engine coolant CHRYSLER TOWN AND COUNTRY 2004 4.G User Guide

Center High Mounted Stop Light (CHMSL)
1. Remove the two screws securing the CHMSL.
2. Twist the bulb socket to remove from the CHMSL
housing.
3. Pull the bulb out of the socket.
4. Replace the bulb, reinstall the socket and reattach the
CHMSL.
License Light
1. Remove the two lens assembly mounting screws.
2. Pull the bulb out of the socket. Replace the bulb and
reattach the lens assembly.
FLUID CAPACITIES
U.S. Metric
Fuel (Approximate)20 Gallons 76 Liters
Engine Oil-with filter
3.3 & 3.8 Liter Engines 5.0 qts 4.7 Liters
Cooling System *
3.3 & 3.8 Liter Engines 13.4 qts 12.6 Liters
* Includes heater and coolant recovery bottle filled to
MAX level.
* Add 2.9 quarts (2.8 liters) if equipped with a rear
heater.
MAINTAINING YOUR VEHICLE 351
7

RECOMMENDED FLUIDS, LUBRICANTS AND
GENUINE PARTS
Engine
Component Fluids, Lubricants and Genuine Parts
Engine Coolant MopartAntifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid Or-
ganic Additive Technology)
Engine Oil Use API Certified, meeting material standard MS-6395, (GF-3). Refer to oil
viscosity chart for correct SAE grade.
Oil Filter 3.3/3.8 liter engines Mopar 5281090 or equiv.
Spark Plugs Refer to the Vehicle Emission Control Information label in the engine com-
partment.
Fuel Selection 87 Octane
352 MAINTAINING YOUR VEHICLE

²Taxi, police, or delivery service (commercial ser-
vice).L
²Off-road or desert operation.
NOTE:Most vehicles are operated under the conditions
listed for Schedule9B9.
Second is ScheduleªAº. It is for vehicles that are not
operated under any of the conditions listed under Sched-
ule9B9.
Use the schedule that best describes your driving condi-
tions. Where time and mileage are listed, follow the
interval that occurs first.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
At Each Stop for Fuel
²Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
²Check the windshield washer solvent and add if required.
Once a Month
²Check tire pressure and look for unusual wear or
damage.
²Inspect the battery and clean and tighten the terminals
as required.
²Check the fluid levels of coolant reservoir, brake
master cylinder and transmission, add as needed.
²Check all lights and all other electrical items for correct
operation.
MAINTENANCE SCHEDULES 357
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

At Each Oil Change
²Change the engine oil filter.
²Inspect the exhaust system.
²Inspect the brake hoses.
²Inspect the CV joints and front suspension compo-
nents.
²Check the automatic transmission fluid level.
²Check the coolant level, hoses, and clamps.
Tire Rotation
²Rotate the tires at 6,000 miles (10 000 km).
358 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 93, 000 96, 000 99, 000 100, 000 102, 000 105, 000
(Kilometers) (149 000) (154 000) (158 000) (160 000) (163 000) (168 000)
Change engine oil and engine oil filter. X X X X X
Inspect the brake linings. X
Inspect the engine air cleaner filter, replace if
necessary. *XXXXX
Replace theengine air cleaner filter*X
Change the All Wheel Drive (AWD) power
transfer unit fluid. (See note at the end of this
chart)X
Change the All Wheel Drive (AWD) overrun-
ning clutch and rear carrier fluid. (See note at
the end of this chart)X
Inspect the serpentine drive belt on 3.3 liter
and 3.8 liter engines, replace if necessary. ³X
Flush and replace the engine coolant at 60
months or 100,000 miles.X
Replace the air conditioning filter. X
366 SCHEDULE ªBº
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 42, 000 48, 000 54, 000 60, 000 66, 000 72, 000
(Kilometers) (67 000) (77 000) (86 000) (96 000) (106 000) (115 000)
[Months] [42] [48] [54] [60] [66] [72]
Change engine oil and engine oil filter. X XXXXX
Inspect the brake linings. X X
Inspect the engine air cleaner filter, replace if
necessary. *XXX XX
Replace theengine air cleaner filter.X
Inspect the tie rod ends and boot seals. X
Check thePCV valveand replace, if neces-
sary.*X
Inspect the serpentine drive belt on 3.3 liter
and 3.8 liter engines, replace if necessary. ³XX
Flush and replace the engine coolant at 60
months, regardless of mileage.X
Replace the air conditioning filter. X X X
370 SCHEDULE ªAº
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 78, 000 84, 000 90, 000 96, 000 100, 000
(Kilometers) (125 000) (134 000) (144 000) (154 000) (160 000)
[Months] [78] [84] [90] [96]
Change engine oil and engine oil filter. X X X X
Inspect the brake linings. X
Inspect the engine air cleaner filter, replace if necessary. * X X X X
Replace theengine air cleaner filter.X
Inspect the tie rod ends and boot seals. X
Check and replace thePCV valve
, if necessary.*X
Inspect the serpentine drive belt on 3.3 liter and 3.8 liter
engines, replace if necessary. ³X
Replace thespark plugs
3.3 liter and 3.8 liter engines.X
Replace theignition cables
3.3 liter and 3.8 liter engines.X
Flush and replace the engine coolant at 100,000 miles, if
not done at 60 months.X
Replace the air conditioning filter. X X
SCHEDULE ªAº 371
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 102, 000 108, 000 114, 000 120, 000
(Kilometers) (163 000) (173 000) (182 000) (192 000)
[Months] [102] [108] [114] [120]
Change engine oil and engine oil filter. X X X X
Inspect the brake linings. X
Inspect the engine air cleaner filter, replace if necessary. * X X X
Replace theengine air cleaner filter.X
Inspect the tie rod ends and boot seals. X
Check thePCV valveand replace, if necessary.* X
Inspect the serpentine drive belt on 3.3 liter and 3.8 liter
engines, replace if necessary. ³XX
Flush and replace the engine coolant at 120 months, if not
done at 100,000 miles (160 000 km).X
Replace the air conditioning filter. X X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.³ This maintenance is not required if previously replaced.
372 SCHEDULE ªAº
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Adding Fuel........................... 279
Adding Washer Fluid..................232,324
Additives, Fuel......................... 277
Adjustable Pedals........................ 116
Air Conditioner Maintenance............... 321
Air Conditioning.....................209,214
Air Conditioning Controls................. 209
Air Conditioning Filter.................230,322
Air Conditioning, Operating Tips............ 229
Air Conditioning, Rear Zone.............216,224
Air Conditioning Refrigerant............... 321
Air Conditioning System..........209,214,219,321
Air Conditioning System, Zone Control........ 210
Air Pressure, Tires....................... 261
Airbag................................ 50
Airbag Deployment....................... 57
Airbag Light.....................54,59,74,162
Airbag Maintenance....................... 58
Airbag, Side............................ 56Alarm Light........................... 164
Alarm System........................... 27
Alignment and Balance................... 267
All Wheel Drive...................244,268,337
Alterations/Modifications, Vehicle............. 7
Antifreeze Disposal...................... 329
Antifreeze (Engine Coolant)..............327,328
Anti-Lock Brake System................... 247
Anti-Lock Warning Light.................. 163
Anti-Theft Security Alarm.................. 27
Appearance Care........................ 339
Ashtray............................... 140
Auto Down Power Windows................ 39
Automatic Dimming Mirror................. 82
Automatic Door Locks..................... 19
Automatic Headlights.................... 108
Automatic Temperature Control............. 219
Automatic Transaxle...................241,335
Adding Fluid......................... 353
386 INDEX

Radiator Cap......................... 329
Selection of Coolant..................327,352
Cruise Control.......................... 117
Cruise Light........................... 167
Cup Holder.........................140,343
Customer Assistance..................... 376
Daytime Running Lights................... 109
Dealer Service.......................... 311
Defroster, Rear Window................... 233
Defroster, Windshield................74,213,223
Digital Video Disc Player.................. 197
Dimmer Control........................ 107
Dipsticks
Automatic Transaxle.................... 336
Disposal
Antifreeze........................... 329
Domelight............................. 108
Door Ajar Light......................... 161Door Locks............................. 17
Door Locks, Automatic.................... 19
Door Opener, Garage..................... 129
Drive Belts............................ 316
Drive Shaft Universal Joints................ 323
Driving
On Slippery Surfaces.................... 299
DVD Player............................ 197
Electric Remote Mirrors.................... 84
Electrical Power Outlets................... 138
Electronic Speed Control................... 117
Electronic Vehicle Information Center......... 125
Emergency, In Case of
Jacking............................. 292
Overheating.......................... 291
Emission Control System Maintenance......310,356
Engine............................... 308
Air Cleaner.......................... 317
INDEX 389
10