lock CHEVROLET TRACKER 1998 1.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine Long Tripmighway Maintenance Schedule
75,000 Miles (125 000 km) (Continued)
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
0 Inspect the locking front hubs (if equipped) for correct operation (or every
0 Inspect the valve lash and adjust if necessary.
Check engine idle speed and adjust it to underhood label specifications.
0 Inspect propeller shafts and u-joints for looseness and damage (or every
rotation pattern and additional information. (See footnote
+.)
3 months, whichever occurs first). Repair or replace
if necessary.
An Emission Control Service.
An Emission Control Service.
(See footnote?.)
15 months, whichever occurs first). Inspect more frequently if used off-road
or for pulling a trailer. Tighten u-joint flange bolts
if necessary.
82,500 Miles (I37 500 km)
0 Change engine oil and filter (or every 7.5 months, whichever occurs first).
0 Rotate tires. See “Tire Inspection and Rotation” in the I\
ndex for proper
0 Inspect the locking front hubs (if equipped) for correct operation (or every
An Emission Control Service.
rotation pattern and additional information. (See footnote +.)
3 months, whichever occurs first). Repair or replace if necessary.
DATE I
MILEAGE
7-42

Downloaded from www.Manualslib.com manuals search engine Iway Maintenance Schedule I
90,000 Miles (150 000 km) (Continued)
0
0
0
Drain, flush and refill cooling system (or every 30 months, w\
hichever occurs
first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean
radiator, condenser, pressure cap and neck. Pressure test the c\
ooling system and pressure cap.
An Emission Control Service. (See footnote?.)
Replace spark plugs.
An Emission Control Service.
Replace air cleaner filter.
An Emission Control Service.
Inspect fuel tank, cap and lines and any hoses for damage or leaks. Replace
fuel tank cap gasket.
An Emission Control Service. (See footnote ?.)
Change manual transmission fluid.
Change transfer case fluid.
Change differential fluid.
Replace fuel filter (or every 30 months, whichever occurs firs\
t).
An Emission Control Service. (See footnote?.)
Inspect the locking front hubs (if equipped) for correct operation (or every
3 months, whichever occurs first). Repair or replace if necessary.
7-44

Downloaded from www.Manualslib.com manuals search engine 1 Long Tripmighway Maintenance Schedule I
Inspect the valve lash and adjust if necessary.
Check engine idle speed and adjust it to underhood label specifications.
0 Inspect propeller shafts and u-joints for looseness and damage (or every
An Emission Control Service.
An Emission Control Service. (See footnote”f)
15 months, whichever occurs first). Inspect more frequently if use\
d off-road
or for pulling a trailer. Tighten u-joint flange bolts if necessary.
rotation pattern and additional information. (See footnote
+.)
Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
97,500 Miles (162 500 km)
Change engine oil and filter (or every 7.5 months, whichever occurs first).
An Emission Control Service.
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
0 Inspect the locking front hubs (if equipped) for correct operation (or every
rotation pattern and additional information. (See footnote +.)
3 months, whichever occurs first). Repair or replace if necessary.
I DATE
7-45

Downloaded from www.Manualslib.com manuals search engine At Least Twice a Year
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages are working properly. Look for any other loose or damaged
safety belt system parts. If you see anything that might
keep a safety belt system from doing its job, have it
repaired. Have any torn or frayed safety belts replaced.
Also look for any opened or broken air bag coverings,
and have them repaired or replaced. (The air bag system
does not need regular maintenance.)
Wiper Blade Check
Inspect wiper blades for wear or cracking. Replace blade
inserts that appear worn or damaged or that streak or
miss areas of the windshield. Also
see “Wiper Blades,
Cleaning” in the Index.
Fluid Level Check
Check the transfer case, axle differential(s) and
automatic
or manual transmission fluid levels and add
as needed. See “Transfer Case,” “Axle, Rear,” “Axle,
Front” and “Automatic Transmission” or “Manual
Transmission” in the Index. Check for leaks.
A fluid loss
in these systems could indicate a problem. Have the
system inspected and repaired at once.
Automatic Transmission Check
Check the transmission fluid level; add if needed. See
“Automatic Transmission” in the Index. A fluid
loss
may indicate a problem. Check the system and repair
if needed.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant specified in Part
D.
Body Lubrication Service
Lubricate all body door hinges. Also lubricate all
hinges and latches, including those for the hood, rear
compartment, glove box door, console door and any
folding seat hardware.
Part D tells you what to use.
More frequent lubrication may be required when
exposed to a corrosive environment.
7-48

Downloaded from www.Manualslib.com manuals search engine Starter Switch Check Brake-Transmission Shift Interlock (BTSI) Check
(Automatic Transmission)
’ A CAUTION: I
When you are doing this check, the vehicle could
move suddenly. If it does, you
or others could be
injured. Follow the
steps below.
1. Before you start, be sure you have enough room
around the vehicle.
2. Firmly apply both the parking brake (see “Parking
Brake” in the Index if necessary) and the regular brake.
NOTE:
Do not use the accelerator pedal, and be
ready to turn
off the engine immediately if it starts.
3. On automatic transmission vehicles, try to start the
engine
in each gear. The starter should work only in
PARK
(P) or NEUTRAL (N). If the starter works in
any other position, your vehicle needs service.
On manual transmission vehicles, put the shift
lever
in NEUTRAL (N), push the clutch down halfway
and try to start the engine. The starter should work
only when the clutch is pushed down all the way to
the floor.
If the starter works when the clutch isn’t
pushed all the way down, your vehicle needs service.
A CAUTION:
When you are doing this check, theqehicle could
I
move suddenly. If it does, you or others could be
injured. Follow the steps below.
I
1. Before you start, be sure you have enough room around the vehicle. It should be parked on a
level surface.
2. Firmly apply the parking brake (see “Parking Brake”
in the Index
if necessary).
NOTE: Be ready to apply the regular brake
immediately if the vehicle begins to move.
3. With the engine off, turn the key to the
ON position,
but don’t start the engine. Without applying the
regular brake, try to move the shift lever out of
PARK (P) with normal effort. If the shift lever
moves out of PARK (P), your vehicle’s BTSI
needs service.
7-49
-

Downloaded from www.Manualslib.com manuals search engine Ignition Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to
LOCK in each shift lever position.
With an automatic transmission, the key should turn
to LOCK only when the shift lever is in PARK (P).
0 With a manual transmission, the key should turn to
LOCK only if you push the key in farther, while
turning it towards LOCK.
On vehicles with a key release lever,
try to turn the key
to LOCK without pressing the lever. The key should
turn to
LOCK only when you press the key lever.
On all vehicles, the key should come out only in LOCK.
Parking Brake and Automatic Transmission
PARK (P) Mechanism Check
A C [TION:
I
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front
of your vehicle in case
it begins to roll.
Be ready to apply the regular
brake at once should the vehicle begin to move.
Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set
the parking brake.
0
0
To check the parking brake’s holding ability:
With the engine running and transmission in
NEUTRAL (N), slowly remove foot pressure
from the regular brake pedal.
Do this until the
vehicle is held by the parking brake only.
To check the PARK (P) mechanism’s holding ability:
With the engine running, shift to PARK
(P).
Then release all brakes. If your vehicle is
four-wheel drive, be sure the transfer case is
not in NEUTRAL
(N).
Underbody Flushing Service
At least every spring, use plain water to flush any
corrosive materials from the underbody. Take care
to clean thoroughly any areas where mud and other
debris can collect.
7-50

Downloaded from www.Manualslib.com manuals search engine Part D: Recommended Fluids
and Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may be obtained from
your dealer.
FLUIDLUBRICANT
Engine Oil with the American
Petroleum Institute Certified
For Gasoline Engines “Starburst” symbol of the
proper viscosity. To determine the preferred viscosity for your
vehicle’s engine, see “Engine
Oil” in the Index.
50/50 mixture of clean water
(preferably distilled) and good
quality Ethylene Glycol Base
Coolant (GM Part
No. 1052753
or equivalent) conforming to
GM Specification 1825M or
approved recycled coolant
conforming to GM
Specification 1825M. See
“Engine Coolant” in the Index.
USAGE
Hydraulic Brake
System
Parking Brake Cable
Guides
Power Steering System
Manual
Transmission (All) and Transfer Case
(Four-Wheel-Drive)
Automatic
Transmission
~
Key Lock Cylinders
FLUIDLUBRICANT
Delco Supreme 11@ Brake
Fluid (GM Part No. 12377967
or equivalent DOT-3 Brake
Fluid).
Chassis Lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of NLGI
# 2, Category LB
or GC-LB.
DEXRON@-I11 Automatic
Transmission Fluid.
GM Goodwrench Synthetic
Manual Transmission Gear Oil
quart) or equivalent SAE
75W-90
GL-4 Gear Oil.
DEXRON@-I11 Automatic
Transmission Fluid.
Multi-Pu ose Lubricant,
Superlube
% (GM Part
No. 12346241 or equivalent).
(GM Part
NO. 12346190 - 1

Downloaded from www.Manualslib.com manuals search engine Chevrolet Roadside
Assistance Program
To enhance Chevrolet’s strong commitment to customer
satisfaction, Chevrolet is excited to announce the
establishment of the Chevrolet Roadside Assistance
Center. As the owner of a 1998 Chevrolet, membership
in Roadside Assistance is free. Roadside Assistance
is available 24 hours a day,
365 days a year, by calling 1-800-CHEV-USA
(1 -800-243-8872). This toll-free number will provide
you over-the-phone roadside assistance with minor
mechanical problems. If your problem cannot be
resolved over the phone, our advisors have access
to a
nationwide network of dealer recommended service
providers. Roadside membership is free, however some
services may incur costs.
Roadside offers two levels of service to the customer,
Basic Care and Courtesy’” Care:
0 Toll-free number, 1 -800-CHEV-USA
Free towing for warranty repairs
Basic over-the-phone technical advice
Available dealer services at reasonable costs (i.e.,
wrecker services, locksmithkey service, glass
repair, etc
.)

Downloaded from www.Manualslib.com manuals search engine ROADSIDE Courtesy" Care PROVIDES:
Roadside Basic Care services (as outlined previously)
Plus:
FREE Non-Warranty Towing (to the closest dealer
from a legal roadway)
0 FREE LocksmithKey Service (when keys are lost
on the road or locked inside)
0 FREE Flat Tire Service (spare installed on the road)
0 FREE Jump Start (at home or on the road)
0 FREE Fuel Delivery ($5 of fuel delivered on
the road) Chevrolet offers Courtesy Transportation
for customers
needing warranty service. Courtesy Transportation will
be offered in conjunction with the coverage provided by the Bumper to Bumper New Vehicle Limited Warranty
to eligible purchasers
of 1998 Chevrolet passenger cars
and light duty trucks. (Please see your selling dealer
for details.)
Note:
Courtesy Care is available to retail and retail lease
customers operating
1998 and newer Chevrolet vehicles
for
a period of 3 years/36,000 miles (60 000 km),
whichever occurs first. All Courtesy Care services must
be pre-arranged by Chevrolet Roadside or dealer Service Management.
Basic Care and Courtesy Care are not part of or
included in the coverage provided by the New Vehicle
Limited Warranty. Chevrolet reserves the right to modify or discontinue
Basic Care and Courtesy Care
at any time.
8 -.6

Downloaded from www.Manualslib.com manuals search engine 0 Section 9 Index
Adding Equipment to the Outside of Your Vehicle ..... 6-3
Air Bag
....................................... 1-25
Adding Equipment
............................ 1-3 1
How Does it Restrain .......................... 1-29
How it Works ................................ 1-27
Location
.................................... 1-27
Readiness Light
......................... 1-26. 2-59
Servicing
................................... 1-31
What Makes it Inflate
.......................... 1-28
What Will You See After
it Inflates ............... 1-29
When Should it Inflate
......................... 1-28
Aircleaner
.................................... 6-15
Air Conditioning ................................ 3-3
Air Conditioning Refrigerants ..................... 6-63
Alignment and Balance. Tire
...................... 6-46
Antenna
...................................... 3-17
Antifreeze
..................................... 6-24
Anti-Lock Brake System Active Light
................. 2-62. 4.9
Brake System Warning Light
................ 2.61. 4.7
Brakes
...................................... 4-7
Appearance Care Materials
....................... 6-56
Arbitration Program
.............................. 8-9
Ashtrays ...................................... 2-40
Aluminum Wheels. Cleaning
...................... 6-54
AppearanceCare
............................... 6-48 Audio Systems
.................................. 3-6
Automatic
Overdrive
................................... 2-15
Overdrive
Off Switch .......................... 2-15
Automatic Transmission
.......................... 2-9
Check
...................................... 7-48
Fluid
....................................... 6-17
Operation
................................... 2-11
Park Mechanism Check
........................ 7-50
Starting Your Engine
........................... 2-9
Front
....................................... 6-23
Rear
....................................... 6-22
Shifting
..................................... 2-11
Axle
Battery
...................................... 6-33
Jump Starting
................................. 5-3
Warnings
................................ 5.3. 5.4
BBB Auto Line
................................. 8-9
Better Business Bureau Mediation
................... 8-9
Blizzard
...................................... 4-41
Brake
Adjustment
.................................. 6-33
Fluid
....................................... 6-30
Master Cylinder
.............................. 6-29
Parking
..................................... 2-21