maintenance Citroen C4 2015 2.G Owner's Manual

9
C4-2_en_Chap00b_vue-ensemble_ed01-2015
C4-2_en_Chap00b_vue-ensemble_ed01-2015
Technical data - Maintenance
Running out of Diesel fuel 211
Checking   levels  
2
15 -218
-
oil
-
 
b
rake   fluid
-


coolant
-
 
p
ower   steering   fluid
-
 
s
creenwash   /   headlamp   wash   fluid
-
 
a
dditive   (Diesel   with   particle  
e

missions
 f
ilter)
AdBlue
  additive  
2
21-228
Changing
 bu

lbs
 2
42-250
-
front
-
rear Petrol
  engines  
2
75 -278
Diesel   engines  
2
79 -284
Dimensions
 2
85
Identification
 ma
rkings
 2
86
bo

nnet

212
Petrol
  underbonnet  
2
13
di

esel underbonnet
2
14Checking
 c

omponents
 2
19-220
-


battery
-
 a

ir   filter   /   passenger   compartment   filter
-

o
il filter
-
 
p
article   filter   (Diesel)
-
 
b
rake   pads   /   discs
Battery 2
56-259
Energy   economy   mode  2 60
Engine
 c
ompartment
 
f

uses
25
1-252, 255
.
over view

11
C4-2_en_Chap00c_eco-conduite_ed01-2015
C4-2_en_Chap00c_eco-conduite_ed01-2015
Limit the causes of excess consumption
Spread loads throughout the vehicle; place the heaviest items in the bottom   of   the   boot,   as   close   as   possible   to   the   rear   seats.
Limit
  the   loads   carried   in   the   vehicle   and   reduce   wind   resistance   (roof  
b

ars,   roof   rack,   bicycle   carrier,   trailer...).   Use   a   roof   box   in   preference.
Remove
  roof   bars   and   roof   racks   after   use.
At
  the   end   of   winter,   remove   snow   tyres   and   refit   your   summer   tyres.
Observe the recommendations on maintenance
Check the tyre pressures regularly, when cold, referring to the label in the   door   aperture,   driver's   side.
Carry
  out   this   check   in   particular:
-
 
b
efore   a   long   journey,
-
 
a
t   each   change   of   season,
-
 
a
fter   a   long   period   out   of   use.
Don't
  forget   the   spare   wheel   and   the   tyres   on   any   trailer   or   caravan.
Have
  your   vehicle   serviced   regularly   (engine   oil,   oil   filter,   air   filter,  
p

assenger   compartment   filter...)   and   observe   the   schedule   of  
o

perations   recommended   in   the   manufacturer's   service   schedule.
With
  a   BlueHDi   Diesel   engine,   if   the   SCR   system   is   faulty   your   vehicle  
b

ecomes   polluting;   go   to   a   CITROËN   dealer   or   a   qualified   workshop  
w

ithout   delay   to   have   the   emissions   of   nitrous   oxides   brought   back   to  
t

he   legal   level.
When
  refuelling,   do   not   continue   after   the   third   cut-off   of   the   nozzle   to  
a

void   any   over flow.
At
  the   wheel   of   your   new   vehicle,   it   is   only   after   the   first   1   800   miles  
(

3 000   kilometres)   that   you   will   see   the   fuel   consumption   settle   down   to  
a

  consistent   average.
.
Eco-driving

80
C4-2_en_Chap04_confort_ed01-2015
C4-2_en_Chap04_confort_ed01-2015
Stop & Start
The heating and air conditioning systems   only   work   when   the   engine  
i

s   running.   To   maintain   a   comfortable  
t

emperature   in   the   passenger  
c

ompartment,   you   can   temporarily  
d

eactivate   the   Stop   &   Start   system   (see  
t

he   corresponding   section).
In
 
order
 
for
 
these
 
systems
 
to
 
be
 
fully
 
effective,
 
follow
 
the
 
operation
 
and
 
maintenance
 
g

uidelines
 belo

w:
F
 
T

o
 
obtain
 
an
 
even
 
air
 
distribution,
 
take
 
care
 
not
 
to
 
obstruct
 
the
 
exterior
 
air
 
intake
 
grilles
 
l

ocated at the base of the windscreen, the nozzles, the vents and the air outlets, as well
as
 
the
 
air
 
extractor
 
located
 
in
 
the
 
boot.
F
 
D

o
 
not
 
cover
 
the
 
sunshine
 
sensor,
 
located
 
on
 
the
 
dashboard;
 
this
 
is
 
used
 
for
 
regulation
 
o

f
 
the
 
air
 
conditioning
 
system.
F
 
O

perate
 
the
 
air
 
conditioning
 
system
 
for
 
at
 
least
 
5
 
to
 
10
 
minutes,
 
once
 
or
 
twice
 
a
 
month
 
t

o
 
keep
 
it
 
in
 
per fect
 
working
 
order.
F
 
E

nsure
 
that
 
the
 
passenger
 
compartment
 
filter
 
is
 
in
 
good
 
condition
 
and
 
have
 
the
 
filter
 
e

lements
 
replaced
 
regularly.
  W

e
 
recommend
 
the
 
use
 
of
 
a
 
combined
 
passenger
 
compartment
 
filter.
 
Thanks
 
to
 
its
 
s

pecial active additive, it contributes to the purification of the air breathed by the
occupants
 
and
 
the
 
cleanliness
 
of
 
the
 
passenger
 
compartment
 
(reduction
 
of
 
allergic
 
s

ymptoms,
 
bad
 
odours
 
and
 
greasy
 
deposits).
F
 
T

o
 
ensure
 
correct
 
operation
 
of
 
the
 
air
 
conditioning
 
system,
 
you
 
are
 
also
 
advised
 
to
 
have
 
i

t
 
checked
 
regularly
 
as
 
recommended
 
in
 
the
 
maintenance
 
and
 
warranty
 
guide.
F
 
I

f
 
the
 
system
 
does
 
not
 
produce
 
cold
 
air,
 
switch
 
it
 
off
 
and
 
contact
 
a
 
CITROËN
 
dealer
 
or
 
a
 
q

ualified
 w

orkshop.
When
 
towing
 
the
 
maximum
 
load
 
on
 
a
 
steep
 
gradient
 
in
 
high
 
temperatures,
 
switching
 
off
 
the
 a
ir
 
conditioning
 
increases
 
the
 
available
 
engine
 
power
 
and
 
so
 
improves
 
the
 
towing
 
ability. The condensation created by the air
conditioning
  results   in   a   discharge  
o

f water under the vehicle which is
per fectly   normal.
If   after   an   extended   stop   in   sunshine,  
t

he   interior   temperature   is   very  
h

igh,   first   ventilate   the   passenger  
c

ompartment   for   a   few   moments.
Put   the   air   flow   control   at   a   setting   high  
e

nough   to   quickly   change   the   air   in   the  
p

assenger
 c
ompartment.
The   air   conditioning   system   does   not  
c

ontain chlorine and does not present
any   danger   to   the   ozone   layer.
Recommendations for ventilation and air conditioning
Comfort

184
C4-2_en_Chap09_conduite_ed01-2015
C4-2_en_Chap09_conduite_ed01-2015
Moving off
A message is displayed if you try to move   the   gear   lever   from   position   P to
another
  position   without   pressing   the  
b

rake
 ped
al. F

Sel
ect position D for automatic
 c
hanging
 o

f   the   six   gears.
The   gearbox   then   operates   in   auto-adaptive  
m

ode,   without   any   intervention   on   the   part  
o

f   the   driver.   It   continuously   selects   the   most  
s

uitable   gear   according   to   the   style   of   driving,  
t

he profile of the road and the load in the
vehicle.
For   maximum   acceleration   without   touching  
t

he lever, press the accelerator pedal down
fully   (kick   down).   The   gearbox   changes   down  
a

utomatically   or   maintains   the   gear   selected  
u

ntil   the   maximum   engine   speed   is   reached.
On   braking,   the   gearbox   changes   down  a
utomatically   to   provide   efficient   engine  b
raking.
If you release the accelerator sharply, the
gearbox
  will   not   change   to   a   higher   gear   for  
s

afety   reasons.
When
  the   engine   is   running   at   idle,   with  
t

he   brakes   released,   if   position   R
, D or
M   is   selected,   the   vehicle   moves   even  
w

ithout   the   accelerator   being   pressed.
When   the   engine   is   running,   never  
l

eave children in the vehicle without
supervision.
When   carrying   out   maintenance   with  
t

he   engine   running,   apply   the   parking  
b

rake   and   select   position   P
.
ne

ver select position N while the
vehicle
  is   moving.
ne

ver select positions P or R unless the
vehicle
  is   completely   stationary.
If position N
 
is
 
engaged
 
inadvertently
 
w

hile
 
driving,
 
allow
 
the
 
engine
 
to
 
r

eturn
 
to
 
idle
 
then
 
engage
 
position
 
D to
accelerate.
F
 
W

ith
 
your
 
foot
 
on
 
the
 
brake,
 
select
 
p

osition


P or N
.
F
 
S

tart
 
the
 
engine.
If this procedure is not followed, there is an
audible
 
signal,
 
accompanied
 
by
 
a
 
message
 
in
 
t

he
 
multifunction
 
screen.
F
 
W

ith
 
the
 
engine
 
running,
 
press
 
the
 
brake
 
ped

al.
F
 
R

elease
 
the
 
parking
 
brake,
 
unless
 
it
 
is
 
p

rogrammed
 
to
 
automatic
 
mode.
F

Sel

ect position R
, D or M,
F
 
G

radually
 
release
 
the
 
brake
 
pedal.
The
 
vehicle
 
moves
 
off
 
immediately.
Automatic operation
Driving

194
C4-2_en_Chap09_conduite_ed01-2015
C4-2_en_Chap09_conduite_ed01-2015
Maintenance
In the event of a malfunction with the system, the "ECO OFF"   switch   warning   lamp   flashes,  
t

hen   comes   on   continuously.
Ha

ve   it   checked   by   a   CITROËN   dealer   or   a  
q

ualified
 w
orkshop.
Operating fault
This system requires a specific battery with a special   specification   and   technology   (reference  
n

umbers   available   from   a   CITROËN   dealer   or   a  
q

ualified
 w
orkshop).
Fitting
  a   battery   not   listed   by  
C

ITROËN introduces   the   risk   of   malfunction   of  
t

he   system.Before
  doing   anything   under   the  
b

onnet, deactivate the Stop & Start
system   to   avoid   any   risk   of   injury  
r

esulting   from   automatic   operation   of  
S

TART   mode.
The   Stop   &   Start   system   makes   use  
o

f   advanced   technology.   All   work   on  
t

his   type   of   battery   must   be   done   only  
b

y   a   CITROËN   dealer   or   a   qualified  
w

orkshop.
In
 
the
 
event
 
of
 
a
 
fault
 
in
 
STOP
 
mode,
 
the
 v

ehicle
 
may
 
stall.
 
All
 
of
 
the
 
instrument
 p

anel
 
warning
 
lamps
 
come
 
on.
Depending
 
on
 
version,
 
an
 
alert
 
m

essage
 
may
 
also
 
be
 
displayed
 
asking
 
y

ou
 
to
 
put
 
the
 
gear
 
lever
 
into
 
position
 
N
and
 
put
 
your
 
foot
 
on
 
the
 
brake
 
pedal.
It is then necessary to switch off the
ignition,
 
then
 
restart
 
the
 
engine
 
using
 
t

he
 
key
 
or
 
the
 
"START/STOP"
 
button.
Reactivation
The system is reactivated automatically a t   every   new   start   using   the   key   or   the  
"

START/STOP"   button.
Press the "ECO OFF"
  switch   again.
The
 
system   is   active   again;   this   is   confirmed  
b

y
 
the
  switch   warning   lamp   going   off   and   the  
d

isplay   of   a   message.
Driving

219
C4-2_en_Chap10_verification_ed01-2015
C4-2_en_Chap10_verification_ed01-2015
Checks
Particle filter (Diesel)
- fixed  illumination   of   the   particle  f
ilter   warning   lamp,   accompanied  
b

y   an   audible   signal   and   a  
m

essage   that   there   is   a   risk   of  
b

lockage   of   the   particle   filter.
The presence of this label, in particular with
the
 
Stop
 
&
 
Start
 
system,
 
indicates
 
the
 
use
 
of
 
a s

pecific 12 V lead-acid battery with special
technology
 
and
 
specification.
 
The
 
involvement
 
o

f
 
a
 
CITROËN
 
dealer
 
or
 
a
 
qualified
 
workshop
 
i

s
 
essential
 
when
 
replacing
 
or
 
disconnecting
 
t

he
 
battery. As
 
soon
 
as   the   traffic   conditions   permit,  
r

egenerate   the   filter   by   driving   at   a   speed   of   at  
l

east
 
40
 
mph   (60   km/h)   until   the   warning   lamp  
g

oes
 
off.
If
 
the
 
warning   lamp   stays   on,   refer   to   the  
"

Additive
 
level"   section.
Unless
 
other wise
 
indicated,
 
check
 
these
 
components
 
in
 
accordance
 
with
 
the
 
manufacturer's
 
service
 
schedule
 
and   according   to   your   engine.
Other wise,
 
have
 
them
 
checked
 
by
 
a
 
CITROËN
 
dealer
 
or
 
a
 
qualified
 
workshop.
Air filter and passenger compartment filter
Refer to the manufacturer's s
ervice schedule for details of the
replacement
  intervals   for   these  
c

omponents.
Oil filter
Replace the oil filter each time the e ngine   oil   is   changed.
Refer
  to   the   manufacturer's  
s

ervice schedule for details of
the
  replacement   interval   for   this  
c

omponent.
12 V battery
The battery does not require any maintenance.
H owever,   check   that   the   terminals   are   clean a

nd   correctly   tightened,   particularly   in   summer
 a

nd   winter.
When carrying out work on the battery, refer to the "12 V battery" section for details of the
precautions
  to   be   taken   before   disconnecting  
t

he   battery   and   following   its   reconnection.Depending
  on   the   environment   (e.g.   dusty  a
tmosphere)   and   the   use   of   the   vehicle  
(e.g.
  city   driving),   replace them twice as often
if necessary .
A
  clogged   passenger   compartment   filter   may  
h

ave   an   adverse   effect   on   the   per formance  
o

f   the   air   conditioning   system   and   generate  
u

ndesirable
 o
dours.The start of saturation of the particle filter is
indicated
  by:
on a n

ew vehicle, the first operations of
regeneration
  of   the   particle   filter   may   be  
a

ccompanied   by   the   smell   of   "burning",  
w

hich   is   per fectly   normal.
Following
  prolonged   operation   of   the  
v

ehicle at very low speed or at idle,
you
  may,   in   exceptional   circumstances,  
n

otice   the   emission   of   water   vapour   at  
t

he   exhaust   on   acceleration.   This   does  
n

ot affect the behaviour of the vehicle
or
  the   environment.
10
Checks

220
C4-2_en_Chap10_verification_ed01-2015
C4-2_en_Chap10_verification_ed01-2015
Automatic
gearbox
The gearbox does not require any maintenance   (no   oil   change).
Refer
  to   the   manufacturer's  
s

ervice schedule for details of
the
  level   checking   interval   for   this  
c

omponent.
Electric parking
brake
This system does not require any routine   servicing.   However,   in  
t

he   event   of   a   problem,   have   the  
s

ystem   checked   by   a   CITROËN  
d

ealer   or   a   qualified   workshop.
Manual parking
brake
If a loss of effectiveness of this
system
 i s  n oticed,  t he  p arking  b rake  
m

ust   be   checked,   even   between  
t

wo   services.
Brake pads
Brake wear depends on the style of   driving,   particularly   in   the   case  
o

f vehicles used in town, over short
distances.
  It   may   be   necessary   to  
Brake disc
wear
For information on checking brake disc wear, contact a CITRoËn
dealer
  or   a   qualified   workshop.For
  more   information,   refer   to   the   "Electric
 p

arking   brake   -   Operating   faults"   section.
Manual gearbox
The gearbox does not require any m
aintenance   (no   oil   change).
Refer
  to   the   manufacturer's   service  
s

chedule   for   the   checking   interval  
f

or   this   component.
Electronic gearbox
The gearbox does not require any maintenance   (no   oil   change).
Refer
  to   the   manufacturer's   service  
s

chedule   for   details   of   the   checking  
i

nterval   for   this   component. Only
  use   products   recommended   by  
C

ITROËN   or   products   of   equivalent  
q

uality
 an
d
 sp
ecification.
In
  order   to   optimise   the   operation   of  
u

nits   as   important   as   those   in   the  
b

raking   system,   CITROËN   selects   and  
o

ffers   very   specific   products.
After
  washing   the   vehicle,   dampness,  
o

r   in   wintry   conditions,   ice   can   form  
o

n   the   brake   discs   and   pads:   braking  
e

fficiency   may   be   reduced.   Make   light  
b

rake   applications   to   dry   and   defrost  
t

he   brakes.
have
  the   condition   of   the   brakes   checked,   even  
b

etween
 v
ehicle
 s
ervices.
Unless   there   is   a   leak   in   the   circuit,   a   drop   in  
t

he   brake   fluid   level   indicates   that   the   brake  
p

ads   are   worn.
Checking   this   system   must   be   done   by   a  
C

ITROËN   dealer   or   a   qualified   workshop.
Checks

271
C4-2_en_Chap11_info-pratique_ed01-2015
C4-2_en_Chap11_info-pratique_ed01-2015
Maintenance
Correct operation is only possible if the towball
and  its   carrier   remain   clean.
Before
  cleaning   the   vehicle   with   a   high  
p

ressure   jet   wash,   the   towbar   harness   socket  
c

arrier   must   be   folded   away,   the   towball  
r

emoved   and   the   blanking   plug   inserted   in   the  
c

a r r i e r.
For
  any   work   on   the   towbar,   got   to   a   CITROËN  
d

ealer   or   a   qualified   workshop.
Refit the protective cover for the ball and the
protective
 
cover
 
for
 
the
 
locking
 
wheel.
Stow
 
the
 
towball
 
in
 
its
 
bag.
Refit
 
the
 
protective
 
blanking
 
plug
 
to
 
the
 
carrier.
Grasp
 
the
 
towball
 
firmly
 
with
 
one
 
hand;
 
with
 
t

he
 
other
 
hand,
 
press
 
and
 
turn
 
the
 
locking
 
w

heel clockwise
 
as
 
far
 
as
 
it
 
will
 
go.
Extract
 
the
 
towball
 
downward.
Be
 
ready
 
for
 
the
 
weight
 
of
 
the
 
towball
 
(

around
 
3.5
 
kg).
 
Risk
 
of
 
injury!
11
Practical information

274
C4-2_en_Chap11_info-pratique_ed01-2015
C4-2_en_Chap11_info-pratique_ed01-2015
"Multimedia":
audio systems, steering mounted audio controls,   speakers,   Hi-Fi   module,   Bluetooth  
h

ands-free   system,   portable   satellite   navigation  
s

ystem,   semi-integral   support   bracket   for  
p

ortable   navigation   system,   mapping   update  
C

D,   driving   assistant,   portable   video   screen,  
p

ortable   video   support   bracket,   230 V/50 Hz  
s

ocket,   230   V/50   Hz   adaptor,   iPhone
®
compatible
 
mobile
 
phone
 
charger,
 
mobile  
p

hone/smartphone
 
bracket,
 
Wi-Fi
 
on
 
board...
By
  going   to   a   CITROËN dealer,   you   can   also  
o

btain   cleaning   and   maintenance   products  
(

interior   and   exterior) - including   ecological  
p

roducts   in   the   "TECHNATURE"   range   -,  
p

roducts   for   topping   up   (screenwash...),   touch-
up
  pens   and   paint   aerosols   for   the   exact   colour  
o

f   your   vehicle,   recharges   (cartridge   for   the  
t

emporary   puncture   repair   kit...),   ...
Installation of radio
communication
transmitters
Before installing any after-market radio communication   transmitter,   you   can  
c

ontact a CITR
oËn
dealer for the
specification
  of   transmitters   which   can  
b

e   fitted   (frequency,   maximum   power,  
a

erial position, specific installation
requirements),
  in   line   with   the   Vehicle  
E

lectromagnetic
 C
ompatibility
 D

irective (2004/104/EC). The
  fitting   of   electrical   equipment   or
 a

ccessories   which   are   not   recommended
 b

y   CITROËN   may   result   in   a   failure   of
 y

our   vehicle's   electronic   system   and
 e

xcessive   electrical   consumption.
Contact a CITR
oËn

dealer
for
  information   on   the   range   of
 r

ecommended   equipment   and
 
 a

ccessories.
Depending
  on   the   legislation   in   force   in  
t

he   country,   certain   safety   equipment  
m

ay   be   compulsory:   high   visibility  s
afety   vests,   warning   triangles,  b
reathalyzers, spare bulbs, spare fuses,
fire
  extinguisher,   first   aid   kit,   mud   flaps  
a

t   the   rear   of   the   vehicle.
Practical information

396
C4-2_en_Chap14_index-alpha_ed01-2015
C4-2_en_Chap14_index-alpha_ed01-2015
Paint colour code .........................................28 6
Panoramic   glass  
sunroof
 ................

......................................... 78
Parcel shelf, rear
 ................................... 11

4 ,
 11
7
Parking
  brake  
........................................1
77,   220
Parking
  brake,   electric  
............................1
8,   170
Parking
 lam

ps
 .............................................. 12

2
Parking
  sensors,   front  
..................................20

6
Parking
  sensors,   rear................................... 205
Particle filter
 .......................................... 21

8,
 21
9
Passenger
 c

ompartment
 
f

ilter
 ........
..................................................... 219
Personalisation
 ...............................

...............36
Player,
  CD   MP3  
............................ 3
06,   369,   370
Port,
  USB  
..................................... 1
03,   306,   371
Priming
  the   fuel   system  
................................2

11
Protecting
  children  
................. 1
35 -149,   157,   159
Puncture
 ................

....................................... 229Quickly
  detachable   towball  
..........................
2
67
P
Navigation ...............................
......................312 N
umber   plate   lamps  ..................................... 25
0
oil
filter
 ...............
...........................................
219
oi
l level
................................................... 29,   215
Opening   the   bonnet  
......................................
2
12
Opening   the   boot  
..............................
. 59,   72,   73
Opening   the   doors  
...............................
.... 59,   71
Opening   the   panoramic  
sunroof blind
 ................................................ 78ope
ration indicator
lamps
 ..............................
........................
16 -28
N
Main beam .............................. ......118,   242,   245
Maintenance .............................. ....................10
Map
  reading   lamps  
...................................... 13

3
Markings,
 id

entification
 ................................ 28

6
Massage
  function   
...............................
...........94
Mat
 .......

......................................................... 11 0
Memorising
  a   speed  
.................................... 19

9
Menu
 ....................................2

94,   296,   298,   312,
314,
  316,   332,   342,   344
Menu,
  main  
..............................
....................362
Menus (Touch
  screen   tablet)  
.................................29

0
Mirror, rear view
 
........................................... 10

0
Mirrors, door ..................................... 98,
  99,   196
Misfuel prevention
 ...............................

.........210
Motorway function (direction
 i

ndicators)
 .................................. 15

0
Mountings
  for   ISOFIX  
seats
 ...............

........................................... 14 4
MP3
  CD  
................
........................ 306,   369,   370 Radio
 ...............

..................................... 300,   363
Radio
 pr

e-equipment
 ...................................2

72
R
dS ................

...................................... 303,   364
Rear
 s

creen
 (
demisting)
 .................................90
R

echarging   the   battery  
........................ 2
58,   259
Reduction of electrical load
 ......................... 26

0
Regeneration
  of   the   particle  
emissions
 f

ilter
 ............................................2

19
Reinitialising
  the   electric  
windows
 ....................................................... 76
R

einitialising   the   remote  
control
 .................................................... 5

8,   63
Remote
  control  
..........................................53

-64
Removable
  screen   (snow   shield).................262
Removing
  a   wheel  
..............................
.........237
Removing
  the   mat  
...............................
..........11 0
Repair
  kit,   puncture  
......................................2

29
Replacing
 bu

lbs
 ..............................
......242-250
Replacing
 f

uses
 ..............................
......251-255
Replacing
  the   air   filter  
...................................2

19
Replacing
  the   oil   filter  
...................................2

19
Replacing
 t

he
 p
assenger
 
c

ompartment   filter  
......................................2

19
Replacing
  wiper   blades.........................131,   261
Resetting
  the   service   indicator  
......................32
R

esetting   the   trip   recorder  
.............................33
R

ev counter
 ................................................1

2-15
R
Oil change .....................................................215
Oil   consumption  ............................................ 2
15
O
QM
alphabetical index