park CHRYSLER 300 SRT 2005 1.G Repair Manual

Cavity Fuse Circuits
32 — —
33 — —
34 — —
35 5 Amp Orange Power Antenna/Garage
Door Opener/Ignition
Delay
36 20 Amp Yellow Radio/Navigation
37 15 Amp Dk.
BlueTransmission
38 5 Amp Orange Analog Clock/Garage
Door Opener
39 10 Amp Red Heated Mirror
40 5 Amp Orange Power Mirror
41 10 Amp Red Climate Control Module/
Headlamp Leveling — if
equipped/Rear Park As-
sist
42 30 Amp Pink Automatic Temperature
Control (ATC) Blower
Motor
43 30 Amp Pink Rear DefrosterCavity Fuse Circuits
44 20 Amp Lt.
BlueAudio Amplifier
VEHICLE STORAGE
If you are leaving your vehicle dormant for more than 21
days you may want to take steps to protect your battery.
You may:
•Disconnect the negative cable from the battery.
•Anytime you store your vehicle, or keep it out of
service (i.e. vacation) for two weeks or more, run the
air conditioning system at idle for about five minutes
in the fresh air and high blower setting. This will
insure adequate system lubrication to minimize the
possibility of compressor damage when the system is
started again.
268 MAINTAINING YOUR VEHICLE

REPLACEMENT LIGHT BULBS
LIGHT BULBS — Interior Bulb Number
Rear Courtesy/Reading Lights.............. W5W
Rear Compartment (Trunk) Light............. 579
Overhead Console Reading Lights............. 578
Visor Vanity Lights.....................A6220
Glove Box Light......................... 194
Door Courtesy.......................... 562
Shift Indicator Light.................JKLE14140
NOTE:For lighted switches, see your dealer for re-
placement instructions.
All of the interior bulbs are glass wedge base or glass
cartridge types. Aluminum base bulbs are not approved
and should not be used for replacement.LIGHT BULBS — Exterior Bulb Number
Low Beam Headlamp – High Intensity
Discharge (HID)........... D1S(Serviced at Dealer)
High Beam Headlamp....................9005
Front Park/Turn Lamp.................3157AK
Front Fog Lamp.......9145/H10 (Serviced at Dealer)
Front Sidemarker......... W5W(Serviced at Dealer)
Tail/Stop Lamp.........................3057
Tail Lamp.............................3057
Turn Signal Lamp.......................3057
Backup Lamp..........................3057
Center High Mount Stop Lamp (CHMSL)....... LED
License.............................. W5W
MAINTAINING YOUR VEHICLE 269
7

BULB REPLACEMENT
Low Beam Headlamp, High Beam Headlamp, and
Park/Turn Lamp
High Intensity Discharge Headlights (HID)
The headlights are a type of high voltage discharge tube.
High voltage can remain in the circuit even with the
headlight switch off and the key removed.Because of
this, you should not attempt to service a headlight bulb
yourself. If a headlight bulb fails, take your vehicle to
an authorized dealer for service.
WARNING!
A transient high tension occurs at the bulb sockets of
High Intensity Discharge (HID) headlights when the
headlight switch is turned ON. It may cause serious
electrical shock or electrocution if not serviced prop-
erly. See your authorized dealer for service.
NOTE:When HID headlights are turned on there is a
blue hue to the lights. This diminishes and becomes more
white after approximately 10 seconds, as the system
charges.
•Open the hood.
•Twist the appropriate bulb socket assembly counter-
clockwise and pull out. Pull the bulb out of the socket
assembly.
NOTE:Removal of the air cleaner filter housing may be
necessary prior to replacing bulbs on driver’s side head-
lamp assembly.
270 MAINTAINING YOUR VEHICLE

RECOMMENDED FLUIDS, LUBRICANTS AND
GENUINE PARTS
Engine
Component Fluids, Lubricants and Genuine Parts
Engine Coolant MoparAntifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid Or-
ganic Additive Technology) or equivalent.
Engine Oil (6.1 Liter) Use API rated SL/CF full synthetic engine oil. SAE 0W-40 is recommended.
Refer to the engine oil viscosity chart for the correct SAE grade meeting
DaimlerChrysler Material Standard MS-10725.
Spark Plugs Refer to the Vehicle Emission Control Information label in the engine com-
partment.
Oil Filter (6.1 Liter) Mopar05281090 or equivalent.
Fuel Selection (6.1 Liter) Premium Unleaded 91 Octane Only or higher.
Chassis
Component Fluids, Lubricants and Genuine Parts
Automatic Transmission MoparATF+4 Automatic Transmission Fluid or equivalent.
Brake Master Cylinder MoparDOT 3 and SAE J1703 or equivalent should be used. Use only rec-
ommended brake fluids.
Power Steering Reservoir MoparATF+4 Automatic Transmission Fluid or equivalent.
Rear Axle API rated GL-5 SAE 75W140 Synthetic Gear Lubricant or equivalent.
276 MAINTAINING YOUR VEHICLE

Miles 93,000 96,000 99,000 100,000 102,000 105,000
(Kilometers) (155 000) (160 000) (165 000) (170 000) (175 000) (180 000)
Change engine oil and engine oil filter, if not re-
placed at 3 months.XXX X X
Inspect theair cleaner filter
and replace if re-
quired.*XXX
Inspect theair cleaner filter
and replace if re-
quired.X
Replace theair cleaner filter.X
Replace thespark plugs.X
Inspect the front and rear brake linings and rotors. X
Check and Inspect the accessory drive belt and ten-
sioner. Replace if required.X
Change the rear axle fluid. X
Replace the air conditioning filter.X
Flush and replace engine coolant at 102,000 miles if
not done at 60 months.X
Rotate the tires. X X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
‡ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE “B” 287
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 78,000 84,000 90,000 96,000 100,000 102,000
(Kilometers) (130 000) (140 000) (150 000) (160 000) (170 000) (180 000)
[Months] [78] [84] [90] [96] [102]
Change engine oil and engine oil filter. X X X X X
Inspect theair cleaner filter
and replace if re-
quired.*XXXX
Replace theair cleaner filter.X
Replace thespark plugs.X
Inspect the front and rear brake linings and ro-
tors.X
Check and Inspect the accessory drive belt and
tensioner. Replace if required.X
Check and replace, if necessary, thePCV valve.
*‡
X
Flush and replace the engine coolant at 102,000
miles if not done at 60 months.X
Replace the air conditioning filter. X X
Rotate the tires. X X X X X
* This maintenance is recommended by the manufacturer
to the owner but is not required to maintain the emis-
sions warranty.
‡ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
290 SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Bearings.............................. 260
Belts, Drive........................... 244
Body Mechanism Lubrication.............. 250
B-Pillar Location....................... 201
Brake Assist System..................... 108
Brake, Parking......................... 191
Brake System.......................193,257
Anti-Lock........................... 193
Fluid Check......................258,276
Hoses.............................. 257
Warning Light....................... 136
Brake/Transmission Interlock.............. 190
Break-In Recommendations, New Vehicle...... 56
Bulb Replacement...................... 270
Bulbs, Light........................... 269
Calibration, Compass.................... 143
Capacities, Fluid....................... 275
Caps, Filler
Fuel............................... 218
Radiator (Coolant Pressure).............. 254
Car Washes........................... 261
Carbon Monoxide Warning.............56,217Cargo Tie-Downs....................... 126
Cassette Tape and Player Maintenance....... 169
Catalytic Converter..................... 245
CD Player............................ 151
Cellular Phone.......................... 66
Chains, Tire........................... 211
Chart, Tire Sizing....................... 198
Child Restraint...................49,51,53,54
Child Restraint Tether Anchors............. 53
Child Safety Locks....................... 18
Clean Air Gasoline...................... 215
Climate Control........................ 171
Clock.............................151,152
Compact Disc Maintenance............... 170
Compass............................. 143
Compass Calibration.................... 143
Compass Variance...................... 144
Computer, Trip/Travel................... 142
Console.............................. 126
Console, Floor......................... 126
Console, Overhead...................... 114
Contract, Service....................... 296
Coolant Pressure Cap.................... 254
INDEX 305
10

Multi-Function Control Lever............... 99
Navigation System...................... 166
New Vehicle Break-In Period............... 56
Occupant Restraints...................... 28
Oil, Engine.........................241,276
Capacity............................ 275
Change Interval...................... 242
Checking........................... 241
Disposal............................ 243
Filter...........................243,276
Filter Disposal....................... 243
Materials Added to.................... 243
Recommendation..................242,275
Viscosity............................ 275
Onboard Diagnostic System............238,239
Opener, Garage Door.................... 115
Operator Manuals (Owner’s Manuals)......... 4
Overhead Console...................... 114
Overheating, Engine..................137,225
Owner’s Manual......................4,299Panic Alarm........................... 20
Park Assist System, Rear.................. 85
Parking Brake......................... 191
Parking On Hill........................ 192
Passing Light.......................... 101
Pedals, Adjustable....................... 94
Personal Settings....................... 147
Pets.................................. 55
Phone, Cellular......................... 66
Phone, Hands-Free....................... 66
Placard, Tire and Loading Information....... 201
Power
Brakes............................. 193
Distribution Center.................... 264
Door Locks.......................... 16
Mirrors............................. 64
Outlet.............................. 123
Seats............................... 87
Steering............................ 196
Steering, Checking.................... 249
Sunroof............................ 120
Tilt/Telescoping Steering Column......... 106
Windows............................ 23
INDEX 311
10

Pregnant Women and Seat Belts............. 34
Pretensioners
Seat Belts............................ 33
Programmable Electronic Features..... 115,119,147
Programming Transmitters............. 115,119
Radial Ply Tires........................ 208
Radiator Cap (Coolant Pressure Cap)........ 254
Radio Broadcast Signals.................. 168
Radio Operation.....................151,171
Radio Remote Controls.................. 166
Radio, Satellite......................... 163
Radio (Sound Systems)................... 151
Rain Sensitive Wiper System.............. 103
Rear Park Assist System................... 85
Rear Seat, Folding....................... 93
Reclining Front Seats..................... 88
Recommended Fluids, Lubricants and Genuine
Parts............................... 276
Recorder, Event Data..................... 47
Recreational Towing..................... 222
Refrigerant............................ 249
Reminder, Seat Belt...................... 33Remote Keyless Entry.................... 19
Remote Sound System Controls............ 166
Remote Trunk Release.................... 26
Replacement Tires...................... 209
Reporting Safety Defects................. 299
Restraint, Head......................... 92
Restraints, Occupant..................... 28
Rocking Vehicle When Stuck.............. 232
Rotation, Tires......................... 212
Safety Checks Inside Vehicle............... 57
Safety Checks Outside Vehicle.............. 57
Safety Defects, Reporting................. 299
Safety Information, Tire.................. 197
Safety Tips............................. 56
Satellite Radio......................... 163
Satellite Radio Antenna.................. 165
Schedule, Maintenance................... 278
Seat Belt Maintenance................... 263
Seat Belt Reminder...................... 33
Seat Belts.............................. 29
Adjustable Upper Shoulder Anchorage...... 32
And Pregnant Women.................. 34
312 INDEX

Child Restraint......................49,54
Extender............................ 34
Front Seat............................ 29
Operating Instructions.................. 29
Pretensioners......................... 33
Reminder........................... 138
Seats................................. 87
Glide-To-Exit......................... 91
Heated.............................. 88
Lumbar Support....................... 88
Power.............................. 87
Rear Folding......................... 93
Reclining............................ 88
Security Alarm (Theft Alarm)............... 22
Selection of Coolant..................253,276
Selection of Oil........................ 242
Sentry Key............................ 12
Service Assistance...................... 294
Service Contract........................ 296
Service Engine Soon Light
(Malfunction Indicator).................. 139
Service Manuals........................ 299
Setting the Clock....................151,152Settings, Personal....................... 147
Shift Speeds........................... 183
Shoulder Belt Upper Anchorage............. 32
Side Airbag............................ 44
Signals, Turn.......................... 134
Slippery Surfaces, Driving On............. 231
Snow Chains (Tire Chains)................ 211
Snow Tires............................ 212
Spark Plugs........................... 244
Speed Control......................... 111
Speedometer.......................... 134
Starting.............................. 181
Engine Fails to Start................... 182
Starting and Operating................... 181
Steering
Linkage............................ 250
Power...........................196,249
Tilt Column......................... 106
Wheel, Tilt.......................... 106
Steering Wheel Mounted Sound System
Controls............................ 166
Storage...........................126,268
Storage, Vehicle.....................177,268
INDEX 313
10