critical to
malfunction but each is dependent
upon the other. For example, if a
vehicle is repeatedly overloaded,
driven at excessive speed or
improperly shifted, no schedule of
maintenance can prevent
malfunction. Also, if a preventive
maintenance schedule is not
followed, or is improperly carried
out, no amount of correct vehicle
operation will prevent malfunction.
If vehicle application, operation and
preventive maintenance schedules
and procedures are followed and
properly carried out, the life of the
vehicle will be greatly extended.
For example, regular attention to the
engine oil is essential. The oil level
must be periodically checked and oil
added whenever needed. Also, the
oil should be changed at the
intervals specified with the proper
quality and viscosity of oil. If your
engine should run excessively low
on oil or if the oil has lost its
lubricating qualities because of old
age, serious engine damage could
occur.
Maintenance Schedule Table
Letters Used to Indicate
Maintenance Service Types
I :
Inspect then clean, repair or
replace as necessary
A : Adjust
R : Replace
T : Tighten to the specified torque
L : Lubricate
C : Clean

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
Index 375
DevicesAuxiliary . . . . . . . . . . . . . . . . . . . . . . .117
Diesel Engine Engine Alarm andAutomatic Shutdown . . . . . . . . 173
Diesel Exhaust Fluid . . . . . . . . 24, 189
Diesel Exhaust Fluid (DEF) Gauge . . . . . . . . . . . . . . . . . . . . . . . . . 72
Diesel Exhaust Fluid (DEF) Warning Light . . . . . . . . . . . . . . . . . . 80
Diesel Particulate Filter . . . . . . . . . 180
Distracted Driving . . . . . . . . . . . . . . . 139
Dome Lamps . . . . . . . . . . . . . . . . . . . . 96
Door
Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Power Locks . . . . . . . . . . . . . . . . . . . . 33
Drive Belt Routing, Engine . . . . . . 363
Driver Behavior . . . . . . . . . . . . . . . . . 139
Driver Information Center (DIC) . . . . . . . . . . . . . . . . . . . 82
Driving
Emergencies . . . . . . . . . . . . 154, 164
For Better Fuel Economy . . . . . . . 24
Hill and Mountain Roads . . . . . . 150
If the Vehicle is Stuck . . . . . . . . . 153
Wet Roads . . . . . . . . . . . . . . . . . . . 149
Winter . . . . . . . . . . . . . . . . . . . . . . . . 151E
Electrical Equipment,Add-On . . . . . . . . . . . . . . . . . . . . . . . 236
Electrical System Overload . . . . . . . . . . . . . . . . . . . . . 287
Emergencies . . . . . . . . . . . . . . 154, 164
Engine Air Cleaner/Filter . . . . . . . . . . . . . 253
Alarm and AutomaticShutdown . . . . . . . . . . . . . . . . . . . 173
Check Light (Malfunction Indicator) . . . . . . . . . . . . . . . . . . . . . . 73
Checks Before Operating . . . . . 175
Compartment Overview . . . . . . . 244
Coolant . . . . . . . . . . . . . . . . . . . . . . . 253
Coolant Temperature Gauge . . . . 72
Cover . . . . . . . . . . . . . . . . . . . . . . . . . 245
Drive Belt Routing . . . . . . . . . . . . 363
Exhaust . . . . . . . . . . . . . . . . . . . . . . 177
Heater . . . . . . . . . . . . . . . . . . . . . . . . 172
High Idle System . . . . . . . . . . . . . 174
Oil Pressure Light . . . . . . . . . . . . . . 79
Overheating . . . . . . . . . . . . . . . . . . 259
Reduced Power Light . . . . . . . . . . . 81
Running While Parked . . . . . . . . 179
Shutdown Warning Light . . . . . . . . 80
Engine Oil Level Indicator Light . . . . . . . . . . . . 79 Engines
Diesel Fuel . . . . . . . . . . . . . . . . . . . 227
Exhaust Brake . . . . . . . . . . . . . . . . . . 222
Exhaust Brake Light . . . . . . . . . . . . . 77
Exhaust Fluid Diesel . . . . . . . . . . . . . . . . . . . . . . . . 189
Extender, Seat Belt . . . . . . . . . . . . . . 49
Exterior Lamp Controls . . . . . . . . . . 92
F
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 180 Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 270
Filter, Engine Air Cleaner . . . . . . . . . . . 253
Fixed Mast Antenna . . . . . . . . . . . . 102
Flash-to-Pass . . . . . . . . . . . . . . . . . . . . 93
Flashers, Hazard Warning . . . . . . . 94
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 310
Fluid Automatic Transmission . . . . . . 251
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 268
Diesel Exhaust . . . . . . . . . . . . . . . . . 24
Power Steering . . . . . . . . . . . . . . . 262
Washer . . . . . . . . . . . . . . . . . . . . . . . 262
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 370
Front Seat Position Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 38

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
Index 377
Lamps (cont'd)License Plate . . . . . . . . . . . . . . . . . 286
Malfunction Indicator (Check
Engine) . . . . . . . . . . . . . . . . . . . . . . . 73
Roofmarker . . . . . . . . . . . . . . . . . . . 284
Sidemarker . . . . . . . . . . . . . . . . . . . 284
Lap Belt . . . . . . . . . . . . . . . . . . . . . . . . . 48
Lighting Illumination Control . . . . . . . . . . . . . 95
Lights Antilock Brake System(ABS) Warning . . . . . . . . . . . . . . . . 76
Automatic Transmission Fluid Temperature . . . . . . . . . . . . . 78
Battery Warning . . . . . . . . . . . . . . . . 73
Brake System Warning . . . . . . . . . 74
Check Engine (Malfunction Indicator) . . . . . . . . . . . . . . . . . . . . . . 73
Cruise Control . . . . . . . . . . . . . . . . . . 82
Daytime Running Lamps (DRL) . . . . . . . . . . . . . . . . . . 81
Diesel Exhaust Fluid (DEF) . . . . . 80
Engine Oil Level Indicator . . . . . . 79
Engine Oil Pressure . . . . . . . . . . . . 79
Engine Shutdown Warning . . . . . 80
Exhaust Brake . . . . . . . . . . . . . . . . . . 77
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 93
High-Beam On . . . . . . . . . . . . . . . . . . 81 Lights (cont'd)
High/Low Beam Changer . . . . . . . 93
Idle Shutdown . . . . . . . . . . . . . . . . . . 80
Overdrive Off . . . . . . . . . . . . . . . . . . . 78
Reduced Engine Power . . . . . . . . 81
Seat Belt Reminders . . . . . . . . . . . . 72
Service Transmission
Warning . . . . . . . . . . . . . . . . . . . . . . . 77
Service Vehicle Soon . . . . . . . . . . . 74
Wait to Start . . . . . . . . . . . . . . . . . . . . 79
Loading the Vehicle . . . . . . . . . . . . . . 58
Locks Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Power Door . . . . . . . . . . . . . . . . . . . . . 33
M
Maintenance and CareAdditional . . . . . . . . . . . . . . . . . . . . . 346
Maintenance Schedule . . . . . . . . . 327
Recommended Fluids andLubricants . . . . . . . . . . . . . . . . . . . 349
Malfunction Indicator Lamp . . . . . . 73
Messages Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 86
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . 33 Heated . . . . . . . . . . . . . . . . . . . . . . . . . 34
N
New Vehicle Break-In . . . . . . . . . . . 165
Noise Control System . . . . . . . . . . 272
O
Odometer . . . . . . . . . . . . . . . . . . . . . . . . 70Trip . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70
Oil Engine . . . . . . . . . . . . . . . . . . . . . . . . 245
Pressure Light . . . . . . . . . . . . . . . . . . 79
Online Owner Center . . . . . . . . . . . 365
Operating Temperature . . . . . . . . . 171
Outlets
Power . . . . . . . . . . . . . . . . . . . . . . . . . . 67
Overdrive Off . . . . . . . . . . . . . . . . . . . 215
Overdrive Off Light . . . . . . . . . . . . . . 78
Overheating, Engine . . . . . . . . . . . . 259
Owner Checks and Services . . . . 340
P
Parking
Brake . . . . . . . . . . . . . . . . . . . . . . . . . 220
Over Things That Burn . . . . . . . 176
Passenger Compartment Air Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 135
Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . 166
Perchlorate Materials Requirements, California . . . . . . 240