transmission CHEVROLET TRACKER 1998 1.G Manual PDF

Downloaded from www.Manualslib.com manuals search engine Ignition Transmission Lock Check
While parked, and with the parking brake set, try to turn
the ignition key to
LOCK in each shift lever position.
With an automatic transmission, the key should turn
to LOCK only when the shift lever is in PARK (P).
0 With a manual transmission, the key should turn to
LOCK only if you push the key in farther, while
turning it towards LOCK.
On vehicles with a key release lever,
try to turn the key
to LOCK without pressing the lever. The key should
turn to
LOCK only when you press the key lever.
On all vehicles, the key should come out only in LOCK.
Parking Brake and Automatic Transmission
PARK (P) Mechanism Check
A C [TION:
I
When you are doing this check, your vehicle
could begin to move. You or others could be
injured and property could be damaged. Make
sure there is room in front
of your vehicle in case
it begins to roll.
Be ready to apply the regular
brake at once should the vehicle begin to move.
Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set
the parking brake.
0
0
To check the parking brake’s holding ability:
With the engine running and transmission in
NEUTRAL (N), slowly remove foot pressure
from the regular brake pedal.
Do this until the
vehicle is held by the parking brake only.
To check the PARK (P) mechanism’s holding ability:
With the engine running, shift to PARK
(P).
Then release all brakes. If your vehicle is
four-wheel drive, be sure the transfer case is
not in NEUTRAL
(N).
Underbody Flushing Service
At least every spring, use plain water to flush any
corrosive materials from the underbody. Take care
to clean thoroughly any areas where mud and other
debris can collect.
7-50

Downloaded from www.Manualslib.com manuals search engine Part D: Recommended Fluids
and Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may be obtained from
your dealer.
FLUIDLUBRICANT
Engine Oil with the American
Petroleum Institute Certified
For Gasoline Engines “Starburst” symbol of the
proper viscosity. To determine the preferred viscosity for your
vehicle’s engine, see “Engine
Oil” in the Index.
50/50 mixture of clean water
(preferably distilled) and good
quality Ethylene Glycol Base
Coolant (GM Part
No. 1052753
or equivalent) conforming to
GM Specification 1825M or
approved recycled coolant
conforming to GM
Specification 1825M. See
“Engine Coolant” in the Index.
USAGE
Hydraulic Brake
System
Parking Brake Cable
Guides
Power Steering System
Manual
Transmission (All) and Transfer Case
(Four-Wheel-Drive)
Automatic
Transmission
~
Key Lock Cylinders
FLUIDLUBRICANT
Delco Supreme 11@ Brake
Fluid (GM Part No. 12377967
or equivalent DOT-3 Brake
Fluid).
Chassis Lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of NLGI
# 2, Category LB
or GC-LB.
DEXRON@-I11 Automatic
Transmission Fluid.
GM Goodwrench Synthetic
Manual Transmission Gear Oil
quart) or equivalent SAE
75W-90
GL-4 Gear Oil.
DEXRON@-I11 Automatic
Transmission Fluid.
Multi-Pu ose Lubricant,
Superlube
% (GM Part
No. 12346241 or equivalent).
(GM Part
NO. 12346190 - 1

Downloaded from www.Manualslib.com manuals search engine USAGE
Manual
Transmission Shift Linkage
Clutch Linkage
Pivot Points
Floor Shift Linkage
Chassis Lubrication
FLUIDLUBRICANT
Chassis Lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of NLGI # 2, Category LB or
I Chassis Lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of NLGI # 2, Category LB or
Lubriplate@ Lubricant Aerosol (GM Part
No. 12346293 or
equivalent)
or lubricant
meeting requirements
of NLGI
# 2 Category LB or GC-LB.
Chassis Lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of NLGI # 2, Category LB or
GC-LB.
i GC-LB.
GC-LB.
USAGE
Front Wheel
FLUIDLUBRICANT
meeting requirements of NLGI
Bearings Wheel Bearing Lubricant
# 2, Category GC or GC-LB
(GM Part No. 1051344
or equivalent).
Rear Axle (All) and
GM Optikleen@ Washer Windshield Washer
8OW-90
GL-5 Gear Lubricant.
(Four-wheel Drive) No. 12345977) or SAE Front Axle
Axle Lubricant (GM Part
Solvent Solvent (GM Part No. 105 15
1 5) or equivalent.
Hood Latch Lubriplate@ Lubricant Aerosol
Assembly, Secondary (GM Part No. 12346293 or
Latch, Pivots, equivalent) or lubricant Spring Anchor and meeting requirements
of NLGI
Release Pawl
# 2, Category LB or GC-LB.
Hood and Door Multi-Pu ose Lubricant,
Hinges Superlube
% (GM Part
No. 12346241 or equivalent).
Weatherstrip (GM Part
No. 12345579
Conditioning Dielectric Silicone Grease
or equivalent).

Downloaded from www.Manualslib.com manuals search engine 1998 CHEVROLET SERVICE PUBLICATIONS ORDERING INFORMATIOh
The following publications covering the operation and servicing of your vehicle can be purchased by filling om
the Service Publication Order Form in this book and mailing it in with your check, money order,
or credit card information to Helm, Incorporated (address below\
.)
SERVICE MANUALS
CURRENT PUBLICATIONS FOR 1998 CHEVROLET
OWNER’S INFORMATION
Service Manuals have the diagnosis and repair information Owner publications are written directly for Owners ana
on engines, transmission, axle, suspension, brakes, intended
to provide basic operational information about tt
electrical, steering, body, etc. vehicle. The owner’s
manual will include the Maintenancc
RETAIL SELL PRICE:
$90.00 Schedule for all models.
TRANSMISSION, TRANSAXLE, TRANSFER CASE
UNIT
REPAIR MANUAL
This manual provides information on unit repair service
procedures, adjustments and specifications for the
1998 GM transmissions, transaxles and transfer cases.
RETAIL SELL PRICE:
$40.00
SERVICE BULLETINS
Service Bulletins give technical service information needed
to knowledgeably service General Motors cars and trucks.
Each bulletin contains instructions to assist in the
diagnosis and service of your vehicle. In-Portfolio: Includes a
Portfolio, Owner’s Manual and
Warranty Booklet. RETAIL SELL PRICE:
$1 5.00
Without Portfolio: Owner’s Manual only.
RETAIL SELL
PRICE: $1 0.00
CURRENT & PAST MODEL ORDER FORMS
Service Publications are available for current and past
model GM vehicles. To request an order form, please
specify year and model name of the vehicle.

Downloaded from www.Manualslib.com manuals search engine I I Service Manual 1998 $90.00
Car & Light Truck Transmission Unit Repair 1998 $40.00
Owner’s Manual In Portfolio 1998 $1 5.00
Owner’s Manual Without Portfolio 1998 $1 0.00
I

Downloaded from www.Manualslib.com manuals search engine 0 Section 9 Index
Adding Equipment to the Outside of Your Vehicle ..... 6-3
Air Bag
....................................... 1-25
Adding Equipment
............................ 1-3 1
How Does it Restrain .......................... 1-29
How it Works ................................ 1-27
Location
.................................... 1-27
Readiness Light
......................... 1-26. 2-59
Servicing
................................... 1-31
What Makes it Inflate
.......................... 1-28
What Will You See After
it Inflates ............... 1-29
When Should it Inflate
......................... 1-28
Aircleaner
.................................... 6-15
Air Conditioning ................................ 3-3
Air Conditioning Refrigerants ..................... 6-63
Alignment and Balance. Tire
...................... 6-46
Antenna
...................................... 3-17
Antifreeze
..................................... 6-24
Anti-Lock Brake System Active Light
................. 2-62. 4.9
Brake System Warning Light
................ 2.61. 4.7
Brakes
...................................... 4-7
Appearance Care Materials
....................... 6-56
Arbitration Program
.............................. 8-9
Ashtrays ...................................... 2-40
Aluminum Wheels. Cleaning
...................... 6-54
AppearanceCare
............................... 6-48 Audio Systems
.................................. 3-6
Automatic
Overdrive
................................... 2-15
Overdrive
Off Switch .......................... 2-15
Automatic Transmission
.......................... 2-9
Check
...................................... 7-48
Fluid
....................................... 6-17
Operation
................................... 2-11
Park Mechanism Check
........................ 7-50
Starting Your Engine
........................... 2-9
Front
....................................... 6-23
Rear
....................................... 6-22
Shifting
..................................... 2-11
Axle
Battery
...................................... 6-33
Jump Starting
................................. 5-3
Warnings
................................ 5.3. 5.4
BBB Auto Line
................................. 8-9
Better Business Bureau Mediation
................... 8-9
Blizzard
...................................... 4-41
Brake
Adjustment
.................................. 6-33
Fluid
....................................... 6-30
Master Cylinder
.............................. 6-29
Parking
..................................... 2-21

Downloaded from www.Manualslib.com manuals search engine Brake (Continued) Pedal Travel
................................. 6-32
Replacing System Parts
........................ 6-33
System Warning Light
......................... 2-60
Trailer
...................................... 4-52
Transmission Shift Interlock
.................... 2-25
Transmission Shift Interlock Check
............... 7-49
Wear
....................................... 6-32
Brakes. Anti-Lock
............................... 4-7
Braking in Emergencies
........................... 4-9
Break-In. New Vehicle
........................... 2-7
Brightness Control
.............................. 2-37
BTSICheck
................................... 7-49
Bulb Replacement
.............................. 6-34
Braking
........................................ 4-6
BTSI
......................................... 2-25
Canadian Roadside Assistance
.................... 8-7
Canvas Top
Lowering and Raising
......................... 2-47
Preparing for Storage
.......................... 2-52
Removing and Installing
....................... 2-51
Capacities and Specifications
...................... 6-61
Carbon Monoxide
..................... 2.6.2.27. 4.42
Cassette Deck Service
........................... 7-47
Cassette Tape Player
............................. 3-8
CareofYour
................................. 3-16
Certification Label
.............................. 4-46
Chains. Safety
................................. 4-51
Chains. Tire
................................... 6-47 Changing a Flat Tire
............................. 5-22
Charging System Light
.......................... 2-59
Checking Your Restraint Systems
.................. 1-51
Chemical Paint Spotting
.......................... 6-55
Child Restraints
................................ 1-38
Securing in a Rear Seat Position
................. 1-44
Securing in the Right Front Seat Position
.......... 1-46
Top Strap
................................... 1-43
Where to Put
................................ 1-42
Cigarette Lighter
............................... 2-40
Circuit Breakers and Fuses
....................... 6-58
Cleaner. Air
................................... 6-15
Cleaning Aluminum Wheels
............................ 6-54
Canvas Top and Plastic Windows
................ 6-53
Fabric
...................................... 6-49
Glass ....................................... 6-51
Inside of Your Vehicle
......................... 6-49
InstrumentPanel
............................. 6-50
Outside of
Your Vehicle ........................ 6-52
Special Problems
............................. 6-50
Stains
...................................... 6-50
Tires
....................................... 6-54
Vinyl
....................................... 6-50
Wheels
..................................... 6-54
Windshield and Wiper Blades
................... 6-51
Climate Control System
........................... 3-2
Clock. Setting the
................................ 3-6
Clutch Adjustment
.............................. 6-21
Clutch System Service
........................... 7-52
Coinholder
.................................... 2-40

Downloaded from www.Manualslib.com manuals search engine Comfort Controls ................................ 3-2
Compact Disc Player
............................ 3- 11
Care
....................................... 3-17
Errors
...................................... 3-13
Control. Loss of
................................ 4-14
Control
of a Vehicle .............................. 4-6
Convertible Top
................................ 2-41
Convex Outside Mirror
.......................... 2-39
Coolant
....................................... 6-24
Levelcheck
................................. 5-15
Radiator
.................................... 5- 19
RecoveryTank ............................... 5-16
Temperature Gage
............................ 2-62
Cooling System
................................ 5-14
Courtesy Transportation
........................... 8-8
Cruise Control
................................. 2-33
Cupholders
.................................... 2-40
Customer Assistance for Text Telephone Users
......... 8-4
Customer Assistance Information
................... 8-1
Customer Satisfaction Procedure
.................... 8-2
Damage Finish
...................................... 6-55
SheetMetal
................................. 6-54
Daytime Running Lamps
......................... 2-37
Daytime Running Lamps Indicator Light
............ 2-67
DeadBattery
................................... 5-3
Defects. Reporting Safety
........................ 8-10
Defensive Driving
............................... 4-2
Defogger. Rear Window
.......................... 3-5 Defogging
..................................... 3-5
Defrosting
..................................... 3-5
Dimensions. Vehicle
............................ 6-63
Dome Lamp Bulb Replacement
.................... 6-40
Dome Lamps
.................................. 2-38
Door Locks
....................................... 2-4
Storage
..................................... 2-39
Downshifting
.................................. 2-17
Drive Position. Automatic Transmission
............. 2-13
DriverPosition
................................. 1-18
Driving
City
........................................ 4-34
Defensive
.................................... 4-2
Drunken
..................................... 4-3
Freeway
.................................... 4-35
Guidelines
.................................. 4-15
InaBlizzard
................................. 4-41
In Foreign Countries
........................... 6-5
IntheRain
.................................. 4-31
Night
...................................... 4-29
Off-Road
................................... 4-15
OnCurves .................................. 4-10
On Grades While Towing a Trailer
............... 4-54
On Hill and Mountain Roads
.................... 4-37
OnSnowandIce
............................. 4-39
Throughwater
............................... 4-33
WetRoads
.................................. 4-31
Winter
...................................... 4-39
WithaTrailer
................................ 4-52
Drunken Driving
................................ 4-3
9-3
. .- ............... ... ........................ .C.-..Y..YIY ..-Fli-..-.--.- .__ ....- - .. - .- -

Downloaded from www.Manualslib.com manuals search engine I
Easy Entry Seat ................................ 1-4
Electrical Equipment. Adding
................ 2.10. 6.57
Electrical System
............................... 6-57
Engine
....................................... 6-10
Coolant Level Check
.......................... 7-47
Coolant Temperature Gage
..................... 2-62
Exhaust
..................................... 2-27
Identification
................................ 6-57
Oil Level Check
.............................. 7-47
Overheating
................................. 5- 12
Running
We Parked ......................... 2-27
Specifications
................................ 6-6 1
Starting Your ................................. 2-9
Engine Compartment Main Fuse Block
.............. 6-60
Adding
..................................... 6-12
Coolant
..................................... 6-24
MainFuseBlock
............................. 6-60
Engineoil
.................................... 6-11
Additives
................................... 6-14
Checking
................................... 6-12
Used
....................................... 6-15
Whentochange
.............................. 6-14
Equipment, Adding
to the Outside of Your Vehicle ...... 6-3
What
Kind to Use ............................. 6-13
Ethan01
........................................ 6-4
Exhaust. Engine
................................ 2-27
Exterior Lamps
................................. 2-37
Fabric cleaning
............................... 6-49
Fifth
Gear. Manual Transmission ................... 2-16 Filling a Portable Fuel Container
.................... 6-7
Filling Your Tank
................................ 6-5
Filter.
Air ...................................... 6-16
Finishcare
.................................... 6-52
FinishDamage
................................. 6-55
First Gear, Manual Transmission
................... 2-15
Flashers, Hazard Warning
......................... 5-2
Flash-to-Pass Feature
........................... 2-31
Flat Tire, Changing
............................. 5-22
Capacities
................................... 6-62
Fluids and Lubricants
............................ 7-53
Foreign Countries, Fuel
........................... 6-5
Fourth Gear, Manual Transmission
................. 2-16
Four-wheel Drive
.................... 2-18,2-20, 6-22
Front Seat Side Pockets
.......................... 2-40
Fluid
Levelcheck
................................. 7-48
French Language Manual
u
FrontAxle .................................... 6-23
Front Sidemarker Lamp Bulb Replacement
........... 6-37
FrontTowing
................................... 5-9
Front
Turn Signal Lamp Bulb Replacement .......... 6-36
Fuel
.......................................... 6-3
Canada
...................................... 6-3
DoorLock ................................... 6-6
FillingYourTank
.............................. 6-5
Gage
....................................... 2-67
.. ...........................
Filling a Portable Container ...................... 6-7
In Foreign Countries
........................... 6-5
Fuses and Circuit Breakers
....................... 6-58
9-4

Downloaded from www.Manualslib.com manuals search engine Gages Engine Coolant Temperature
.................... 2-62
Fuel ....................................... 2-67
GAWR
....................................... 4-46
Gear Positions. Automatic Transmission
............. 2- 11
GloveBox
.................................... 2-39
Gross Axle Weight Rating ........................ 4-46
Gross Vehicle Weight Rating
...................... 4-46
Guide en Franqais
-11
GVWR ....................................... 4-46
Gear Positions. Manual Transmission
............... 2-
15
.. ................................
Halogen Bulbs ................................ 6-34
Hazard Warning Flashers
.......................... 5-2
HeadRestraints
................................. 1-4
Headlamps
.................................... 2-3 1
Bulb Replacement ............................ 6-34
High/Low Beamchanger
...................... 2-31
Hearing Impaired. Customer Assistance
.............. 8-4
Heating
........................................ 3-3
Highway Hypnosis
.............................. 4-37
Hill and Mountain Roads ......................... 4-37
Hitches. Trailer
................................. 4-51
Hood Checking Thingsunder
......................... 6-8
Prop
........................................ 6-9
Release
...................................... 6-8
Hood Latch Operation Check
..................... 7-47
Horn
......................................... 2-29
Hubs. Freewheeling
............................. 2- 18
Hydroplaning
.................................. 4-33 Ignition
Positions
............................... 2-8
Ignition Transmission Lock Check
................. 7-50
Inflation. Tire
.................................. 6-41
Inside Daymight Rearview Mirror
................. 2-38
Inspections Brakesystem
................................ 7-52
Engine Cooling System
........................ 7-51
Exhaust Systems
............................. 7-51
Front Axle
.................................. 7-52
Front Drive Axle Boot
......................... 7-51
Front Drive Axle Seal
......................... 7-51
Ignition Transmission Lock Check
............... 7-50
Rear Axle
................................... 7-52
Steering
.................................... 7-51
Suspension
.................................. 7-51
Throttle Linkage
.............................. 7-52
Instrument Panel
............................... 2-54
Brightness Control
............................ 2-37
Cleaning
.................................... 6-50
Cluster
..................................... 2-56
FuseBlock
.................................. 6-58
Interior Lamps
................................. 2-37
Jack. Tire
.................................... 5-24
Jumpstarting
................................... 5-3
Key Lock Cylinders Service
..................... 7-48
Keys
.......................................... 2-2
9-5