ECU CHRYSLER PT CRUISER 2005 1.G Owner's Manual

WARNING!
Unintended movement of a vehicle could injure
those in and near the vehicle. As with all vehicles,
you should never exit a vehicle while the engine is
running. Before exiting a vehicle, you should always
shift the vehicle into P (Park), remove the key from
the ignition, and apply the parking brake. Once the
key is removed from the ignition, the transmission
shift lever is locked in the P (Park) position, securing
the vehicle against unwanted movement. Further-
more, you should never leave children unattended
inside a vehicle.
The following indicators should be used to ensure that
you have engaged the transmission shift lever into the P
(Park) position:
•When shifting into P (Park), depress the button on the
shift lever and firmly move the lever all the way
forward until it stops.
•Look at the shift indicator window on the console to
ensure it is in the P (Park) position.
•When engaged in P (Park), you will not be able to
move the shifter rearward without depressing the shift
lever button.
CAUTION!
Before moving the shift lever out of P (Park), you
must turn the ignition from LOCK to ON so the
steering wheel and shift lever are released. Other-
wise, damage to the steering column or shifter could
result.
202 STARTING AND OPERATING

Do not raise the vehicle until you are sure the jack is
securely engaged.
4. Raise the vehicle by turning the jack screw to the right,
using the swivel wrench. Raise the vehicle only until the
tire just clears the surface and enough clearance is
obtained to install the spare tire. Minimum tire lift
provides maximum stability.
WARNING!
Raising the vehicle higher than necessary can make
the vehicle less stable. It could slip off the jack and
hurt someone near it. Raise the vehicle only enough
to remove the tire.
5. Remove the wheel nuts and pull the wheel and wheel
covers where applicable off the hub. Install the spare
wheel and wheel nuts with the cone shaped end of the
nuts toward the wheel. Lightly tighten the nuts. To avoid
the risk of forcing the vehicle off the jack, do not tighten
the nuts fully until the vehicle has been lowered.
WARNING!
To avoid possible personal injury, handle the wheel
covers with care to avoid contact with any sharp
edges.
NOTE:The wheel cover is held on the wheel by the
wheel nuts. When reinstalling original wheel, properly
align the wheel cover to the valve stem, place the wheel
cover onto the wheel, then install the wheel nuts.
252 WHAT TO DO IN EMERGENCIES

6. Lower the vehicle by turning the jack screw to the left.
7. Finish tightening the nuts. Push down on the wrench
while tightening the wheel nuts. Alternate nuts until each
nut has been tightened twice. Correct wheel nut torque is
100 ft. lbs (135 N·m). If you doubt that you have
tightened the nuts correctly, have them checked with a
torque wrench by your dealer or at a service station.
8. Remove the wheel blocks and lower the jack until it is
free. Stow the lug wrench, and jack in their designated
location. Secure all parts using the means provided.
WARNING!
A loose tire or jack thrown forward in a collision or
hard stop could endanger the occupants of the ve-
hicle. Always stow the jack parts and the spare tire in
the places provided.
9. Place the deflated (flat) tire in the cargo area,have the
tire repaired or replaced as soon as possible.
WARNING!
A loose tire thrown forward in a collision or hard
stop could injure the occupants in the vehicle. Have
the deflated (flat) tire repaired or replaced immedi-
ately.
10. Check the tire pressure as soon as possible. Correct
pressure as required.
WHAT TO DO IN EMERGENCIES 253
6

Manual Transaxle
Your vehicle may be towed if the gearshift lever is in
NEUTRAL. If the transaxle is not operative, the vehicle
must be towed with the front wheels off the ground.
All Transaxles
CAUTION!
If the vehicle being towed requires steering, the
ignition switch must be in the OFF position, not in
the LOCK or ACCESSORY positions.
Do not attempt to use sling type equipment when
towing. When securing vehicle to flat bed truck, do
not attach to front or rear suspension components.
Damage to your vehicle may result from improper
towing.
If it is necessary to use the accessories while being towed
(wipers, defrosters, etc.), the key must be in the ON
position, not the ACCESSORY position. Make certain the
transaxle remains in NEUTRAL.
Without The Ignition Key
Special care must be taken when the vehicle is towed
with the ignition in the LOCK position. A dolly should be
used under the front wheels if the rear wheels are raised.
Proper towing equipment is necessary to prevent dam-
age to the vehicle.
Towing This Vehicle Behind Another Vehicle (Flat
Towing With All Four Wheels On The Ground)
If your vehicle is equipped with a manual transaxle, it
may be towed at any legal highway speed, for any
distance, if the transaxle is in neutral.
If the ignition key is not available, vehicles with auto-
matic transaxles can not be flat towed at any time.
WHAT TO DO IN EMERGENCIES 259
6

•Do not change the thermostat for summer or winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory coolant performance, poor gas
mileage, and increased emissions.
Hoses And Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling indicate deterioration of the rubber
Pay particular attention to the hoses nearest to high heat
sources such as the exhaust manifold. Inspect hose rout-
ing to be sure hoses do not touch any heat source or
moving component that may cause heat damage or
mechanical wear.
Insure nylon tubing in these areas has not melted or
collapsedInspect all hose connections such as clamps and cou-
plings to make sure the are secure and no leaks are
present.
Components should be replaced immediately if there is
any evidence of degradation that could cause failure.Fuel System Connections
Electronic Fuel Injection high pressure fuel systems are
designed with tubes and special connects, connections
and clamps which have unique material characteristics to
provide adequate sealing and resist attack by deterio-
rated gasoline.
You are urged to use only the manufactures-specified
tubes, connections and clamps, or their equivalent in
material and specification, in any fuel system servicing.
MAINTAINING YOUR VEHICLE 289
7

Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Suggested service intervals can be found in the Mainte-
nance Section.
WARNING!
Riding the brakes can lead to brake failure and
possibly an accident. Driving with your foot resting
or riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You wouldn’t have your full
braking capacity in an emergency.
Brake And Power Steering System Hoses
When servicing the vehicle for scheduled maintenance,
inspect the surface of the hoses and nylon tubing for
evidence of heat and mechanical damage. Hard and
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling suggest deterioration of the rubber. Particu-
lar attention should be made to examining those hose
surfaces nearest to high heat sources, such as the exhaust
manifold.
Inspect all hose clamps and couplings to make sure they
are secure and no leaks are present.
Insure nylon tubing in these areas has not melted or
collapsed.
290 MAINTAINING YOUR VEHICLE

Overhead Reading Light (Overhead Console). . . T1037
Overhead Reading Light (Rearview Mirror).....T192
Rear Cargo............................T906
Seat Belt Indicator....................... LED
Security Alarm Indicator................... LED
Malfunction Indicator Light................ LED
Temperature Indicator.................... LED
Trac (Active) Indicator................... VFD*
TRAC OFF Indicator..................... LED
Trip Indicator......................... VFD*
Turn Signal Indicator...................... 103
Visor Vanity.........................6501966
Voltage Indicator........................ LED
NOTE:* Vacuum Fluorescent Display
All the inside bulbs are brass or glass wedge base.
Aluminum base bulbs are not approved and should not
be used for replacement.LIGHTS BULBS — Outside Bulb No.
Low Beam Headlight...................9006XS
High Beam Headlight...................9005XS
Front Park/Turn Signal/Side Marker
Light............................4157NAKX
Front Fog Light.........................9006
Center High Mounted Stop Light
(CHMSL).........................921–W16W
Rear Tail/Stop/Turn Signal Light......3157–P27/7W
Backup Light.....................3157-P27/7W
License Light........................... 168
MAINTAINING YOUR VEHICLE 307
7

ABS (Anti-Lock Brake) System.............. 212
Adding Engine Coolant (Antifreeze).......... 286
Adding Fuel........................... 239
Adding Washer Fluid..................... 192
Additives, Fuel......................... 237
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 276
Air Conditioner Maintenance............... 279
Air Conditioning Controls................. 183
Air Conditioning, Operating Tips............ 188
Air Conditioning Refrigerant.............279,280
Air Conditioning System................183,279
Air Pressure, Tires....................... 225
Airbag................................ 43
Airbag Deployment....................... 50
Airbag Light.....................47,52,62,142
Airbag Maintenance....................... 51
Airbag, Side............................ 49
Alarm, Panic............................ 23
Alarm System........................26,137Alignment and Balance................... 232
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 181
Antifreeze (Engine Coolant)...........285,311,312
Capacities........................... 311
Disposal............................ 287
Anti-Lock Brake System (ABS).............. 212
Anti-Lock Warning Light.................. 139
Anti-Theft Security Alarm.................. 26
Appearance Care........................ 297
Auto Down Power Windows................ 32
Automatic Door Locks..................... 20
Automatic Transaxle..............12,196,199,293
Fluid and Filter Changes................. 295
Fluid Level Check...................... 294
Interlock System.....................18,200
Reset Mode.......................... 201
Selection Of Lubricant................... 293
Shifting............................. 201
350 INDEX

Key, Sentry............................. 14
Key-In Reminder......................... 14
Keyless Entry System...................... 22
Keys................................. 12
Knee Bolster..........................47,49
Lane Change and Turn Signals.............. 138
Lap/Shoulder Belts....................... 34
Latches
Hood............................... 93
Lead Free Gasoline...................... 235
Liftgate................................ 28
Light Bulbs.........................306,308
Lights...............................62,94
Airbag........................47,52,62,142
Anti-Lock........................... 139
Back-Up............................. 310
Brake Warning........................ 140
Center Mounted Stop................... 310Courtesy/Reading...................... 94
Daytime Running....................... 97
Dimmer Switch, Headlight................ 96
Engine Temperature Warning.............. 138
Fog ...........................97,143,309
Front Replacement..................... 308
Headlight Switch....................... 96
Headlights............................ 96
High Beam Indicator.................... 139
Instrument Cluster...................... 96
Interior.............................. 95
Liftgate Ajar.......................... 137
Lights On Reminder..................... 97
Low Fuel............................ 143
Malfunction Indicator................... 142
Oil Pressure.......................... 137
Rear Servicing........................ 309
Seat Belt Reminder..................... 139
Security Alarm......................... 26
INDEX 357
10

Security Alarm (Theft Alarm)................ 26
Sentry Key...........................14,27
Sentry Key Programming................... 16
Service and Maintenance.................. 316
Service Assistance....................... 340
Service Contract......................... 342
Service Manuals........................ 346
Setting the Clock........................ 144
Severe Service.......................... 319
Shift Speeds, Manual Transaxle.............. 207
Shoulder Belts........................... 34
Side Airbag............................. 49
Side Window Demisters................... 190
Slippery Surfaces, Driving On............... 256
Snow Tires............................ 233
Spare Tire.......................228,229,249
Spark Plugs............................ 274
Speed Control.......................102,141
Speedometer........................... 138Speedometer and Odometer................ 134
Starting............................... 196
Automatic Transmission................. 196
Engine Fails to Start.................... 197
Manual Transmission................... 196
Starting Procedures...................... 196
Steering
Power...........................213,280
Tilt Column.......................... 100
Wheel Lock........................... 17
Storage............................121,306
Storage Bin............................ 121
Stuck, Freeing.......................... 257
Sun Roof.............................. 114
Sun Visor Extension....................... 70
Supplemental Restraint System - Airbag........ 43
Synthetic Engine Oil...................... 272
System, Navigation...................... 177
362 INDEX