seat adjustment CHEVROLET LOW CAB FORWARD 2020 User Guide

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
212 Driving and Operating
Operation of Parking Brake
The parking brake lever is located to
the right of the driver's seat.
To set the parking brake, completely
stop the vehicle. Then, without
pressing the release button (1), hold
the brake pedal down while pulling
the parking brake lever (2) all the
way up.The parking brake indicator light in
the instrument panel will come on
when the lever is pulled up. Before
you leave the driver's seat, follow
the steps under
“Parking, or Leaving
Driver's Seat”. See Braking0134.
To release the parking brake, hold
the brake pedal down while pushing
the release button of the parking
brake lever and lower the lever. The
parking brake indicator light in the
instrument panel will go out.
The parking brake indicator light is
designed to remind you if the
parking brake is not released when
the engine control switch is on.
If the parking brake warning light
remains on when the parking brake
lever is lowered, a brake failure or a
drop in air pressure may be the
cause.
Check the brake air pressure for
correct level. If the brake air
pressure is low, contact your local
Isuzu Dealer for service.
If you notice the parking brake lever
travel has increased over time, this
means the cable adjustment must be checked by a qualified
technician. Adjustment may be
required due to parking brake shoe
wear. See
Control of a Vehicle
0 130.
Inspection
Pull the parking brake lever slowly
from the fully released position while
counting the clicks produced as the
lever engages ratchet plate notches
to check that it can be raised the
proper amount and the lever is held
firmly.

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
Vehicle Care 235
Engine Cover
Engine Inspection Cover (Crew
Cab Model)
To gain access to the engine,
release the catch hooks (3) and
raise the passenger’s seat
cushion (2). The cover can be held
up by a strap (1), permitting engine
inspection and adjustment. Engine Inspection Sub Cover
(Crew Cab Model)
To gain access to the engine
compartment, pull the lock lever
(red) (1) on the driver
’s seat
cushion (2) to unlock it, raise the
driver ’s seat cushion and remove
the sub cover. Engine Coolant Reserve Tank
Inspection Cover (Crew Cab
Model)To gain access to the engine
coolant reserve tank, remove the
inspection cover located under the
rear left seat.
Engine Oil
Engine oil is an important factor
determining engine performance
and longevity. Be sure to use only
the specified oil and oil filters. The
engine oil level must be checked

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
Service and Maintenance 337
one side, unusual sounds when
braking, increased brake pedal
travel or harder pedal. The front and
rear brakes are attached to an auto
adjuster mechanism. If there are no
defects, as the pedal travel is
properly maintained, adjustments
are not necessary. Check regularly
that the brake fluid reservoir
(left-hand side of the instrument
panel) or HBB reservoir (5500HD,
5500XD models: left side behind the
cab) is properly filled and check for
fluid leaks. Any of these conditions
could indicate the need for brake
system inspection and/or service.
G: Exhaust System :Be alert for
any changes in the sound of the
exhaust system or any smell of
fumes. These are signs the system
may be leaking. Have it checked
and/or repaired at once. (Refer to
"Engine Exhaust Emissions Caution
(Carbon Monoxide)" under Engine
Exhaust 0168).
H: Windshield Wipers and
Washers : Check operation and
condition of the wiper blades. Check
the flow of the washer spray. I: Defroster :
Turn the outlet
selector knob to "Defroster" and the
fan speed control knob to the fully
clockwise position. Then check the
airflow from the ducts at the inside
base of the windshield.
J: Rearview Mirrors and Sun
Visors : Check that friction joints
hold mirrors and sun visors in place.
K: Horn : Sound the horn, now and
then, to be sure it works.
L: Lap-Shoulder Belts : Check the
seat belt system (including webbing,
buckles, latch plates and anchors)
for proper operation, and for
damage.
M: Seat Adjusters : When
adjusting the driver's manual seat,
be sure the seat adjusters latch by
pushing the seat forward and
backward. Do not attempt to adjust
the seat when the vehicle is in
motion.
N: Lamps : Check panel lighting,
warning lamps, indicator lamps and
interior lamps. On the outside,
check: license plate lamps, side
marker lamps, reflectors on outside mirrors, headlamps, parking lamps,
identification and clearance lamps,
taillights, brake lamps, turn signals,
cornering lamps, backup lamps and
hazard warning flashers. Have
headlamp aim checked immediately
if beams seem improperly aimed.
O: Glass, Mirrors, Lights and/or
Reflectors Condition :
Look for
broken, scratched, dirty or damaged
glass, mirrors, lamps or reflectors
that could reduce the view or
visibility, or cause injury. Replace,
clean or repair promptly.
P: Door Latches : Check that doors
close, latch and lock tightly. Check
for broken, damaged or missing
parts that might prevent tight
latching.
Q :Tilt Cab (Driving Position) : Be
sure the tilt lever is down and
locked.
R: Fluid Leaks : Check for fuel,
water, oil or other fluid leaks by
looking at the surface beneath the
vehicle after it has been parked for

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
Index 365
IndexA
Accessories andModifications . . . . . . . . . . . . . . . . . . 230
Add-On Electrical Equipment . . . 227
Additional Maintenance and Care . . . . . . . . . . . . . . . . . . . . . . 336
Adjustments Seat, Initial Drive . . . . . . . . . . . . . . . 26
Agreements Trademarks and License . . . . . .119
Air Cleaner/Filter, Engine . . . . . . . 243
Air Conditioning . . . . . . . . . . . . . . . . 121
Air Filter, Passenger Compartment . . . . . . . . . . . . . . . . . 125
Air Vents . . . . . . . . . . . . . . . . . . . . . . . 124
AM-FM Radio . . . . . . . . . . . . . . . . . . . . 85
Antenna Fixed Mast . . . . . . . . . . . . . . . . . . . . . 90
Antilock Brake System (ABS) . . . 207
Warning Light . . . . . . . . . . . . . . . . . . . 64
Appearance Care Exterior . . . . . . . . . . . . . . . . . . . . . . . 307
Interior . . . . . . . . . . . . . . . . . . . . . . . . 313
Assistance Program,
Roadside . . . . . . . . . . . . . . . . . . . . . . 358
Audio Bluetooth . . . . . . . . . . . . . . . . . . . . . 108 Audio Players
CD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90
Automatic Transmission . . . . . . . . . . . . . . . . . 196
Transmission Fluid . . . . . . . . . . . 241
Automatic Transmission Selector Lever . . . . . . . . . . . . . . . . 205
Shift Lock Control Function
Check . . . . . . . . . . . . . . . . . . . . . . . 264
Automatic Transmission Fluid Temperature Warning Light . . . . . 66
Automatic Transmission Overdrive Off . . . . . . . . . . . . . . . . . . 206
Auxiliary Devices . . . . . . . . . . . . . . . . . . . . . . . 107
Axle, Rear . . . . . . . . . . . . . . . . . 261, 262
B
Battery - North America . . . . 259, 301
Battery Warning Light . . . . . . . . . . . . 61
Biodiesel . . . . . . . . . . . . . . . . . . . . . . . 219
Blade Replacement, Wiper . . . . . 265
Bluetooth
Overview . . . . . . . . . . . . . . . . . . . . . . 111
Bluetooth Audio . . . . . . . . . . . . . . . . 108
Brake Exhaust . . . . . . . . . . . . . . . . . . . . . . 213
System Warning Light . . . . . . . . . . 62

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
368 Index
Fluid (cont'd)Power Steering . . . . . . . . . . . . . . . 252
Washer . . . . . . . . . . . . . . . . . . . . . . . 252
Frequency Statement
Radio . . . . . . . . . . . . . . . . . . . . . . . . . 362
Front Seat Position Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 26
Fuel Biodiesel . . . . . . . . . . . . . . . . . . . . . 219
Cold Weather Operation . . . . . . 221
Diesel Engines . . . . . . . . . . . . . . . 218
Economy, Driving for Better . . . 129
Filling the Tank . . . . . . . . . . . . . . . 225
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 260
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Running out of Fuel . . . . . . . . . . . 224
Water in Fuel . . . . . . . . . . . . . . . . . 221
Fuel for Diesel Engines . . . . . . . . . 218
G
Gauges
Diesel Exhaust Fluid (DEF) . . . . . 60
Engine Coolant Temperature . . . 60
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Odometer . . . . . . . . . . . . . . . . . . . . . . . 58
Speedometer . . . . . . . . . . . . . . . . . . . 58
Tachometer . . . . . . . . . . . . . . . . . . . . . 59
Trip Odometer . . . . . . . . . . . . . . . . . . 58 Gauges (cont'd)
Warning Lights and
Indicators . . . . . . . . . . . . . . . . . . . . . 56
General Information
Vehicle Care . . . . . . . . . . . . . . . . . . 230
Getting In and Out of the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 17
Glove Box . . . . . . . . . . . . . . . . . . . . . . . 43
GM Mobility Reimbursement Program . . . . . . . . . . . . . . . . . . . . . . . 358
H
Hazard Warning Flashers . . . . . . . . 82
HeadlampsAiming . . . . . . . . . . . . . . . . . . . . . . . . 267
Bulb Replacement . . . . . . . 267, 270
Daytime Running Lamps(DRL) Indicator Light . . . . . . . . . . 69
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 81
High-Beam On Light . . . . . . . . . . . . 69
High/Low Beam Changer . . . . . . . 81
Heated Mirrors . . . . . . . . . . . . . . . . . . . 22
Heater Engine . . . . . . . . . . . . . . . . . . . . . . . . 163
Heating . . . . . . . . . . . . . . . . . . . . . . . . . 121
High Idle System . . . . . . . . . . . . . . . 165
High-Beam On Light . . . . . . . . . . . . . 69
Hill and Mountain Roads . . . . . . . . 141 Hooks
Shopping Bag . . . . . . . . . . . . . . . . . . 45
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
HVAC . . . . . . . . . . . . . . . . . . . . . . . . . . . 121
I
Idle Shutdown . . . . . . . . . . . . . . . . . . 164
Idle Shutdown Light . . . . . . . . . . . . . 68
Ignition Positions . . . . . . . . . . . . . . . 157
Information Publication Ordering . . . . . . . . . . 362
Information on Loading the
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 46
Instrument Cluster . . . . . . . . . . . . . . . 57
Instrument Panel Storage Area . . . . . . . . . . . . . . . . . . . 43
Instrument Panel
Overview . . . . . . . . . . . . . . . . . 8, 10, 11
Introduction . . . . . . . . . . . . . . . . . . . . . . . 2
J
Jump Starting - North America . . . . . . . . . . . . . . . . . . . . . . . 301
K
Keyless EntryRemote (RKE) System . . . . . . . . . 14
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
Index 371
Service (cont'd)Climate Control System . . . . . . . 121
Doing Your Own Work . . . . . . . . 231
Scheduling Appointments . . . . . 359
Transmission Warning Light . . . . 65
Vehicle Soon Light . . . . . . . . . . . . . . 62
Shift Lock Control Function Check, Automatic
Transmission . . . . . . . . . . . . . . . . . . 264
Shopping Bag Hooks . . . . . . . . . . . . 45
Sidemarker Lamps . . . . . . . . . . . . . 274
Signals, Turn and Lane-Change . . . . . . . . . . . . . . . . . . 82
Specifications and
Capacities . . . . . . . . . . . . . . . . . . . . . 349
Speedometer . . . . . . . . . . . . . . . . . . . . 58
Starting and Stopping the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . 159
Steering . . . . . . . . . . . . . . . . . . . . . . . . 140 Fluid, Power . . . . . . . . . . . . . . . . . . 252
Wheel Adjustment . . . . . . . . . . . . . . 53
Stoplamps and Back-up Lamps Bulb Replacement . . . . . . . . . . . . 276
Storage Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
Storage Areas Glove Box . . . . . . . . . . . . . . . . . . . . . . 43 Storage Areas (cont'd)
Information on Loading the
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . 46
Instrument Panel . . . . . . . . . . . . . . . 43
Storage Compartments . . . . . . . . . . 42
Stuck Vehicle . . . . . . . . . . . . . . . . . . . 144
Sun Visors . . . . . . . . . . . . . . . . . . . . . . . 25
System Noise Control . . . . . . . . . . . . . . . . . 262
T
Tachometer . . . . . . . . . . . . . . . . . . . . . . 59
TaillampsBulb Replacement . . . . . . . . . . . . 276
Temperature, Operating . . . . . . . . 162
Text Telephone (TTY) Users . . . . 357
Three-Point Seat Belt . . . . . . . . . . . . 33
Tires If a Tire Goes Flat . . . . . . . . . . . . 300
Pressure . . . . . . . . . . . . . . . . . . . . . . 297
Rotation . . . . . . . . . . . . . . . . . . . . . . 297
Tires and Wheels . . . . . . . . . . . . . . . 285
Towing Vehicle . . . . . . . . . . . . . . . . . . . . . . . 305
Trademarks and License Agreements . . . . . . . . . . . . . . . . . . . 119
Transmission Automatic . . . . . . . . . . . . . . . . . . . . . 196 Transmission (cont'd)
Fluid, Automatic . . . . . . . . . . . . . . 241
Overdrive Off, Automatic . . . . . . 206
Service Warning Light . . . . . . . . . . 65
Trip Odometer . . . . . . . . . . . . . . . . . . . 58
Turn and Lane-Change Signals . . . . . . . . . . . . . . . . . . . . . . . . . 82
Turn Signal Bulb Replacement . . . . . . . . . . . . 276
U
USB Port . . . . . . . . . . . . . . . . . . . . . . . . 98
Using This Manual . . . . . . . . . . . . . . . . 3
V
Vehicle
Control . . . . . . . . . . . . . . . . . . . . . . . 130
Getting In and Out . . . . . . . . . . . . . . 17
Identification Number (VIN) . . . 343
Messages . . . . . . . . . . . . . . . . . . . . . . 74
Security . . . . . . . . . . . . . . . . . . . . . . . . 21
Service Soon Light . . . . . . . . . . . . . 62
Starting and Stopping . . . . . . . . . 159
Towing . . . . . . . . . . . . . . . . . . . . . . . . 305
Vehicle Care Tire Pressure . . . . . . . . . . . . . . . . . 297
Vehicle Data Recording and Privacy . . . . . . . . . . . . . . . . . . . . . . . . 363