cooling CHEVROLET TRACKER 1998 1.G Owner's Manual

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Long TriplHighway Intervals I
Every 7,500 Miles (12 500 km): Engine Oil and Filter
Change (or every
7.5 months, whichever occurs first).
Free-Wheeling Hubs Inspection (if equipped) (or every
3 months, whichever occurs first). Tire Rotation.
Transmission Service (severe conditions only).
Engine Idle Speed Check. Valve Lash (Clearance)
Adjustment. Propeller Shafts and U-Joints Inspection (or every
15 months, whichever occurs first).
Every 30,000 Miles (50 000 km): Engine Accessory
Drive Belt Inspection (or every
24 months, whichever
occurs first). Cooling System Service (or every
30 months, whichever occurs first). Spark Plug
Replacement. Air Cleaner Filter Replacement. Fuel
Tank, Cap and Lines Inspection. Front Wheel Bearing
Repack (2WD only) (or at each brake relining,
whichever occurs first). Manual Transmission Fluid
Change. Transfer Case Fluid Change. Differential
Fluid Change. Fuel Filter Replacement (or every
30 months, whichever occurs first).
Every 15,000 Miles (25 000 km): Automatic
Long Tripmighway Intervals
Every 45,000 Miles (75 000 km): Automatic
Transmission Fluid Hose Replacement (or every
45 months, whichever occurs first).
Every 50,000 Miles (83 000 km): Positive Crankcase
Ventilation (PCV) Valve Replacement.
Every 60,000 Miles (100 000 km): Engine Timing
and Distributor Check. Fuel Tank Cap Gasket
Replacement. Emission System Hoses Inspection.
Camshaft Timing Belt Replacement. Spark Plug
Wire Replacement (or every
60 months, whichever
occurs first). Wiring Harness and Connectors
Inspection (or every
60 months, whichever occurs
first). Brake Fluid Service.
At 90,000 Miles (150 000 km): Camshaft Timing
Belt Inspection.
Every 100,000 Miles (166 000 km): Automatic
Transmission Service (normal conditions). Fuel
Injector Inspection. Evaporative Emissions
Canister Replacement.
These intervals only summarize maintenance services.
Be sure to
follow the complete maintenance schedule on
the following pages.
7-7

Downloaded from www.Manualslib.com manuals search engine I Short Trip/City Maintenance Schedule
30,000 Miles (50 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Inspect engine accessory drive belts (or every 24 months, whichever
An Emission Control Service.
occurs first).
An Emission Control Service.
0 Drain, flush and refill cooling system (or every 30 months, whichever occurs
first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean
radiator, condenser, pressure cap and neck. Pressure test the c\
ooling system
and pressure cap.
An Emission Control Service. (See footnote?.)
bearings (or at each brake relining, whichever occurs first).
An Emission Control Service.
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Replace spark plugs.
I DATE I
0 Replace air cleaner filter.
An Emission Control Service.
0 Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket
for any damage. Replace parts as needed.
An Emission Control Service. (See footnote?.)
(Continued)
7-13

Downloaded from www.Manualslib.com manuals search engine 1 Short TripKity Maintenance Schedule I
60,000 Miles (100 000 km) (Continued)
0 Change automatic transmission fluid and filter if the vehicle is mainly driven
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly r\
eaches
- In hilly or mountainous terrain.
90°F (32°C) or higher.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, change the fluid
and filter every
100,000 miles (166 000 km).
occurs first).
An Emission Control Sewice.
first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean
radiator, condenser, pressure cap and neck. Pressure test the c\
ooling system and pressure cap.
An Emission Control Service. (See footnote?.)
0 Replace spark plugs.
An Emission Control Service.
0 Replace spark plug wires (or every 60 months, whichever occurs first),
An Emission Control Service.
0 Inspect engine accessory drive belts (or every 24 months, whichever
0 Drain, flush and refill cooling system (or every 30 months, w\
hichever occurs
7-20

Downloaded from www.Manualslib.com manuals search engine I Short Trip/City Maintenance Schedule I
0 Change automatic transmission fluid and filter if the vehicle is mainly driven
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly r\
eaches
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, change the fluid
and
filter every 100,000 miles (166 000 km).
occurs first).
An Emission Control Service.
17 Inspect camshaft timing belt.
An Emission Control Service. (See footnote T.)
90°F (32°C) or higher.
0 Inspect engine accessory drive belts (or every 24 months, whichever
0 Drain, flush and refill cooling system (or every 30 months, whichever occur\
s
first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean
radiator, condenser, pressure cap and neck. Pressure test the cooling system
and pressure cap.
An Emission Control Service. (See footnote?.)
0 Replace spark plugs.
An Emission Control Service.
(Continued)
7-27

Downloaded from www.Manualslib.com manuals search engine Long Tripmighway Maintenance Schedule
30,000 Miles (50 000 km) (Continued)
0 For Two-Wheel-Drive vehicles only: Clean and repack the front wheel
0 Change automatic transmission fluid and filter if the vehicle is mainly driven
bearings (or at each brake relining, whichever occurs first). \
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly reaches
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, change the fluid
and filter every
100,000 miles (166 000 km).
rotation pattern and additional information. (See footnote +.)
90°F (32°C) or higher.
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
0 Inspect engine accessory drive belts (or every 24 months, whichever
occurs first).
An Emission Control Service.
first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean
radiator, condenser, pressure cap and neck. Pressure test the cooling system
and pressure cap.
An Emission Control Service. (See footnote“f)
0 Drain, flush and refill cooling system (or every 30 months, whichever occurs
7-34

Downloaded from www.Manualslib.com manuals search engine Long Tripmighway Maintenance Schedule
0 Inspect engine accessory drive belts (or every 24 months, whichever
occurs
first). An Emission Control Service.
0 Drain, flush and refill cooling system (or every 30 months, whichever occurs
first).
See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean
radiator, condenser, pressure cap and neck. Pressure test the c\
ooling system
and pressure cap.
An Emission Control Service. (See footnote?.)
0 Replace spark plugs.
An Emission Control Service.
17 Replace air cleaner filter.
An Emission Control Service.
0 Inspect fuel tank, cap and lines and any hoses for damage. Replace fuel tank
cap gasket.
An Emission Control Service. (See footnote “f)
0 Change manual transmission fluid.
0 Change transfer case fluid.
0 Change differential fluid.
0 Replace fuel filter (or every 30 months, whichever occurs first).
0 Inspect the locking front hubs (if equipped) for correct operation (or every
An Emission Control Service. (See footnote?.)
3 months, whichever occurs first). Repair or replace as necessary.
(Continued)
7-39

Downloaded from www.Manualslib.com manuals search engine Iway Maintenance Schedule I
90,000 Miles (150 000 km) (Continued)
0
0
0
Drain, flush and refill cooling system (or every 30 months, w\
hichever occurs
first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean
radiator, condenser, pressure cap and neck. Pressure test the c\
ooling system and pressure cap.
An Emission Control Service. (See footnote?.)
Replace spark plugs.
An Emission Control Service.
Replace air cleaner filter.
An Emission Control Service.
Inspect fuel tank, cap and lines and any hoses for damage or leaks. Replace
fuel tank cap gasket.
An Emission Control Service. (See footnote ?.)
Change manual transmission fluid.
Change transfer case fluid.
Change differential fluid.
Replace fuel filter (or every 30 months, whichever occurs firs\
t).
An Emission Control Service. (See footnote?.)
Inspect the locking front hubs (if equipped) for correct operation (or every
3 months, whichever occurs first). Repair or replace if necessary.
7-44

Downloaded from www.Manualslib.com manuals search engine Part C: Periodic
Maintenance Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall).
You should let your dealer’s service
department or other qualified service center do these
jobs. Make sure any necessary repairs are completed
at once.
7xhaust Syste:-- p- 1sy::A’on
inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections or other conditions which
could cause a heat build-up in the floor pan or could
let exhaust fumes into the vehicle. See “Engine
Exhaust” in the Index.
Proper procedures to perform these services may be found in a service manual. See “Service and Owner
Publications” in the Index.
Steering, Suspension and Front Drive
Axle Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing
parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc. Clean and then inspect
the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Engine Cooling System Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes, fittings
and clamps; replace as needed. Clean the outside
of the
radiator and air conditioning condenser.
To help ensure
proper operation, a pressure test of the cooling system
and pressure cap is recommended at least once a year.
7-5 1

Downloaded from www.Manualslib.com manuals search engine Comfort Controls ................................ 3-2
Compact Disc Player
............................ 3- 11
Care
....................................... 3-17
Errors
...................................... 3-13
Control. Loss of
................................ 4-14
Control
of a Vehicle .............................. 4-6
Convertible Top
................................ 2-41
Convex Outside Mirror
.......................... 2-39
Coolant
....................................... 6-24
Levelcheck
................................. 5-15
Radiator
.................................... 5- 19
RecoveryTank ............................... 5-16
Temperature Gage
............................ 2-62
Cooling System
................................ 5-14
Courtesy Transportation
........................... 8-8
Cruise Control
................................. 2-33
Cupholders
.................................... 2-40
Customer Assistance for Text Telephone Users
......... 8-4
Customer Assistance Information
................... 8-1
Customer Satisfaction Procedure
.................... 8-2
Damage Finish
...................................... 6-55
SheetMetal
................................. 6-54
Daytime Running Lamps
......................... 2-37
Daytime Running Lamps Indicator Light
............ 2-67
DeadBattery
................................... 5-3
Defects. Reporting Safety
........................ 8-10
Defensive Driving
............................... 4-2
Defogger. Rear Window
.......................... 3-5 Defogging
..................................... 3-5
Defrosting
..................................... 3-5
Dimensions. Vehicle
............................ 6-63
Dome Lamp Bulb Replacement
.................... 6-40
Dome Lamps
.................................. 2-38
Door Locks
....................................... 2-4
Storage
..................................... 2-39
Downshifting
.................................. 2-17
Drive Position. Automatic Transmission
............. 2-13
DriverPosition
................................. 1-18
Driving
City
........................................ 4-34
Defensive
.................................... 4-2
Drunken
..................................... 4-3
Freeway
.................................... 4-35
Guidelines
.................................. 4-15
InaBlizzard
................................. 4-41
In Foreign Countries
........................... 6-5
IntheRain
.................................. 4-31
Night
...................................... 4-29
Off-Road
................................... 4-15
OnCurves .................................. 4-10
On Grades While Towing a Trailer
............... 4-54
On Hill and Mountain Roads
.................... 4-37
OnSnowandIce
............................. 4-39
Throughwater
............................... 4-33
WetRoads
.................................. 4-31
Winter
...................................... 4-39
WithaTrailer
................................ 4-52
Drunken Driving
................................ 4-3
9-3
. .- ............... ... ........................ .C.-..Y..YIY ..-Fli-..-.--.- .__ ....- - .. - .- -

Downloaded from www.Manualslib.com manuals search engine Gages Engine Coolant Temperature
.................... 2-62
Fuel ....................................... 2-67
GAWR
....................................... 4-46
Gear Positions. Automatic Transmission
............. 2- 11
GloveBox
.................................... 2-39
Gross Axle Weight Rating ........................ 4-46
Gross Vehicle Weight Rating
...................... 4-46
Guide en Franqais
-11
GVWR ....................................... 4-46
Gear Positions. Manual Transmission
............... 2-
15
.. ................................
Halogen Bulbs ................................ 6-34
Hazard Warning Flashers
.......................... 5-2
HeadRestraints
................................. 1-4
Headlamps
.................................... 2-3 1
Bulb Replacement ............................ 6-34
High/Low Beamchanger
...................... 2-31
Hearing Impaired. Customer Assistance
.............. 8-4
Heating
........................................ 3-3
Highway Hypnosis
.............................. 4-37
Hill and Mountain Roads ......................... 4-37
Hitches. Trailer
................................. 4-51
Hood Checking Thingsunder
......................... 6-8
Prop
........................................ 6-9
Release
...................................... 6-8
Hood Latch Operation Check
..................... 7-47
Horn
......................................... 2-29
Hubs. Freewheeling
............................. 2- 18
Hydroplaning
.................................. 4-33 Ignition
Positions
............................... 2-8
Ignition Transmission Lock Check
................. 7-50
Inflation. Tire
.................................. 6-41
Inside Daymight Rearview Mirror
................. 2-38
Inspections Brakesystem
................................ 7-52
Engine Cooling System
........................ 7-51
Exhaust Systems
............................. 7-51
Front Axle
.................................. 7-52
Front Drive Axle Boot
......................... 7-51
Front Drive Axle Seal
......................... 7-51
Ignition Transmission Lock Check
............... 7-50
Rear Axle
................................... 7-52
Steering
.................................... 7-51
Suspension
.................................. 7-51
Throttle Linkage
.............................. 7-52
Instrument Panel
............................... 2-54
Brightness Control
............................ 2-37
Cleaning
.................................... 6-50
Cluster
..................................... 2-56
FuseBlock
.................................. 6-58
Interior Lamps
................................. 2-37
Jack. Tire
.................................... 5-24
Jumpstarting
................................... 5-3
Key Lock Cylinders Service
..................... 7-48
Keys
.......................................... 2-2
9-5