fuel filter CHRYSLER PT CRUISER 2007 1.G Owners Manual

Towing Tips — Automatic Transmission
The “D” range can be selected when towing. However, if
frequent shifting occurs while in this range, the “3” range
should be selected.
NOTE:Using the “3” range while operating the vehicle
under heavy operating conditions will improve perfor-
mance and extend transmission life by reducing exces-
sive shifting and heat build up. This action will also
provide better engine braking.
The automatic transmission fluid and filter should be
changed if you REGULARLY tow a trailer for more than
45 minutes of continuous operation. See Schedule “B” in
section 8 of this manual for transmission fluid change
intervals.
NOTE:Check the automatic transmission fluid level
before towing.
Towing Tips — Electronic Speed Control (If
Equipped)

Don’t use in hilly terrain or with heavy loads.
When using the speed control, if you experience speed
drops greater than 10 mph (16 km/h), disengage until
you can get back to cruising speed.
Use speed control in flat terrain and with light loads to
maximize fuel efficiency.
STARTING AND OPERATING 337
5

MAINTAINING YOUR VEHICLE
CONTENTS

2.4L Turbo Engine Compartment............358

2.4L Engine Compartment................359

Onboard Diagnostic System — OBD II........360
▫Loose Fuel Filler Cap Message............360

Emissions Inspection And Maintenance
Programs............................361

Replacement Parts......................362

Dealer Service.........................363

Maintenance Procedures..................363▫Engine Oil..........................363
▫Drive Belts — Check Condition And Tension . . 367
▫Spark Plugs.........................368
▫Ignition Wiring System.................368
▫Catalytic Converter....................368
▫Engine Timing Belt....................369
▫Crankcase Emission Control System........369
▫Fuel Filter..........................370
▫Air Cleaner Element (Filter)..............370
7

Check ventilation hose for indication of damage or
plugging deposits. Replace if necessary.
Fuel Filter
A plugged fuel filter can cause hard starting or limit the
speed at which a vehicle can be driven. Should an
excessive amount of dirt accumulate in the fuel tank,
frequent filter replacement may be necessary. The fuel
filters are located inside the fuel tank. See your dealer for
service.
Air Cleaner Element (Filter)
Under normal driving conditions, replace the filter at the
intervals shown on Schedule “A”. If, however, you drive
the vehicle frequently under dusty or severe conditions,
the filter element should be inspected periodically and
replaced if necessary at the intervals shown on Schedule
“B”.NOTE:For vehicles with a Turbo engine, a small
amount of oil accumulation in the air cleaner box is
normal. The amount will depend on driving style. The air
cleaner box should be cleaned out and a new make-up-
air filter element should be installed during the normal
air filter maintenance procedure.
WARNING!
The air cleaner can provide a measure of protection
in the case of engine backfire. Do not remove the air
cleaner unless such removal is necessary for repair or
maintenance. Make sure that no one is near the
engine compartment before starting the vehicle with
the air cleaner removed. Failure to do so can result in
serious personal injury.
370 MAINTAINING YOUR VEHICLE

2. Fully compress the clip to get the lamp to come out
completely.
3. Remove the socket from the housing.
4. Pull the bulb out of the socket and replace.Center High Mounted Stop Light
1. Open the liftgate and remove the liftgate CHMSL
cover.
2. Remove CHMSL lens from the housing by unlatching
the two side latches.
3. Pull the bulb out of the socket and replace.
FLUIDS AND CAPACITIES
U.S. Metric
Fuel (Approximate)15 Gallons 56.7 Liters
Engine Oil-With Filter
2.4 Liter Engines (Use API Certified SAE 5W-30 Engine Oil. 5.0 qts 4.7 Liters
Cooling System *
2.4 Liter Engines (MoparAntifreeze/Coolant 5 Year/
100,000 Miles Formula), or equivalent.6.5 qts 6.2 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
404 MAINTAINING YOUR VEHICLE

FLUIDS, LUBRICANTS AND GENUINE PARTS
Engine
Component Fluids, Lubricants and Genuine Parts
Engine Coolant MoparAntifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid Or-
ganic Additive Technology) or equivalent.
Engine Oil Use API Certified SAE 5W-30 Engine Oil. Refer to your engine oil filler cap
for correct SAE grade meeting DaimlerChrysler Material Standard MS-6395.
Engine Oil Filter Non Turbo—Mopar 4105409AB or equiv. Turbo—Mopar 4781452BB or equiv.
Spark Plugs Refer to the Vehicle Emission Control Information label in the engine com-
partment.
Fuel Selection 91 Octane for High Output 2.4L Turbo and 87 Octane for 2.4L Standard
Turbo and 2.4L Standard Non Turbo Engines.
MAINTAINING YOUR VEHICLE 405
7

At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder and transaxle and add as needed.
•Check all lights and all other electrical items for correct
operation.
•Check rubber seals on each side of the radiator for
proper fit.
At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front suspension compo-
nents.
•Check the automatic transaxle fluid level.
•Check the manual transaxle fluid level and fill plug
condition.
•Check the coolant level, hoses, and clamps.
410 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SCHEDULE “B”—ALL ENGINES
Follow schedule “B”—All Engines if you usually operate
your vehicle under one or more of the following condi-
tions.
Change the automatic transmission fluid and filter every
60,000 miles (100 000 km) if the vehicle is usually
operated under one or more of the conditions marked
with an.
Change the manual transaxle fluid every 48,000 miles (80
000 km) if the vehicle is usually operated under one or
more of the conditions marked with an †.
•Day and night temperatures are below 32° F (0° C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16.2 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90° F (32° C ).
•Trailer towing.†
•Taxi, police, or delivery service (commercial ser-
vice).†
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first, and follow schedule “B—All
Engines” of theMaintenance Schedulessection of this
manual.
SCHEDULE “B”—ALL ENGINES 411
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

ABS (Anti-Lock Brake System).............. 294
Adding Engine Coolant (Antifreeze).......... 379
Adding Fuel........................... 323
Adding Washer Fluid..................... 274
Additives, Fuel......................... 321
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 370
Air Conditioner Maintenance............... 372
Air Conditioning Controls................. 265
Air Conditioning, Operating Tips............ 270
Air Conditioning Refrigerant.............372,373
Air Conditioning System................265,372
Air Pressure, Tires....................... 308
Airbag.............................. 54,88
Airbag Deployment..................... 66,99
Airbag Light.................... 68,101,113,225
Airbag Maintenance.................... 67,101
Airbag, Side.......................... 63,97
Alarm, Panic............................ 31
Alarm System (Security Alarm)............ 35,224Alignment and Balance................... 316
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 263
Antifreeze (Engine Coolant)...........378,404,405
Capacities........................... 404
Disposal............................ 380
Anti-Lock Brake System (ABS).............. 294
Anti-Lock Warning Light.................. 225
Anti-Theft Security Alarm (Theft Alarm)........ 35
Appearance Care........................ 389
Auto Down Power Windows................ 43
Automatic Door Locks................... 20,21
Automatic Transaxle.............. 13,278,281,385
Fluid and Filter Changes................. 387
Fluid Level Check...................... 386
Interlock System..................... 18,282
Reset Mode.......................... 283
Selection Of Lubricant................... 385
Shifting ............................. 283
442 INDEX

Electronic Speed Control (Cruise Control)...... 187
Electronic Vehicle Information Center (EVIC).... 227
Emergency Deck Lid Release Latch (Convertible) . . 41
Emergency, In Case of
Jacking............................. 342
Jump Starting......................... 347
Towing ............................. 351
Emergency Seat Back Release (Sedan).......... 39
Emission Control System Maintenance......361,408
Engine............................358,359
Break-In Recommendations............... 111
Checking Oil Level..................... 363
Cooling ............................. 377
Exhaust Gas Caution.................... 322
Fuel Requirements..................... 318
Jump Starting......................... 347
Oil ...........................363,404,405
Oil Change Interval.................... 364
Oil Filler Cap...................358,359,366OilFilter ............................ 405
Oil Selection.......................... 366
Oil Synthetic......................... 366
Overheating.......................... 340
Temperature Gauge..................... 220
TimingBelt .......................... 369
Event Data Recorder................... 68,101
Exhaust Gas Caution.............. 38,112,322,376
Exhaust System......................... 376
Fabric Care............................ 391
Filler Location Fuel...................... 220
Filters
Air Cleaner.......................... 370
Engine Fuel.......................... 370
Engine Oil........................367,405
Flashers.............................. 340
Hazard Warning....................... 340
Flat Tire Stowage........................ 347
446 INDEX

Flooded Engine Starting................... 280
Fluid, Brake........................... 406
Fluid Capacities......................... 404
Fluid Leaks............................ 114
Fluid Level Checks
Automatic Transaxle.................... 386
Fluids ................................ 405
Fluids, Lubricants and Genuine Parts.......... 405
Fog Light Service........................ 402
Fog Lights..........................180,225
Folding Front Passenger Seat............... 160
Folding Rear Seat.....................165,166
Folding Rear Seat (Convertible).............. 166
Folding Rear Seat (Sedan).................. 165
Freeing A Stuck Vehicle................... 350
Fuel..............................318,405
Adding............................. 323
Additives............................ 321
Capacity............................ 404CleanAir ............................ 319
Filler Cap (Gas Cap).................220,323
Filler Door (Gas Cap)................... 220
Filter ............................... 370
Gasoline............................ 318
Gauge.............................. 220
Hoses.............................. 382
Light ............................... 225
Octane Rating........................ 318
Requirements......................... 318
System Hoses......................... 382
Tank Capacity........................ 404
Fueling ............................... 323
Fuses................................ 396
Garage Door Opener (HomeLink) ........... 190
Gas Cap (Fuel Filler Cap)............323,325,360
Gasoline, Clean Air...................... 319
Gasoline (Fuel)......................318,404
INDEX 447
10