door lock CHRYSLER VOYAGER 2001 Owner's Guide

Symptom:
*LEFT FRONT DOOR AJAR SWITCH SENSE CIRCUIT OPEN
POSSIBLE CAUSES
INTERMITTENT CONDITION
LEFT FRONT DOOR AJAR SWITCH GROUND CIRCUIT OPEN
LEFT FRONT DOOR LOCK MOTOR/AJAR SWITCH
LEFT FRONT DOOR AJAR SWITCH SENSE CIRCUIT OPEN
BODY CONTROL MODULE INTERNAL MALFUNCTION
TEST ACTION APPLICABILITY
1 Open the driver door.
With the DRBIIItin Inputs/Outputs, read the DR DOOR AJAR SW state.
Does the DRBIIItdisplay CLOSED?All
Ye s®The condition that caused this symptom is currently not present.
Inspect the related wiring harness for a possible intermittent
condition. Look for any chafed, pierced, pinched or partially
broken wires.
Perform BODY VERIFICATION TEST - VER 1.
No®Go To 2
2 Disconnect the Left Front Door Lock Motor/Ajar switch connector.
Using a 12-volt Test Light connected to 12-volts, test the Ground circuit for
continuity.
Does the light illuminate?All
Ye s®Go To 3
No®Repair the Ground circuit for an open.
Perform BODY VERIFICATION TEST - VER 1.
3 Disconnect the Left Front Door Lock Motor/Ajar Switch connector.
With the DRBIIItin Inputs/Outputs, read the DR DOOR AJAR SW state.
Connect a jumper wire between Sense circuit and the Ground circuit.
Does the DRBIIItdisplay DR DOOR AJAR SW: CLOSED?All
Ye s®Replace the Left Front Door Lock Motor/Ajar Switch.
Perform BODY VERIFICATION TEST - VER 1.
No®Go To 4
4 Disconnect the Body Control Module C3 harness connector.
Disconnect the Left Front Door Lock Motor/Ajar Switch harness connector.
Measure the resistance of the Sense circuit.
Is the resistance below 5.0 ohms?All
Ye s®Replace the Body Control Module.
Perform BODY VERIFICATION TEST - VER 1.
No®Repair the Left Front Door Ajar Switch Sense circuit for an open.
Perform BODY VERIFICATION TEST - VER 1.
428
DOOR AJAR

Symptom:
*LEFT FRONT DOOR AJAR SWITCH SENSE CIRCUIT SHORTED
TO GROUND
POSSIBLE CAUSES
LEFT FRONT DOOR LOCK MOTOR/AJAR SWITCH SHORTED TO GROUND
LEFT FRONT DOOR AJAR SWITCH SENSE CIRCUIT SHORTED TO GROUND
BODY CONTROL MODULE INTERNAL MALFUNCTION
TEST ACTION APPLICABILITY
1 With the DRBIIItin Inputs/Outputs, read the DR DOOR AJAR SW state.
Disconnect the Left Front Door Lock Motor/Ajar Switch harness connector.
With the DRBIIItin Inputs/Outputs, read the DR DOOR AJAR SW state.
Did the Switch State change from CLOSED to OPEN?All
Ye s®Replace the Left Front Door Lock Motor/Ajar Switch.
Perform BODY VERIFICATION TEST - VER 1.
No®Go To 2
2 Disconnect the Body Control Module C3 harness connector.
Disconnect the Left Front Door Lock Motor/Ajar Switch harness connector.
Using a 12-volt Test Light connected to 12-volts, test the Sense circuit for a short to
ground.
Does the Test Light illuminate?All
Ye s®Repair the Left Front Door Ajar Switch Sense circuit for a short to
ground.
Perform BODY VERIFICATION TEST - VER 1.
No®Replace the Body Control Module.
Perform BODY VERIFICATION TEST - VER 1.
429
DOOR AJAR

Symptom:
*LEFT SLIDING DOOR AJAR SWITCH SENSE CIRCUIT OPEN
POSSIBLE CAUSES
GROUND CIRCUIT OPEN
LEFT SLIDING DOOR AJAR SWITCH SENSE CIRCUIT OPEN
LEFT SLIDING DOOR AJAR SWITCH SENSE CIRCUIT OPEN
BODY CONTROL MODULE INTERNAL MALFUNCTION
LEFT SLIDING DOOR LOCK MOTOR/AJAR SWITCH
TEST ACTION APPLICABILITY
1 Disconnect the Left Sliding Door Lock Motor/Ajar Switch harness connector at the
bottom of the door.
Connect a jumper wire between the Left Sliding Door Ajar Switch Sense circuit and
ground.
With the DRBIIItin Inputs/Outputs, read the LSLIDE DR AJAR SW state.
Did the Switch State change from OPEN to CLOSED?All
Ye s®Go To 2
No®Go To 4
2 Reconnect the Left Sliding Door Lock Motor/Ajar Switch connector at the bottom of
the door.
Remove the door panel from the sliding door.
Disconnect the Left Sliding Door Lock Motor/Ajar Switch connector at the door
mechanism.
Connect a jumper wire between the Left Sliding Door Ajar Switch Sense circuit and
ground.
With the DRBIIItin Inputs/Outputs, read the LSLIDE DR AJAR SW state.
Did the Switch State change from OPEN to CLOSED?All
Ye s®Go To 3
No®Repair the Left Sliding Door Lock Motor/Ajar Switch harness for
an open between the door mechanism and the intermediate
harness connector at the bottom of the door.
Perform BODY VERIFICATION TEST - VER 1.
3 Disconnect the Left Sliding Door Lock Motor/Ajar Switch connector at the door
mechanism.
Connect a jumper wire between the Left Sliding Door Ajar Switch Sense circuit and
the Ground circuit.
With the DRBIIItin Inputs/Outputs, read the LSLIDE DR AJAR SW state.
Did the Switch State change from OPEN to CLOSED?All
Ye s®Replace the Sliding Door Lock Motor/Ajar Switch.
Perform BODY VERIFICATION TEST - VER 1.
No®Repair the Ground circuit for an open.
Perform BODY VERIFICATION TEST - VER 1.
430
DOOR AJAR

TEST ACTION APPLICABILITY
4 Disconnect the Left Sliding Door Lock Motor/Ajar Switch harness connector at the
bottom of the sliding door.
Gain access to the BCM C3 connector.
Back probe a jumper wire from the Left Sliding Door Ajar Switch Sense circuit at the
BCM to ground.
With the DRBIIItin Inputs/Outputs, read the LSLIDE DR AJAR SW state.
Did the Switch State change from OPEN to CLOSED?All
Ye s®Repair the Left Sliding Door Ajar Switch Sense circuit for an open
between the intermediate connector and the Body Control Mod-
ule.
Perform BODY VERIFICATION TEST - VER 1.
No®Replace the Body Control Module.
Perform BODY VERIFICATION TEST - VER 1.
431
DOOR AJAR
*LEFT SLIDING DOOR AJAR SWITCH SENSE CIRCUIT OPEN ÐContinued

Symptom:
*LEFT SLIDING DOOR AJAR SWITCH SENSE CIRCUIT SHORTED
TO GROUND
POSSIBLE CAUSES
LEFT SLIDING DOOR LOCK MOTOR/AJAR SWITCH SHORTED TO GROUND
LEFT SLIDING DOOR AJAR SWITCH SENSE CIRCUIT SHORTED TO GROUND
BODY CONTROL MODULE INTERNAL MALFUNCTION
LEFT SLIDING DOOR LOCK MOTOR/AJAR SWITCH
TEST ACTION APPLICABILITY
1 With the DRBIIItin Inputs/Outputs, read the LSLIDE DR AJAR SW state.
Disconnect the Left Sliding Door Lock Motor/Ajar Switch harness connector at the
bottom of the door.
With the DRBIIItin Inputs/Outputs, read the LSLIDE DR AJAR SW state.
Did the Switch State change from CLOSED to OPEN?All
Ye s®Go To 2
No®Go To 3
2 Reconnect the Left Sliding Door Lock Motor/Ajar Switch connector at the bottom of
the door.
Remove the door panel from the sliding door.
Disconnect the Left Sliding Door Lock Motor/Ajar Switch connector at the door
mechanism.
With the DRBIIItin Inputs/Outputs, read the LSLIDE DR AJAR SW state.
Did the Switch State change from CLOSED to OPEN?All
Ye s®Replace the Sliding Door Lock Motor/Ajar Switch.
Perform BODY VERIFICATION TEST - VER 1.
No®Repair the Left Sliding Door Lock Motor/Ajar Switch harness for
a short to ground between the door mechanism and the interme-
diate harness connector at the bottom of the door.
Perform BODY VERIFICATION TEST - VER 1.
3 Disconnect the Body Control Module C3 harness connector.
Disconnect the Left Sliding Door Lock Motor/Ajar Switch harness connector at the
bottom of the sliding door.
Using a 12-volt Test Light connected to 12-volts, test the Sense circuit for a short to
ground.
Does the Test Light illuminate?All
Ye s®Repair the Left Sliding Door Ajar Switch Sense circuit for a short
to ground.
Perform BODY VERIFICATION TEST - VER 1.
No®Replace the Body Control Module.
Perform BODY VERIFICATION TEST - VER 1.
432
DOOR AJAR

Symptom:
*RIGHT FRONT DOOR AJAR SWITCH SENSE CIRCUIT OPEN
POSSIBLE CAUSES
INTERMITTENT CONDITION
RIGHT FRONT DOOR AJAR SWITCH GROUND CIRCUIT OPEN
RIGHT FRONT DOOR LOCK MOTOR/AJAR SWITCH
RIGHT FRONT DOOR AJAR SWITCH SENSE CIRCUIT OPEN
BODY CONTROL MODULE INTERNAL MALFUNCTION
TEST ACTION APPLICABILITY
1 Open the passenger door.
With the DRBIIItin Inputs/Outputs, read the PASS DOOR AJAR SW state.
Does the DRBIIItdisplay CLOSED?All
Ye s®The condition that caused this symptom is currently not present.
Inspect the related wiring harness for a possible intermittent
condition. Look for any chafed, pierced, pinched or partially
broken wires.
Perform BODY VERIFICATION TEST - VER 1.
No®Go To 2
2 Disconnect the Right Front Door Lock Motor/Ajar switch connector.
Using a 12-volt Test Light connected to 12-volts, test the Ground circuit for
continuity.
Does the light illuminate?All
Ye s®Go To 3
No®Repair the Ground circuit for an open.
Perform BODY VERIFICATION TEST - VER 1.
3 Disconnect the Right Front Door Lock Motor/Ajar Switch connector.
With the DRBIIItin Inputs/Outputs, read the PASS DOOR AJAR SW state.
Connect a jumper wire between Sense circuit and the Ground circuit.
Does the DRBIIItdisplay PASS DOOR AJAR SW: CLOSED?All
Ye s®Replace the Right Front Door Lock Motor/Ajar Switch.
Perform BODY VERIFICATION TEST - VER 1.
No®Go To 4
4 Disconnect the Body Control Module C3 harness connector.
Disconnect the Right Front Door Lock Motor/Ajar Switch harness connector.
Measure the resistance of the Sense circuit.
Is the resistance below 5.0 ohms?All
Ye s®Replace the Body Control Module.
Perform BODY VERIFICATION TEST - VER 1.
No®Repair the Right Front Door Ajar Switch Sense circuit for an
open.
Perform BODY VERIFICATION TEST - VER 1.
435
DOOR AJAR

Symptom:
*RIGHT FRONT DOOR AJAR SWITCH SENSE CIRCUIT SHORTED
TO GROUND
POSSIBLE CAUSES
RIGHT FRONT DOOR LOCK MOTOR/AJAR SWITCH SHORTED TO GROUND
RIGHT FRONT DOOR AJAR SWITCH SENSE CIRCUIT SHORTED TO GROUND
BODY CONTROL MODULE INTERNAL MALFUNCTION
TEST ACTION APPLICABILITY
1 With the DRBIIItin Inputs/Outputs, read the PASS DOOR AJAR SW state.
Disconnect the Right Front Door Lock Motor/Ajar Switch harness connector.
With the DRBIIItin Inputs/Outputs, read the PASS DOOR AJAR SW state.
Did the Switch State change from CLOSED to OPEN?All
Ye s®Replace the Right Front Door Lock Motor/Ajar Switch.
Perform BODY VERIFICATION TEST - VER 1.
No®Go To 2
2 Disconnect the Body Control Module C3 harness connector.
Disconnect the Right Front Door Lock Motor/Ajar Switch harness connector.
Using a 12-volt Test Light connected to 12-volts, test the Sense circuit for a short to
ground.
Does the Test Light illuminate?All
Ye s®Repair the Right Front Door Ajar Switch Sense circuit for a short
to ground.
Perform BODY VERIFICATION TEST - VER 1.
No®Replace the Body Control Module.
Perform BODY VERIFICATION TEST - VER 1.
436
DOOR AJAR

Symptom:
*RIGHT SLIDING DOOR AJAR CIRCUIT OPEN
POSSIBLE CAUSES
GROUND CIRCUIT OPEN
RIGHT SLIDING DOOR AJAR SWITCH SENSE CIRCUIT OPEN
RIGHT SLIDING DOOR AJAR SWITCH SENSE CIRCUIT OPEN
BODY CONTROL MODULE INTERNAL MALFUNCTION
RIGHT SLIDING DOOR LOCK MOTOR/AJAR SWITCH
TEST ACTION APPLICABILITY
1 Disconnect the Right Sliding Door Lock Motor/Ajar Switch harness connector at the
bottom of the door.
Connect a jumper wire between the Right Sliding Door Ajar Switch Sense circuit and
ground.
With the DRBIIItin Inputs/Outputs, read the RSLIDE DR AJAR SW state.
Did the Switch State change from OPEN to CLOSED?All
Ye s®Go To 2
No®Go To 4
2 Reconnect the Right Sliding Door Lock Motor/Ajar Switch connector at the bottom of
the door.
Remove the door panel from the sliding door.
Disconnect the Right Sliding Door Lock Motor/Ajar Switch connector at the door
mechanism.
Connect a jumper wire between the Right Sliding Door Ajar Switch Sense circuit and
ground.
With the DRBIIItin Inputs/Outputs, read the RSLIDE DR AJAR SW state.
Did the Switch State change from OPEN to CLOSED?All
Ye s®Go To 3
No®Repair the Right Sliding Door Lock Motor/Ajar Switch harness for
an open between the door mechanism and the intermediate
harness connector at the bottom of the door.
Perform BODY VERIFICATION TEST - VER 1.
3 Disconnect the Right Sliding Door Lock Motor/Ajar Switch connector at the door
mechanism.
Connect a jumper wire between the Right Sliding Door Ajar Switch Sense circuit and
the Ground circuit.
With the DRBIIItin Inputs/Outputs, read the RSLIDE DR AJAR SW state.
Did the Switch State change from OPEN to CLOSED?All
Ye s®Replace the Sliding Door Lock Motor/Ajar Switch.
Perform BODY VERIFICATION TEST - VER 1.
No®Repair the Ground circuit for an open.
Perform BODY VERIFICATION TEST - VER 1.
437
DOOR AJAR

TEST ACTION APPLICABILITY
4 Disconnect the Right Sliding Door Lock Motor/Ajar Switch harness connector at the
bottom of the sliding door.
Gain access to the BCM C3 connector.
Back probe a jumper wire from the Right Sliding Door Ajar Switch Sense circuit at
the BCM to ground.
With the DRBIIItin Inputs/Outputs, read the RSLIDE DR AJAR SW state.
Did the Switch State change from OPEN to CLOSED?All
Ye s®Repair the Right Sliding Door Ajar Switch Sense circuit for an
open between the intermediate connector and the Body Control
Module.
Perform BODY VERIFICATION TEST - VER 1.
No®Replace the Body Control Module.
Perform BODY VERIFICATION TEST - VER 1.
438
DOOR AJAR
*RIGHT SLIDING DOOR AJAR CIRCUIT OPEN ÐContinued

Symptom:
*RIGHT SLIDING DOOR AJAR CIRCUIT SHORTED TO GROUND
POSSIBLE CAUSES
RIGHT SLIDING DOOR LOCK MOTOR/AJAR SWITCH SHORTED TO GROUND
RIGHT SLIDING DOOR AJAR SWITCH SENSE CIRCUIT SHORTED TO GROUND
BODY CONTROL MODULE INTERNAL MALFUNCTION
RIGHT SLIDING DOOR LOCK MOTOR/AJAR SWITCH
TEST ACTION APPLICABILITY
1 With the DRBIIItin Inputs/Outputs, read the RSLIDE DR AJAR SW state.
Disconnect the Right Sliding Door Lock Motor/Ajar Switch harness connector at the
bottom of the door.
With the DRBIIItin Inputs/Outputs, read the RSLIDE DR AJAR SW state.
Did the Switch State change from CLOSED to OPEN?All
Ye s®Go To 2
No®Go To 3
2 Reconnect the Right Sliding Door Lock Motor/Ajar Switch connector at the bottom of
the door.
Remove the door panel from the sliding door.
Disconnect the Right Sliding Door Lock Motor/Ajar Switch connector at the door
mechanism.
With the DRBIIItin Inputs/Outputs, read the RSLIDE DR AJAR SW state.
Did the Switch State change from CLOSED to OPEN?All
Ye s®Replace the Sliding Door Lock Motor/Ajar Switch.
Perform BODY VERIFICATION TEST - VER 1.
No®Repair the Right Sliding Door Lock Motor/Ajar Switch harness for
a short to ground between the door mechanism and the interme-
diate harness connector at the bottom of the door.
Perform BODY VERIFICATION TEST - VER 1.
3 Disconnect the Body Control Module C3 harness connector.
Disconnect the Right Sliding Door Lock Motor/Ajar Switch harness connector at the
bottom of the sliding door.
Using a 12-volt Test Light connected to 12-volts, test the Sense circuit for a short to
ground.
Does the Test Light illuminate?All
Ye s®Repair the Right Sliding Door Ajar Switch Sense circuit for a
short to ground.
Perform BODY VERIFICATION TEST - VER 1.
No®Replace the Body Control Module.
Perform BODY VERIFICATION TEST - VER 1.
439
DOOR AJAR