key CHEVROLET SPARK 2020 Workshop Manual

Chevrolet Spark Owner Manual (GMNA-Localizing-U.S./Canada-13556236) -
2020 - CRC - 4/23/19
228 Vehicle Care
FusesUsage
26 Engine control module/
Transmission
control module
battery
27 Canister vent solenoid
28 –
29 Automatic occupant sensing
30 Headlamp leveling motor
31 Horn
32 Front fog lamps
33 Left high-beam headlamp
34 Right high-beam headlamp
35 Virtual key pass system module
36 Rear wiper
37 Left cornering lamp
38 Washer motor Fuses
Usage
39 Right cornering lamp
40 –
41 Virtual key pass system sensor
42 Starter 2
43 In-panel bussed electrical center
44 Automated manual transmission
45 Starter 1
46 ABS pump
47 Cooling fan –high
48 Front wiper motor
49 Accessory/ Retained
accessory power
Relays Usage
RLY1 Rear defogger
RLY2 Transmission control module Relays
Usage
RLY3 Fuel pump motor
RLY4 Starter 2
RLY5 A/C system
RLY6 –
RLY7 Cooling fan –low
RLY8 Run/Crank
RLY9 Powertrain
RLY10 Starter 1 RLY11 Cooling fan –high
RLY12 Front fog lamps

Chevrolet Spark Owner Manual (GMNA-Localizing-U.S./Canada-13556236) -
2020 - CRC - 4/23/19
242 Vehicle Care
installed and the sensor
matching process is performed
successfully. See your dealer for
service.
. Replacement tires or wheels do
not match the original equipment
tires or wheels. Tires and wheels
other than those recommended
could prevent the TPMS from
functioning properly. See Buying
New Tires 0245.
. Operating electronic devices or
being near facilities using radio
wave frequencies similar to the
TPMS could cause the TPMS
sensors to malfunction.
If the TPMS is not functioning
properly, it cannot detect or signal a
low tire pressure condition. See
your dealer for service if the TPMS
malfunction light and DIC message,
if equipped, come on and stay on.
TPMS Sensor Matching
Process
Each TPMS sensor has a unique
identification code. The identification
code needs to be matched to a new
tire/wheel position after rotating the vehicle’s tires or replacing one or
more of the TPMS sensors. Also,
the TPMS sensor matching process
should be performed after replacing
a spare tire with a road tire
containing the TPMS sensor. The
malfunction light and the DIC
message, if equipped, should go off
at the next ignition cycle. The
sensors are matched to the tire/
wheel positions, using a TPMS
relearn tool, in the following order:
driver side front tire, passenger side
front tire, passenger side rear tire,
and driver side rear. See your
dealer for service or to purchase a
relearn tool. A TPMS relearn tool
can also be purchased. See Tire
Pressure Monitor Sensor Activation
Tool at
www.gmtoolsandequipment.com or
call 1-800-GM TOOLS
(1-800-468-6657).
There are two minutes to match the
first tire/wheel position, and
five minutes overall to match all four
tire/wheel positions. If it takes
longer, the matching process stops
and must be restarted.
The TPMS sensor matching
process is:
1. Set the parking brake.
2. Turn the ignition on without starting the vehicle or place the
vehicle in Service Mode. See
Ignition Positions (Keyless
Access) 0160 or
Ignition Positions (Key Access)
0 162.
3. Use MENU to select the Vehicle Information Menu
(Menu 2) in the Driver
Information Center (DIC).
4. Use the thumbwheel (or up and down arrows) to scroll to the
Tire Pressure Learn Menu Item
(Base DIC) or the Tire
Pressure Menu Item screen
(Uplevel DIC).
5. Press and hold SET/CLR to begin the sensor matching
process.
A message requesting
acceptance of the process may
display.

Chevrolet Spark Owner Manual (GMNA-Localizing-U.S./Canada-13556236) -
2020 - CRC - 4/23/19
268 Vehicle Care
Caution (Continued)
Damage could occur and the
repairs would not be covered by
the vehicle warranty.
Brake System
Visually inspect brake lines and
hoses for proper hook-up, binding,
leaks, cracks, chafing, etc. Inspect
disc brake pads for wear and rotors
for surface condition. Inspect drum
brake linings/shoes for wear or
cracks. Inspect all other brake parts.
Steering, Suspension, and
Chassis Components
Visually inspect steering,
suspension, and chassis
components for damaged, loose,
or missing parts or signs of wear at
least once a year.
Inspect power steering for proper
attachment, connections, binding,
leaks, cracks, chafing, etc.
Visually check constant velocity joint
boots and axle seals for leaks.
Body Component Lubrication
Lubricate all key lock cylinders,
hood hinges, liftgate hinges, and the
steel fuel door hinges, unless the
components are plastic. Applying
silicone grease on weatherstrips
with a clean cloth will make them
last longer, seal better, and not stick
or squeak.
Underbody Maintenance
At least twice a year, spring and fall,
use plain water to flush any
corrosive materials from the
underbody. Take care to thoroughly
clean any areas where mud and
other debris can collect.
Do not directly power wash the
transfer case and/or front/rear axle
output seals. High pressure water
can overcome the seals and
contaminate the fluid. Contaminated
fluid will decrease the life of the
transfer case and/or axles and
should be replaced.
Sheet Metal Damage
If the vehicle is damaged and
requires sheet metal repair or
replacement, make sure the body
repair shop applies anti-corrosion
material to parts repaired or
replaced to restore corrosion
protection.
Original manufacturer replacement
parts will provide the corrosion
protection while maintaining the
vehicle warranty.
Finish Damage
Quickly repair minor chips and
scratches with touch-up materials
available from your dealer to avoid
corrosion. Larger areas of finish
damage can be corrected in your
dealer's body and paint shop.
Chemical Paint Spotting
Airborne pollutants can fall upon
and attack painted vehicle surfaces
causing blotchy, ring-shaped
discolorations, and small, irregular
dark spots etched into the paint
surface. See“Finish Care”
previously in this section.

Chevrolet Spark Owner Manual (GMNA-Localizing-U.S./Canada-13556236) -
2020 - CRC - 4/23/19
284 Service and Maintenance
Recommended Fluids, Lubricants, and Parts
Recommended Fluids and Lubricants
Fluids and lubricants identified below by name, part number, or specification can be obtained from your dealer.Usage Fluid/Lubricant
Brake/Clutch Hydraulic System DOT 4 Hydraulic Brake Fluid (GM Part No. 19299570, in Canada 19299571).
Engine Coolant 50/50 mixture of clean, drinkable water and use only DEX-COOL Coolant.
See Cooling System 0208.
Engine Oil Engine oil meeting the dexos1 specification of the proper SAE viscosity
grade. ACDelco dexos1 full synthetic is recommended. See Engine Oil
0 202.
Hood Latch Assembly, Secondary Latch, Pivots, Spring Anchor, and Release Pawl Lubriplate Lubricant Aerosol (GM Part No. 89021668, in Canada 89021674)
or lubricant meeting requirements of NLGI #2, Category LB or GC-LB.
Key Lock Cylinders, Hood and Door Hinges Multi-Purpose Lubricant, Superlube (GM Part No. 12346241, in
Canada 10953474).
Transmission - Automatic ACDelco CVT Fluid (Part No. 19260800, in Canada 19299096). Transmission - Manual Manual Transmission Fluid (GM Part No. 19351859, in Canada 19351860).
Weatherstrip Conditioning Weatherstrip lubricant (GM Part No. 3634770, in Canada 10953518) or equivalent.
Windshield Washer Automotive windshield washer fluid that meets regional freeze protection requirements.

Chevrolet Spark Owner Manual (GMNA-Localizing-U.S./Canada-13556236) -
2020 - CRC - 4/23/19
306 OnStar
Press=to:
. Open the OnStar app on the
infotainment display.
Or
. Give OnStar Turn-by-Turn
Navigation voice commands.
. Obtain and customize the Wi-Fi
hotspot name or SSID and
password, if equipped.
Press
Qto connect to an
Advisor to:
. Verify account information or
update contact information.
. Get driving directions. .
Receive a Diagnostic check of
the vehicle's key operating
systems.
. Receive Roadside Assistance.
. Manage Wi-Fi Settings,
if equipped.
Press
>to get a priority connection
to an OnStar Advisor available
24/7 to:
. Get help for an emergency.
. Be a Good Samaritan or
respond to an AMBER Alert.
. Get assistance in severe
weather or other crisis situations
and find evacuation routes.
OnStar Services
Emergency
Emergency Services require an
active safety and security plan. With
Automatic Crash Response, built-in
sensors can automatically alert a
specially trained OnStar Advisor
who is immediately connected in to
the vehicle to help.
Press
>for a priority connection to
an OnStar Advisor who can contact
emergency service providers, direct
them to your exact location, and
relay important information.
With OnStar Crisis Assist, specially
trained Advisors are available
24 hours a day, 7 days a week, to
provide a central point of contact,
assistance, and information during a
crisis.
With Roadside Assistance, Advisors
can locate a nearby service provider
to help with a flat tire, a battery
jump, or an empty gas tank.

Chevrolet Spark Owner Manual (GMNA-Localizing-U.S./Canada-13556236) -
2020 - CRC - 4/23/19
316 Connected Services
Diagnostics
By monitoring and reporting on the
vehicle's key systems, OnStar
Advanced Diagnostics, if equipped,
provides a way to keep up on
maintenance. Capabilities vary by
model. See www.onstar.com for
details and system limitations.
Features are subject to change. For
updates on feature capabilities, see
my.chevrolet.com. Message and
data rates may apply.

Chevrolet Spark Owner Manual (GMNA-Localizing-U.S./Canada-13556236) -
2020 - CRC - 4/23/19
322 Index
J
JackAuxiliary . . . . . . . . . . . . . . . . . . . . . . 127
Jump Starting - North America . . . . . . . . . . . . . . . . . . . . . . . 257
K
Keyless Entry
Remote (RKE) System . . . . . 10, 13
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
L
Labeling, Tire Sidewall . . . . . . . . . . 233
Lamps Courtesy . . . . . . . . . . . . . . . . . . . . . . .113
Daytime Running (DRL) . . . . . . .110
Dome . . . . . . . . . . . . . . . . . . . . . . . . . .113
Exterior Controls . . . . . . . . . . . . . . 109
Exterior Lamps OffReminder . . . . . . . . . . . . . . . . . . . .110
Exterior Lighting Battery
Saver . . . . . . . . . . . . . . . . . . . . . . . .115
License Plate . . . . . . . . . . . . . . . . . 224
Malfunction Indicator (Check Engine) . . . . . . . . . . . . . . . . . . . . . . . 89
On Reminder . . . . . . . . . . . . . . . . . . . 97 Lamps (cont'd)
Reading . . . . . . . . . . . . . . . . . . . . . . .114
Lane Departure Warning (LDW) . . . . . . . . . . . . . . . . 189
Lane Departure Warning Light . . . 93
Lap-Shoulder Belt . . . . . . . . . . . . . . . 39
LATCH System Replacing Parts after aCrash . . . . . . . . . . . . . . . . . . . . . . . . . 70
LATCH, Lower Anchors and Tethers for Children . . . . . . . . . . . . 63
LED Lighting . . . . . . . . . . . . . . . . . . . . 221
Liftgate . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Lighting Entry . . . . . . . . . . . . . . . . . . . . . . . . . .114
Exit . . . . . . . . . . . . . . . . . . . . . . . . . . . .114
Illumination Control . . . . . . . . . . . .113
LED . . . . . . . . . . . . . . . . . . . . . . . . . . 221
Lights Airbag Readiness . . . . . . . . . . . . . . . 87
Antilock Brake System(ABS) Warning . . . . . . . . . . . . . . . . 92
Brake System Warning . . . . . . . . . 91
Charging System . . . . . . . . . . . . . . . 89
Check Engine (Malfunction
Indicator) . . . . . . . . . . . . . . . . . . . . . . 89
Cruise Control . . . . . . . . . . . . . . . . . . 97
Door Ajar . . . . . . . . . . . . . . . . . . . . . . . 98 Lights (cont'd)
Engine Coolant Temperature
Warning . . . . . . . . . . . . . . . . . . . . . . . 95
Engine Oil Pressure . . . . . . . . . . . . 96
Flash-to-Pass . . . . . . . . . . . . . . . . . .110
Front Fog Lamp . . . . . . . . . . . . . . . . 97
High-Beam On . . . . . . . . . . . . . . . . . . 97
High/Low Beam Changer . . . . . .110
Hood Ajar . . . . . . . . . . . . . . . . . . . . . . 98
Immobilizer . . . . . . . . . . . . . . . . . . . . . 96
Lane Departure Warning . . . . . . . . 93
Low Fuel Warning . . . . . . . . . . . . . . 96
Operate Pedal . . . . . . . . . . . . . . . . . . 92
Reduced Engine Power . . . . . . . . 97
Seat Belt Reminders . . . . . . . . . . . . 87
Service Vehicle Soon . . . . . . . . . . . 91
StabiliTrak OFF . . . . . . . . . . . . . . . . . 94
Tire Pressure . . . . . . . . . . . . . . . . . . . 95
Traction Control System
(TCS)/StabiliTrak . . . . . . . . . . . . . . 94
Traction Off . . . . . . . . . . . . . . . . . . . . . 94
Ultrasonic Parking Sensor . . . . . . 93
Up-Shift . . . . . . . . . . . . . . . . . . . . . . . . 92
Warning, Power Steering . . . . . . . 93
Locks Automatic Door . . . . . . . . . . . . . . . . . 18
Delayed Locking . . . . . . . . . . . . . . . . 18
Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17

Chevrolet Spark Owner Manual (GMNA-Localizing-U.S./Canada-13556236) -
2020 - CRC - 4/23/19
324 Index
Parking (cont'd)Brake and P (Park)
Mechanism Check . . . . . . . . . . 217
Extended . . . . . . . . . . . . . . . . . . . . . 169
Over Things That Burn . . . . . . . 169
Ultrasonic Sensor Light . . . . . . . . . 93
Passenger Airbag Status Indicator . . . . . . . . . . . . . . . . . . . . . . . 88
Passenger Compartment Air
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Passenger Sensing System . . . . . 49
Perchlorate Materials Requirements, California . . . . . . 198
Personalization
Vehicle . . . . . . . . . . . . . . . . . . . . . . . 105
Phone Apple CarPlay andAndroid Auto . . . . . . . . . . . . . . . . 135
Bluetooth . . . . . . . . . . . . . . . . 130, 131
Port USB . . . . . . . . . . . . . . . . . . . . . . . . . . 124
Power Door Locks . . . . . . . . . . . . . . . . . . . . . 17
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Outlets . . . . . . . . . . . . . . . . . . . . . . . . . 82
Protection, Battery . . . . . . . . . . . . .114
Reduced Engine Light . . . . . . . . . . 97
Retained Accessory (RAP) . . . 167 Power (cont'd)
Windows . . . . . . . . . . . . . . . . . . . . . . . 26
Power Steering Warning Lights . . . . . . . . . . . . . . . . . . . . . . . . . . 93
Pregnancy, Using Seat Belts . . . . 41
Privacy Vehicle Data Recording . . . . . . . 303
Program Courtesy Transportation . . . . . . 297
Prohibited Fuels . . . . . . . . . . . . . . . . 192
Proposition 65 Warning,
California . . . . . . . . . . . .197, 215, 257, Back Cover
Publication Ordering Information . . . . . . . . . . . . . . . . . . . . 300
R
Radio Frequency Statement . . . . 301
Radio Reception . . . . . . . . . . . . . . . . 123
RadiosAM-FM Radio . . . . . . . . . . . . . . . . . 121
Satellite . . . . . . . . . . . . . . . . . . . . . . . 123
Reading Lamps . . . . . . . . . . . . . . . . . 114
Rear Seats . . . . . . . . . . . . . . . . . . . . . . 34
Rear Vision Camera (RVC) . . . . . 183
Rear Window Washer/Wiper . . . . . 81
Rearview Mirrors . . . . . . . . . . . . . . . . 25 Reclining Seatbacks . . . . . . . . . . . . . 32
Recommended
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 191
Recommended Fluids and Lubricants . . . . . . . . . . . . . . . . . . . . . 284
Records Maintenance . . . . . . . . . . . . . . . . . . 286
Recreational Vehicle Towing . . . . 261
Reduced Engine Power Light . . . . 97
Reimbursement Program, GM Mobility . . . . . . . . . . . . . . . . . . . 295
Remote Keyless Entry (RKE) System . . . . . . . . . . . . . . 10, 13
Replacement Parts Airbags . . . . . . . . . . . . . . . . . . . . . . . . . 55
Maintenance . . . . . . . . . . . . . . . . . . 285
Replacing Airbag System . . . . . . . . 55
Replacing LATCH System Parts after a Crash . . . . . . . . . . . . . 70
Replacing Seat Belt System Parts after a Crash . . . . . . . . . . . . . 43
Reporting Safety Defects Canadian Government . . . . . . . . 302
General Motors . . . . . . . . . . . . . . . 302
U.S. Government . . . . . . . . . . . . . 301
Restraints Where to Put . . . . . . . . . . . . . . . . . . . 61