coolant capacity CHEVROLET MONTE CARLO 1981 4.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine If you have to add coolant more than four times a year (either to the recovery
tank or to the radiator), see your dealer for a cooling system check.
NOTICE: If you use the proper quality antifreeze, there is no· need to add extra inhihitorsor additiveswtlich claim to improve-the system. They may be harmful to the proper operation of the system.
Cooling' System Service
The cooling system should be serviced at the intervals specified in Section A of
the Maintenance Schedule folder as follows:
1. Wash the radiator cap and filler neck with clean water. See step 1 of "Coolant Replacement" for the proper way to remove the radiator cap.
2. Check the coolant level in the radiator and have it tested for freeze
protection.
Add ethylene glycol antifreeze, if needed, to maintain freeze
protection at-3JOC (~$4°f).
3. Have the cooling system and radiator cap tested for a pressure capacity of 105. kPa (15psi). (The pressure cantle anywhere from 95 kPa, or 14 psi,
to 120
kPa, or 18 psi.) If a replacement cap is needed, use an AC cap, or
an equivalent cap, designed fof coolant recovery systems and specffied for
your model.
4. Tighten all radiator hose clamps ang heater hose clamps and inspect all
hoses. Replace the hOSes if they are swollen, "checked" or otherwise worn.
NOTICE: Take care when tightening the hose clamps at the radiator. Overtightening could bend or collapse the radiator fittings.
5. Clean the front of the radiator core and air conditioning condenser to
remove dirt and other objects. Also clean the auxiliary engine oil andlor
transmission fluid cooler if the vehicle has them.
Coolant Replacernent
At the intervals specffied in Section A of the Maintenance Schedule folder, flush
9r1d refill the cooling system as follows:
1. Remove the radiator cap when the engine is cool:
•
Turn the cap slowly to the left until it reaches a "stop." Do not press
down while turning the
cap.
• Wait until any remaining pressure (indicated by a hissing sound) is
relieved, then press down on the cap and continue turning it to the left.
CAUTION: To help avoid the dangarm being burned. donotrem_ove the radiator cap While the engine' and radiator are. still. hot. Scaldingftukland steam ean be blown out under ~re It the cap is taken off too SOOf1.
2. When the cap is removed, run the engine until the upper rad.iator hose is
hot.
(ThiS shows that th~ thermostat is open and the coolant is flowing
through the system.)
3. Stop the engine. Open Ihe,actialor drain valVE! to drain the coolant. Drainage may be speeded by removing the drain plugs in the block, ff so
equipped.
5-7

Downloaded from www.Manualslib.com manuals search engine AJt Cleaner. Ail CoricIitionor FOlK Season .. Mainten ance .. AM" Pressu-e. Tires. AM" Vents. Alterna tOf tGEN) l.ghl AUniIlUffi Cafe .. AM or AM-FM Radios Antenna Antifreeze . Appearaoc e Care . Ash1rays & Lignler s. Assistance. Owl"lef Automat ic Door Locks. Automatic Transmission CorwElfter ClUlch Maintenanr;e
"""'-OpefaJ .... '1 TiPS.: AKIe. Re ar Standard . lifnited-SHp . Babies. AesCraint 01 .. BaIt Joints .. fun..., E mergency S ta ring F reedom. Gas Caution ..• GEN 191I... .•.• Test Indicator ...
. ........ 5-9
2-24
5-11
5-12
2-23 ....... 2·17 ... 2:27. 2-28 2·29 (Seo "Coolant") ,.,
2·22 6·' ,.,
2·10 5-5 .. 2 -9 2 ·'
5 ·'
5·' 1·10. ,-" . 5·1 0
3 ·' 5-10 3·' 2-17 5·10 Betore Dr iving Your Vehide... \. Bells: Sea!....,.. . (See I'Se at Belts") Blower, Healer & Air Cond.. 2-24. 2-25
Body Da mage . 4-4
.. """ ~,. Pedal Travel Trailer Towing .... Warning Ught .
2·14 2-\4 H2 2-17
Breakers . <;ircui t. • ..... 2-21. 7·3 Bteak ..... Period. New Vehicle ..• 2·2 Srioj'!( Headlights 2·7. 2·21 Brighl Metal Cleaning 4-4
Bulbs & Fuses.. 7·3. 7-4 Bumpers & HiIC:·~s. '·13 ~ 'Jack Operation ...... 3-4 B.w:ers._ . (See "'SOunds'" CoirpJler Con"mand Cont rOl System:~ 2·\8, 5·3 Cop Coolant A ecovery Tant.: .. ................. , .. 5-6 F uel.. 5-2 f>o¥Iier Steefing.. _____ -._ ....... ...... 0<. _____ -5-9 Radiator ... 5·8 Capacity, Cargo Weight. 5-11 Capacities. FlUid:. 7- Car Break-In Period . New.. 2-2 . car -Chemicals ... carbon Monoxide cautJorI .... ___ 4·' 2·' Care & Cleaning. Appearance . . .. 4·' Cargo Capacity . 5-11 Cargo on Root . Carrying,. '·2 Catalytic Converter . . ..................... ....... 5-2 ~ Command Control System .. -2·18. , ·3 Chains. Tire .. 5·15
7-6
Changing Wheets & Tires .. _ Cl-£O< ENGtl'E light .. Chectlbt, DrillSf . Child Seals & Restr ainls Chrome Protection .. ag.yette lighter ... CirCUIt Beakers QtiZOtlS Band Raoio . C!earIing .. Clock.I .. Cloth Trim Care .. ClutCh . Converter
Cold W&ather Starting ....
3 ·4 . 3·5 2 ·18. 5-3 ,., I -tO. 1·11 ... 2·22 2·21 , 7·3 2·29 . ..... 4·' 2-22 '·2 2·10 2·8 ~ip""lt Plocedu.-e . . ... 6 ·1
Condi lioner, Air (See "All" Cooditioner"~ Cons umer Relation s ... Converter ClUtch Con...eJo: Mirror Cooling System Afltilreeze (CooIanI) .. Overheating R ecovery Tank Service,. Thermoslal . COfl"lefing Lights . CorTosion Pmlection. Countries. Oper-ating in Fo.-eign .. Courtesy lights CruISe Control Cus!omer Service . 5·6
3·3
3 ·4 ,
5·6 '·7 '·8 2·7 . . 4-5 2· ' 2·30
2·12
6·' Damage, Sheet Metal . 4·4 Detogger,Re..-WiNJoW.. 2-25 DelrOSlor. Windshield . 2·24. 2·25 Delay Wipers 2·20 Descending a· Grade 2-9 Ditlererlliai (Rear Axle) limited·Slip __ 5·9 ,Malt)l~O 5 ·9
Trailllfing. 1·1 2
Dimensions 7· , Oimn'\e( Switch, Head~L 2·14 O ipshCks A.utomalic Tfansmission .. . 5-4 Engine Oil 5·3 Power Steering. 5-9 Directional Signals.. 2-7 Disc Brakes 2·15 Door loc::ks . __ ................ 1-2 Orivet' Checklist 1-1 Driving Down S teep Grades .... 2-9 in OU'sty Areas . 5 .... on Slippery Surlaces .................... 2·9 Economy ripS. Fuel .............................. 2-4 E lectric· Po_oo QpIion$ .. (See "Power"') Electrical System Banerv .. S-1 0 Bulbs .. . ....... ...... .... ........... 7,4 Circuit Breakers ....... , ........................ , 7-3 Fuses:. 7·3 GEN (Genefalor) lighI ..................... 2· 17 Jump S tarting 3- Spark Plugs 7-2 Voltmeter . 2·19 Emetgency. In Case oj Bralle WCIIllWlg li!1Il .. Eroglne Hot light .. • .. 2·17 . 2·17

Downloaded from www.Manualslib.com manuals search engine ~_ fOIl a/or OdIe) ... .. 2·17 Engine -T""1* .... -(tOn... . ..... -2·17 FASTEN SEAT BELTS._ .......... -1·5 GEN (Electrical Sysl.m) . . ........ 2·17 Hazard War'rWIg Flasher . . ........ . 3·1 Headlight Circuit breaker.. . 2·~.7·3 HeedigtIf SWi1ch ••...• _ ..... ......•..•...• 2·7. 2.21
HeadIirj1ts On Reminder .. . ....... 2-21 Hi!tI·Beam rdcaIor .. . ....... 2·21 t-K>T. . ...........•.• _ .. ....... ....... 2-'17 Instrumenl Panel... ...... 2.15 Interior .... 01.. (PresstMe) .. ... .
--
....• . '2-30 2·19 ...... 2·14 Seal Bell FIerrindBf.. 1·8 Switch Headlights ................. ......... 2·21 TEMP (Teq)8falU'e). . ...... 2,19 LJmited·SIp Oift«enIiaI.. . ........ _5--5
""'" DOOr, . • ... ... ... 1,2 ._ .... . 2·16 GloVe Box .. 19ni1ion .. .... ............. ....... .......... _ .. 2--6 Keys ,.,
Theft Protection .... ..... ..... .........• ............. 2:2 Tn,ri:. -Powcw I\aIease .. ... 2·22 Low Seat. Child & ""8111.. . ... _. HI _ Luggage /Cargo Capacity. ; ..... ,. ..... 5-11 Mainlen PressUfe Gage ... Pressure ligtll .. RecommendaTion .
5-3. 7·1 ................ 2·19 . ................. 2·17 . ........ 5- ,3
Turbo Chaoge Interval .... ........... 2·33. 5-4 01.. Ught . . .......... .... 2-17 Openings. Roof ....... ... .. : ..... (See " Roofs") Opening 'The Hood (tnside Back Cover) Trunk ..... 2-22 Windows 1-2 Operating SpeecI$ . New car . __ -2-2 OperMing rIPS Fuel Economy .. : .... : ..... . __ ... 2"" Trailer Towing.. 1-12 Transmission .. . .... ...... 2-9 V...tilaeion Sys&em.. . ...... 2-22 Openllion ., Foreign Countries .. 2-4 Outside AIIarYiew Minor. _. . 1·3 Overheating" Engine 3-3 'Oversees Operation .. 2-4 7-8
............. Pwting Brake Pa1cing Lights ... PCII Valv. & Filter ...
... 2·. . 2·14 ... 1·. .... 7·2 Pat.1 Travel, Brake ............................ 2,14 Poishing ' & Waxing.. .. ....... ..... .......... 4-4 PoIUion ~ .... (see "Emission ConIrol")
""-~ ... Brakft: .. Door LockS .. Seett ...
.............. .......... 2-25 . .................. 2 ·14 ' ·2 .................. . 1-3 --.g ........................... . .., 2-11 2·22 Trunk Refease-.. WIfIdOoWs .. .... '·3 Pressur •• Oil GagII... .. ..... ..... ...... 2·19 L911... ............................ .. .... 2·17 Pr ....... e. ne Innation .. . So-I 2 P\..tse ""* .. 2·20 I!'ushing to Start.. . .... ..... ............. .... 5-2 ........ Andfreaze (Coolant). .. 5-6 CAp. Pressure ... . ................... ....... 5-8 o.ddng l..IMI' ... _....... ......... 5-6 0vemee8ing .... 3·3 Tha-mostat... .. 5·8 Aldol & Antennas... .. ...... 2-26 • 2~29 ..... wndoW Defogger ... . ................... .... 2-25
--I.irJWted.SIip ...... ....... 2-30. 5-9 MainTenance. ... 5·5 Stanc*d . .. 5-9 Tra iletlng.. 1·12 ReaMew Mirrors 1 -3 Aeco-v Tn. Coolant ... __ .-.................. 5·6 -.. Hood .: ' .. .' ... ' (Inside Back Cover) Seatbac k Latch 1-4 Trunk ... .. .... 2-22 Reminder Lights .......... ....... {See "L ights ") Replacomenl fastlilOef s. . .. 5· 1 Reptacement Maint9l1anc; e Schedule. .,' 5· t Reptacement Owner's Manua:.. (See Older Form) Replacement Parts.. . ....... ..... ... , ..•. 5-1 ReWaints ... Rests. Head . {See "Seal Sells") ..... 1-5 .. , 3 -9 Rocking Car When Stuc k ... RooIs C.rying cargo On .. SunrOQll ...... v-.nyt ...... ____ .... _ ......
'·2 . ..... 2 ·30 ______ ..... ...... 4-4 AotiMiOn. Tire .......... ........... .............. ..... 5·13 Ruslprooting.. .. ........ 4-5 Rust Protection SaMIy Belts .. .....
........ 4-5 .. {See "Seal 8eIts .. )
_ .............. , .. . .. .... '·4 1 ·10 CtIiIcI ...... .................. .. ~ .. . .............. ... ... 1,3 Heet RMltaints ............................... " 1-5 laIcl'lM ..
.... -
. . ..... .... .......... .. 1-4
c. ................................ .. • ... 0&-3 1·10 Child Reser ..... .