towing CHRYSLER CONCORDE 2004 2.G User Guide

Under normal operating conditions, the catalytic con-
verter will not require maintenance. However, it is im-
portant to seek service to assure proper catalyst operation
and prevent possible catalyst damage. If the Malfunction
Indicator light is flashing, immediate service is required.
CAUTION!
Damage to the catalytic converter can result if your
vehicle is not kept in proper operating condition. In
the event of engine malfunction, particularly involv-
ing engine misfire or other apparent loss of perfor-
mance, have your vehicle serviced promptly. Contin-
ued operation of your vehicle with a severe
malfunction could cause the converter to overheat,
resulting in possible damage to the converter and the
vehicle.
WARNING!
A hot exhaust system can start a fire if you park over
materials that can burn. Such materials might be
grass or leaves coming into contact with your ex-
haust system. Do not park or operate your vehicle in
areas where your exhaust system can contact any-
thing that can burn.
In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe
and abnormal catalyst overheating. If this occurs, stop
the vehicle, turn off the engine and allow it to cool.
Service, including a tune up to manufacturer’s specifica-
tions, should be obtained immediately.
To minimize the possibility of catalyst damage:
•Do not shut off the engine or interrupt the ignition
when the transaxle is in gear and the vehicle is in
motion.
•Do not try to start the engine by pushing or towing the
vehicle.
MAINTAINING YOUR VEHICLE 201
7

•Wipe the dipstick clean and reinsert until seated.
Remove dipstick and note reading.
•If the fluid is hot(180° F / 82° C), the reading should
be in the cross hatched area marked ”HOT” (between
the upper two holes in the dipstick).
•If the fluid is cold(80° F / 27° C), the reading should
be in the cross hatched area marked “COLD” (between
the lower two holes in the dipstick).
•If the fluid level shows low, add sufficient transmis-
sion fluid to bring to the proper level.
CAUTION!
Do not overfill. Dirt and water in the transaxle can
cause serious damage. To prevent dirt and water
from entering the transaxle after checking or replen-
ishing fluid, make certain that the dipstick cap is
seated properly.
Fluid and Filter Changes
Automatic transmission fluid and filter should be
changed as follows:
Maintenance schedule “A”— No change necessary
Maintenance schedule “B”— Every 60,000 miles (96 000
km) change fluid and filter under the following condi-
tions:
•Police, taxi, limousine, commercial type operation, or
trailer towing where the vehicle is drivenregularlyfor
more than 45 minutes of continuous operation.
NOTE:Refer to Section 8 of this manual for mainte-
nance schedules.
If the transaxle is disassembled for any reason, the fluid
and filter should be changed.
Special Additives
The manufacturer recommends against the addition of
any fluid additives to the transaxle. The only exception to
this policy is the use of special dyes to aid in detecting
fluid leaks. The use of transmission sealers should be
avoided as they may adversely affect seals.
MAINTAINING YOUR VEHICLE 219
7

EMISSION CONTROL SYSTEM MAINTENANCE
The “Scheduled” maintenance services, listed inbold
typemust be done at the times or mileages specified to
assure the continued proper functioning of the emission
control system. These, and all other maintenance services
included in this manual, should be done to provide best
vehicle performance and reliability. More frequent main-
tenance may be needed for vehicles in severe operating
conditions such as dusty areas and very short trip
driving.
Inspection and service also should be done any time a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the
emission control devices and systems on your vehicle
may be performed by any automotive repair establish-
ment or individual using any automotive part which has
been certified pursuant to U.S. EPA or, in the State of
California, California Air Resources Board regulations.
MAINTENANCE SCHEDULES
There are two maintenance schedules that show the
requiredservice for your vehicle.
First is Schedule“B”. It is for vehicles that are operated
under the conditions that are listed below and at the
beginning of the schedule.
•Day or night temperatures are below 32° F (0° C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90° F (32° C).
•Trailer towing.
•Taxi, police, or delivery service (commercial ser-
vice).
•Off-road or desert operation.
236 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SCHEDULE “B”
Follow schedule “B” if you usually operate your vehicle
under one or more of the following conditions. Change
the automatic transmission fluid and filter every 60,000
miles (96 000 km) if the vehicle is usually operated under
one or more of the conditions marked with an.
•Day or night temperatures are below 32° F (0° C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16.2 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90° F (32° C).
•Trailer towing.
•Taxi, police or delivery service (commercial ser-
vices).
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule “B” of the
Maintenance Schedulessection of this manual.
SCHEDULE “B” 239
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Instrument Panel..................... 223
Seat Belts........................... 223
Vinyl.............................. 221
Washing............................ 220
Waxing............................. 221
Wheels............................. 221
Windshield Wiper Blades............... 209
Climate Control........................ 137
Clock................................ 113
Coat Hook............................. 55
Compact Disc Maintenance............... 136
Compact Disc Player................. 114,119
Compact Spare Tire..................... 162
Compass............................94,98
Compass Calibration...................94,98
Compass Variance....................... 95
Computer, Trip/Travel..................93,96
Console, Overhead....................... 75
Contract, Service....................... 254
Cooling System........................ 210
Adding Coolant (Antifreeze)............. 211
Coolant Level........................ 213
Disposal of Used Coolant............... 211Drain, Flush, and Refill................. 211
Inspection........................... 210
Points to Remember................... 213
Pressure Cap........................ 212
Radiator Cap........................ 212
Rubber and Plastic Components.......... 214
Selection of Coolant................... 211
Corrosion Protection.................... 220
Courtesy Lights......................... 66
Crankcase Emission Control System......... 202
Cruise Light.........................73,110
Cup Holder............................ 55
Customer Assistance.................... 252
Daytime Brightness, Interior Lights.......... 65
Daytime Running Lights.................. 68
Dealer Service......................... 193
Defroster, Rear Window.................. 139
Defroster, Windshield...............50,138,143
Diagnostic System, Onboard............ 111,191
Dimmer Switch, Headlight................. 69
Disabled Vehicle Towing................. 186
264 INDEX

Tilt Steering Column..................... 71
Time Delay, Headlight.................... 67
Timing Belt........................... 202
Tires ...........................50,159,259
Air Pressure......................159,161
Alignment.......................... 167
Balancing........................... 167
Chains............................. 163
Changing........................177,178
Flat Changing........................ 177
High Speed......................... 161
Jacking............................. 178
Pressure Label....................... 161
Quality Grading...................... 259
Radial............................. 162
Replacement......................... 165
Rotation............................ 166
Snow Tires.......................... 164
Spare Tire........................... 162
Spinning............................ 163
Tread Wear Indicators.................. 164
To Open Hood.......................... 64Towing.............................. 172
Disabled Vehicle...................... 186
Trailering........................... 172
Traction Control...................72,109,159
Trailer Towing......................... 172
Transaxle
Additives........................... 219
Automatic........................153,217
Filter.............................. 219
Operation........................... 154
Selection of Lubricant.................. 217
Transmission
Range Indicator.................... 112,154
Transmitter Battery Service................ 22
Transmitter, Garage Door Opener..........76,81
Transmitter Programming................. 20
Transporting Pets........................ 48
Traveler Trip Computer................... 93
Tread Wear Indicators................... 164
Trip Computer........................93,96
Trip Odometer.......................... 98
Trip Odometer Reset Button............... 111
272 INDEX