fuel cap CHEVROLET TRACKER 1994 User Guide

Maintenance Schedule
sc 1 ection A: Scheduled Maintenance Services (Cont.) 1 ITEM
NO.
12
13
14
15
SERVICE
Positive Crankcase Ventilation
{PCV) Valve Replacement*
-
Inspect valve for proper
function. Replace
the valve
every
50,000 miles (83 000 km)
as well as any worn, plugged or
collapsed hases.
Exhaust
Gas Recirculation
{EGR) System Inspection* -
lpspect at 50,pOO mile
(83 000 km) intervals.
Replace every
30,000 miles
(50 ODD km) or more often under
dusty conditions.
Ask your dealer
for the proper replacement
intervals
for your driving
qonflitions.
Fuel Tank. Cap and Lines
wection*t
- Inspect fuel tank,
cap, lines and hoses
for damage
or-leaks. Inspect fuel cap gasket
for an even filler neck imprint or
any damage at
30,000 miles
(50 000 h). Replace parts as
Cleaner
Filter Replacement*-
ITEM
NO.
16
17
18
19
20
21
SERVICE
needed. Replace the cap and
gasket at
60,000 mile
(100 000 km) intervals.
Fuel Filter Re&uxmmt*
-
Replace the fuel filter every
30,000 miles (50 000 km), or
sooner if clogged.
Fuel Injector Inspectim*
-
Inspect at 100,000 mile
( 166 000 km) intervals,
Heated
Own Sensor
dacemea*
- Replace at
80,000 miles (133 000 km).
Etive va E-ns Canister
Redacernent"
- Replace at
100,000 mile
(166 000 km)
intervals.
me Control Module (ECM)
and Associated Sensors
Jnspectipn*
- Inspect at 100,000
mile (1.66 000 km) intervals.
lsslon Svstem
Hoses
Inspection" - Inspect at 60,000
mile (100 OD0 km) intervals.
0.
..
ITEM
NO.
22
23
SERVICE
Three-way CUytlc Convertex
Jnspection"
- Inspect at 100,000
mile (166 000 km) intervals.
At each si1 change, inspect the
entire exhaust system for leaks
and loose fittings, especially
if
the vehicle is used off-road.
E-e Timing and Dlstnbu tor
Check*
- Adjust the timing to the
underhood label specifications.
Inspect the inside and outside
of
the distributor cap and rotor for
cracks, carbon tracking and
corrosion. Clean or replace
as
needed.
..
* An Emission Control Service.
t The US. Environmental Protection Agency
or
the California 4ir Resources Eoard has
determined that the failure to perjorm this
maintenance item
will not nullifjt the emission
warranty or
limit recall liabiliw prior to the
completion
of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be petfiimed at the
indicated intervals and the maintenance
be
recorded in "Section E: Maintenance
Record."
... 21 6
ProCarManuals.com

Service Station Information
See Page 163
(I I Ill1 n
Cooling System Reservoir Hood Release
Check and add coolant gdy at the coolant See Page 159
recovery tank. The fluid should be at the
“FULL” mark when the engine is warm.
If the engine is cool, the level should be
at the “LOW” mark or
a little higher.
See Page 170 Windshield Washer
Fluid Reservoir
See Page 174 Engine Oil Dipstick
See Page 162
Battery
Engine Oil Fill Cap
The Delco Freedom“ battery needs
no water. See Page 176
See Tire-Loading Information label on the
inside of the rear edge
of the driver’s door.
See Page 181
Spare Tire Pressure Fuel Cap
See Tire-Loading Information label on the Capacity I1 U.S. Gal. (42 L).
inside of the rear edge of the driver‘s door. LJse unleaded gas only, 87 octane or
See Page 181 higher.
See Page 156
Ill IIII H 1
ProCarManuals.com