ESP Citroen C4 2015 2.G Service Manual

255
C4-2_en_Chap11_info-pratique_ed01-2015
C4-2_en_Chap11_info-pratique_ed01-2015
Fuse N°Rating Functions
F19 30 AWindscreen
  wipers   slow   /   fast   speed.
F20 15 AFront
  and   rear   screenwash   pump.
F21 20 AHeadlamp
  wash   pump.
F22 15 AHorn.
F23 15 ARight-hand
  main   beam   headlamp.
F24 15 ALeft-hand
  main   beam   headlamp.
F27 5 ALeft-hand
 d

ipped
 h
eadlamp.
F28 5 ARight-hand
 d

ipped
 h
eadlamp.
Engine compartment fuses
The fusebox is placed in the engine compartment   near   the   battery   (left-hand   side).
Access to the fuses
F Unclip  the   cover.
F  C hange   the   fuse   (see   corresponding  
par

agraph).
F

W
hen you have finished, close the cover
carefully
  to   ensure   sealing   of   the   fusebox.
Fuse table
11
Practical information

259
C4-2_en_Chap11_info-pratique_ed01-2015
C4-2_en_Chap11_info-pratique_ed01-2015
Charging the battery using
a battery charger
F Disconnect   the   battery   from   the   vehicle.
F F ollow the instructions for use provided by
the
  manufacturer   of   the   charger.
F
 
C
onnect   the   battery   starting   with   the  
n

egative   terminal   (-).
F
 
C
heck   that   the   terminals   and   connectors  
a

re   clean.   If   they   are   covered  
w
ith
 s
ulphate
 (

whitish   or   greenish   deposit),   remove   them  
a

nd   clean   them.
Reinitialisation after
reconnection
after any reconnection of the battery, switch on
the  ignition   and   wait   at   least   one   minute   before  
s

tarting,   to   allow   time   for   the   initialisation   of   the  
e

lectronic   systems.
By
  referring   to   the   corresponding   sections,   you  
s

hould   set   or   initialise   the   following   systems  
y

ourself:
-

o
ne-touch electric windows,
-
 
t
ime   and   date,
-
 
a
udio   and   navigation   system   settings.
Check
  that   no   alert   message   or   warning   lamp  
c

omes   on   after   switching   on   the   ignition.
However,
  if   minor   problems   persist   after  
c

arrying   out   these   operations,   contact   a  
C

ITROËN   dealer   or   a   qualified   workshop.
Reconnecting the (+) cable
F Position  the   open   clamp   E of the cable on
the   positive   post   (+)   of   the   battery.
F
 
P
ress   vertically   on   the   clamp   E to position
it
  correctly   on   the   battery.
F
 
L
ock   the   clamp   by   spreading   the  
p

ositioning   lug   and   then   lowering   the   tab   D.
Disconnecting the (+) cable
F Raise   the   locking   tab   D fully to release the
cable t erminal c lamp E.
D
o   not   apply   excessive   force   on   the  
t

ab   as   locking   will   not   be   possible   if   the  
c

lamp   is   not   positioned   correctly;   start  
t

he   procedure   again. With Stop & Start, the battery does not
have
  to   be   disconnected   for   charging.
11
Practical information

260
C4-2_en_Chap11_info-pratique_ed01-2015
C4-2_en_Chap11_info-pratique_ed01-2015
Load reduction modeE nergy ec onomy m ode
Switching to economy mode
Once this period has elapsed, a message a
ppears   in   the   screen   indicating   that   the  
v

ehicle   has   switched   to   economy   mode   and   the  
a

ctive   functions   are   put   on   standby.
Exiting economy mode
These functions are reactivated automatically the   next   time   the   vehicle   is   driven.
F
 
I
n   order   to   resume   the   use   of   these   functions
 i

mmediately,   start   the   engine   and   let   it   run   for   a
 f

ew
 m
inutes.
The
  time   available   to   you   will   then   be   double  
t

he   period   for   which   the   engine   is   left   running.  
H

owever, this period will always be between
five
  and   thirty   minutes.
System
 
which
 
manages
 
the
 
use
 
of
 
certain
 
f

unctions
 
according
 
to
 
the
 
level
 
of
 
charge
 
r

emaining
 
in
 
the
 
battery.
When
 
the
 
vehicle
 
is
 
being
 
driven,
 
the
 
load
 
r

eduction
 
function
 
temporarily
 
deactivates
 
c

ertain
 
functions,
 
such
 
as
 
the
 
air
 
conditioning,
 
t

he
 
heated
 
rear
 
screen...
The deactivated functions are reactivated
automatically
 
as
 
soon
 
as
 
conditions
 
permit. System
 
which
 
manages
 
the
 
period
 
of
 
use
 
of
 
certain
  functions   to   conserve   a   sufficient   level   of  
c

harge
 
in
 
the
 
battery.
After
 
the
 
engine
 
has
 
stopped,
 
you
 
can
 
still
 
use
 
functions   such   as   the   audio   equipment,   windscreen  
w

ipers,
 
dipped
 
beam
 
headlamps,
 
courtesy
 
lamps,
 
etc.   for
 a m
aximum
 c
ombined
 p
eriod
 o
f
 t
hirty  
m

inutes.
A  flat   battery   prevents   the   engine   from  
s

tarting   (refer   to   the   corresponding  
par

agraph).
This
 
period
 
may
 
be
 
greatly
 
reduced
 
if
 
t

he
 
battery
 
is
 
not
 
fully
 
charged.
If
 
the
 
telephone
 
is
 
being
 
used
 
at
 
the
 
s

ame
 
time
 
on
 
the
 
navigation
 
system,
 i

t
 
w

ill
 
be
 
interrupted
 
after
 
1

0
 m

inutes.
Practical information

261
C4-2_en_Chap11_info-pratique_ed01-2015
C4-2_en_Chap11_info-pratique_ed01-2015
Changing a wiper blade
Before removing a front
wiper blade
F Within  one   minute   after   switching   off  t
he   ignition,   operate   the   wiper   stalk   to  
p

osition the wiper blades vertically on the
windscreen.
Removing
F Raise   the   corresponding   wiper   arm.
F  U nclip   the   wiper   blade   and   remove   it.
Fitting
F Put  the   corresponding   new   wiper   blade   in  p
lace   and   clip   it.
F
 
F
old   down   the   wiper   arm   carefully.
After fitting a front wiper
blade
F Switch  on   the   ignition.
F  O perate   the   wiper   stalk   again   to   park   the  
w

iper   blades.
11
Practical information

275
C4-2_en_Chap12_caracteristique_ed01-2015
C4-2_en_Chap12_caracteristique_ed01-2015
* The maximum power corresponds to the value type-approved on a test bed, under conditions defined in European legislation (Directive 1999/99/EC).
Petrol engines and gearboxes
.../1: model   fitted   with   low   rolling   resistance   tyres.
.../2:  model
  fitted   with   very   low   rolling   resistance   tyres.
Petrol engine
VTi 95Puretech 110 V Ti 120
Gearbox Manual

(5 - speed) Manual
(5 - speed) Manual

(5 - speed) Automatic

(4 - speed)
Model code:
NC... 8FR0HNZ6
HNZ6/1
HNZ6/2 5FS0
5FS9

5FS9/D
Cubic   capacity   (cc)
1   397
1   199
1   598
Bore   x   stroke   (mm)
77   x   72.5
75   x   90.5
77   x   85.8
Max   power*:   EU   standard   (kW)
7081 88
Max   power   engine   speed   (rpm)
6   000
5 500 6   000
Max   torque:   EU   standard   (Nm)
13 5205 160
Max   torque   engine   speed   (rpm)
4 0001 500 4 250
Fuel UnleadedUnleaded Unleaded
Catalytic converter Ye sYe s Ye s
Engine oil capacity (in litres) 4.253.5 4.25
12
Technical data

276
C4-2_en_Chap12_caracteristique_ed01-2015
C4-2_en_Chap12_caracteristique_ed01-2015
* The maximum power corresponds to the value type-approved on a test bed, under conditions defined in European legislation (Directive 1999/99/EC).
. ../S:
 
model   fitted   with   Stop   &   Start.
.../1:  model
  fitted   with   low   rolling   resistance   tyres.
.../2:
 

model   fitted   with   very   low   rolling   resistance   tyres.
Petrol engine
Puretech 130 S&STHP 155
Gearbox Manual

(6- speed) EAT6 Automatic
(6- speed) ETG6 Electronic

(6- speed)
Model code:
NC... HNYM/S
HNYM/1S HNY T/S
HNY T/1S
HNY T/2S 5FV8/P
Cubic   capacity   (cc)
1   199
1   598
Bore   x   stroke   (mm)
70   x   90.5
77   x   85.8
Max   power*:   EU   standard   (kW)
96115
Max   power   engine   speed   (rpm)
5 5006   000
Max   torque:   EU   standard   (Nm)
230240
Max   torque   engine   speed   (rpm)
1   750
1 400
Fuel UnleadedUnleaded
Catalytic converter Ye sYe s
Engine oil capacity (in litres) 3.54,25
Technical data

279
C4-2_en_Chap12_caracteristique_ed01-2015
C4-2_en_Chap12_caracteristique_ed01-2015
* The maximum power corresponds to the value type-approved on a test bed, under conditions defined in European legislation (Directive 1999/99/EC).
Diesel engines and gearboxes
.../S: model   fitted   with   Stop   &   Start.
.../1:  model   fitted   with   low   rolling   resistance   tyres   (for   example:   MICHELIN   Energy   Saver).
.../2:
 

model   fitted   with   very   low   rolling   resistance   tyres.
Diesel engine
HDi 90HDi 90 FAP BlueHDi 100 e-HDi 115
Gearbox Manual
(5 - speed) Manual
(5 - speed) Manual
(5 - speed) Manual
(6- speed) ETG6
Electronic (6- speed)
Model code:
NC... 9HJC

9HJC/1 9HP0BHY6
BHY6/1
BHY6/2S 9HD8/S

9HD8/1S
9HD8/2S 9HD8/1PS

9HD8/ 2PS
Cubic   capacity   (cc)
1   560
1   560
1   560
1   560
Bore   x   stroke   (mm)
75   x   88.3 75   x   88.3 75   x   88.3
75   x   88.3
Max   power*:   EU   standard   (kW)
6868 73 84
Max   power   engine   speed   (rpm)
4 0004 000 3   750
3   600
Max   torque:   EU   standard   (Nm)
230230254 270
Max   torque   engine   speed   (rpm)
1   750
1   750
1   750
1   750
Fuel
die
sel
die
sel
die
sel
die
sel
Catalytic converter Ye sYe sYe s Ye s
Particle   filter   (FAP)
n
o
Ye s Ye s Ye s
Engine oil capacity (in litres) 3.753.753.75 3.75
12
Technical data

280
C4-2_en_Chap12_caracteristique_ed01-2015
C4-2_en_Chap12_caracteristique_ed01-2015
* The maximum power corresponds to the value type-approved on a test bed, under conditions defined in European legislation (Directive 1999/99/EC).
. ../S:
 
model   fitted   with   Stop   &   Start.
.../1:
 

model   fitted   with   low   rolling   resistance   tyres   (for   example:   MICHELIN   Energy   Saver).
.../2:
 

model   fitted   with   very   low   rolling   resistance   tyres.
Diesel engine
BlueHDi 115BlueHDi 120HDi 150 FAPBlueHDi 150
Gearbox Manual
(6- speed) E AT 6
Automatic (6- speed) Manual
(6- speed) E AT 6
Automatic (6- speed) Manual
(6- speed) E AT 6
Automatic (6- speed)
Model code:
NC... BHXM/S
BHXM/1S
BHXM/2S BHX T/S
BHX T/1S
BHX T/2S BHZM/S
BHZM/1S
BHZM/2S BHZT/S
BHZ T/1S
BHZT/2S RHE8

RHE8/1 AHRM/S
AHRM/1S
AHRM/2S
Cubic   capacity   (cc)
1   560
1   560
1   997
1   997
Bore   x   stroke   (mm)
75   x   88.3
75   x   88.3
85   x   88 85   x   88
Max   power*:   EU   standard   (kW)
858811 011 0
Max   power   engine   speed   (rpm)
3   500
3   500
3   750
4 000
Max   torque:   EU   standard   (Nm)
300300340370
Max   torque   engine   speed   (rpm)
1   750
1   750
2 000 2 000
Fuel
die
sel
die
sel
die
sel
die
sel
Catalytic converter Ye sYe sYe sYe s
Particle   filter   (FAP)
Ye sYe sYe sYe s
Engine oil capacity (in litres) 3.753.755.256 .1
Technical data

04
C4-2_en_Chap13b_SMEGplus_ed01-2015
C4-2_en_Chap13b_SMEGplus_ed01-2015
Preset a station
Press on "Preset".
Select   a   radio   station   or   frequency
(refer   to   the   corresponding   section).
Select   a   number   in   the   list   to   preset   the  
previously

  chosen   radio   station.
A
 

long   press   on   a   number   presets   (memorises)  
the

  station.
o

r
a press on this button presets all of the stations
one

  after   the   other.
Recall pre-set stations
Press on Media
  to   display   the   primary   page  
then select "

Save".
RADIO
302

04
305
C4-2_en_Chap13b_SMEGplus_ed01-2015
C4-2_en_Chap13b_SMEGplus_ed01-2015
RADIO
If "DAB / FM auto tracking" is activated, there is a difference of a few  seconds   when   the   system   switches   to   "FM"   analogue   radio   with  
sometimes

  a   variation   in   volume.
When
  the   digital   signal   is   restored,   the   system   automatically  
changes

  back   to   "DAB".
Select
 
change
 
of
 
source.
Press on Media
 
to
 
display
 
the
 
primary
 
page.
Select "DAB Radio".
Select "List"
 
in
 
the
 
primary
 
page.
or
Select "Radio list"
 
in
 
the
 
secondary
 
page.
Select
 
the
 
radio
 
station
 
from
 
the
 
list
 
offered.
Digital
 
radio
 
provides
 
higher
 
quality
 
reception
 
and
 
also
 
the
 
graphical

 
display
 
of
 
current
 
information
 
on
 
the
 
radio
 
station
 
being
 
listened

 
to.
 
Select
 
"List"
 
in
 
the
 
primary
 
page.
The
 
range
 
of
 
multiplexes
 
available
 
is
 
displayed
 
in
 
alphabetical
 
order

.
Press Media  to   display   the   primary   page   then  
press

  on   the   secondary   page.
Select "Settings".
Select "RADIO".
Select "Digital/FM auto tracking " then
"Confirm". "DAB"   does   not   cover   100%   of   the   territory.
When   the   digital   radio   signal   is   weak,   "DAB / FM   auto   tracking"  
allows

  you   to   continue   listening   to   the   same   station,   by  
automatically

  switching   to   the   corresponding   "FM"   analogue  
station

  (if   there   is   one).
If   the   "DAB"   station   being   listened   to   is   not   available   on   "FM"   ("DAB/
FM"
  option   greyed   out),   or   "DAB / FM   auto   tracking"   is   not   activated,  
the

  sound   will   cut   out   while   the   digital   signal   is   too   weak.
Digital radio - DAB / FM auto tracking
DAB (Digital Audio Broadcasting)
Digital radio