transmission CHEVROLET TRAX 2015 1.G Warranty Guide

Black plate (6,1)Canadian Limited Warranty and Owner Assistance Information (GMNA-
Localizing-Canada-5853288) - 2014 - CRC - 11/7/12
6 New Vehicle Limited Warranty
"What Is Covered" and those items
listed under“What Is Not Covered”
later in this section.
Engine Coverage includes:All
internally lubricated parts, engine oil
cooling hoses and lines. Also
included are all actuators and
electrical components internal to the
engine (e.g., Active Fuel
Management Valve Lifter Oil
Manifold) cylinder head, block,
timing gears, timing chain, timing
cover, oil pump/oil pump housing,
OHC carriers, valve covers, oil pan,
seals, gaskets, manifolds, flywheel,
water pump, harmonic balancer,
engine mount, turbocharger, and
supercharger. Timing belts are
covered until the first scheduled
maintenance interval.Exclusions:Excluded from the
powertrain coverage are sensors,
wiring, connectors, engine radiator,
coolant hoses, coolant, and heater
core. Coverage on the engine
cooling system begins at the inlet to
the water pump and ends with the
thermostat housing and/or outlet
that attaches to the return hose.
Also excluded is the starter motor,
entire pressurized fuel system
(in-tank fuel pump, pressure lines,
fuel rail(s), regulator, injectors, and
return line) as well as the Engine/
Powertrain Control Module and/or
module programming.Transmission/Transaxle Coverage
includes:All internally lubricated
parts, case, torque converter,
mounts, seals, and gaskets as well
as any electrical components
internal to the transmission/
transaxle. Also covered are any
actuators directly connected to the
transmission (slave cylinder, etc.).
Exclusions:Excluded from the
powertrain coverage are
transmission cooling lines, hoses,
radiator, sensors, wiring, and
electrical connectors. Also excluded
are the clutch and pressure plate as
well as any Transmission Control
Module and/or module
programming.

Black plate (11,1)Canadian Limited Warranty and Owner Assistance Information (GMNA-
Localizing-Canada-5853288) - 2014 - CRC - 11/7/12
New Vehicle Limited Warranty 11
When a tire is removed from service
due to a covered warranty condition
under a tire manufacturer's limited
warranty program, you may be
eligible for a tire replacement or a
comparable new tire on a prorated
basis.
The tire manufacturer's limited
warranty program, which can be
obtained by calling or visiting the
tire manufacturer's website or any
authorized dealer, is in lieu of all
other remedies or warranties,
expressed or implied, arising by
law or otherwise, including fitness
for a particular purpose or
merchantability. The tire
manufacturer's expressly disclaim
liability for indirect, special,
incidental, or consequential
damages, lost profit, loss of
business, loss of goodwill, loss of
reputation, punitive or any other
damage, cost, or loss of any kind.Towing
Towing is covered to the nearest
authorized dealer if your vehicle
cannot be driven because of a
warranted defect.
6.6L Duramax Diesel Engine
Coverage
For trucks equipped with a
6.6L Duramax Diesel Engine, the
diesel engine assembly, including
turbocharger components (except
those items listed under“What Is
Not Covered”) is covered for defects
in material or workmanship without
a deductible for up to 5 years or
160 000 kilometres, (Chevrolet and
GMC), whichever comes first, and
6 years or 110 000 kilometres
(Buick), whichever comes first.
.Cylinder block and heads and all
internal lubricant parts, intake
and exhaust manifolds, timing
gears, timing gear chain or belt
and cover, flywheel, harmonic
balancer, valve covers, oil pan,oil pump, water pump, fuel
pump, engine mounts, seals,
and gaskets.
.Diesel Fuel Metering System:
injection pump, nozzles, high
pressure lines, high pressure
sealing devices.
.Glow Plug Control System:
control/glow plug assembly,
glow plugs, cold advance relay,
Engine Control Module (ECM).
.Fuel injection control module,
integral oil cooler, transmission
adapter plate, left and right
common fuel rails, fuel filter
assembly, fuel temperature
sensor, and function blocks.
Important:Some of the above
components may also be covered
by the Emissions Warranty with
no deductible. See theEmission
Warranty Parts List on page 29for
details.

Black plate (12,1)Canadian Limited Warranty and Owner Assistance Information (GMNA-
Localizing-Canada-5853288) - 2014 - CRC - 11/7/12
12 New Vehicle Limited Warranty
Aftermarket Engine Performance
Enhancement Products and
Modifications
Some aftermarket engine
performance products and
modifications promise a way to
increase the horsepower and torque
levels of your vehicle's powertrain.
You should be aware that these
products may have detrimental
effects on the performance and life
of the engine, exhaust emission
system, transmission and drivetrain.
The Duramax Diesel Engine, Allison
Automatic Transmission
®and
drivetrain have been designed
and built to offer industry leading
durability and performance in the
most demanding applications.
Engine power enhancement
products may enable the engine to
operate at horsepower and torque
levels that could damage, create
failure, or reduce the life of the
engine, engine emission system,
transmission and drivetrain.Damage failure, or reduced life of
the engine, transmission emission
system, drivetrain or other vehicle
components caused by aftermarket
engine performance enhancement
products or modifications may not
be covered under your vehicle
warranty.
Sheet Metal Coverage
Sheet metal panels are covered
against corrosion and rust-through
as follows:
Corrosion:For Chevrolet and
GMC, body sheet metal panels are
covered against rust for 3 years or
60 000 kilometres, whichever comes
first. For Buick, body sheet metal
panels are covered against rust
for 4 years or 80 000 kilometres,
whichever comes first.Rust-Through:For Chevrolet and
GMC, any body sheet metal panel
that rusts through due to corrosion
(an actual hole in the sheet metal)
is covered for up to 6 years or
160 000 kilometres, whichever
comes first. This coverage only
applies to the body sheet metal
panels and not to other metal
components.
Rust-Through:For Buick, any
body sheet metal panel that rusts
through due to corrosion (an actual
hole in the sheet metal) is covered
for up to 6 years, unlimited
kilometres. This coverage only
applies to the body sheet metal
panels and not to other metal
components.
Important:Cosmetic or surface
corrosion (resulting from stone
chips, dents, or scratches in the
paint, or failure to repair paint
damaged by stone chips, dents,
or scratches in the paint) is not
included in the sheet metal
coverage.

Black plate (20,1)Canadian Limited Warranty and Owner Assistance Information (GMNA-
Localizing-Canada-5853288) - 2014 - CRC - 11/7/12
20 New Vehicle Limited Warranty
For eAssist owners requiring more
comprehensive coverage than that
provided under this eAssist
warranty, a GM Protection Plan may
be available. See your Buick or
Chevrolet dealer for more details.
eAssist Components
The energy storage control module
and components including eAssist
battery, eAssist battery disconnect,
powerpack assembly, and the
eAssist battery cooling fan.
Starter Generator Unit
The starter generator unit, starter
generator cooling pump, and the
high voltage 3-phase/12 volt cable
assembly.Other eAssist Components
Auxiliary transmission pump
What Is Not Covered
In addition to the“What is Not
Covered”section previously, this
eAssist warranty does not cover the
following items:
Wear Items
Wear items, such as brake linings,
are not covered in this eAssist
warrantyMaintenance
As the vehicle owner, you are
responsible for the performance of
the scheduled maintenance listed in
your owner manual. Maintenance
intervals, checks, inspections, and
recommended fluids and lubricants
as prescribed in the owner manual
are necessary to keep your vehicle
in good working condition. Any
damage caused by owner/lessee
failure to follow scheduled
maintenance may not be covered by
warranty. Scheduled maintenance
includes such items as:
.Brake Pads/Linings
.Coolants and Fluids
.Filters

Black plate (21,1)Canadian Limited Warranty and Owner Assistance Information (GMNA-
Localizing-Canada-5853288) - 2014 - CRC - 11/7/12
Things to Know About the New Vehicle Limited Warranty 21
Warranty Repairs—
Component Exchanges
In the interest of customer
satisfaction, General Motors
of Canada Limited may offer
exchange service on some vehicle
components. This service is
intended to reduce the amount of
time your vehicle is not available for
use due to repairs. Components
used in exchange are service
replacement parts that may be new,
remanufactured, or refurbished.
Remanufactured parts meet
GM approved service parts
requirements and are made from
previously used components in a
process that involves disassembly,
inspection, cleaning, update of
software and replacement parts
as appropriate, testing and
reassembly.Refurbished parts meet GM
approved service part requirements
and are previously used parts that
are inspected, cleaned, tested, and
repackaged.
All exchange components used
meet GM standards and are
warranted the same as new
components. Examples of the types
of components that might be
serviced in this fashion include:
engine and transmission
assemblies, instrument cluster
assemblies, radios, compact disc
players, batteries, and powertrain
control modules.
Maintenance and Warranty
Service Records
Retain receipts covering
performance of regular
maintenance. Receipts can be
very important if a question arises
as to whether a malfunction is
caused by lack of maintenance or a
defect in material or workmanship.A“Maintenance Record”is provided
in the maintenance schedule
section of the owner manual for
your convenience in recording
services performed.
For your records, the servicing
dealer should provide a copy of the
warranty repair order listing all
warranty repairs performed.
Warranty Repairs—Recycled
Materials
Both Environment Canada
guidelines and GM support the
capture, purification, and reuse
of automotive air conditioning
refrigerant gases and engine
coolant.
As a result, any repairs GM may
make to your vehicle may involve
the installation of purified reclaimed
refrigerant and coolant.

Black plate (29,1)Canadian Limited Warranty and Owner Assistance Information (GMNA-
Localizing-Canada-5853288) - 2014 - CRC - 11/7/12
Emission Warranty Parts List 29
Listed below are most of the
systems that affect emissions of
your vehicle. Emission control
components of these systems are
covered by the Emission Control
Systems Warranty as applicable,
or up to the replacement interval
specified in the owner manual.
If failure of one of the above parts
results in failure of another part
under the Emission Control Systems
Warranty, both will be covered
by this warranty. For detailed
information concerning specific
parts covered by the Emission
Control Systems Warranty, ask your
dealer.
Important:Certain parts may be
covered beyond these warranties if
shown with asterisk as follows:
(*) 8 years/130 000 kilometres,
whichever comes first.Powertrain Control System
Camshaft Position Actuator
Camshaft Position Actuator Valve
Coolant Sensor
Data Link Connector
Engine Control Module (ECM) *
Engine Coolant Temperature Sensor
Fuel Control Module *
Intake Air Temperature Sensor
Malfunction Indicator Lamp
Manifold Absolute Pressure Sensor
Mass Air Flow Sensor
Oxygen Sensor(s)
Powertrain Control Module (PCM) *
Throttle Position Sensor
Vehicle Control Module (VCM) *
Vehicle Speed Sensor
Wheel Speed SensorTransmission Controls and
Torque Management
Control Solenoids and Pressure
Switches
Clutch Solenoids and Switches
Park/Neutral Switch
Transmission Control Module *
Transmission Fluid Temperature
Sensor
Transmission Speed Sensors
Fuel Management System
Diesel Fuel Injection Pump
Diesel Direct Fuel Injector Assembly
Fuel Injector
Fuel Pressure Regulator
Fuel Pressure Sensor
Fuel Rail Assembly
Fuel Temperature Sensor
High Pressure Fuel Pump (SIDI)

Black plate (31,1)Canadian Limited Warranty and Owner Assistance Information (GMNA-
Localizing-Canada-5853288) - 2014 - CRC - 11/7/12
Emission Warranty Parts List 31
Exhaust Gas Recirculation (EGR)
System
EGR Feed and Delivery Pipes
EGR Temperatuer Sensor
EGR Valve
EGR Valve Cooler
Secondary Air Injection System
Air Pump
Check Valves
Evaporative Emission Control
System (Gasoline Engines)
Canister
Canister Solenoid and Valve
Fuel Feed and Return Pipes and
Hoses
Fuel Filler Cap
Fuel Level Sensor
Fuel Limiter Vent Valve
Fuel Tank(s)Fuel Tank Filler Pipe (with restrictor)
Fuel Tank Vacuum or Pressure
Sensor
Hybrid
Auxiliary Transmission Fluid Pump
Battery Cooling Circuit
Battery Control Module *
Battery Pack Current Sensor
Brake Pedal Travel Sensor
Drive Motors and Resolvers
Drive Motor/Generator Control
Module *
Electro-Hydraulic Brake Control
Module *
Energy Storage Control Module *
Hybrid Batteries
Hybrid Battery Temperature and
Voltage Sensors
SGCM Coolant Circuit (fan,
relay, pump)
Starter GeneratorStarter Generator Control Module *
Starter Generator Drive Belt
Traction Power Inverter
Module (TPIM) *
Voltec Specific Components
Vehicle Interface Control Module *
Voltec RESS Battery *
Onboard Charger *
Charge Port
Charge Port Switches and Sensors
Voltec EVAP Canister Assembly
Voltec RESS Thermal Management
E-compressor *
Port Valves
Battery Temperature Sensors
Battery High Voltage Heater
Battery Coolant Pump
Power Electronics
Coolant Pump
Air and Coolant Temperature
Sensors
Rfg. Temperature and Pressure
Sensors