check engine CHEVROLET MONTE CARLO 1976 2.G Owner's Manual

Downloaded from www.Manualslib.com manuals search engine for 3 hours or more, or driven
less than 1 mile.
2. It is normal for tiTe pressures to
increase 4-8 PSI when the tires
become hot from
driving. Do not
"bleed" (reduce tire inflation
pressures)
after driving your
vehicle. Bleeding serves
to in­
crease tire flexing and heat build­
up which can result in tire dam­
age and failure.
3. For sustained driving
at turn­
pike speeds; cold inflation
pressures should be increased 4
PSI above the recommended
cold inflation pressures on the
tire placard up
to a maximum of
32
PSI for load range B tires, 36
PSI for load range C, and 40 PSI
for load range D. Sustained
speeds above 75 mph are not
recommended when the 4
PSI
adjustment would require pres­
sures greater than the maximum
pressures above.
4, Always use a tire pressure gauge
(a pocket type gauge is recom­
mended) when checking infla­
tion pressures. Underinflated
radial tires may have the same
appearance
as a properly inflated
radial tire.
Visual inspection of
-tires for in/laton is totally inade,
quate especially in the case 0/
radial tires. If inflation pressure
of an individual tire
is found to be
consistently low, have your
dealer find and correct the cause.
5. Be sure to re-install the tire in­
flation valve caps, if
so equipped,
to prevent dirt and moisture
from entering the valve core
which could cause air leakage.
Inspection and Rotation
Your tires perform different jobs
(front tires are involved with steer­
ing and rear tires normally with
propelling the vehicle) and can
wear differently depending on the
type of roads driven, individual
5-16
I
I '
,
)1, I
I I ( I , I , )' ,t
I ) I )
I , I I I I (
PROPERLY INFLATED
BIAS-BELTED TIRE
PROPERL Y INFLATED
RADIAL TIRE

Downloaded from www.Manualslib.com manuals search engine Air Cleaner
Your Cl:
receives its power from
a
mixture of gasoline and air. The
air is taken into the system through
the air cleaner so it's important to
replace~he air cJea!1er at required
intervals. A dirty
air cleaner re­
duces . engine efficiency.
Properly Tuned'Engine
Overall tuning (a check on tlin­
ing , spark plugs, emission control
devices, etc;)
can improve your
car's gas mi,leage . You just
can't
expect an "out-of-tune" engine to
give you good gas mileage and
cleaner air.
Excess Weight
Fuel economy is related to the
work. the engine . must do. The
heavier the load , the more power it
take
s. Keep excess weight to a
minimum by removing any per­
sonal effects or luggage from the
car or trunk when they are not
needed.
Tire Inflation
Underinfiation not only causes
needless wear of the tires, but
can
also waste gasoline. It's a good
idea to check tire pressures
regularly.
Wheel Alignment
Incorrect "toe in" or "toe out" can
have the effect,of dragging your
front tires sideways
and may cause
premature tire wear.
It takes power
to carry this extra load and that
takes gas from your tank.
Catalytic Converter
The catalytic converter is an
emi ssio n control device added to
5-22 the
exhaust system to reduce hy­
drocarbon
and carbon monoxide
pollutants from the exhaust gas
stream. The converter contains
beads which are coated with a cata­
lytic material containing platinum
and palladium.
Use of the catalytic converter
has the advantage
of allowing the
engine
to be re-tuned for improved
fuel economy anddriveability.
The catalytic converter requires
the use
of unleaded fuel only,
Unleaded gasoline is used to re­
duce combustion chamber deposits,
corrosion
and to prevent lead con­
tamination
of the catalyst that
would render it ineffective.
The use
of leaded fuel will cause the COIO- .
lytic converter to become ineffec­
tive
as an emission control device.

Downloaded from www.Manualslib.com manuals search engine FUSES AND CIRCUIT BREAKER: (Continued) Tho hSDdlomp clrculls are proleded by a dreult breaker In the light Iwitch. An slsc:trlcol overload will cause the lamps to go on and off, or In som~ cOles to remain off'. If this condition deve lo ps, have your
wiring circuit. checked Immediately. In addition to a fuse, the windshield
wiper mot or Is also protected by a circuit breaker. If the motor oyer· heats, due to overk>adlng caused by heClvy snow, etc. tl\e wipers will
remam stopped unltl the motor cools. Also, a c.Irc:uit brea ker. mounted on
the firewall, protects the power window, power seat, and other circuits when vehicle Is so equipp.d. Where current load Is too heavy, the
circuit breake r Intermittently opens and closes, protecting the circuit until the cause Is found and eliminated. Fuses, located in the Junction Block beneath the dash on the driver's .Ide are: Radio, TCS SoL, Hydra·matic Downshift and Anti·Diesel Control, Pulse Wiper System, ChQke Pull Off ........................ . W/S Wiper............. .• . .. . .................... . Stop Lamps, Hazard flasher..... . ......... . Heater, A /C ...... . . .. ' Dir. Sig., B /U lamps, Power Window Relay. Inst.lamps, Heater Dial,::, ..... Inst. Panel Warning Lamps, Gauges, Cruise Control, Rear Defogger Override Relay, SeaL8elt Warning Buzzer. ..... -. c •••••. Warning Buuer, Luggage Lamp, Clock, Courtesy Light, Ligflter,
lOA 25A lOA 25A .. 20A 3 A
lOA
Glove Box Light. . . . .. . . . . . . . ..... 20A Tail lamp, Parking Lamp, License, and Side Marking Lamp... . ..... 20A
An Air Conditioning high blower speed fuse, 30 amps., is located in an In-tine fuse holder runnin g from JUnction block to AI ... Conditioning -relay. Do not Ufe fuses of higher amperage rating than those recommended
obove. Fusible ,
LInks are in(:orporated into 'he wiring system. These are wires of such a gauge that they will fuse (or melt) before damage occun to an _ent ire wiring harn ess in tile even' of an electrical
overload. See your Chevrole t Deal er if fusible link re placement
becom es necessary.
BULB SPECIFICATIONS Heodlamp Unit Outer-High Beam ..........•..•.. Low 8eam .... · .•.••..••....
Inner -High Beam .......... , . •.. .. Parking lamp and Front Directional Signal. .......••... Toil and Stop Lamps Re,ar Directianal Slgn(ll .......•..... license Plate Lamp ............•..... Back.up Lamp ................•.••.. Glo .... Comportment lamp .•..••.....• Indicotor lamps Clock lamp Temperature Indicdtor Lamp 011 Pressure Indica'tor lamp Generator Indicator lamp Hi-880m Indkator lamp Auto. Trans. Quadrant Lamp
Directional Signal Indicator Lamp
Brake System W,a ,rn!ng Lamp Seat Belt Warning Lamp oOor Open Warning Lamp Inshvmen' Panel Ou.ter lamps. Sid. Morker-FrOl1i ................. . Side Marker-Rear ................. . Heater, Ale COntrol Panel Lamp .....•.
D ome Lamp ....................... . lU9t1oge Compartment Lamp ......... . Underhood lamp ................... . Courtesy Lamp ..................... .
Radio Dial Lamp (All exe. Stereo ond Tape player) . . ................ . RadiO, Oial Lamp (Stereo and Tape player) .................... .
Reading lamp ..................•... Radio Indicator .......••..••.•.••...
6-3
Can_uea power Humb ...
37Y~W 4000 55W (S.ale~, Beom)
37V1W 5001 (Sealed Beam)
24-2.2 11S7NA
32-3 1157 3 168
32 I J 56 2 1891
2 194
3 168
2 194
2
194
2 1895
12 211·2or211al 15 1003 15 93
6 631
3 1816
2 564 15 1004 I 66

Downloaded from www.Manualslib.com manuals search engine INDEX
Absorbers, Superlift Shock. . . . . . . . . .. 2-27
Accessory Drive Belts. . . . . . . . . . . . . .. 5-4 Accessory P()sition, Steering Column Lock. . . . . . . . . . . . . . . . . . .. 2-2
Acrylic Lacquer. . . . . . . . . . . . . . . . . . .. 4-5 Adjusters, Automatic Brake. . . . . . . . .. 2-9 Air Adjustable Superlift Shock Absorbers. . . . . . . . . . . . . . . .. 2-27 Air Circulation .......... " ..••..... 2-17 Air Cleaner . . . . . . . . . . .. . . . . • • . . . . .. 5-4 Air Conditioning
Automatic Operation. .. . . . . . . . . . .. 2-22
4 Seasons Operation. . . . . . . . . . . . .. 2-20 Maintenance. . . . . . . . . . . . . . . . . . . .. 5-12 Air Inlets , Ventilating System ........ 2-17 Antenna •.......... -•....•• , . • . . . . .. 2-25 Anti-freeze (See Cooling System).... .. ~l Anti-Spin Differential. . . . . . . . . . . . . .. 2-27 Anti-Theft Key Buzzer System ........ 2-2 Anti-Theft Steering Column Lock. . . .. 2-2
Appearance Care. . . . . . . . . . . . . . . . . .. 4-1 Ash Trays. . . . . . .. .. . . .. . . . . . . . . ... 2-10 Automatic Brake Adjusters. . . . . . . . .. 2-9 Automatic Transmissions Fluid Check.. .. . . . . . . . . . . . . . . . . .. 5-5 Fluid Recommendations ... , . . . . . .. 5~5 Maintenance. . . . . . . . . . . . . . . . . . . .. 5-5 Operation ...... ,., ....... "., .... 2.4
Starter Safety Switch .. , ..•• ' .• ' . '. 2·3 Axle Rear Fluid Level ............... , . . . . .. 5-9 Maintenance .............•...... , 5·9 Backup Lights.... . . . . .. . . ... . . . . . .. 6-3 Ban Joints . . . . . . . . . . . . . . .. .. . .. . . .. 5·10
Bassinet Placement.. • . . . . . . • . . . . .. .. 1-9 Battery Emergency Starting, . , •...... , . . .. 3-2 Auid Level ........ , , .In side Back -Cover Gas Caution. .. .. . . .. . . . . . . .. . . .. 3-3 Specifications ....... , ............. 6-1 Bearings, Front Wheel. ......... , .... 5·11 Before Driving Your Chevr olet. ...... 1-1 Belted Tires .. , "., ............ , .... 5·14 Belts Engine Drive .... , . . . . . . . . . •.. . . . .. 5-4 Lap ............................. 1-4 Shoulder, ......... , ............ '. 1-4 Blower, Ventilating ................. 2-19 Body Identif ication Number .......... 6-1 Brakes D,riying Through Deep Water, . , , .. 2-8 Linings .. , ...................... , 2-8 Maintenance ..... ' . ... , . . . . . . . . . . 5-11 Master Cylind er Level ......••..... 5-11 Parking Brake.. . . . . . . . . . . .. . . . . .. 2-8 Pedal Travel ........... , . . . . . . . .. 2-8 Power, ...................• , ..... 2-8 Self-Adjusting ... , .......• " ...... 2-8 Trailer .................... ,..... I-to Warning Light. .... -.............. 2-1 2 Break-In Period Cars Pulling Trailers. . .. ...... .... 1-10 New Car ......... ,., ... ,........ ii Bright Metal Cleaning ....... '. ' . . . . .. 4-5 "Brights" Headlamp Indicator , ...... , 2-13
Buckles, Seat Belt., ........... ,. .. .. 1-4
Bulbs and Fuses .............. , . , . .. 6-3 Bumper Jack
Operation ........ , ...•••••..•.... 3-4 Stowage ............ , .••. , . . . . . .. 3-5 Seat Belt Buzzer Key Remin der ................ , . .. 2-3
6-8
Cap,
Engine Oil ...... , . . . . • . . . . . . • . . .. 5-2 Gasoline ............. , . . . . . . • . . .. 5-2
Ca~~~fti~~·:::::::::::::::::: :::::: ~: Carbon Monoxide Caution •.. , ..•.... 2-1 Carpet Care... . . . . .. . . . . . .. . . . . .. .. 4-2 Carrier, Infant Safety................ 1-8 Carrier, Roof Luggage ........ , . . . .. 2~27 Catalytic Converter ........... , .. 5-22, 5-23 Changin g Wheels and TlCes. . . . . . . . .. 3-4 Cha rging System Indicator Light...... 2-12
Chassis Maintenance. . . . . . . . . . . . . . .. 5-9 Child Restraint
Cars Not Equipped With
Special Child Restraints. , .. , ..• 1-8
Child Safety Seat. .. . .. . . . . . .. . . .. 1-8 Infant Safety carrier. .. . . . . . . . . . .. 1-8 Chrome Protection ....... , .......... 4-5 Cigarette Lighter. . . . . . . . . . . . . . . . .. . 2-15 Circuit Breakers, Headlamps. . . . . . . .. 6-2 Cleaning
Carpet Care.. . . . . . . . . . . . . . . . • . . .. 4~2 Exterior Finish and Trim. . . . . • . . .. 4-5 Fabric and Interio r Trim .......... 4-1 Solvents Recommended ........ , . .. 4-1 Spot Removal. ...... : . . .. . . .. . . .. 4-3 Vinyl Top ........ , . , . . . . . . •• . . .. 4-5 Clock ............................. 2-15 Coa t Hooks.......... ........••.... 1-2 Cold Weather Starting.. . . . . . . • • • . . .. 2-3
Comp artment
Glove., .... , .. , ....... , ...•..... 1-1 Luggage ....................... :. 2·33 Complaint Procedure. . . . . . . . . . •• . . .. 6-4 Conditioner, Air.. .. . . . . .. . . • .. . .... 2-20 Controlled Differential .......••• , . .. 2-27

Downloaded from www.Manualslib.com manuals search engine Converter, Catalylic .............. .5-22, 5-23 Cooling System Care ............................ 5·7 Coolant "Recommendation ....... ;. 5-7 Overheating Caution. . . . . . . . . . . . .. 3-4 Courtesy Lights ............ ." ..... , 6-2.317 Cowl Air Inlets ...... , ...... , ...... . Cruise Control ............. -. . . . . . .. 2-6 Dealer. Assistance ........... -;. ...... 6-4 Defogger, Rear Window ......... , . .. 2-20 Defroster, Defogger, Windshield ...... 2-19 Dimensions, Vehicle ......• -', ........ ' 6-1 Dimmer Switch, Headlarnp : ........ ' 2-9 Directional Signals .. , . , ...... , . . . . .. 2-5 Door Locks... ....... ............ .. 1·2 Power Doo r Locks .... , •...••...... 2-27 prive Belts, Engine. . . . . . . . . . . . . . . .. 5-4 Driver ' Sj;at Adju stment; .......... , ,..... 1-2 ," D~titfy Conditions. Operating Unqer. .. 5-2 ~ Economy Gauge, Fuel...... .. ..... .. 2~14 Electric Clock ................ , .. , .. 2~15 Electrical System Battery ....................... 5·13. 6-1 Bulbs ........................... 6-3 Fuses ... " ...................... 6-3 Generator Indicator Light ..•...... 2~12 Emergency, In Case Of, . ' . , .. ~ . . . . .. 3~ 1
Brake Warnin~ Light ............. ' 2~12 Generator Indicator Not Charging.. 2-12 Hazard Warning Flasher ........... 3-1 Jacking To Change Wheels......... 3·4 Jump Starting with Auxiliary Battery 3-2
Overheated Radiator ............ ,. 3-4 Pushing To Start ................ ' 3-2 Spare Tire .... , . . . . . . . . . . . • . • . . .. 3-4
Towing .. , ...............•.... , ., 3-1
Engine
Cooling. . . . .. .. .. . .. .. .. .. .. .... 5-7 Exhaust Gas Caution, ........•... , 2-1 Flooded , Starting Procedure. .•• . . .. 2-3 Overheating .. , .. , . .. . . . . . . . . . . . .. 3-4 Serial Number.. .. .. .. .. .. .. .. .... 6-1 Specificati ons ......... , ....... , , .. 6-2
Starting .................. ....... 2·3 Temperature Light.. , ........ -. .. ,. 2-12
Engine Oil Capacity .... ' .... , .... , ....•••. ',," 6-1 Change Interval .......• ' .. , • . . . .. 5-2 Dip Stick........ ........ ........ 5-2 Filter .......... .-. . . . . . . . . . . • . . . .. 5-2
Pressure Indicator .•.......••.... , 2-11 Recommendation. . . . . . . . . . . . . . . .. 5-3 Ethylene Glycol Coolant... . . . . . . . . .. 5·7 Exhaust Gas caution.... .... ...... .. 2 .. 1
Driving With Trunk Open. ........ 2-1 Exhau st System Checks ........ ,' .. 2-1 Parked With Engine Running. , .... 2-1 Pulling A Trailer. .............. " 2_1 Exterior Finish and Trim Care. . . . . .. 4-5
Fabric Care.. .. .. .. .. ... .. .. .. .. ... 4-1 Fan Belt ............................. 5-4 Ventilating .•... , ................ , 2-19 Filter, Oil. .... " ................ , . .. 5-2 Finish Care Exterior .......... , . , .. , 4-5 First Few Hundred Miles of Driving .. , ........... ' .... ; . . . . . .. ii
Flammable Cleaning Solvents. . . . . . .. 4-2 Flashers Hazard Warning .... ~. ............ 3-1 Turn Signal. ..... ' ......... , . . . .. 2-5 Flooded. Engin e, Starting. . . . . • . • . . .. 2-3 Floor Controls. .. .. .. .. .. .. .. .. .... 2·8
6-9
Fluid Capacities ........... ·......... 6.1 Fluid Levels
Battery ..... , ......... Inside Back Cover
Brake Master Cylinder., ..... , .... 5-11 Engine Oil .............. , ........ 5·2 Power Steering .. , ......... '" . . .. 5.10 Radiator .................. ,. ,-... , 5-7 Rear Axle ................... '.... 5-9 Transmission ....... , . , ........... , 5-5
Fluid Recommendations
Brake
........................... 5.11 Power Steering, .......... '. -..... ~'. 5-11 Rad.iat~r, : ......... ....... ,.,."., 5-7 TranslOlsslon ....... , . . . . . . . . . . . .. 5·5 Windshield Washer .. , ., ....... ;--.-, 2-15 Fogging, With Air Conditioner ..... " 2-21 Folding Seat Back Latches ... ........ 1·2 Foreign Countries , Operation In .... ,. 1-12 Four Way Hazard Flasher. , . , , ... , ,. 3-1
Front Suspen sion. . . . . . . .. . . . . . . . . .. 5-10 Front Wheel Bearings ... :: ......... ,. 5·11 Fue l (See Gasoline) Fuel Economy Gauge ..... , ... , ,. . .. 2-14 Fumes, Engine Exhaust., ....•..... , .• 2-1 Fuses Cbart ........................... 6-3 Location.... . .. . . . . .. .. . . . . . . . . . . 6-2 Gas Station Information .,. Inside Back Cover Gasoline, Capacities ..... : , , . . . . . . .. 6-1 Do Not Use For Cleaning .. , . , . , ., 4-2 FlUer Cap Location .... Inside Back Cover
Fumes ........................... 2·1 Gauge ........... ,..... .......... 2·11 Low·Lead............ ...... ...... s· Recommendations, .... ,...... .... 5-1 Gauge, FueL .... ,........ .. ........ 2-11 Gearshift Lever... . . . . . . . . . . . . . . . . .. 2·4 Generator Indicator Light ........... 2·12

Downloaded from www.Manualslib.com manuals search engine Thermostat. . . . . . . . . . . . . . • • . . . . . . .. 5~9 Tilt Steering Wheel.. . . . . . . • • . . . . . . .. 2·6 Tire Belted ........................... 5·14 Care ............................ 5·14 Changing. . . . . . . . . . . . . .. . . . . . . . .. 34 Damage and Repair ............... 5·18 Full Rated Load...... ............ 5·16 High Speed Operation............. 5·16 Hydroplaning. . . .. .. . . .. . .. . .. ... 5·18 Inflation Pressure. . . . . • • . . • . . . . . .• 5:..14 Inspection ... ".,., ... ' .••.... "., 5~16 Load Limit. . .................... 5·16 Radial Tires....... .. ....... ...... 5·14 Rotation ... ,.,.,.,." ., " .. , .... -: ·5~16 Traction .. "., ... , .. , ... " . . ,'.;'~. 5-18 Tread Wear Indicators...... ....... 5-19 US1ge andOptions ..... ' .......... 5·15 Towing Caution ....•.•........•... , ...... 3~1 Disabled Vehicle.......... ........ 3·1 To Start. . .. . . . . . . .. . . .. . . .. .. . .. 3·1 Toxic .
Cleaning Solvents ..... , , . . .. .. . . •. 4~2 Exhaust Fumes ...... , ......•• , , .. 2~ 1
Traction, Wet.Roads."' .... ,.,.,,., 5~18 Traffic Hazard flasher. . . . .. .. .. . ... 3·1 Trailer Hauling .. , . , . , ........... , . . 1·10
Break ·In Period. . .. .. .. .......... I·JO Cautions ...•................•.. ,. 1·11 Equipment. .. . . . . . . . . . .. . . . . • .. .. 1·10 Sj?ecial
Maintenance .. ,
. , ........ , 1·11 TIre Inflation ..... , .. , . ........... 5·14 Trailer Tongue Load, .......... , .. 1~11 Transmission Automatic. . . . . . . . . . . . . . . . . . . . . . . 2-4
Braking Effect On Hills.......... .. 2·4 Checking Fluid Level. ..... . . . . . . . .. 5·5 Fluid And Strainer ............ , .,. 5·5 Fluid Change Interval ..• " ....• , . .. 5·5 Maintenance. , •...... , . , '. '. . . . . . .. 5-5 Shift Controls .......... " . . .. . . .. 2-4 Turbo Hydra~matic .........• . , . .. 2·4 Tray. Ash .......................... 2-JO Tread Wear Indicators .... .',.,., ... , 5-19 Trim Care, Interior ............. , ... , 4-1 Trunk Driving With Trunk Open. .. ...... 2·1 Turoo..Hydra~matic Maintenance. . . . . . . . . . . . . . . . . . . .. 5·5 Operation .................... , . .. 2-4 Turn. Signals and Lane Change Feature ............... , . . . . . . . . .. 2~5 Underbody Maintenance .... , . . . . . . .. 5~ 13 Upholstery And Carpet Care. . . . . . . .. 4·1 Vehicle Identification Number ....... , 6-1 Vehicle Loading, ...... , ...... , .. , , . . .. 5~ 15 Ventilating Blower., ...... :., .. " .. .. 2-19
Ventilating System .................. 2-17
Vinyl
Fabric Care Interior. . . . . . . . • • . . . .. 4·1
6-12 r
Roof Care .................... '" 4·6 Volatile Cleaning Solvents, .. ,., ..... 4-2 Caution ... , . , . , , . , .. , ......•.. ,. 4-2
Volume Control, Radio ... , ..... , .... 2~25 Warning Flasher. Hazard ............ 3-1 Warning Lights ..................... 2·11 Brake ........................... 2·12
Engine Temperature ......... , .... , 2-12 Generator •............... , . , .. .. 2~ 12 Oil Pressure. . . . . . . . . . . . . . . . . . . ... 2~ 12 Warranty (See Warranty Folder) Washers Windshield..... .. ... . . .. ... .. .... 2·15 Washing Your Car .................. 4-5
Waxing And Polishin g .. , , . . . • • • . . . .. 4·5 Wheel Bearings , Front.... . . . . . . . . . .. 5~11 Wheel Changing.. ... . . . . . . . . . . . . . .. 34 Wheel, Tilt Steering ........... ...... &2·6 Wmdows ;,; Power ....................••..... 1·3 Rear, Defogger. .......... ,' ...... 2-20 Windshield
Defrosting and Defoggin g ............ 2·20
Pulse Wiper System ...... ,. . .... .. 2~16 Washer Use In Cold Weather .. ,.,. 2-15 Washer Solution ....... , .......... 2-15 Wipers And Wasbers .............. 2~15 Wrecker, Towing .•.........•....... 3~1 Zone Offices. . . . . . . . . . . . . . . . • • . . . .. &.6

Downloaded from www.Manualslib.com manuals search engine ,
Service Publications-Chevrolet
The following publi9ations coveri ng t he operation and servicing o f you r Chevr olet can be pu rchased by filling out the
reverse-sid e of this ord er fo rm an d mailing it with you r check or money order to Helm Incorporated
FORM NO. DESCRIPTION . PRICE
ST 329-76 1976 PASSENGER CAR SERVICE AND OVERHAUL $4.25 . SUPPLEMENT
(Available
January, 1976_) For complete coverage ST
329-74 and ST 333-74 should also be purchased.
.-
ST 329-74 1974 SERVICE MANUAL • 7_50
Include s" on-the-car adjustments,
maintenance, and re-
moval and install ation o f compon ents. Some overhaul
information
is als o included (e.g. B rake Master Cylinder ,
distributor,
etc .) . Will provide service information to
handle most own er's requirement s.
ST333-74 1974 OVERHAUL MANUAL 6_50
I neludes basic off-the -car overhaul of major components
(
e.g . engine, transmi ssion, etc.). .
ST 335-76
1976 BODY SERVICE MANUAL 7.00
Includes:
Complete Body Service Information for all
". body styles.
" . " ST 3.04-76 1976 OWNER'S MANUAL 1.00 .
-J -~-NOTE: Please fill in r eve!'seside of this form completely Pric es subj ect to c hange

Downloaded from www.Manualslib.com manuals search engine " I. NU'I,~':' ,!"'IM$Q till In order torm completely
.. and MAIL TO: CUT HERE
,
"
HELM, Incorporated
Poot Office Box 07130
CANADIAN RESIDENTS should order publications from the Owner
Relations Department>: G eneral Motors of Canada Limited, Oshawa,
Ontario, L1J5Z6. Make check or money order payable to General
Detroit , Michigan 48207 Motors of Canada Lim ited. '
QUANtITY , FORM'NO, YEAR PRICE EACH X QUANTITY . TQTAL
$ X = ,$
,", S X . $
, / " $ , X = $ ,',
, ,f,',' $ X = $ "
$ X = $
P,ic. Subject to Change ; Total Order $
All orders :will be mailed within 10 days of receipt. Midll'lI Pllrtb.Slff-Add,IYt ,5,1'$ T,x Please allow adequate tiir-e for pos~1 service. -+ Michigan Sales Tax $
Thl.l. YOu, .• hipp,,~. Iflbel .... PIe ••• print c, ... ,'Y
Chevrol.t Mln"1I FROM. .. .'~~
HELM, Inco,po",ted
Post Office Box 07130
, DistributiDn Department
Detroit, Michigan 48207 :.;r Aeturn' 'Requested
FOR ________ -,==~~----------Name
Street Address Apt. No.
City, State'a~d Zip Code
Grand Total $ " ,
Mab check or money order (NO STAMPS) ... , forthis'amount payabl e to Helm",lnc.
NOTE: Purchasers outside domestic U.S.A . ple ase write to Helm , Incorporated, p, O. Bo x 07130 , betroit, Michigan 48207 for quotation,
•
Name of Purchaser (Please print clearly)
Street Address ( ~t.No. '{
City,. State aJ"ii Zip Code .': PLEASE COMPLETE ,;6HIP/#'tNG 1.".4BEI-, ",,\,,',' I

Downloaded from www.Manualslib.com manuals search engine GAS STATION INFORMATION Refer to "Service and Maintenance"
Section for Further
Details.
Gas Cap -Located behind the
licen
se plate (coupes and sedans)
and le
ft rear fender on station
wagon model
s. See gas cap re­
moval procedure in "Service and
Maintenance" Section (Page 5-2).
Gasoline Recommendalion ­
Use only an unleaded gasoline.
. Hood Release
To Raise Hood-Th e hood release
handl e
is located beneath the in­
strument panel to the left of the steering
column. Pull the release
handle to relea
se the hood lock and
then raise the hood manually
as
shown on illustr ation.
Engine Oil DipstiCk-Located on
the left side of engine block. Check
o
il l eve l as the last operation in a
fuel stop. Main tain betwee n
"ADD"
and "FULL" marks on dipstick .
Engine Oil Recommendation­
Use only high quality SE oils. See
page 5-3 for oil viscosity chart.
Tire Inflation Pressures-Check
at least monthly. Keep inflated to
pressures shown on tire placard
af­
fixed to left front door of your ve­
hicle.
Windshield Washer -Check res­
ervoir fluid level regularly.
Use a
washer fluid, such
as GM Opti­
kleen.
Battery-Check the fluid level
monthly.
If the fluid level is low, add
only colorless, odorless drinking
water
oJ distilled water' to bring
level to
split ring in !iller opening.
EUCTROlY1E LEVEL TOO .O W
ElECTROLYTE AT CORRECt LEVEL