power steering CHEVROLET SILVERADO 2007 1.G User Guide

When to Check Power Steering Fluid
It is not necessary to regularly check power
steering uid unless you suspect there is a leak in
the system or you hear an unusual noise. A
uid loss in this system could indicate a problem.
Have the system inspected and repaired.
How to Check Power Steering Fluid
To check the power steering uid, do the following:
1. Turn the key off and let the engine
compartment cool down.
2. Wipe the cap and the top of the reservoir
clean.
3. Unscrew the cap and wipe the dipstick with a
clean rag.
4. Replace the cap and completely tighten it.
5. Remove the cap again and look at the
uid level on the dipstick.
The level should be at the FULL COLD mark. If
necessary, add only enough uid to bring the level
up to the mark.
What to Use
To determine what kind of uid to use, see
Recommended Fluids and Lubricants on page 639.
Always use the proper uid. Failure to use the
proper uid can cause leaks and damage hoses
and seals.
Windshield Washer Fluid
What to Use
When windshield washer uid needs to be added,
be sure to read the manufacturer’s instructions
before use. Use a uid that has sufficient
protection against freezing in an area where the
temperature may fall below freezing.
527

(E) Rim Diameter:Diameter of the wheel in
inches.
(F) Service Description:The service description
indicates the load range and speed rating of a
tire. The load index can range from 1 to 279.
Speed ratings range from A to Z.
Tire Terminology and Denitions
Air Pressure:The amount of air inside the tire
pressing outward on each square inch of the
tire. Air pressure is expressed in pounds
per square inch (psi) or kilopascal (kPa).
Accessory Weight:This means the combined
weight of optional accessories. Some examples of
optional accessories are, automatic transmission,
power steering, power brakes, power windows,
power seats, and air conditioning.
Aspect Ratio:The relationship of a tire’s height
to its width.
Belt:A rubber coated layer of cords that is
located between the plies and the tread. Cords
may be made from steel or other reinforcing
materials.Bead:The tire bead contains steel wires wrapped
by steel cords that hold the tire onto the rim.
Bias Ply Tire:A pneumatic tire in which the plies
are laid at alternate angles less than 90 degrees
to the centerline of the tread.
Cold Tire Pressure:The amount of air pressure
in a tire, measured in pounds per square inch (psi)
or kilopascals (kPa) before a tire has built up heat
from driving. SeeInation - Tire Pressure on
page 561.
Curb Weight:This means the weight of a motor
vehicle with standard and optional equipment
including the maximum capacity of fuel, oil, and
coolant, but without passengers and cargo.
DOT Markings:A code molded into the sidewall
of a tire signifying that the tire is in compliance
with the U.S. Department of Transportation (DOT)
motor vehicle safety standards. The DOT code
includes the Tire Identication Number (TIN),
an alphanumeric designator which can also identify
the tire manufacturer, production plant, brand,
and date of production.
GVWR:Gross Vehicle Weight Rating. See
Loading Your Vehicle on page 427.
558

Fuses Usage
REAR SEAT Rear Seats
AUX PWR2 Rear Accessory Power Outlet
SWC BKLT Steering Wheel Controls Backlight
DDM Driver Door Module
CTSYDome Lamps, Driver’s Side Turn
Signal
LT STOP TRN Driver Side Turn Signal, Stoplamp
DIM Instrument Panel Back Lighting
RT STOP TRNPassenger Side Turn Signal,
Stoplamp
Fuses Usage
PDMPassenger Door Module, Universal
Home Remote System
UNLCK2 Power Door Lock 2 (Unlock Feature)
LCK2 Power Door Lock 2 (Lock Feature)
STOP LAMPSStoplamps, Center-High Mounted
Stoplamp
REAR HVAC Rear Climate Controls
PWR MIR Power Mirror
BCM Body Control Module (BCM)
AUX PWR Accessory Power Outlets
IS LAMPS Interior Lamps
UNLCK1 Power Door Lock 1 (Unlock Feature)
OBS DET Ultrasonic Rear Parking Assist
LCK1 Power Door Lock 1 (Lock Feature)
REAR WPR Not Used
COOLED
SEATSNot Used
DSMDriver Seat Module, Remote
Keyless Entry System
DRV UNLCKDriver’s Power Door Lock (Unlock
Feature)
613

Circuit Breaker Usage
LT DRDriver’s Side Power Window Circuit
Breaker
Harness
ConnectorUsage
LT DR Driver’s Door Harness Connection
BODY Harness Connector
BODY Harness Connector
Center Instrument Panel Fuse Block
The center instrument panel fuse block is
located underneath the instrument panel, to the
left of the steering column.
Top View
Harness
ConnectorUsage
BODY 2 Body Harness Connector 2
BODY 1 Body Harness Connector 1
BODY 3 Body Harness Connector 3
HEADLINER 3 Headliner Harness Connector 3
HEADLINER 2 Headliner Harness Connector 2
HEADLINER 1 Headliner Harness Connector 1
614

Maintenance Footnotes
(Gasoline Engine)
This maintenance section applies to vehicles with
a gasoline engine. If your vehicle has a diesel
engine, see the maintenance schedule section in
the DURAMAX
®Diesel Engine Supplement.
†The U.S. Environmental Protection Agency or
the California Air Resources Board has determined
that the failure to perform this maintenance item
will not nullify the emission warranty or limit
recall liability prior to the completion of the
vehicle’s useful life. We, however, urge that all
recommended maintenance services be performed
at the indicated intervals and the maintenance
be recorded.
#Lubricate the front suspension, steering linkage,
transmission shift linkage, and parking brake cable
guides. Control arm ball joints on 2500/3500 series
vehicles require lubrication but should not be
lubricated unless their temperature is
10°F (−12°C) or higher, or they could be damaged.
Control arm ball joints on 1500 series vehicles are
maintenance-free. Vehicles used under severe
commercial operating conditions require lubrication
on a regular basis every 3,000 miles (5 000 km).(a)Visually inspect brake lines and hoses for
proper hook-up, binding, leaks, cracks, chang,
etc. Inspect disc brake pads for wear and rotors for
surface condition. Inspect drum brake
linings/shoes for wear or cracks. Inspect other
brake parts, including drums, wheel cylinders,
calipers, parking brake, etc.
(b)Visually inspect front and rear suspension and
steering system for damaged, loose or missing
parts, signs of wear or lack of lubrication. Inspect
power steering lines and hoses for proper
hook-up, binding, leaks, cracks, chang, etc.
Visually check constant velocity joints, rubber
boots, and axle seals for leaks.
(c)Visually inspect hoses and have them replaced
if they are cracked, swollen, or deteriorated.
Inspect all pipes, ttings and clamps; replace with
genuine GM parts as needed. To help ensure
proper operation, a pressure test of the cooling
system and pressure cap and cleaning the outside
of the radiator and air conditioning condenser is
recommended at least once a year.
(d)Visually inspect wiper blades for wear or
cracking. Replace wiper blades that appear worn
or damaged or that streak or miss areas of
the windshield.
633

Usage Fluid/Lubricant
Hydraulic Brake
SystemDelco
®Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Windshield
WasherGM Optikleen
®Washer Solvent.
Power Steering
SystemGM Power Steering Fluid
(GM Part No. U.S. 89021184, in
Canada 89021186).
Automatic
TransmissionDEXRON
®-VI Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
Floor Shift
LinkageLubriplate Lubricant Aerosol
(GM Part No. U.S. 12346293, in
Canada 992723) or lubricant
meeting requirements of NLGI #2
Category LB or GC-LB.
Usage Fluid/Lubricant
Chassis
LubricationChassis Lubricant
(GM Part No. U.S. 12377985, in
Canada 88901242) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Front Axle
(1500 Series)SAE 80W-90 Axle Lubricant
(GM Part No. U.S. 1052271, in
Canada 10950849).
Front Axle
(1500 HD,
2500, 2500 HD,
and 3500
Series)SAE 75W-90 Synthetic Axle
Lubricant (GM Part
No. U.S. 12378261, in
Canada 10953455) meeting
GM Specication 9986115.
Rear AxleSAE 75W-90 Synthetic Axle
Lubricant (GM Part
No. U.S. 12378261, in
Canada 10953455) meeting
GM Specication 9986115.
640

Appearance Care (cont.)
Weatherstrips........................................... 604
Windshield and Wiper Blades................... 606
Ashtray....................................................... 235
Audio System.............................................. 302
AM-FM Radio.......................................... 306
Audio Steering Wheel Controls................. 370
Care of Your CD and DVD Player............ 373
Care of Your CDs and DVDs................... 372
Fixed Mast Antenna................................. 373
Navigation/Radio System, see
Navigation Manual................................ 357
Radio with CD................................308, 314
Rear Seat Audio (RSA)............................ 368
Setting the Time...................................... 303
Theft-Deterrent Feature............................ 370
Understanding Radio Reception............... 371
XM™ Satellite Radio Antenna System...... 373
Audio System(s)
Radio with CD and DVD.......................... 324
Automatic Headlamp System....................... 225
Automatic Transmission
Fluid........................................................ 510
Operation................................................. 140
Auxiliary Roof Mounted Lamp Switch.......... 227B
Battery........................................................ 533
Electric Power Management..................... 229
Run-Down Protection............................... 230
Before Leaving on a Long Trip.................... 416
Brake
Emergencies............................................ 383
Parking.................................................... 164
Brakes........................................................ 529
System Warning Light.............................. 258
Braking....................................................... 380
Braking in Emergencies............................... 383
Break-In, New Vehicle................................. 134
Bulb Replacement....................................... 545
Center High-Mounted Stoplamp
(CHMSL) and Cargo Lamp................... 547
Halogen Bulbs......................................... 545
Headlamps............................................... 546
License Plate Lamps................................ 550
Pickup Box Identication and Fender
Marker Lamps...................................... 548
Replacement Bulbs.................................. 551
Taillamps, Turn Signal, Stoplamps and
Back-up Lamps..................................... 548
Buying New Tires........................................ 572
670

Entry Lighting.............................................. 228
Event Data Recorders (EDR)...................... 659
Exit Lighting................................................ 228
Extender, Safety Belt..................................... 45
Exterior Lamps............................................ 223
F
Filter
Engine Air Cleaner................................... 507
Finish Damage............................................ 608
Fixed Mast Antenna.................................... 373
Flashers, Hazard Warning........................... 213
Flash-to-Pass.............................................. 216
Flat Tire...................................................... 579
Flat Tire, Changing...................................... 580
Flat Tire, Storing......................................... 596
Fluid
Automatic Transmission............................ 510
Power Steering........................................ 526
Windshield Washer.................................. 527
Fog Lamp
Fog .......................................................... 226
Fog Lamp Light........................................... 267
Four-Wheel Drive...............................149, 541
Four-Wheel-Drive Light................................ 267
Front Axle................................................... 543Fuel............................................................ 490
Additives.................................................. 492
California Fuel.......................................... 491
E85 (85% Ethanol)................................... 493
Filling a Portable Fuel Container.............. 497
Filling Your Tank...................................... 494
Fuels in Foreign Countries....................... 494
Gage....................................................... 268
Gasoline Octane...................................... 491
Gasoline Specications............................ 491
Low Warning Light................................... 269
Fuses
Center Instrument Panel Fuse Block........ 614
Fuses and Circuit Breakers...................... 612
Instrument Panel Fuse Block................... 612
Underhood Fuse Block............................. 615
Windshield Wiper..................................... 611
G
Gage
Engine Coolant Temperature.................... 260
Fuel......................................................... 268
Oil Pressure............................................. 265
Speedometer........................................... 250
674

Passing....................................................... 389
PASS-Key®III+........................................... 131
PASS-Key®III+ Operation........................... 132
Pickup Conversion to Chassis Cab.............. 441
Power
Door Locks.............................................. 121
Electrical System..................................... 611
Lumbar Controls........................................ 11
Retained Accessory (RAP)....................... 136
Seat.......................................................... 10
Sliding Rear Window................................ 128
Steering Fluid.......................................... 526
Windows.................................................. 127
Pretensioners, Safety Belt............................. 45
Privacy........................................................ 659
Programmable Automatic Door Locks.......... 121
Puddle Lamps............................................. 226
Q
Questions and Answers About Safety Belts ... 26
R
Radios........................................................ 302
AM-FM Radio.......................................... 306
Care of Your CD and DVD Player............ 373Radios (cont.)
Care of Your CDs and DVDs................... 372
Navigation/Radio System, see
Navigation Manual................................ 357
Radio with CD................................308, 314
Radio with CD and DVD.......................... 324
Rear Seat Audio...................................... 368
Setting the Time...................................... 303
Theft-Deterrent......................................... 370
Understanding Reception......................... 371
Rainsense™ II Wipers................................. 218
Reading Lamps........................................... 228
Rear Axle.................................................... 540
Locking.................................................... 383
Rear Door Security Locks........................... 122
Rear Doors................................................. 123
Rear Safety Belt Comfort Guides.................. 42
Rear Seat Armrest...................................... 201
Rear Seat Audio (RSA)............................... 368
Rear Seat Entertainment System................. 357
Rear Seat Operation.............................. 20, 21
Rear Seat Passengers, Safety Belts.............. 39
Rearview Mirror, Automatic Dimming with
Compass and Temperature Display.......... 175
Rearview Mirror, Automatic Dimming with
OnStar®, Compass and Temperature
Display..................................................... 171
679

Safety Warnings and Symbols......................... 4
Scheduled Maintenance............................... 627
Seatback Latches.......................................... 19
Seats
Center Seat............................................... 19
Head Restraints......................................... 18
Heated Seats............................................. 12
Manual........................................................ 9
Manual Lumbar.......................................... 11
Memory, Mirrors and Pedals...................... 13
Power Lumbar........................................... 11
Power Seats.............................................. 10
Rear Seat Operation........................... 20, 21
Reclining Seatbacks................................... 15
Seatback Latches...................................... 19
Secondary Latch System............................. 592
Securing a Child Restraint
Center Front Seat Position......................... 72
Rear Seat Position..................................... 69
Right Front Seat Position.................... 72, 78
Right Front Seat Position (Crew Cab)........ 83
Security Light.............................................. 266
Service........................................................ 488
Accessories and Modications.................. 488
Adding Equipment to the Outside of
Your Vehicle......................................... 490
California Proposition 65 Warning............. 489Service (cont.)
Doing Your Own Work............................. 489
Engine Soon Light................................... 262
Publications Ordering Information............. 666
Servicing Your Airbag-Equipped Vehicle....... 104
Sheet Metal Damage................................... 608
Shifting Into Park (P)................................... 165
Shifting Out of Park (P)............................... 167
Shoulder Belt Height Adjuster........................ 35
Signals, Turn and Lane-Change.................. 215
Sliding Rear Window, Power....................... 128
Snow Plow.................................................. 434
Spare Tire................................................... 600
Installing.................................................. 586
Removing................................................ 582
Storing..................................................... 596
Specications, Capacities............................ 620
Speedometer............................................... 250
StabiliTrak
®System..................................... 384
StabiliTrak®Indicator Light........................... 260
Starting Your Engine................................... 136
Steering...................................................... 387
Steering Wheel Controls, Audio................... 370
Steering Wheel, Tilt Wheel.......................... 214
Storage Areas............................................. 198
Cargo Management System..................... 201
Center Console Storage Area................... 199
681