wheel CHEVROLET SUBURBAN 1995 Owners Manual

Part C: Periodic Maintenance Inspections
Listed below are inspections and services which should be performed at
least twice a year (for instance, each spring and fall).
You should let your
GM dealer’s service department or other qualified service center do these
jobs.
Make sure any necessary repairs are completed at once.
Steering and Suspension lnspection
Inspect the front and rear suspension and steering system for damaged,
loose or missing parts, signs
of wear, or lack of lubrication. Inspect power
steering lines and hoses for proper hookup, binding, leaks, cracks, chafing,
etc. (On vehicles equipped with manual steering gear, check
for seal
leakage.)
Exhaust System lnspection
Inspect the complete exhaust system. Inspect the body near the exhaust
system.
Look for broken, damaged, missing or out-of-position parts as well
as open seams, holes, loose connections, or other conditions which could
cause
a heat build-up in the floor pan or could let exhaust fumes into the
vehicle.
See “Engine Exhaust’’ in the Index.
Accelerator Control System
On gasoline engines, lubricate the pivot at the TBI throttle lever stud with
engine oil.
Do not oil any accelerator or cruise control cables. Replace any
cables that have high effort or excessive wear.
Drive Axle Service
Check readfront axle fluid level and add as needed. Check constant velocity
joints and axle seals for leaking.
Transfer Case (Four- Wheel Drive) Inspection
Every 12 months or at oil change intervals, check front axle and transfer
case and add lubricant when necessary. Oil the control lever pivot point and
all exposed control linkage. Check vent hose
at transfer case for kinks and
proper installation. More frequent lubrication
may be required on off-road
use.
ProCarManuals.com

USAGE FLUIDLUBRICANT
Power Steering System
GM Power Steering Fluid (GM Part
No. 10500 17 or equivalent).
Manual Transmission (RPO MG5) Synchromesh Transmission
Fluid
(GM Part No. 12345349 or
equivalent).
Automatic Transmission
.Key Lock Cylinders
Automatic Transmission Shift
Linkage
Floor Shift Linkage
Chassis Lubrication
Front Wheel Bearings
Differential, Standard, Front and
Rear Axle
Differential, Locking
Transfer Case DEXRON@-111
Automatic
Transmission Fluid.
Lubricate with Multi-Purpose
Lubricant (GM Part No. 12345 120)
or synthetic SAE 5W-30 engine oil.
Engine
oil.
Engine oil.
Chassis lubricant (GM Part
No. I2346003 or equivalent) or
lubricant meeting requirements
of
NLGI Grade 2, Category LB or
GC-LB.
Wheel bearing lubricant meeting
requirements
of NLGI Grade 2,
Category GC
or GC-LB (GM Part
No. I2346003 or equivalent).
Axle Lubricant
(GM Part
No. 105227 1) or SAE 8OW-90
GL-5 Gear Lubricant.
Axle Lubricant (GM Part
No. 1052271) or SAE 8OW-90
GL-5 Gear Lubricant.
DEXRON@-111 Automatic
Transmission Fluid.
Column Shift Lever and Propeller Chassis lubricant meeting
Shaft requirements
of NLGI Grade 2,
Category LB or GC-LB (GM Part
No. 12346003).
Windshield Washer Solvent GM Optikleen@ Washer Solvent
(GM Part No. 1051515) or
equivalent.
7-98
ProCarManuals.com

Index
A
Adding Equipment to Your Air Bag-Equipped Vehicle (See “Supplemental
Inflatable Restraint System (SIR)”) Air Bag (See “Supplemental Inflatable Restraint System (SIR)”)
Readiness Light (See “Lights”)
Air Cleaner (See “Engine-Air Cleaner”)
Air Conditioning (See “Heater/Air Conditioning Controls”)
Antenna
....................................................... 3-28
Anti-Lock Brakes (See “Brakes”)
Appearancecare
............. i .................................. 6-62
Materials Chart
............................................... 6-71
Arbitration Program (See “Better Business Bureau Mediation”)
Audiosystems
................................................... 3-9
Care of Your Cassette Player and Tape
............................. 3-27
Care of Compact Discs
......................................... 3-28
ETR@ AM-FM Stereo Audio Cassette System
...................... 3-12
ETR@ AM-FM Stereo Audio Cassette ATC System
.................. 3-14
ETR@ AM-FM Stereo Audio Compact Disc (CD) ATC System
......... 3-19
Remote Cassette Player
...................................... 3-25
ETR@’AM-FM Stereo Audio System
.............................. 3-10
THEFTLOCK Theft Deterrent Feature
........................ 3-17, 3-23
Understanding Radio Reception
.................................. 3-26
Automatic Transmission (See “Transmission”)
Axle Front (See “Four-wheel Drive”)
LockingRe ar
................................................. 2-25
Rear
........................................................ 6-31
B
Battery ........................................................ 6-45
Belts (See “Safety Belts”)
Better Business Bureau Mediation
.................................... 8-3
Blizzard (See “Driving-If You’re Caught in a Blizzard”)
Brakes Adjustment
.................................................. 643
Anti-Lock (ABS)
.............................................. 4-5
Anti-Lock Warning Light (See “Lights”)
Hydro-Boost Brake System (Hydraulic Pump)
...... ......... 6-39
Master Cylinder
.............................................. 6-41
Parking ..................................................... 2-26
PedalTravel ................................................. 6-43
Replacingparts
............................................... 6-44
System Warning Light (See “Lights”)
To Check Brake Fluid
........................................ 6-42
Trailer (See “Trailer-Brakes”)
Transmission Shift Interlock (BTSI)
............................... 2-21
Wear
....................................................... 6-43
Braking
......................................................... 4-5
In Emergencies
................................................ 4-7
Break-In. New Vehicle ............ .......................... 2-10
1
ProCarManuals.com

Bulb Replacement Center High Mounted Stop Lamp (CHMSL)
........................ 6-52
Front Park Turn Signal Lamps with Composite
...................... 6-49
Front Park Turn Signal Lamps with Sealed Beam
.................... 6-48
HalogenBulbs
................................................ 6-47
RearLamps
.................................................. 6-52
Composite Headlamps
......................................... 6-47
Replacement Chart
............................................ 6-82
Roof Marker Lamps
........................................... 6-51
Sealed Beam Headlamps ........................................ 6-46
Side Marker Lamps
............................................ 6-50
Taillamps
.................................................... 6-50
C
Capacities and Specifications ....................................... 6-76
Cargo Security Shade
............................................. 2-82
Cargo Tie Downs
................................................ 2-84
Catalytic Converter
.............................................. 6-53
Changing a Flat Tire
.............................................. 5-25
Chemical Paint Spotting
........................................... 6-70
Child Security Locks
.............................................. 2-8
Cigarette LightedAshtrays
....................................... 2-57
CarbonMonoxide
.......................................... 2.29.
4-43
Care of Your Cassette Tape Player (See “Audio Systems”
)
Cassette Tape Player System (See “Audio Systems” )
Center High Mounted Stop Lamp (CHMSL) (See “Lamps”)
Certificationmire Label
........................................... 4-37
Child Restraints (See “Safety Belts”)
Circuit Breakers (See “Fuses and Circuit Breakers”)
Cleaning DieselEngine
................................................ 6-14
Fabric Protection
.............................................. 6-65
Finishcare
.................................................. 6-68
Glass
....................................................... 6-67
Insideofvehicle
.............................................. 6-63
Leather
..................................................... 6-66
OutsideofVehicle
............................................. 6-67
Instrument Panel.
Top
.......................................... 6-66
Outside
of the Windshield and Wiper Blades ........................ 6-67
Special Problems
.............................................. 6-65
Tires
....................................................... 6-69
Vinyl
....................................................... 6-66
Weatherstrips
................................................. 6-67
Wheels and Tires
.............................................. 6-69
Audio System with AUTO TONE System
.......................... 3-10
Audio System without AUTO TONE System
........................ 3-9
Compass
....................................................... 2-52
Control of a Vehicle
............................................... 4-4
Clock, Setting
the
Comfort Controls
................................................. 3-1
Compact Disc (CD) System (See “Audio Systems”)
2
ProCarManuals.com

ConvenienceNet ................................................ 2-84
Coolant (See “Engine”)
Cooling System Capacity
.......................................... 6-77
Courtesy Transportation
............................................ 8-7
Crankcase Capacity
.............................................. 6-78
Cruise Control (Option)
........................................... 2-43
OnHills ..................................................... 2-47
Passing Another Vehicle
........................................ 246
To Erase Speed Memory ........................................ 248
ToGetOutOf
................................................ 2-47
ToIncreaseSpeed
............................................. 245
ToReduceSpeed
.............................................. 2-46
ToResume
.................................................. 245
ToSet
...................................................... 244
Customer Assistance for the Hearing or Speech Impaired
................. 8-3
Customer Assistance Information
.................................... 8-1
Customer Satisfaction Procedure
................................... 8-1
Daytime Running Lamps (DRL) Indicator Light (See “Lights”)
Diesel Fuel Requirements and Fuel System (See “Fuel-Diesel”)
Differential (See “Axle”)
Doors .......................................................... 2-3
Locks
........................................................ 2-6
PanelDoors
................................................... 2-5
PowerDoorLocks
............................................. 2-7
SideDoors
.................................................... 2-3
Tailgate Glass and Tailgate
.................................. 2-4, 2-34
Drive Axle (See “Axle”)
Driving AtNight
.................................................... 4-23
City
........................................................ 4-26
Defensive
.................................................... 4-1
Freeway ..................................................... 4-27
Guidelines
................................................... 4-11
Hill and Mountain Roads
....................................... 4-29
Highway Hypnosis
............................................ 4-28
If You’re Caught in a Blizzard
................................... 4-33
SnoworIce
.................................................. 4-31
In Snow (Diesel Engines)
....................................... 2-15
IntheRain ................................................... 4-24
LossofControl
............................................... 4-10
Nightvision ................................................. 4-24
Off-Road Driving with Your Four-wheel Drive Vehicle
.............. 4-12
Before You
Go Off-Roading .................................. 4-12
After Off-Road Driving
...................................... 4-23
Passing
...................................................... 4-9
Through Deep Standing Water ................................... 2-15
Winter
...................................................... 4-31
DrunkenDriving
............................................... 4-2
3
ProCarManuals.com

E
Eiectrical System
Engine Add-On
Equipment
........................................... 6-74
Adding Coolant
. Diesel Engine ........................... 5.18, 636
Adding Coolant
- Gasoline Engine .... , .................... 5-1 1’6-35 .
Air Cieaner
Coolant
.........................
Coolant Heater ...................
Coolant Temperature Gage (See “Gages‘
Diesel Heater Output
...............
.
......................
Control Module System ............
........................... 6-25
........................... 6-53
........................... 6-33
.................. 2-19.3-4. 6-19
1
............................ 3-4
Exhaust
..................................................... 2-31
FanNoise
................................................... 5-24
Identification .................................. 6-72.6-73.6-76. 6-77
Oil (See “Oil”)
Overheating
................................................... 5-9
RunningWhileParked ......................................... 2-32
Starting Your Gasoline Engine
................................... 2-13
Starting Your Diesel Engine
..................................... 2-15
Exhaust System
............................................... 6-53
F
Filter Replacement Chart (See “Service-Replacement Parts and Filter
Recommendations’’)
Fluid Capacities (See “Capacities and Specification”)
Fluid Leak Check
..................................... ........ 6-45
Fluids (See “Scheduled Maintenance Services”)
Four-WheelDrive
............................................... 2-33
Front Axle Locking Feature
..................................... 2-35
Transfer Case
........................................... 2-33. 6-32
Canadian
..................................................... 6-5
Diesel
....................................................... 6-4
Filling Your Tank ............................................. 6-11
Foreign Countries (Gasoline Engines)
............................. 6-11
Filter Replacement (Diesel Engines)
............................... 6-9
Gage (See “Gages”)
Gasoline
..................................................... 6-2
Gasolines for Cleaner Air
........................................ 6-3
Running Out of Fuel (Diesel Engines) .............................. 6-8
Tankcapacity ................................................ 6-78
Water in Fuel (Diesel Engines) ............................... 2-70. 6-5
Fuses and Circuit Breakers ................................... 6-75. 6-81
FuseBlock
............................................. 6-766-80
Fuel
4
ProCarManuals.com

Outside ..................................................... 2-54
ModelReference
.................................................. iv
Multifunction Lever
.............................................. 2-39
0
Odometer (See “Gages”) Off-Road Driving (See “Driving-Off-Road Driving with Your Four Wheel Drive
Vehicle”)
Oil Off-Road Recovery
... , ....... I ............................. 4-9
.
DieselEngines ............................................... 6-20
Additives
................................................. 6-24
Pressure Gage (See “Gages”) ToCheck
............................................... 6-21
WhatKindtoUse
.......................................... 6-22
WhentoAdd
.............................................. 6-21
What to Do with Used Oil
.................................... 6-24
Gasoline Engines
............................................. 6-14
Additives
................................................. 6-19
Pressure Gage (See “Gages”)
ToCheck
............................................... 6-15
WhatKindtoUse .......................................... 6-16
WhentoAdd
.............................................. 6-15
Whentochange ............................................ 6-19
What to Do with Used Oil
.................................... 6-20
Owner Checks and Services
...................................... 7-92
Whentochange
............................................ 6-24
P
Parking
Brake (See “Brakes-Parking”)
On Hills (See “Towing-Parking on Hills”)
Over Things That Burn
......................................... 2-30
Passing (See “Driving-Passing”)
Periodic Maintenance Inspections (See “Scheduled Maintenance Services”) Power
Door Locks (See “Doors”) Steering
...................................................... 4-7
SteeringFluid
................................................ 6-39
Take-Off(PT0)
.............................................. 4-35
Winches
..................................................... 4-34
7
Radiator Pressure Cap ............................................ 6-37
Radio (See “Audio Systems”)
Rear Axle (See “Axle”)
Rear Window Defogger
............................................ 3-7
Recommended Fluids and Lubricants (See “Scheduled Maintenance Services”)
RecoveryHooks
................................................. 5-40
ProCarManuals.com

Seats ........................................................... 1-1
Controls ...................................................... 1-1
Easy Entry Seat (Suburban Second Seat)
............................ 1-7
Easy Entry Seat (2-Door Utility Model)
............................ 1-5
Folding Second Seat (Suburban) ................................. 1-13
Head Restraints
................................................ 1-6
ManualFrontSeats
............................................. 1-1
Power Lumbar Adjustment
....................................... 1-3
Powerseats ................................................... 1-2
Rear Folding Seat (2-Door Utility Model) ........................... 1-8
Rear Folding Seat (&Door Utility Model)
.......................... 1-10
Reclining Front Seatback
........................................ 1-3
Removable Rear (Third Seat (Suburban))
.......................... 1-15
SeatbackLatches
............................................... 1-4
Doing Your Own Service Work ................................... 6-1
Parts Identification Label
....................................... 6-74
Publications
................................................... 8-8
Replacement Parts and Filter Recommendations
...... 676,677, 6-78, 6-79
Service
Service Engine Soon Light
(See “Lights”)
Servicing Your Air Bag-Equipped Vehicle (See “supplemental Inflatable Restraint
System (SIR)”)
Shift Indicator Light (See “Lights”)
Shifting Into Park (P)
............................................. 2-27
Shifting Out of Park (P)
........................................... 2-28
Shock Absorbers
................................................ 6-44
Specifications Chart (See “Service - Replacement Parts and Filter
Recommendations”) SpareTire
................................................. 5-26, 5-30
Speedometer and Odometer (See “Gages”)
Starting Your Engine (See “Engine-Starting”)
Steering
........................................................ 4-7
Column Shift Lever
............................................ 2-26
In Emergencies
................................................ 4-8
Tips
......................................................... 4-7
Step-BumperPad
................................................ 2-86
Storage Compartments
............................................ 2-58
Sunvisors ..................................................... 2-55
Supplemental Inflatable Restraint System (SIR)
........................ 1-29
How the Air Bag System Works
.................................. 1-30
Servicing Your Facial Air Bag-Equipped Vehicle
.................... 1-32
Surge Tank Pressure Cap
........................... , ............ 6-38
Adding Equipment to
Your Facial Air Bag-Equipped Vehicle
.......... 1-33
T
Tachometer (See “Gages”)
Theft
.......................................................... 2-10
Thermostat
..................................................... 6-38
Tilt Wheel (Option)
.............................................. 2-39
Tires
........................................................... 6-54
Balancing (See “Wheel Alignment and Tire Balance”)
Chains
...................................................... 6-62
Flat (See “Changing a Flat Tire”)
Inspection and Rotation
.........................
Loading (See “Loading Your Vehicle”)
.......... 6-56
ProCarManuals.com

New ........................................................ 6-58
Pressure
..................................................... 6-55
Spare (See “Spare Tire”)
Uniform Tire Quality Grading
................................... 6-59
Top Strap (See “Safety Belts-Child Restraints”)
Torque Lock (See “Transmission-Torque Lock”)
Towing
ATrailer
.................................................... 4-39
DrivingonGrades
.......................................... 4-45
Driving with a Trailer
....................................... 4-43
ParkingonHills
............................................ 445
Passing
................................................... 4-44
Safety Chains
.............................................. 4-42
Hitches
..................................................... 4-42
TowingYourVehicle
.............................................. 5-7
Trailer Brakes
...................................................... 4-43
Towing (See “Towing”)
Wiring Harness
.......................................... 2-85, 6-75
Trailering Package (See “Loading Your Vehicle”)
Transmission
Automatic
.............................................. 2-20, 6-26
HowToCheck ............................................. 6-26
When to Check and Change Fluid
.............................. 6-26
FiveSpeedManual
....................................... 2-23, 6-29
How To Add Fluid
.......................................... 6-30
HowToCheck
............................................. 6-29
ShiftLight
................................................ 2-24
Shiftspeeds
............................................... 2-25
Whentocheck
............................................. 6-29
Torque Lock (Automatic Transmission)
....................... 2-27, 2-29
HowToAdd
............................................... 6-29
Trip Odometer (See “Gages”)
Turn Signal and Lane Change Indicator (See “Lights”)
V
Vehicle
Damage Warnings
..................... ... ......... vi
Identification Number
..................................... 6.72. 6.73
Loading (See “Loading Your Vehicle”)
Storage
..................................................... 6-45
Symbols
............................................. vi, vu, vm, ix
Ventilation System
................................................ 3-8
Tips ......................................................... 3-8
Voltmeter (See “Gages”)
.....
W
Warning
Devices. Other
............................ .......... 5-2
Hazard Flashers (See “Hazard Warning Flashers”)
Lights and Indicators
........................................... 2-69
Alignment and Tire Balance
..................................... 6-60
Aluminum ................................................... 6-69
Wheels
ProCarManuals.com

Hub Caps and Wheel Nut Caps ..................................
NutTighteningSequence .......................................
NutTorque ..................................................
Replacement .................................................
Used Replacement ............................................
Windows ......................................................
5-32
5-37
6-77
6-60
6-61
2-35
Defogger. Rear
............................................ 3-7
Rear Window Wiper and Washer ................................. 2-56
Washer ...................................................... 2-42
WasherFluid
................................................. 6-40
Wiper Blade Chatter ........................................... 6-67
Wiper Blade Cleaning (See “Cleaning”)
Wiper Blade Replacement
...................................... 6-44
Wipers ...................................................... 2-41
Windshield
11
ProCarManuals.com