belt CHRYSLER 300 SRT 2008 1.G Service Manual

Inspect belts for evidence of cuts, cracks, glazing, or
frayed cords and replace if there is indication of damage
that could result in belt failure. Also, check belt routing to
make sure there is no interference between the belts and
other engine components. See your authorized dealer for
service.
Spark Plugs
Spark plugs must fire properly to assure engine perfor-
mance and emissions control. New plugs should be
installed at the specified mileage. The entire set should be
replaced if there is any malfunction due to a faulty spark
plug. Malfunctioning spark plugs can damage the cata-
lytic converter. Refer to “Fluids, Lubricants, and Genuine
Parts” in this section for the proper type of spark plug for
use in your vehicle.
Engine Air Cleaner Filter
Refer to the Maintenance Schedule in Section 8 for engine
air cleaner filter maintenance intervals.
NOTE:Be sure to follow the “dusty or off-road condi-
tions” maintenance interval if applicable.
WARNING!
The air induction system (air cleaner, hoses, etc) can
provide a measure of protection in the case of engine
backfire. Do not remove the air induction system (air
cleaner, hoses, etc) unless such removal is necessary
for repair or maintenance. Make sure that no one is
near the engine compartment before starting the
vehicle with the air induction system (air cleaner,
hoses, etc) removed. Failure to do so can result in
serious personal injury.
394 MAINTAINING YOUR VEHICLE

Air Conditioner Maintenance
For best possible performance, your air conditioner
should be checked and serviced by an authorized dealer
at the start of each warm season. This service should
include cleaning of the condenser fins and a performance
test. Drive belt tension should also be checked at this
time.WARNING!
•Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause
the system to fail, requiring costly repairs. Refer to
Section 3 of the Warranty Information book for
further warranty information.
•The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected
should be done by an experienced technician.
MAINTAINING YOUR VEHICLE 399
7

Seat Belt Maintenance
Do not bleach, dye, or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage can also weaken the fabric.
If the belts need cleaning, use MoparTotal Clean, a mild
soap solution, or lukewarm water. Do not remove the
belts from the vehicle to wash them.
Replace the belts if they appear frayed or worn or if the
buckles do not work properly.
Cleaning the Center Console Cupholders
Clean with a damp cloth or towel using a mild detergent
with the cupholder in the center console.
NOTE:The cupholder cannot be removed.
FUSES (POWER DISTRIBUTION CENTERS)
Fuses (Front Power Distribution Center)
A power distribution center is located in the engine
compartment. This center contains fuses and relays.
Front Power Distribution Center
MAINTAINING YOUR VEHICLE 419
7

Auto Unlock, Doors....................... 30
Auto Up Power Windows.................. 34
Automatic Dimming Mirror................. 84
Automatic Door Locks................... 29,30
Automatic Headlights.................... 133
Automatic Temperature Control (ATC)......... 284
Automatic Transaxle
Special Additives...................... 414
Automatic Transmission.............305,413,414
Adding Fluid......................414,437
Autostick.........................308,310
Fluid and Filter Changes................. 414
Fluid Change......................... 414
Fluid Level Check...................... 413
FluidType ........................... 437
Shifting ............................. 305
Special Additives...................... 414
Automatic Transmission Limp Home Mode . . 309,310
Autostick...........................308,310AxleFluid ............................. 437
Axle Lubrication (Axle Fluid)............... 437
BallJoints ............................. 401
Battery............................... 397
Emergency Starting..................... 377
Jump Starting......................... 377
Keyless Transmitter Replacement (RKE)....... 23
Location..........................377,397
Bearings.............................. 414
Belts,Drive ............................ 393
Belts, Seat............................ 40,76
Body Mechanism Lubrication............... 401
B-Pillar Location........................ 332
Brake Assist System...................... 322
Brake Control System, Electronic............. 320
Brake Fluid............................ 437
Brake, Parking.......................... 315
Brake System........................317,410
INDEX 459
10

Dealer Service.......................... 390
Deck Lid, Emergency Release................ 38
Deck Lid, Power Release................... 37
Defroster, Rear Window................... 292
Defroster, Windshield................... 77,288
Delay (Intermittent) Wipers................. 141
Diagnostic System, Onboard................ 387
Digital Video Disc (DVD) Player..........232,251
Dimmer Switch, Headlight................. 138
Dipsticks
Oil (Engine).......................... 391
Disabled Vehicle Towing................... 381
Disposal
Antifreeze (Engine Coolant)............... 407
Engine Oil........................... 393
Door Locks............................. 27
Door Locks, Automatic.................... 29
Door Opener, Garage..................... 177
DriveBelts ............................ 393Driving
On Slippery Surfaces.................... 312
Through Flowing, Rising, or Shallow
tanding Water.......................... 313
DVD Player (Video Entertainment System)...... 273
Electric Rear Window Defrost............... 292
Electric Remote Mirrors.................... 86
Electrical Power Outlets................... 187
Electronic Brake Control System............. 320
Electronic Power Distribution Center (Fuses).... 419
Electronic Speed Control (Cruise Control)....150,153
Electronic Stability Program (ESP)............ 323
Electronic Throttle Control Warning Light...... 205
Electronic Vehicle Information Center (EVIC).... 209
Emergency Deck Lid Release................ 38
Emergency, In Case of
FreeingVehicleWhenStuck ............... 380
Hazard Warning Flasher................. 370
462 INDEX

Jump Starting.......................... 377
Key, Programming........................ 17
Key, Replacement........................ 16
Key, Sentry (Immobilizer)................... 15
Key-In Reminder......................... 15
Keyless Entry System...................... 20
Keys................................. 12
Knee Bolster............................ 49
Lane Change and Turn Signals.............. 138
Lap/Shoulder Belts....................... 40
LATCH (Lower Anchors and Tether for
CHildren) ............................ 68,69
Latch Plate............................. 41
Latches................................ 77
Hood............................... 131
Lead Free Gasoline...................... 357
Leaks, Fluid............................ 77LifeofTires ............................ 341
LightBulbs .......................... 77,427
Lights .............................. 77,132
Airbag........................ 56,61,76,201
Anti-Lock.........................200,319
Automatic Headlights................... 133
Brake Assist Warning................... 327
Brake Warning.....................201,317
Bulb Replacement...................427,428
Courtesy/Reading...................138,176
Cruise .............................. 199
Daytime Running...................... 136
Dimmer Switch, Headlight.............137,138
Electronic Stability Program (ESP) Indicator . . . 327
Electronic Throttle Control Warning......... 205
Engine Temperature Warning.............. 200
Exterior.............................. 77
Fog .............................137,199
Hazard Warning Flasher................. 370
INDEX 467
10

Headlight Switch...................... 132
Headlights........................132,428
Headlights On Reminder................. 136
Headlights On With Wipers............134,142
High Beam........................138,205
High Beam Indicator.................... 205
Illuminated Entry....................... 20
Instrument Cluster..................132,199
Intensity Control....................... 139
Interior..........................139,176
License............................. 434
Lights On Reminder.................... 136
Low Fuel............................ 199
LowTire ............................ 206
Malfunction Indicator (Check Engine)........ 208
Map Reading......................138,176
Oil Pressure.......................... 208
Parade Mode (Daytime Brightness).......... 140
Passing............................. 138Reading..........................138,176
Seat Belt Reminder..................... 205
Service...........................427,428
Service Engine Soon (Malfunction Indicator) . . . 208
SmartBeams.......................... 134
Tire Pressure Monitoring (TPMS)........206,347
Traction Control....................... 327
Turn Signal................... 77,137,138,199
VanityMirror .......................... 88
Voltage............................. 208
Warning (Instrument Cluster Description)..... 199
Loading Vehicle......................364,365
Capacities........................... 365
Tires ............................... 332
Locks................................. 27
AutoUnlock .......................... 30
Automatic Door........................ 29
Child Protection........................ 30
Door................................ 27
468 INDEX

Placard, Tire and Loading Information......... 332
Port
Universal Serial Bus (USB).............232,251
USB .............................232,251
Power
Brakes.............................. 317
Deck Lid Release....................... 37
Distribution Center (Fuses)............... 419
Door Locks........................... 28
Mirrors .............................. 86
Outlet (Auxiliary Electrical Outlet).......... 187
Seats............................... 120
Steering............................. 319
Steering, Checking..................... 400
Sunroof............................. 184
Tilt/Telescoping Steering Column........... 147
Windows............................. 33
Power Steering Fluid..................400,437
Pregnant Women and Seat Belts.............. 48Pretensioners
Seat Belts............................. 46
Programmable Electronic Features............ 226
Programming Transmitters
(Remote Keyless Entry).................... 20
Radial Ply Tires......................... 339
Radiator Cap (Coolant Pressure Cap).......... 406
Radio Broadcast Signals................... 231
Radio, Navigation....................... 251
Radio Operation...................233,253,283
Radio Remote Controls.................... 281
Radio, Satellite............232,233,251,253,268,273
Radio (Sound Systems).................232,251
Rain Sensitive Wiper System................ 142
Rear Cup Holder........................ 189
Rear Park Sense System................... 172
Rear Seat, Folding....................... 125
Rear Wheel Bearings..................... 414
INDEX 471
10

Rear Window Defroster................... 292
Rear Window Features.................... 292
Reception, Radio........................ 231
Reclining Front Seats..................... 121
Recorder, Event Data...................... 62
Recreational Towing...................... 367
Reformulated Gasoline.................... 358
Refrigerant............................ 400
Release, Hood.......................... 131
Reminder, Lights On..................... 136
Reminder, Seat Belt....................... 46
Remote Control
Starting System........................ 25
Remote Keyless Entry (RKE)................. 20
Remote Sound System (Radio) Controls........ 281
Remote Starting System.................... 25
Remote Trunk Release..................... 37
Replacement Bulbs....................... 427
Replacement Keys........................ 16Replacement Parts....................... 389
Replacement Tires....................... 342
Reporting Safety Defects................... 453
Restraint, Head......................... 123
Restraints, Child......................... 64
Restraints, Occupant...................... 39
Rocking Vehicle When Stuck................ 380
Rotation, Tires.......................... 345
Safety Checks Inside Vehicle................. 76
Safety Checks Outside Vehicle............... 77
Safety Defects, Reporting.................. 453
Safety, Exhaust Gas....................... 75
Safety Information, Tire................... 328
Safety Tips............................. 74
Satellite Radio............232,233,251,253,268,273
Satellite Radio Antenna................... 270
Schedule, Maintenance.................... 440
Seat Belt Maintenance.................... 419
472 INDEX

Seat Belt Reminder....................... 46
Seat Belts.......................... 39,40,76
Adjustable Upper Shoulder Anchorage........ 44
And Pregnant Women................... 48
Child Restraint................... 64,65,66,71
Extender............................. 48
Front Seat.......................... 40,41
Inspection............................ 76
Operating Instructions................... 41
Pretensioners.......................... 46
Rear Seat............................. 40
Reminder............................ 205
Untwisting Procedure.................... 45
Seats................................. 120
Adjustment.......................... 120
Easy Entry........................... 129
Head Restraints....................... 123
Heated............................. 124
Height Adjustment..................... 120Lumbar Support....................... 122
Memory............................. 126
Power.............................. 120
Rear Folding......................... 125
Reclining ............................ 121
Seatback Release....................... 125
Tilting .............................. 120
Security Alarm (Theft Alarm)............. 18,205
Selection of Coolant (Antifreeze)..........405,436
Selection of Oil......................... 392
Sentry Key (Immobilizer)................... 15
Sentry Key Programming................... 17
Sentry Key Replacement................... 16
Service Assistance....................449,450
Service Contract......................... 451
Service Engine Soon Light
(Malfunction Indicator).................... 208
Service Manuals........................ 454
Setting the Clock.............231,234,237,253,258
INDEX 473
10