engine overheat CHEVROLET SONIC 2017 2.G User Guide

Chevrolet Sonic Owner Manual (GMNA-Localizing-U.S./Canada-10122660) -2017 - crc - 5/13/16
228 Vehicle Care
Checking Coolant
The vehicle must be on a levelsurface when checking the coolantlevel.
It is normal to see coolant moving inthe upper coolant hose return linewhen the engine is running.
Check to see if coolant is visible inthe coolant surge tank. If the coolantinside the coolant surge tank isboiling, do not do anything else untilit cools down.
If coolant is visible but the coolantlevel is not at or above the markpointed to, add a 50/50 mixture ofclean drinkable water andDEX-COOL coolant.
Be sure the cooling system is coolbefore this is done.
If no coolant is visible in the coolantsurge tank, add coolant as follows:
How to Add Coolant to the
Coolant Surge Tank
Caution
This vehicle has a specific
coolant fill procedure. Failure to
follow this procedure could cause
the engine to overheat and be
severely damaged.
If no problem is found, check to seeif coolant is visible in the coolantsurge tank. If coolant is visible butthe coolant level is not at theindicated level mark, add a 50/50 mixture of clean, drinkable waterand DEX-COOL coolant at thecoolant surge tank, but be sure thecooling system, including thecoolant surge tank pressure cap, iscool before you do it.
{Warning
Steam and scalding liquids from a
hot cooling system can blow out
and burn you badly. Never turn
(Continued)
Warning (Continued)
the cap when the cooling system,
including the surge tank pressure
cap, is hot. Wait for the cooling
system and surge tank pressure
cap to cool.
{Warning
Adding only plain water or some
other liquid to the cooling system
can be dangerous. Plain water
and other liquids, can boil before
the proper coolant mixture will.
The coolant warning system is set
for the proper coolant mixture.
With plain water or the wrong
mixture, the engine could get too
hot but you would not get the
overheat warning. The engine
could catch fire and you or others
could be burned. Use a 50/
50 mixture of clean, drinkable
water and DEX-COOL coolant.

Chevrolet Sonic Owner Manual (GMNA-Localizing-U.S./Canada-10122660) -2017 - crc - 5/13/16
230 Vehicle Care
By this time, the coolant levelinside the coolant surge tankmay be lower. If the level islower, add more of the properDEX-COOL coolant mixture tothe coolant surge tank until thelevel reaches the indicatedlevel mark.
5. Replace the pressure captightly.
Check the level in the coolant surgetank when the cooling system hascooled down. If the coolant is not atthe proper level, repeat Steps 1–3andreinstallthepressurecap.If the coolant still is not at the properlevel when the system cools downagain, see your dealer.
Caution
If the pressure cap is not tightly
installed, coolant loss and
possible engine damage may
occur. Be sure the cap is properly
and tightly secured.
Engine Overheating
The vehicle has an indicator to warnof the engine overheating.
If the decision is made not to lift thehood when this warning appears,get service help right away. SeeRoadside AssistanceProgram0311.
If the decision is made to lift thehood, make sure the vehicle isparked on a level surface.
Then check to see if the enginecooling fan is running. If the engineis overheating, the fan should berunning. If it is not, do not continueto run the engine. Have the vehicleserviced.
Caution
Running the engine without
coolant may cause damage or a
fire. Vehicle damage would not be
covered by the vehicle warranty.
If Steam Is Coming from the
Engine Compartment
{Warning
Steam from an overheated engine
can burn you badly, even if you
just open the hood. Stay away
from the engine if you see or hear
steam coming from it. Just turn it
off and get everyone away from
the vehicle until it cools down.
Wait until there is no sign of
steam or coolant before you open
the hood.
If you keep driving when the
engine is overheated, the liquids
in it can catch fire. You or others
could be badly burned. Stop the
engine if it overheats, and get out
of the vehicle until the engine
is cool.
If No Steam Is Coming from
the Engine Compartment
If an engine overheat warning isdisplayed but no steam can be seenor heard, the problem may not be

Chevrolet Sonic Owner Manual (GMNA-Localizing-U.S./Canada-10122660) -2017 - crc - 5/13/16
Vehicle Care 231
too serious. Sometimes the enginecan get a little too hot when thevehicle:
.Climbs a long hill on a hot day.
.Stops after high-speed driving.
.Idles for long periods in traffic.
If the overheat warning is displayedwith no sign of steam:
1. Turn the air conditioning off.
2. Turn the heater on to thehighest temperature and to thehighest fan speed. Open thewindows as necessary.
3. When it is safe to do so, pull offthe road, shift to P (Park) orN(Neutral) for an automatictransmission or Neutral for amanual transmission, and letthe engine idle.
If the overheat warning no longerdisplays, the vehicle can be driven.Continue to drive the vehicle slowlyfor about 10 minutes. Keep a safevehicle distance from the vehicle infront. If the warning does not come
back on, continue to drive normallyand have the cooling systemchecked for proper fill and function.
If the warning continues, pull over,stop, and park the vehicleright away.
If there is no sign of steam, idle theengine for three minutes whileparked. If the warning is stilldisplayed, turn off the engine until itcools down.
Washer Fluid
What to Use
When the vehicle needs windshieldwasher fluid, be sure to read themanufacturer's instructions beforeuse. If operating the vehicle in anarea where the temperature may fallbelow freezing, use a fluid that hassufficient protection againstfreezing.
Adding Washer Fluid
Open the cap with the washersymbol on it. Add washer fluid untilthe tank is full. SeeEngineCompartment Overview0217forreservoir location.
Caution
.Do not use washer fluid thatcontains any type of waterrepellent coating. This cancause the wiper blades tochatter or skip.
.Do not use engine coolant(antifreeze) in thewindshield washer. It candamage the windshieldwasher system and paint.
(Continued)

Chevrolet Sonic Owner Manual (GMNA-Localizing-U.S./Canada-10122660) -2017 - crc - 5/13/16
334 Index
Driving (cont'd)
If the Vehicle is Stuck . . . . . . . . . 178
Loss of Control . . . . . . . . . . . . . . . 174
Off-Road Recovery . . . . . . . . . . . 174
Vehicle Load Limits . . . . . . . . . . . 178
Wet Roads . . . . . . . . . . . . . . . . . . . 175
Winter . . . . . . . . . . . . . . . . . . . . . . . . 176
E
Electrical Equipment,
Add-On . . . . . . . . . . . . . . . . . . . . . . . 211
Electrical System
Engine Compartment Fuse
Block . . . . . . . . . . . . . . . . . . . . . . . . 243
Fuses and Circuit Breakers . . . 242
Instrument Panel Fuse
Block . . . . . . . . . . . . . . . . . . . . . . . . 246
Overload . . . . . . . . . . . . . . . . . . . . . 242
Emergency
OnStar®...................... 322
Engine
Air Cleaner/Filter . . . . . . . . . . . . . 224
Check and Service Engine
Soon Light . . . . . . . . . . . . . . . . . . .112
Compartment Overview . . . . . . . 217
Coolant . . . . . . . . . . . . . . . . . . . . . . . 227
Coolant Temperature
Warning Light . . . . . . . . . . . . . . . . 118
Cooling System . . . . . . . . . . . . . . . 226
Engine (cont'd)
Drive Belt Routing . . . . . . . . . . . . 306
Exhaust . . . . . . . . . . . . . . . . . . . . . . 190
Heater . . . . . . . . . . . . . . . . . . . . . . . . 186
Oil Life System . . . . . . . . . . . . . . . 222
Oil Messages . . . . . . . . . . . . . . . . . 127
Oil Pressure Light . . . . . . . . . . . . .118
Overheating . . . . . . . . . . . . . . . . . . 230
Reduced Power Light . . . . . . . . . 120
Running While Parked . . . . . . . . 190
Starting . . . . . . . . . . . . . . . . . . . . . . . 185
Entry Lighting . . . . . . . . . . . . . . . . . . . 138
Event Data Recorders . . . . . . . . . . 319
Exit Lighting . . . . . . . . . . . . . . . . . . . . 138
Extended Parking . . . . . . . . . . . . . . . 189
Extender, Safety Belt . . . . . . . . . . . . 64
Exterior Lamp Controls . . . . . . . . . 134
Exterior Lighting Battery
Saver . . . . . . . . . . . . . . . . . . . . . . . . . 139
F
Filter,
Engine Air Cleaner . . . . . . . . . . . 224
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 135
Flashers, Hazard Warning . . . . . . 136
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 267
Changing . . . . . . . . . . . . . . . . . . . . . 269
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 288
Fluid
Automatic Transmission . . . . . . 223
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 233
Washer . . . . . . . . . . . . . . . . . . . . . . . 231
Fog Lamps . . . . . . . . . . . . . . . . . . . . . 137
Bulb Replacement . . . . . . . . . . . . 239
Folding Mirrors . . . . . . . . . . . . . . . . . . 47
Forward Collision Alert
(FCA) System . . . . . . . . . . . . . . . . . 204
Forward Collision Alert (FCA)
Warning Light . . . . . . . . . . . . . . . . . 116
Frequency Statement
Radio . . . . . . . . . . . . . . . . . . . . . . . . . 317
Front Fog Lamp
Light . . . . . . . . . . . . . . . . . . . . . . . . . . 120
Front Seat Armrest . . . . . . . . . . . . . . 56
Front Seats
Adjustment . . . . . . . . . . . . . . . . . . . . . 53
Heated . . . . . . . . . . . . . . . . . . . . . . . . . 56
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 207
Additives . . . . . . . . . . . . . . . . . . . . . 208
Economy Driving . . . . . . . . . . . . . . . 24
Filling a Portable Fuel
Container . . . . . . . . . . . . . . . . . . . 210
Filling the Tank . . . . . . . . . . . . . . . 209
Foreign Countries . . . . . . . . . . . . 208
Gauge . . . . . . . . . . . . . . . . . . . . . . . . 109
Low Fuel Warning Light . . . . . . . .119

Chevrolet Sonic Owner Manual (GMNA-Localizing-U.S./Canada-10122660) -2017 - crc - 5/13/16
Index 337
Maintenance Schedule (cont'd)
Recommended Fluids and
Lubricants . . . . . . . . . . . . . . . . . . . 300
Malfunction Indicator Lamp . . . . . 112
Manual Mirrors . . . . . . . . . . . . . . . . . . 46
Manual Mode . . . . . . . . . . . . . . . . . . . 192
Manual Transmission . . . . . . . . . . . 193
Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 224
Manual Windows . . . . . . . . . . . . . . . . 48
Media
Avoiding Untrusted Devices . . 149
Messages
Engine Oil . . . . . . . . . . . . . . . . . . . . 127
Tire . . . . . . . . . . . . . . . . . . . . . . . . . . . 127
Vehicle . . . . . . . . . . . . . . . . . . . . . . . 126
Mirrors
Convex . . . . . . . . . . . . . . . . . . . . . . . . . 46
Folding . . . . . . . . . . . . . . . . . . . . . . . . . 47
Heated . . . . . . . . . . . . . . . . . . . . . . . . . 47
Manual . . . . . . . . . . . . . . . . . . . . . . . . . 46
Manual Rearview . . . . . . . . . . . . . . . 47
Power . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Monitor System, Tire
Pressure . . . . . . . . . . . . . . . . . . . . . . 257
Multi-band Antenna . . . . . . . . . . . . . 148
N
Navigation
OnStar®...................... 323
New Vehicle Break-In . . . . . . . . . . . 181
O
Odometer . . . . . . . . . . . . . . . . . . . . . . . 109
Trip . . . . . . . . . . . . . . . . . . . . . . . . . . . 109
Off-Road
Recovery . . . . . . . . . . . . . . . . . . . . . 174
Oil
Engine . . . . . . . . . . . . . . . . . . . . . . . . 220
Engine Oil Life System . . . . . . . 222
Messages . . . . . . . . . . . . . . . . . . . . 127
Pressure Light . . . . . . . . . . . . . . . . .118
Older Children, Restraints . . . . . . . 77
Online Owner Center . . . . . . . . . . . 310
OnStar . . . . . . . . . . . . . . . . . . . . . . . . . 320
OnStar®Additional
Information . . . . . . . . . . . . . . . . . . . . 326
OnStar®Connections . . . . . . . . . . . 323
OnStar®Diagnostics . . . . . . . . . . . . 325
OnStar®Emergency . . . . . . . . . . . . 322
OnStar®Navigation . . . . . . . . . . . . . 323
OnStar®Overview . . . . . . . . . . . . . . 321
OnStar®Security . . . . . . . . . . . . . . . 322
Operate Pedal Light . . . . . . . . . . . . 115
Operation
Fog Lamps . . . . . . . . . . . . . . . . . . . 137
Operation (cont'd)
Infotainment System . . . . . . . . . . 144
Ordering
Service Publications . . . . . . . . . . 316
Outlets
Power . . . . . . . . . . . . . . . . . . . . . . . . 105
Overheating, Engine . . . . . . . . . . . . 230
Overview . . . . . . . . . . . . . . . . . . . . . . . 143
Owner Manual Indicator . . . . . . . . 114
P
Park
Shifting Into . . . . . . . . . . . . . . . . . . . 187
Shifting Out of . . . . . . . . . . . . . . . . 188
Parking . . . . . . . . . . . . . . . . . . . . . . . . . 189
Brake . . . . . . . . . . . . . . . . . . . . . . . . . 196
Brake and P (Park)
Mechanism Check . . . . . . . . . . 236
Extended . . . . . . . . . . . . . . . . . . . . . 189
Over Things That Burn . . . . . . . 189
Ultrasonic Sensor Light . . . . . . . .116
Parking Assist . . . . . . . . . . . . . . . . . . 203
Passenger Airbag Status
Indicator . . . . . . . . . . . . . . . . . . . . . . 111
Passenger Compartment Air
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 169
Passenger Sensing System . . . . . 71
Perchlorate Materials
Requirements, California . . . . . . 213