coolant temperature CHEVROLET SILVERADO 2017 3.G User Guide
[x] Cancel search | Manufacturer: CHEVROLET, Model Year: 2017, Model line: SILVERADO, Model: CHEVROLET SILVERADO 2017 3.GPages: 509, PDF Size: 8.87 MB
Page 369 of 509

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9956065) - 2017 - CRC - 4/29/16
368 Vehicle Care
4. Remove the four screws (1) ontop of the cover of the housingand lift up the cover.
5. Remove the engine air cleaner/filter from the housing. Takecare to dislodge as little dirt aspossible.
6. Clean the engine air cleaner/filter sealing surfaces and thehousing.
7. Inspect or replace the engineair cleaner/filter.
8. Reverse Steps 2–4toreinstallthe filter cover housing.
{Warning
Operating the engine with the air
cleaner/filter off can cause you or
others to be burned. The air
cleaner not only cleans the air; it
helps to stop flames if the engine
backfires. Use caution when
working on the engine and do not
drive with the air cleaner/filter off.
Caution
If the air cleaner/filter is off, dirt
can easily get into the engine,
which could damage it. Always
have the air cleaner/filter in place
when you are driving.
Cooling System
If the vehicle has the Duramaxdiesel engine, see the Duramaxdiesel supplement.
The cooling system allows theengine to maintain the correctworking temperature.
5.3L V8 Engine Shown, 4.3L
V6 Engine and 6.2L V8 Engine
Similar
1. Coolant Surge Tank
2. Coolant Surge TankPressure Cap
3. Engine Electric CoolingFans (Out of View)
{Warning
An electric engine cooling fan can
start even when the engine is not
running. To avoid injury, always
(Continued)
Page 371 of 509

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9956065) - 2017 - CRC - 4/29/16
370 Vehicle Care
Warning (Continued)
overheat warning. The engine
could catch fire and you or others
could be burned. Use a
50/50 mixture of clean, drinkable
water and DEX-COOL coolant.
Use a 50/50 mixture of clean,drinkable water and DEX-COOLcoolant. If using this mixture,nothing else needs to be added.This mixture:
.Gives freezing protection downto✓37 °C (✓34 °F), outsidetemperature.
.Gives boiling protection up to129 °C (265 °F), enginetemperature.
.Protects against rust andcorrosion.
.Will not damage aluminum parts.
.Helps keep the proper enginetemperature.
Caution
If improper coolant mixture,
inhibitors, or additives are used in
the vehicle cooling system, the
engine could overheat and be
damaged. Too much water in the
mixture can freeze and crack
engine cooling parts. The repairs
would not be covered by the
vehicle warranty. Use only the
proper mixture of engine coolant
for the cooling system. See
Recommended Fluids and
Lubricants0462.
Never dispose of engine coolant byputting it in the trash, or by pouringit on the ground, or into sewers,streams, or bodies of water. Havethe coolant changed by anauthorized service center, familiarwith legal requirements regardingused coolant disposal. This will helpprotect the environment and yourhealth.
Checking Coolant
The coolant surge tank is located inthe engine compartment on thepassenger side of the vehicle. SeeEngine CompartmentOverview0354.
The vehicle must be on a levelsurface when checking the coolantlevel.
5.3L V8 Shown, 4.3L V6, 6.0L V8,
and 6.2L V8 Similar
Check to see if coolant is visible inthe coolant surge tank. If the coolantinside the coolant surge tank isboiling, wait until it cools down. Thecoolant level should be at or above
Page 373 of 509

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9956065) - 2017 - CRC - 4/29/16
372 Vehicle Care
4. With the coolant surge tankpressure cap off, start theengine and let it run until theengine coolant temperaturegauge indicates approximately90 °C (195 °F).
By this time, the coolant levelinside the coolant surge tankmay be lower. If the level islower, add more of the propermixture to the coolant surgetank until the level reaches theFULL COLD mark.
5. Replace the pressure captightly.
6. Verify coolant level after theengine is shut off and thecoolant is cold. If necessary,repeat coolant fill procedureSteps 1–6.
Caution
If the pressure cap is not tightly
installed, coolant loss and
possible engine damage may
occur. Be sure the cap is properly
and tightly secured.
Engine Overheating
If the vehicle has the Duramaxdiesel engine, see the Duramaxdiesel supplement.
Caution
Running the engine without
coolant may cause damage or a
fire. Vehicle damage would not be
covered by the vehicle warranty.
The vehicle has several indicatorsto warn of engine overheating.
There is a coolant temperaturegauge in the vehicle's instrumentcluster. SeeEngine CoolantTe m p e r a t u r e G a u g e0133.
In addition, there are ENGINEOVERHEATED STOP ENGINE,ENGINE OVERHEATED IDLEENGINE, and ENGINE POWER ISREDUCED messages in the DriverInformation Center (DIC). SeeEngine Cooling System Messages0152andEngine PowerMessages0153.
If the decision is made not to lift thehood when this warning appears,get service help right away. SeeRoadside AssistanceProgram0476.
If the decision is made to lift thehood, make sure the vehicle isparked on a level surface.
4.3L V6, 5.3L V8, and 6.2LV8 Engines
Check to see if the engine coolingfans are running. If the engine isoverheating, the fans should berunning. If they are not, do notcontinue to run the engine and havethe vehicle serviced.
If Steam is Coming from the
Engine Compartment
{Warning
Steam from an overheated engine
can burn you badly, even if you
just open the hood. Stay away
from the engine if you see or hear
steam coming from it. Just turn it
(Continued)
Page 374 of 509

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9956065) - 2017 - CRC - 4/29/16
Vehicle Care 373
Warning (Continued)
off and get everyone away from
the vehicle until it cools down.
Wait until there is no sign of
steam or coolant before you open
the hood.
If you keep driving when the
engine is overheated, the liquids
in it can catch fire. You or others
could be badly burned. Stop the
engine if it overheats, and get out
of the vehicle until the engine
is cool.
If No Steam is Coming from
the Engine Compartment
The ENGINE OVERHEATED STOPENGINE or the ENGINEOVERHEATED IDLE ENGINEmessage, along with a low coolantcondition, can indicate a seriousproblem.
If there is an engine overheatwarning, but no steam is seen orheard, the problem may not be tooserious. Sometimes the engine canget a little too hot when the vehicle:
.Climbs a long hill on a hot day.
.Stops after high-speed driving.
.Idles for long periods in traffic.
.To w s a t r a i l e r ; s e eTr a i l e rTo w i n g0318.
If the ENGINE OVERHEATEDSTOP ENGINE or the ENGINEOVERHEATED IDLE ENGINEmessage appears with no sign ofsteam, try this for a minute or so:
1. Turn the air conditioning off.
2. Turn the heater on to thehighest temperature and to thehighest fan speed. Open thewindows as necessary.
3. When it is safe to do so, pull offthe road, shift to P (Park) orN(Neutral)andlettheengine idle.
If the temperature overheat gauge isno longer in the overheat zone or anoverheat warning no longer
displays, the vehicle can be driven.Continue to drive the vehicle slowlyfor about 10 minutes. Keep a safevehicle distance from the vehicle infront. If the warning does not comeback on, continue to drive normallyand have the cooling systemchecked for proper fill and function.
If the warning continues, pull over,stop, and park the vehicleright away.
If there is still no sign of steam andthe vehicle is equipped with anengine driven cooling fan, pushdown the accelerator until theengine speed is about twice as fastas normal idle speed for at leastfive minutes while the vehicle isparked. If the warning is still there,turn off the engine and get everyoneout of the vehicle until it cools down.
If there is no sign of steam, idle theengine for five minutes whileparked. If the warning is stilldisplayed, turn off the engine until itcools down.
Page 375 of 509

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9956065) - 2017 - CRC - 4/29/16
374 Vehicle Care
Overheated Engine
Protection
Operating Mode
If an overheated engine conditionexists and the ENGINE POWER ISREDUCED message displays, anoverheat protection mode whichalternates firing groups of cylindershelps to prevent engine damage. Inthis mode, a loss in power andengine performance will be noticed.This operating mode allows thevehicle to be driven to a safe placein an emergency. Driving extendeddistances and/or towing a trailer inthe overheat protection modeshould be avoided.
Caution
After driving in the overheated
engine protection operating
mode, the engine oil will be
severely degraded. Any repairs
performed before the engine is
cool may cause engine damage.
Allow the engine to cool before
(Continued)
Caution (Continued)
attempting any repair. Repair the
cause of coolant loss, change the
oil, and reset the oil life system.
SeeEngine Oil0359.
Engine Fan
If the vehicle has a clutched enginecooling fan, when the clutch isengaged, the fan spins faster toprovide more air to cool the engine.In most everyday driving conditions,the fan is spinning slower and theclutch is not fully engaged. Thisimproves fuel economy and reducesfan noise. Under heavy vehicleloading, trailer towing, and/or highoutside temperatures, the fan speedincreases as the clutch more fullyengages, so an increase in fannoise may be heard. This is normaland should not be mistaken as thetransmission slipping or makingextra shifts. It is merely the coolingsystem functioning properly. The fanwill slow down when additionalcooling is not required and theclutch disengages.
This fan noise may also be heardwhen starting the engine. It will goaway as the fan clutch partiallydisengages.
If the vehicle has electric coolingfan(s), the fans may be heardspinning at low speed during mosteveryday driving. The fans may turnoff if no cooling is required. Underheavy vehicle loading, trailer towing,high outside temperatures,or operation of the air conditioningsystem, the fans may change tohigh speed and an increase in fannoise may be heard. This is normaland indicates that the coolingsystem is functioning properly. Thefans will change to low speed whenadditional cooling is no longerrequired.
The electric engine cooling fansmay run after the engine has beenturned. off. This is normal and noservice is required.
Page 499 of 509

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9956065) - 2017 - CRC - 4/29/16
498 Index
C
Calibration . . . . . . . . . . . . . . . . . . . . . . 122
California
Fuel Requirements . . . . . . . . . . . 312
Perchlorate Materials
Requirements . . . . . . . . . . . . . . . 352
California
Proposition
65 Warning . . . . . . . . . .351, 378, 432
Canadian Vehicle Owners . . . . . . . . 2
Capacities and
Specifications . . . . . . . . . . . . . . . . . 468
Carbon Monoxide
Engine Exhaust . . . . . . . . . . . . . . . 276
Ta i l g a t e . . . . . . . . . . . . . . . . . . . . . . . . . 4 2
Winter Driving . . . . . . . . . . . . . . . . 257
Cargo
Tie-Downs . . . . . . . . . . . . . . . . . . . . . 117
Cargo Lamp . . . . . . . . . . . . . . . . . . . . 177
Caution, Danger, and Warning . . . . 3
CD Player . . . . . . . . . . . . . . . . . . . . . . 196
Center Console Storage . . . . . . . . 116
Center High-Mounted
Stoplamp (CHMSL) and
Cargo Lamp . . . . . . . . . . . . . . . . . . . 389
Center Seat . . . . . . . . . . . . . . . . . . . . . 58
Chains, Tire . . . . . . . . . . . . . . . . . . . . 419
Charging
Wireless . . . . . . . . . . . . . . . . . . . . . . 126
Charging System Light . . . . . . . . . 138
Check
Ignition Transmission Lock . . . 383
Malfunction Indicator
Engine Light . . . . . . . . . . . . . . . . 138
Child Restraints
Infants and Young Children . . . . . 90
Lower Anchors and Tethers
for Children . . . . . . . . . . . . . . . . . . . 96
Older Children . . . . . . . . . . . . . . . . . . 88
Securing . . . . . . . . . . . . . . . . . 102, 106
Systems . . . . . . . . . . . . . . . . . . . . . . . . 92
Cleaning
Exterior Care . . . . . . . . . . . . . . . . . 441
Interior Care . . . . . . . . . . . . . . . . . . 446
Climate Control
Systems . . . . . . . . . . . . . . . . . 237, 238
Air Conditioning . . . . . . . . . 237, 238
Dual Automatic . . . . . . . . . . . . . . . 240
Heating . . . . . . . . . . . . . . . . . . 237, 238
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . 123
Cluster, Instrument . . . . . . . . . . . . . 128
Clutch, Hydraulic . . . . . . . . . . . . . . . 366
Collision Damage Repair . . . . . . . 479
Compartments
Storage . . . . . . . . . . . . . . . . . . . . . . . .115
Compass . . . . . . . . . . . . . . . . . . . . . . . 122
Messages . . . . . . . . . . . . . . . . . . . . 151
Connections
OnStar®...................... 488
Control . . . . . . . . . . . . . . . . . . . . . . . . . 297
Traction and Electronic
Stability . . . . . . . . . . . . . . . . . . . . . 295
Control Light
Hill Descent . . . . . . . . . . . . . . . . . . 141
Control of a Vehicle . . . . . . . . . . . . . 248
Convex Mirrors . . . . . . . . . . . . . . . . . . 46
Coolant
Engine . . . . . . . . . . . . . . . . . . . . . . . . 369
Engine Temperature Gauge . . 133
Cooling System . . . . . . . . . . . . . . . . . 368
Engine Messages . . . . . . . . . . . . 152
Courtesy Transportation
Program . . . . . . . . . . . . . . . . . . . . . . . 478
Cruise Control . . . . . . . . . . . . . . . . . . 298
Light . . . . . . . . . . . . . . . . . . . . . . . . . . 145
Cupholders . . . . . . . . . . . . . . . . . . . . . 116
Customer Assistance . . . . . . . . . . . 475
Offices . . . . . . . . . . . . . . . . . . . . . . . . 474
Te x t Te l e p h o n e ( T T Y )
Users . . . . . . . . . . . . . . . . . . . . . . . 475
Customer Information
Service Publications
Ordering Information . . . . . . . . 481
Page 500 of 509

Chevrolet Silverado Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-9956065) - 2017 - CRC - 4/29/16
Index 499
Customer Satisfaction
Procedure . . . . . . . . . . . . . . . . . . . . . 472
D
Damage Repair, Collision . . . . . . . 479
Danger, Warning, and Caution . . . . 3
Data Collection
Infotainment System . . . . . . . . . . 485
OnStar . . . . . . . . . . . . . . . . . . . . . . . 485
Data Recorders, Event . . . . . . . . . 484
Daytime Running
Lamps (DRL) . . . . . . . . . . . . . . . . . . 174
Defensive Driving . . . . . . . . . . . . . . . 248
Delayed Locking . . . . . . . . . . . . . . . . . 40
Diagnostics
OnStar®...................... 490
Distracted Driving . . . . . . . . . . . . . . . 247
Dome Lamps . . . . . . . . . . . . . . . . . . . 178
Door
Ajar Messages . . . . . . . . . . . . . . . 151
Delayed Locking . . . . . . . . . . . . . . . . 40
Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
Power Locks . . . . . . . . . . . . . . . . . . . . 40
Drive Belt Routing, Engine . . . . . . 471
Driver Assistance Systems . . . . . 301
Driver Information
Center (DIC) . . . . . . . . . . . . . 145, 147
Driving
Assistance Systems . . . . . . . . . . 304
Driving (cont'd)
Characteristics and
To w i n g T i p s . . . . . . . . . . . . . . . . . 3 1 5
Defensive . . . . . . . . . . . . . . . . . . . . . 248
Drunk . . . . . . . . . . . . . . . . . . . . . . . . . 248
For Better Fuel Economy . . . . . . . 31
Hill and Mountain Roads . . . . . . 256
If the Vehicle is Stuck . . . . . . . . . 258
Loss of Control . . . . . . . . . . . . . . . 250
Off-Road . . . . . . . . . . . . . . . . . . . . . 251
Off-Road Recovery . . . . . . . . . . . 250
Vehicle Load Limits . . . . . . . . . . . 259
Wet Roads . . . . . . . . . . . . . . . . . . . 255
Winter . . . . . . . . . . . . . . . . . . . . . . . . 257
Dual Automatic Climate
Control System . . . . . . . . . . . . . . . . 240
E
E85 or FlexFuel . . . . . . . . . . . . . . . . 312
Electrical Equipment,
Add-On . . . . . . . . . . . . . . . . . . . . . . . 345
Electrical System
Engine Compartment Fuse
Block . . . . . . . . . . . . . . . . . . . . . . . . 390
Fuses . . . . . . . . . . . . . . . . . . . . . . . . 390
Instrument Panel Fuse
Block . . . . . . . . . . . . . . . . . . . 393, 395
Overload . . . . . . . . . . . . . . . . . . . . . 389
Emergency
OnStar®...................... 487
Engine
Air Cleaner/Filter . . . . . . . . . . . . . 367
Check and Service Engine
Soon Light . . . . . . . . . . . . . . . . . . 138
Compartment Overview . . . . . . . 354
Coolant . . . . . . . . . . . . . . . . . . . . . . . 369
Coolant Heater . . . . . . . . . . . . . . . 272
Coolant Temperature
Gauge . . . . . . . . . . . . . . . . . . . . . . 133
Cooling System . . . . . . . . . . . . . . . 368
Cooling System Messages . . . 152
Drive Belt Routing . . . . . . . . . . . . 471
Exhaust . . . . . . . . . . . . . . . . . . . . . . 276
Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . 374
Oil Life System . . . . . . . . . . . . . . . 362
Oil Messages . . . . . . . . . . . . . . . . . 152
Oil Pressure Gauge . . . . . . . . . . 132
Overheated Protection
Operating Mode . . . . . . . . . . . . . 374
Overheating . . . . . . . . . . . . . . . . . . 372
Power Messages . . . . . . . . . . . . . 153
Running While Parked . . . . . . . . 277
Starting . . . . . . . . . . . . . . . . . . . . . . . 269
Entry Lighting . . . . . . . . . . . . . . . . . . . 179
Equipment, Towing . . . . . . . . . . . . . 335
Event Data Recorders . . . . . . . . . . 484