wiring CHEVROLET TRAX 2015 1.G Warranty Guide

Black plate (6,1)Canadian Limited Warranty and Owner Assistance Information (GMNA-
Localizing-Canada-5853288) - 2014 - CRC - 11/7/12
6 New Vehicle Limited Warranty
"What Is Covered" and those items
listed under“What Is Not Covered”
later in this section.
Engine Coverage includes:All
internally lubricated parts, engine oil
cooling hoses and lines. Also
included are all actuators and
electrical components internal to the
engine (e.g., Active Fuel
Management Valve Lifter Oil
Manifold) cylinder head, block,
timing gears, timing chain, timing
cover, oil pump/oil pump housing,
OHC carriers, valve covers, oil pan,
seals, gaskets, manifolds, flywheel,
water pump, harmonic balancer,
engine mount, turbocharger, and
supercharger. Timing belts are
covered until the first scheduled
maintenance interval.Exclusions:Excluded from the
powertrain coverage are sensors,
wiring, connectors, engine radiator,
coolant hoses, coolant, and heater
core. Coverage on the engine
cooling system begins at the inlet to
the water pump and ends with the
thermostat housing and/or outlet
that attaches to the return hose.
Also excluded is the starter motor,
entire pressurized fuel system
(in-tank fuel pump, pressure lines,
fuel rail(s), regulator, injectors, and
return line) as well as the Engine/
Powertrain Control Module and/or
module programming.Transmission/Transaxle Coverage
includes:All internally lubricated
parts, case, torque converter,
mounts, seals, and gaskets as well
as any electrical components
internal to the transmission/
transaxle. Also covered are any
actuators directly connected to the
transmission (slave cylinder, etc.).
Exclusions:Excluded from the
powertrain coverage are
transmission cooling lines, hoses,
radiator, sensors, wiring, and
electrical connectors. Also excluded
are the clutch and pressure plate as
well as any Transmission Control
Module and/or module
programming.

Black plate (7,1)Canadian Limited Warranty and Owner Assistance Information (GMNA-
Localizing-Canada-5853288) - 2014 - CRC - 11/7/12
New Vehicle Limited Warranty 7
Transfer Case Coverage includes:
All internally lubricated parts, case,
mounts, seals, and gaskets as well
as any electrical components
internal to the transfer case. Also
covered are any actuators directly
connected to the transfer case as
well as encoder motor.
Exclusions:Excluded from the
powertrain coverage are transfer
case cooling lines, hoses, radiator,
sensors, wiring, and electrical
connectors as well as the transfer
case control module and/or module
programming.Drive Systems Coverage
includes:All internally lubricated
parts, final drive housings, axle
shafts and bearings, constant
velocity joints, propeller shafts and
universal joints. All mounts,
supports, seals, and gaskets as well
as any electrical components
internal to the drive axle. Also
covered are any actuators directly
connected to the drive axle (e.g.,
front differential actuator).Exclusions:Excluded from the
powertrain coverage are all wheel
bearings, drive wheel front and rear
hub bearings, locking hubs, drive
system cooling, lines, hoses,
radiator, sensors, wiring, and
electrical connectors related to drive
systems as well as any drive system
control module and/or module
programming.

Black plate (18,1)Canadian Limited Warranty and Owner Assistance Information (GMNA-
Localizing-Canada-5853288) - 2014 - CRC - 11/7/12
18 New Vehicle Limited Warranty
Chevrolet Volt Coverage
Propulsion Battery Warranty
Policy
Like all batteries, the amount of
energy that the high voltage
“propulsion”battery can store will
decrease with time and miles
driven. Depending on use, the
battery may degrade as little as
10% to as much as 30% of capacity
over the warranty period. A dealer
service technician will determine
if the battery energy capacity (kWh
storage) is within the proper limit,
given the age and mileage of the
vehicle. Typical tests can take up to
24 hours.
Repair
If possible, components will be
repaired or replaced, and the
original battery will be returned to
the vehicle.Replace (If Necessary)
Under warranty, the high voltage
battery may be replaced with either
a new or factory reconditioned high
voltage battery with an energy
capacity (kWh storage) level at or
above that of the original battery
prior to the failure.
Your Volt battery warranty
replacement may not return your
vehicle to an“as new”condition,
but it will make your Volt fully
operational appropriate to its age
and mileage.
Other Voltec/Electric Propulsion
Components
High Voltage Wiring, Voltec Control
Modules, E-Compressor, Traction
Power Inverter Module (TPIM),
Accessory Power Module (APM),
and Voltec/Electric Propulsion
On-Board Charger.Brakes
Brake Modulator Assembly
Electric Drive Unit
Electric drive unit assembly and
internal components, including the
auxiliary fluid pump, auxiliary pump
controller, and 3-phase cables.
What Is Not Covered
In addition to the”What Is Not
Covered“section previously, the
Voltec warranty does not cover the
following items:
Wear Items
Wear items, such as brake linings,
are not covered in the Voltec
warranty.

Black plate (32,1)Canadian Limited Warranty and Owner Assistance Information (GMNA-
Localizing-Canada-5853288) - 2014 - CRC - 11/7/12
32 Emission Warranty Parts List
Miscellaneous Items Used with
Above Components are Covered
Belts
Boots
Clamps
Connectors
Ducts
Fittings
Gaskets
Grommets
Hoses
Housings
Mounting Hardware
Pipes
PulleysSealing Devices
Springs
Tubes
Wiring and Relays
What Is Not Covered
The Emission Control Systems
Warranty Obligations DO NOT
APPLY TO conditions resulting from
tampering, abuse, neglect,
or improper maintenance. Items
listed under“What Is Not Covered”
underNew Vehicle Limited Warranty
on page 5also apply to the
emission related warranties.Parts specified in the maintenance
schedule as requiring scheduled
replacement are covered up to their
first replacement interval or the
applicable emission warranty
coverage period, whichever comes
first. There is no coverage under
this warranty for the failure of parts
which are not replaced as required
in the vehicle maintenance
schedule. If failure of one of these
parts results in failure of another
part, neither will be covered under
the Emission Control Systems
Warranty.
For detailed information concerning
specific parts covered by these
emission control systems
warranties, ask your dealer.