steering CHRYSLER 300 2012 2.G Workshop Manual

8. Disconnect the positive(+)jumper cable from the
positive(+)post of the booster battery.
9. Disconnect the positive(+)end of the jumper cable
from the remote positive(+)post of the discharged
vehicle.
If frequent jump-starting is required to start your vehicle
you should have the battery and charging system in-
spected at your authorized dealer.
CAUTION!
Accessories that can be plugged into the vehicle
power outlets draw power from the vehicle’s battery,
even when not in use (i.e., cellular phones, etc.).
Eventually, if plugged in long enough, the vehicle’s
battery will discharge sufficiently to degrade battery
life and/or prevent the engine from starting.
FREEING A STUCK VEHICLE
If your vehicle becomes stuck in mud, sand, or snow, it
can often be moved by a rocking motion. Turn your
steering wheel right and left to clear the area around the
front wheels. Then shift back and forth between DRIVE
and REVERSE. Using minimal accelerator pedal pressure
to maintain the rocking motion, without spinning the
wheels, is most effective.
CAUTION!
Racing the engine or spinning the wheels may lead to
transmission overheating and failure. Allow the en-
gine to idle with the shift lever in NEUTRAL for at
least one minute after every five rocking-motion
cycles. This will minimize overheating and reduce
the risk of transmission failure during prolonged
efforts to free a stuck vehicle.
462 WHAT TO DO IN EMERGENCIES

MAINTENANCE PROCEDURES
The pages that follow contain therequiredmaintenance
services determined by the engineers who designed your
vehicle.
Besides those maintenance items specified in the fixed
maintenance schedule, there are other components which
may require servicing or replacement in the future.
CAUTION!
•Failure to properly maintain your vehicle or per-
form repairs and service when necessary could
result in more costly repairs, damage to other
components or negatively impact vehicle perfor-
mance. Immediately have potential malfunctions
examined by an authorized Chrysler Group LLC
dealership or qualified repair center.
(Continued)
CAUTION! (Continued)
•Your vehicle has been built with improved fluids
that protect the performance and durability of
your vehicle and also allow extended maintenance
intervals. Do not use chemical flushes in these
components as the chemicals can damage your
engine, transmission, power steering or air condi-
tioning. Such damage is not covered by the New
Vehicle Limited Warranty. If a flush is needed
because of component malfunction, use only the
specified fluid for the flushing procedure.
478 MAINTAINING YOUR VEHICLE

Cavity Cartridge
FuseMini-
FuseDescription
1 — — Fuse – Spare
2 40 Amp
Green— Radiator Fan #1
3 50 Amp
Red— Power Steering #1
4 30 Amp
Pink— Starter
5 40 Amp
Green— Anti-Lock Brakes
6 — — Fuse – Spare
7 — — Fuse – Spare
8 — — Fuse – Spare
9 — 20 Amp
YellowAll-Wheel Drive Module –
If Equipped
10 — 10 Amp
RedSecurity
11 — 20 Amp
YellowHornsCavity Cartridge
FuseMini-
FuseDescription
12 — 10 Amp
RedAir Conditioning Clutch
13 — — Fuse – Spare
14 — 25 Amp
NaturalAnti-Lock Brakes
15 — 25 Amp
NaturalTransmission
16 — — Fuse – Spare
18 50 Amp
Red— Radiator Fan #2
19 50 Amp
Red— Power Steering #2
20 30 Amp
Pink— Wiper Motor
21 30 Amp
Pink— Headlamp Washers
22 — — Fuse – Spare
23 — — Fuse – Spare
7
MAINTAINING YOUR VEHICLE 509

Cavity Cartridge
FuseMini-
FuseDescription
24 — — Fuse – Spare
28 — 25 Amp
NaturalFuel Pump
29 — 15 Amp
BlueTransmission/Shifter
30 — — Fuse – Spare
31 — 25 Amp
NaturalEngine Module
32 — — Fuse – Spare
33 — — Fuse – Spare
34 — 25 Amp
NaturalPowertrain #1
35 — 20 Amp
YellowPowertrain #2
36 — 10 Amp
RedAnti-Lock Brake Module
37 — 10 Amp
RedEngine Controller/Rad
Fan RelaysCavity Cartridge
FuseMini-
FuseDescription
38 — 10 Amp
RedAirbag Module
39 — 10 Amp
RedPower Steering
Module/AC Clutch Relay
48 — 10 Amp
RedAWD Module/Front Axle
Disconnect
49 — — Fuse – Spare
50 — — Fuse – Spare
51 — 20 Amp
YellowVacuum Pump
52 — — Fuse – Spare
53 — — Fuse – Spare
510 MAINTAINING YOUR VEHICLE

Cavity Car-
tridge
FuseMini-
FuseDescription
33 — 15 Amp
BlueIgnition Switch/Wireless
Module
34 — 10 Amp
RedSteering Column
Module/Clock
35 — 10 Amp
RedBattery Sensor
36 — — Fuse — Spare
37 — 15 Amp
BlueRadio
38 — 20 Amp
YellowPower Outlet Inside
Arm Rest
40 — — Fuse — Spare
41 — — Fuse — Spare
42 30 Amp
Pink— Rear DefrostCavity Car-
tridge
FuseMini-
FuseDescription
43 — 25 Amp
NaturalRear Heated Seats/
Steering Wheel
44 — 10 Amp
RedPark Assist/Blind Spot/
Camera
45 — 15 Amp
BlueCluster/Rearview
Mirror/Compass
46 — 10 Amp
RedAdaptive Cruise Control
47 — 10 Amp
RedAdaptive Front Lighting
48 — 20 Amp
YellowActive Suspension
49 — — Fuse — Spare
50 — — Fuse — Spare
514 MAINTAINING YOUR VEHICLE

Chassis
Component Fluid, Lubricant, or Genuine Part
Automatic Transmission – 3.6L En-
gineShell L12108 Transmission Fluid or equivalent.
Automatic Transmission – 5.7L En-
gineMOPARATF+4Automatic Transmission Fluid or equivalent licensed
ATF+4product.
Brake Master Cylinder MOPARDOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir MOPARHydraulic Fluid or equivalent meeting MS-11655, such as Fuchs
EG ZH 3044 or Pentosin CHF 11s.
Front Axle API GL-5 SAE 75W90 Synthetic Gear Lubricant or equivalent.
Rear Axle API GL-5 SAE 75W140 Synthetic Gear Lubricant or equivalent.
Transfer Case MOPARTransfer Case Lubricant for BorgWarner 44–40 or equivalent.
7
MAINTAINING YOUR VEHICLE 523

Once A Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery, and clean and tighten the terminals
as required.
•Check the fluid levels of the coolant reservoir, brake
master cylinder, and power steering, and add as
needed.
•Check all lights and other electrical items for correct
operation.At Each Oil Change
•Change the engine oil filter.
•Inspect the brake hoses and lines.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S528 MAINTENANCE SCHEDULES

Paint Care............................. 502
Panic Alarm............................ 24
Park Sense System, Rear................... 225
Parking Brake.......................... 375
Passing Light........................... 181
Pedals, Adjustable....................... 194
Pets.................................. 81
Placard, Tire and Loading Information......... 393
Power
Deck Lid Release..................... 41
Distribution Center (Fuses)...........508,511
Door Locks......................... 31
Mirrors............................ 97
Outlet (Auxiliary Electrical Outlet)........ 254
Seats............................. 157
Steering........................... 373
Sunroof.........................247,251
Tilt/Telescoping Steering Column......... 191
Windows........................... 38Power Steering Fluid..................... 523
Pregnant Women and Seat Belts.............. 56
Preparation for Jacking.................... 452
Pretensioners
Seat Belts........................... 54
Programming Transmitters
(Remote Keyless Entry).................... 21
Radial Ply Tires......................... 400
Radiator Cap (Coolant Pressure Cap).......... 495
Radio Operation........................ 332
Radio Remote Controls.................... 330
Rain Sensitive Wiper System................ 189
Rear Camera........................... 235
Rear Cupholder......................... 261
Rear Park Sense System................... 225
Rear Seat, Folding....................... 168
Rear Window Defroster................... 267
Rear Window Features.................... 267
10
INDEX 565

SmartBeams........................... 177
Snow Chains (Tire Chains)................. 406
Snow Tires............................ 408
Sound System
Kicker............................ 328
Spare Tire.......................401,402,450
Spark Plugs............................ 522
Specifications
Fuel (Gasoline)...................420,522
Oil ............................... 522
Speed Control (Cruise Control)...........196,199
Speedometer........................... 280
Starting.............................26,348
Automatic Transmission................ 348
Cold Weather....................... 351
Engine Fails to Start.................. 351
Remote............................ 26
Starting and Operating.................... 348
Starting Procedures...................... 348Steering
Column Controls..................... 180
Column Lock....................... 190
Power............................ 373
Tilt Column......................190,191
Wheel, Heated...................... 192
Wheel, Tilt......................190,191
Steering Wheel Audio Controls.............. 330
Steering Wheel Mounted Sound System
Controls.............................. 330
Storage............................262,516
Storage, Vehicle......................342,516
Storing Your Vehicle...................... 516
Stuck, Freeing.......................... 462
Sun Roof...........................247,251
Sunglasses Storage....................... 238
Supplemental Restraint System - Airbag........ 56
Sway Control, Trailer..................... 435
Synthetic Engine Oil...................... 481
568 INDEX

System, Remote Starting.................... 26
Tachometer............................ 276
Telescoping Steering Column.............190,191
Temperature Control, Automatic (ATC)........ 340
Temperature Gauge, Engine Coolant.......284,449
Tether Anchor, Child Restraint............... 75
Theft Alarm (Security Alarm)................ 18
Theft System (Security Alarm)............... 18
Tilt Steering Column...................190,191
Time Delay, Headlight.................... 176
Tire and Loading Information Placard......... 393
Tire Identification Number (TIN)............. 391
Tire Markings.......................... 387
Tire Safety Information.................... 387
Tires ............................86,397,549
Aging (Life of Tires).................. 404
Air Pressure........................ 397
Chains............................ 406Changing.......................449,453
Compact Spare...................... 401
Flat Changing....................... 449
General Information.................. 397
High Speed......................... 400
Inflation Pressures.................... 398
Jacking.........................452,453
Life of Tires........................ 404
Load Capacity....................393,394
Pressure Monitor System (TPMS)......... 410
Pressure Warning Light................ 277
Quality Grading..................... 549
Radial............................ 400
Replacement........................ 405
Rotation........................... 409
Safety..........................387,397
Sizes............................. 389
Snow Tires......................... 408
Spare Tire.......................... 450
10
INDEX 569