radiator cap CHRYSLER PT CRUISER 2008 1.G Owners Manual

NOTE:If equipped with a center cap that covers the
wheel nuts, pry off the cap using the small end of the lug
wrench. To reinstall the cap, make sure it is properly
lined up before pushing it on to the wheel.
2. Loosen, but do not remove, the wheel nuts by turning
them to the left one turn while the wheel is still on the
ground.
CAUTION!
Do not attempt to raise the vehicle by jacking on the
cross-member below the radiator, on the front sus-
pension cross-member, or on the rear axle assembly.
3. There are two front jacking locations on each side of
the body and rear jacking locations located on the trailing
arm bracket under the triangular cut out symbol. Turn the jack screw to the right until the jack head is properly
engaged with the lift area closest to the wheel to be
changed.
Do not raise the vehicle until you are sure the jack is
securely engaged.
Jacking Locations
WHAT TO DO IN EMERGENCIES 365
6

COOLING SYSTEM
WARNING!
•
When working near the radiator cooling fan, dis-
connect the fan motor lead or turn the ignition
switch to the OFF position. The fan is temperature
controlled and can start at any time the ignition
switch is in the ON position.
•
You or others can be badly burned by hot coolant
or steam from your radiator. If you see or hear
steam coming from under the hood, don’t open the
hood until the radiator has had time to cool. Never
try to open a cooling system pressure cap when the
radiator is hot.
Coolant ChecksCheck engine coolant (antifreeze) protection every 12
months (before the onset of freezing weather, where
applicable). If coolant is dirty or rusty in appearance, the
system should be drained, flushed and refilled with fresh
coolant. Check the front of the A/C condenser for any
accumulation of bugs, leaves, etc. If dirty, clean by gently
spraying water from a garden hose vertically down the
face of the condenser.
Check the coolant recovery bottle tubing for brittle rub-
ber, cracking, tears, cuts and tightness of the connection
at the bottle and radiator. Inspect the entire system for
leaks.
398 MAINTAINING YOUR VEHICLE

Adding CoolantYour vehicle has been built with an improved engine
coolant that allows extended maintenance intervals. This
coolant can be used up to five Years or 100,000 miles
before replacement. To prevent reducing this extended
maintenance period, it is important that you use the same
coolant throughout the life of your vehicle. Please review
these recommendations for using Hybrid Organic Addi-
tive Technology (HOAT) coolant.
When adding coolant:•
The manufacturer recommends using Mopar
Antifreeze/Coolant five Year/100,000 Mile Formula
HOAT (Hybrid Organic Additive Technology).
•
Mix a minimum solution of 50% HOAT engine coolant
and distilled water. Use higher concentrations (not to
exceed 70%) if temperatures below34°F(37° C)
are anticipated.
•
Use only high purity water such as distilled or deion-
ized water when mixing the water/engine coolant
solution. The use of lower quality water will reduce
the amount of corrosion protection in the engine
cooling system.
Please note that it is the owner’s responsibility to main-
tain the proper level of protection against freezing ac-
cording to the temperatures occurring in the area where
the vehicle is operated.
NOTE: Mixing coolant types will decrease the life of the
engine coolant and will require more frequent coolant
changes.
Cooling System Pressure CapThe cap must be fully tightened to prevent loss of
coolant, and to insure that coolant will return to the
radiator from the coolant recovery bottle.
400 MAINTAINING YOUR VEHICLE

The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
coolant freeze point or replacing coolant. Advise your
service attendant of this. As long as the engine operating
temperature is satisfactory, the coolant bottle need only
be checked once a month.
When additional coolant is needed to maintain the
proper level, it should be added to the coolant bottle. Do
not overfill.Points To RememberNOTE:When the vehicle is stopped after a few miles (a
few kilometers) of operation, you may observe vapor
coming from the front of the engine compartment. This is
normally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot coolant to
enter the radiator. If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•
Do not overfill the coolant recovery bottle.
•
Check coolant freeze point in the radiator and in the
coolant recovery bottle. If antifreeze needs to be
added, contents of coolant recovery bottle must also be
protected against freezing.
•
If frequent coolant additions are required, or if the
level in the coolant recovery bottle does not drop when
the engine cools, the cooling system should be pres-
sure tested for leaks.
•
Maintain coolant concentration at 50% HOAT engine
coolant (minimum) and distilled water for proper
corrosion protection of your engine which contains
aluminum components.
402 MAINTAINING YOUR VEHICLE

Shifting............................. 297
Special Additives ...................... 410
Autostick ............................. 299
Back-Up Lights ......................... 427
Ball Joints ............................. 395
Battery ............................... 392
Keyless Transmitter Replacement (RKE) .....29,35
Belts, Drive ............................ 388
Belts, Engine ........................... 390
Body Mechanism Lubrication ............... 395
Boot, Convertible Top .................. 128,132
B-Pillar Location ........................ 317
Brake Fluid ............................ 431
Brake, Parking .......................... 305
Brake System ........................ 307,404
Anti-Lock (ABS) ....................... 308
Fluid Check .......................... 406
Hoses .............................. 404 Master Cylinder
....................... 406
Parking ............................. 305
Warning Light ........................ 231
Brakes ............................. 307,404
Brake/Transmission Interlock ............... 295
Break-In Recommendations, New Vehicle ....... 115
Bulb Replacement ..................... 424,425
Bulbs, Light ............................ 424
Calibration, Compass ...............238,247,248
Capacities, Antifreeze (Engine Coolant) ........ 429
Capacities, Fluid ........................ 429
Caps, Filler Fuel ................................ 340
Oil (Engine) .................... 378,379,387
Radiator (Coolant Pressure) ............... 400
Car Washes ............................ 411
Carbon Monoxide Warning ................. 339
INDEX 471
10

Convertible Top Maintenance............... 416
Convertible Top Manual Override .........134,373
Cool Down, Turbo ....................... 293
Coolant (Antifreeze) ................... 429,430
Coolant Pressure Cap (Radiator Cap) .......... 400
Cooling System ......................... 398
Adding Coolant (Antifreeze) .............. 400
Coolant Level ...................... 398,401
Disposal of Used Coolant ................ 401
Drain, Flush, and Refill .................. 399
Inspection ........................... 401
Points to Remember .................... 402
Pressure Cap ......................... 400
Radiator Cap ......................... 400
Selection of Coolant (Antifreeze) ........... 399
Corrosion Protection ...................... 411
Crankcase Emission Control System .......... 390
Cruise Light ........................... 229
Cup Holder ............................ 208 Customer Assistance
..................... 461
Data Recorder, Event ................... 70,105
Dealer Service .......................... 383
Deck Lid (Convertible) ..................... 39
Deck Lid, Emergency Release Latch (Convertible) . . 41
Deck Lid, Power Release (Convertible) ......... 39
Defroster, Rear Window ................... 217
Defroster, Windshield .................. 1 16,279
Delay (Intermittent) Wipers ................. 192
Diagnostic System, Onboard ................ 380
Dimmer Switch, Headlight ................. 189
Dipsticks Automatic Transaxle .................... 408
Disposal Antifreeze (Engine Coolant) ............... 401
Engine Oil ........................... 387
Door Locks ............................. 19
Door Locks, Automatic .................... 21
INDEX 473
10

Overheating, Engine...................... 358
Owner’s Manual (Operator Manual) .........4,465
Paint Care ............................. 411
Panel Rear Shelf ........................ 210
Panic Alarm .......................... 26,32
Parking Brake .......................... 305
Passenger Seat Back Tilt (Easy Entry System) .... 168
Passing Light ........................... 190
Personal Settings ........................ 244
Pets ............................... 80,114
Phone, Cellular ......................... 138
Phone, Hands-Free (UConnect™) ............ 138
Placard, Tire and Loading Information ......... 317
Power Deck Lid Release ....................... 39
Distribution Center (Fuses) ............... 419
Door Locks ........................... 20
Outlet (Auxiliary Electrical Outlet) .......... 206Seats
............................... 165
Steering .......................... 310,394
Steering, Checking ..................... 394
Sunroof ............................. 204
Windows ............................. 42
Power Steering Fluid .................. 394,431
Pregnant Women and Seat Belts ............54,89
Preparation for Jacking .................... 362
Pretensioners Seat Belts ........................... 53,88
Programmable Electronic Features ............ 244
Programming Transmitters (Remote Keyless
Entry) ............................... 27,33
Radial Ply Tires ......................... 324
Radiator Cap (Coolant Pressure Cap) .......... 400
Radio Broadcast Signals ................... 250
Radio Operation ................... 251,259,277
Radio, Satellite .......................... 273
INDEX 481
10