check engine CHEVROLET S10 1996 2.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine 90,000 Miles (150 000 km) (Continued)
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel bearings (or at
each brake relining, whichever occurs first).
An Emission Control Sewice.?
0 Replace fuel filter.
Replace air cleaner filter.
An Emission Control Service.
DATE SERVICED BY ACTUAL MILEAGE
97,500 Miles (142.500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate the front suspension, ball joints,
steering linkage and transfer case shift
linkage, parking brake cable guides,
propshaft splines, universal joints, brake
pedal springs and clutch pedal springs at
every
oil change (or every 12 months,
whichever occurs first).
0 Check readfront axle fluid level and add
fluid as needed. Check constant velocity
joints and axle seals for leaking.**
7-44

Downloaded from www.Manualslib.com manuals search engine Long Tripmighway Maintenance Schedule
0 Rotate tires. See “Tire Inspection
and Rotation” in the Index for proper
rotation pattern and additional information.
During tire rotation, check brake calipers
for freedom
of movement. Refer to the
appropriate
GM service manual for proper
caliper service procedures.
DATE ACTUAL MILEAGE SERVICED BY:
I I I
100,000 Miles (1 66 000 km)
0 Drain, flush and refill cooling system
(or every
60 months since last service,
whichever occurs first). See “Engine
Coolant” in the Index for what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test the cooling system and pressure cap.
An Emission Control Service.?
0 Inspect spark plug wires.
An Emission Control Service.
Replace spark plugs.
An Emission Control Service.
(Continued)
7-45

Downloaded from www.Manualslib.com manuals search engine Part B: Owner Checks and Services
Listed below are owner checks and services which
should be performed
at the intervals specified to help
ensure the safety, dependability and emission control
performance
of your vehicle.
Be sure
any necessary repairs are completed at once.
Whenever any fluids or lubricants are added
to your
vehicle, make sure they are the proper ones, as shown
in Part
D.
At Each Fuel Fill
It is important for you or a service station attendant to
pegorm these underhood checks at each fuel
fill.
Engine Oil Level Check
Check the engine oil level and add the proper oil
if necessary. See “Engine Oil” in the Index for
further details.
Engine Coolant Level Check
Check the engine coolant level and add the proper
coolant mix if necessary. See “Engine Coolant” in
the
Index for further details.
Windshield Washer Fluid Level Check
Check the windshield washer fluid level in the
windshield washer tank and add the proper fluid if
necessary. See “Windshield Washer Fluid” in the Index
for further details.
At Least -Once a Month
Tire Inflation Check
Make sure tires are inflated to the correct pressures. See
“Tires”
in the Index for further details.
Cassette Deck Service
Clean cassette deck. Cleaning should be done every
50 hours of tape play. See “Audio Systems” in the Index
for further details.
7-47

Downloaded from www.Manualslib.com manuals search engine At Least Twice a Year
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages are
working properly. Look for any other loose or damaged
safety belt system parts. If you see anything that might
keep a safety belt system from doing its job, have it
repaired. Have any torn or frayed safety belts replaced.
Also look for any opened or broken air bag covers, and
have them repaired
or replaced. (The air bag system
does not need regular maintenance.)
Manual Transmission Check
Check the transmission fluid level; add if needed. See
“Manual Transmission” in the Index. A fluid
loss may
indicate a problem. Check the system and repair if needed.
Automatic Transmission Check
Check the transmission fluid level; add if needed. See
“Automatic Transmission” in the Index.
A fluid loss may
indicate a problem. Check the system and repair if needed.
Hydraulic Clutch System Check
At Least Four Times a Year
Tailgate Lubrication Service
Lubricate tailgate latch bolt, handle assembly pivot
points, and hinges with lubricant recommended in
Part
D. Lubricate every 3,000 miles (5 000 km) if
following schedule I or every
7,500 miles (12 500 km)
if following schedule 11.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
specified in Part
D.
Body Lubrication Service
Lubricate all body door and fuel door hinges, latches
and locks including the glove box, console doors and the
body hood, and any moving seat hardware. Lubricate
the hood safety lever pivot and prop rod pivot. Part
D
tells you what to use. More frequent lubrication may be
required when exposed to a corrosive environment.
Check the fluid level in the clutch reservoir. See
“Hydraulic Clutch Fluid” in the Index.
A fluid loss in
this system could indicate a problem. Have the system
inspected and repaired at once.
7-48

Downloaded from www.Manualslib.com manuals search engine Starter Switch Check
A CAUTION:
When you are doing this check, the vehicle could
move suddenly.
If it does, you or others could be
injured.
Follow the steps below.
1. Before you start, be sure you have enough room
2. Firmly apply both the parking brake (see “Parking
Brake” in the Index
if necessary) and the regular brake.
NOTE:
Do not use the accelerator pedal, and be
ready to turn off the engine immediately if
it starts.
3. On automatic transmission vehicles, try to start the
engine in each gear. The starter should work
only in
PARK (P) or NEUTRAL (N). If the starter works in
any other position, your vehicle needs service.
On manual transmission vehicles, put the shift lever
in NEUTRAL (N), push the clutch down halfway
and try to start
the engine. The starter should work.
only when the clutch is pushed down all the way
to
the floor. If the st,arter works when the clutch isn’t
pushed all the way down, your vehicle needs service.
around
the vehicle.
Brake-Transmission Shift Interlock (BTSI) Check
(Automatic Transmission)
t
--- I
When you are doing this check, the vehicle could
move suddenly.
If it does, you or others could be
injured. Follow the steps below.
1.
2.
3.
Before you start, be sure you have enough room
around the vehicle. It should be parked on a
level surface.
Firmly apply the parking brake (see “Parking Brake”
in the Index if necessary).
NOTE: Be ready to apply the regular brake
immediately if the vehicle begins
to move.
With
the engine off, turn the key to the RUN
position, but don’t start the engine. Without applying
the regular brake, try to move the shift lever
out of
PARK
(P) with normal effort. If the shift lever
moves out of PARK (P), your vehicle’s BTSI
needs service.
7-49

Downloaded from www.Manualslib.com manuals search engine Steering Column Lock Check
,While parked, and with the parking brake set, try to turn
the key to LOCK in each shift lever position.
With an automatic transmission, the key should turn
to LOCK only when the shift lever is in PARK (P).
With a manual transmission, the key should
turn to LOCK only when the shift lever is in
REVERSE (R).
On vehicles with a key release button, try to turn the key
to LOCK without pressing the button. The key should
turn to LOCK only when you press the key button.
On all vehicles, the key should come out only in LOCK. Parking Brake and Automatic Transmission
PARK (P) Mechanism Check
When you are doing this check, your vehicle
could begin to move.
You or others could be
injured and property could be damaged. Make
sure there is room in front of your vehicle in case
it begins to roll. Be ready to apply the regular
brake at once should the vehicle begin to move.
~~
Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot
on the regular brake, set the
parking brake.
To check the parking brake: With the engine running
and transmission in NEUTRAL
(N), slowly remove
foot pressure from the regular brake pedal.
Do this
until the vehicle is held by the parking brake only.
To check the PARK (P) mechanism’s holding ability:
with the engine running, shift
to PARK (P). Then
release all brakes.
7-50

Downloaded from www.Manualslib.com manuals search engine Drive Axle Service
Check readfront axle fluid level and add as needed.
Check constant velocity joints and axle seals for leaking.
Transfer Case (Four- Wheel Drive)
Inspection
Every 12 months or at oil change intervals, check front
axle and transfer case and add lubricant when necessary.
Check vent hose at transfer case for kinks and proper
installation. More frequent lubrication may be required
on off-road use.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors
for surface condition. Also inspect
drum brake linings
for wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc.
Check parking brake adjustment. You may need to have
your brakes inspected more often if your driving habits
or conditions result in frequent braking.
7-52

Downloaded from www.Manualslib.com manuals search engine Part E: Maintenance Record
After the scheduled services are performed, record the
date, odometer reading and who performed the service
in the boxes provided after the maintenance interval.
Any additional information from “Owner Checks and Services” or “Periodic Maintenance” can be added on
the following record pages. Also, you should retain all
maintenance receipts. Your owner information portfolio
is a convenient place to store them.
Maintenance Record
ODOMETER
DATE READING SERVICED
BY MAINTENANCE PERFORMED ~~ ~

Downloaded from www.Manualslib.com manuals search engine Section 9 Index
Accessory Power Outlet ......................... 2-47
Adding Sound Equipment
........................ 3- 17
Add-on Equipment
............................. 4-44
AirBag
....................................... 1-18
Adding Equipment ............................ 1-24
How Does
it Restrain .......................... 1-21
How
it Works ................................ 1-20
Location
.................................... 1-20
Readiness Light
......................... 1-1 9. 2.54
Servicing
................................... 1-23
What Makes
it Inflate .......................... 1-2 I
What Will You See After it Inflates ............... 1-22
When Should
it Inflate ......................... 1-20
Aircleaner
............................... 6.14. 6.67
Air Conditioning/Heater Controls
................... 3-2
Air Conditioning Refrigerants
..................... 6-68
Alignment and Balance. Tire
...................... 6-50
Aluminum Wheels. Cleaning
...................... 6-58
Antenna. Fixed
................................. 3-18
Anti-Lock Brakes ............................... 4-6
Anti-Lock Brake System Warning Light
......... 2.56. 4.6
Appearancecare
............................... 6-52
Appearance Care Materials
....................... 6-60
Arbitration Program
.............................. 8-7
Armrest. Storage ............................... 2-45
Ashtrays
...................................... 2-46
Audio Systems
.................................. 3-5
Automatic Overdrive
............................ 2-16
Automatic Transmission
Check
...................................... 7-48
Fluid ................................... 6-16. 6-68
Operation
................................... 2-14
Park Mechanism Check
........................ 7-50
Shifting
..................................... 2-14
Front
....................................... 6-23
Rear
.................................. 2.19. 6.21
Axle
Battery
...................................... 6-35
Jump Starting ................................. 5-2
Replacement. Keyless Entry
..................... 2-5
Warnings
.................................... 5-2
BBB Auto Line
................................. 8-7
Better Business Bureau Mediation ................... 8-7
BrakeFluid .................................... 6-31
Brake. Parking
................................. 2-25
Brake System Warning Light
...................... 2-55
ChargeLight
................................ 2-54
9-1

Downloaded from www.Manualslib.com manuals search engine I
Brakes Adjustment ........... ....................... '6-34
qMager Cylinder ............................... 6-31 Anti-Lock .................................... 4-6
Pedal Travel- ................................. 6-34
Replading System Parts ......................... 6-34
Trailer 4-52
Wear ....................................... 6-33
Brake-Transmission' Shift Interlock Check ........... 7-49
Braking ......................................... 4-5
......................................
BTaking in Emergencies ........................... 4-8
Break-In, New Vehicle ............................ 2-8
BTSI Check .................................... 7-49
Bulb Replacement .......................... 6-35., 6-66
Brightness Control ............................. ; 2-42
Canadian Roadside Assistance .................... 8-6
Capacities and Specifications ................. 6-66. 6-68
Cassette Tape Player ......................... 3.7. 3.9
Center High-Mounted Stoplamp Bulb Replacement .... 6-39
Center Passenger Position ........................ 1-25
Certif?cation/Tire Label ............... , ........... 4-42
Chains
Carbon Manoxide .......................... 2.30. 4.40
Care ....................................... 3-18
Safety ...................................... 4-51
Tire ......................................... 6-52 Changing a Flat Tire ............................. 5-22
Charging System Light .......................... 2-54
Check Gages Light ' ' ... ' .. 2-62 ............... ..........
Checking Your Restraint Systems .................... 1-38 Chemical Paint Spotting .......................... 6-59
ChiSd-ReStraints ........................... 1 .... 1-30
Securing in the Center Seat Position (Except W40) . . 1-31
Securing in the Right FTont Seat Position .......... 1-33
Where Not to Put
Top
Strap
................................... : 1-30.
......................... 1-32. 1-33
Cleaner, Air .............................. 6-14, 6-67
Aluminum Wheels ............................ 6-58
Inside of Your Vehicle ......................... 6-53
.
Cigarette Lighter ................................ 2-46
Circuit Breakers and Fuses ......................... 6-63
Cleaning
Fabric
........................................ 6-53
Glass 6-56
Instrument Panel ................ .'. ....... 1 ... 6-55
Leather .................. : ..................... 6-55
Outside of Your Vehicle' ........................ 6-57
Safety Belts ................................... 6-56
Stains ...................................... 6-54
Tires 6-58
.Vinyl ....................................... 6-55
Weatherstrips .................... : ............ 6-56
.......................................
........................................
Wheels ...................................... 6-58
Windshield and Wiper Blades ................... 6-56
Climate Control System ........................... 3-1
Clock, Setting ................................... 3-5
Comfort Controls ................................ 3-1 Clutch, Hydraulic ................................ 6-20
Compact Disc Care ......... I. .................... 3-18
9-2