fuel filter CHEVROLET LOW CAB FORWARD 2019 Owner's Guide
[x] Cancel search | Manufacturer: CHEVROLET, Model Year: 2019, Model line: LOW CAB FORWARD, Model: CHEVROLET LOW CAB FORWARD 2019Pages: 382, PDF Size: 5.95 MB
Page 353 of 382

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
352 Service and Maintenance
5.2L Diesel
PartGM Part Number
Engine Air Cleaner 97780479
Engine Oil Filter 98298404
Fuel Filter: Engine Side 98147525
Fuel Filter: Chassis Side 98037481
Replacement Fasteners
During vehicle maintenance, any
fasteners used to replace older
ones must have the same
measurements and strength as
those removed, whether metric or
customary. Fasteners taken from
the vehicle should be saved for
reuse in the same location when
possible. Where a fastener cannot
be used again, take care to choose
a replacement that matches the old
one. For information and help, see
your dealer.{Warning
This vehicle is primarily
dimensioned in the metric system.
Most fasteners are metric and
many are very close in dimension
to well-known customary
fasteners in the inch system.
Mismatched or incorrect fasteners
can result in damage to the
vehicle or possibly personal
injury.
Page 363 of 382

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
362 Technical Data
Parking Brake
Lever effective stroke (Under pull force of approx. 147 N (15 kg/33 lb) 6–8 notches
Electrical System
Battery type [BCI size] (RC-CCA) x No. of units 31T (160–750) x 2
*7
Starter
12 V/3.0 kw
Alternator 12 V/140 amp
Tightening Torque
Oil pan drain plug 83.3Y(8.5 kgf m/61.0 lb ft)
Oil filter drain plug —
Oil filter —
Oil filter cartridge 63.7Y(6.5 kgf m/47.0 lb ft)
Remarks:
*1see Engine Oil 0245.
Remarks:*2see Engine Coolant 0253.
Remarks:*3see Automatic Transmission Fluid 0251.
Remarks:*4see Rear Axle (Gear Oil Viscosity Chart) 0271 orRear Axle (Oil Level Check) 0272.
Remarks:*5only for vehicles equipped with optional limited slip differential.
Remarks:*6The fuel tank capacity is stated on a metal plate attached to the fuel tank body. Only fill the tank to
95 percent of its capacity; this allows room for the expansion of the fuel.
Remarks:
*7larger capacity batteries 31 (180-930) × 2 can also be used. However, do not mix batteries of different
types and from different makers.
Page 376 of 382

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
Index 375
DevicesAuxiliary . . . . . . . . . . . . . . . . . . . . . . .117
Diesel Engine Engine Alarm andAutomatic Shutdown . . . . . . . . 173
Diesel Exhaust Fluid . . . . . . . . 24, 189
Diesel Exhaust Fluid (DEF) Gauge . . . . . . . . . . . . . . . . . . . . . . . . . 72
Diesel Exhaust Fluid (DEF) Warning Light . . . . . . . . . . . . . . . . . . 80
Diesel Particulate Filter . . . . . . . . . 180
Distracted Driving . . . . . . . . . . . . . . . 139
Dome Lamps . . . . . . . . . . . . . . . . . . . . 96
Door
Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Power Locks . . . . . . . . . . . . . . . . . . . . 33
Drive Belt Routing, Engine . . . . . . 363
Driver Behavior . . . . . . . . . . . . . . . . . 139
Driver Information Center (DIC) . . . . . . . . . . . . . . . . . . . 82
Driving
Emergencies . . . . . . . . . . . . 154, 164
For Better Fuel Economy . . . . . . . 24
Hill and Mountain Roads . . . . . . 150
If the Vehicle is Stuck . . . . . . . . . 153
Wet Roads . . . . . . . . . . . . . . . . . . . 149
Winter . . . . . . . . . . . . . . . . . . . . . . . . 151E
Electrical Equipment,Add-On . . . . . . . . . . . . . . . . . . . . . . . 236
Electrical System Overload . . . . . . . . . . . . . . . . . . . . . 287
Emergencies . . . . . . . . . . . . . . 154, 164
Engine Air Cleaner/Filter . . . . . . . . . . . . . 253
Alarm and AutomaticShutdown . . . . . . . . . . . . . . . . . . . 173
Check Light (Malfunction Indicator) . . . . . . . . . . . . . . . . . . . . . . 73
Checks Before Operating . . . . . 175
Compartment Overview . . . . . . . 244
Coolant . . . . . . . . . . . . . . . . . . . . . . . 253
Coolant Temperature Gauge . . . . 72
Cover . . . . . . . . . . . . . . . . . . . . . . . . . 245
Drive Belt Routing . . . . . . . . . . . . 363
Exhaust . . . . . . . . . . . . . . . . . . . . . . 177
Heater . . . . . . . . . . . . . . . . . . . . . . . . 172
High Idle System . . . . . . . . . . . . . 174
Oil Pressure Light . . . . . . . . . . . . . . 79
Overheating . . . . . . . . . . . . . . . . . . 259
Reduced Power Light . . . . . . . . . . . 81
Running While Parked . . . . . . . . 179
Shutdown Warning Light . . . . . . . . 80
Engine Oil Level Indicator Light . . . . . . . . . . . . 79 Engines
Diesel Fuel . . . . . . . . . . . . . . . . . . . 227
Exhaust Brake . . . . . . . . . . . . . . . . . . 222
Exhaust Brake Light . . . . . . . . . . . . . 77
Exhaust Fluid Diesel . . . . . . . . . . . . . . . . . . . . . . . . 189
Extender, Seat Belt . . . . . . . . . . . . . . 49
Exterior Lamp Controls . . . . . . . . . . 92
F
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 180 Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 270
Filter, Engine Air Cleaner . . . . . . . . . . . 253
Fixed Mast Antenna . . . . . . . . . . . . 102
Flash-to-Pass . . . . . . . . . . . . . . . . . . . . 93
Flashers, Hazard Warning . . . . . . . 94
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 310
Fluid Automatic Transmission . . . . . . 251
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 268
Diesel Exhaust . . . . . . . . . . . . . . . . . 24
Power Steering . . . . . . . . . . . . . . . 262
Washer . . . . . . . . . . . . . . . . . . . . . . . 262
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 370
Front Seat Position Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 38
Page 377 of 382

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500/5500 Series (GMNA-
Localizing-U.S.-12407814) - 2019 - crc - 12/13/17
376 Index
FuelBiodiesel . . . . . . . . . . . . . . . . . . . . . 228
Cold Weather Operation . . . . . . 230
Diesel Engines . . . . . . . . . . . . . . . 227
Economy Driving . . . . . . . . . . . . . . . 24
Filling the Tank . . . . . . . . . . . . . . . 235
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 270
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Running out of Fuel . . . . . . . . . . . 233
Water in Fuel . . . . . . . . . . . . . . . . . 231
Fuel for Diesel Engines . . . . . . . . . 227
G
Gauges
Diesel Exhaust Fluid (DEF) . . . . . 72
Engine Coolant Temperature . . . 72
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Odometer . . . . . . . . . . . . . . . . . . . . . . . 70
Speedometer . . . . . . . . . . . . . . . . . . . 70
Tachometer . . . . . . . . . . . . . . . . . . . . . 71
Trip Odometer . . . . . . . . . . . . . . . . . . 70
Warning Lights andIndicators . . . . . . . . . . . . . . . . . . . . . 68
General Information Vehicle Care . . . . . . . . . . . . . . . . . . 240
Getting In and Out of the
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 29 Glove Box . . . . . . . . . . . . . . . . . . . . . . . 55
GM Mobility Reimbursement
Program . . . . . . . . . . . . . . . . . . . . . . . 366
H
Hazard Warning Flashers . . . . . . . . 94
HeadlampsAiming . . . . . . . . . . . . . . . . . . . . . . . . 277
Bulb Replacement . . . . . . . 277, 280
Daytime Running Lamps(DRL) Indicator Light . . . . . . . . . . 81
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 93
High-Beam On Light . . . . . . . . . . . . 81
High/Low Beam Changer . . . . . . . 93
Heated Mirrors . . . . . . . . . . . . . . . . . . . 34
Heater Engine . . . . . . . . . . . . . . . . . . . . . . . . 172
Heating . . . . . . . . . . . . . . . . . . . . . . . . . 131
High Idle System . . . . . . . . . . . . . . . 174
High-Beam On Light . . . . . . . . . . . . . 81
Hill and Mountain Roads . . . . . . . . 150
Hooks Shopping Bag . . . . . . . . . . . . . . . . . . 57
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
HVAC . . . . . . . . . . . . . . . . . . . . . . . . . . . 131
I
Idle Shutdown . . . . . . . . . . . . . . . . . . 174
Idle Shutdown Light . . . . . . . . . . . . . 80
Ignition Positions . . . . . . . . . . . . . . . 166
Information Publication Ordering . . . . . . . . . . 370
Information on Loading the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 58
Instrument Cluster . . . . . . . . . . . . . . . 69
Instrument Panel Storage Area . . . . . . . . . . . . . . . . . . . 55
Introduction . . . . . . . . . . . . . . . . . . . . . . . 2
J
Jump Starting - North America . . . . . . . . . . . . . . . . . . . . . . . 311
K
Keyless EntryRemote (RKE) System . . . . . . . . . 26
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
L
Lamps
Cargo . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Cornering . . . . . . . . . . . . . . . . . . . . . . . 95
Dome . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Exterior Controls . . . . . . . . . . . . . . . . 92
Interior . . . . . . . . . . . . . . . . . . . . . . . . 287