fuel pump Citroen JUMPY 2016 2.G Owner's Manual

10
Jumpy _en_Chap00b_vue-ensemble_ed01-2016
Maintenance - Technical data
Dimensions 328-331
Identification markings 3 37
Running out of fuel
(priming pump)

3

27
Checking levels

2

78 -280
-

oil
-

b

rake fluid
-

p

ower steering fluid
-


coolant
-
s

creenwash, headlamp wash fluid
-

a

dditive (Diesel with particle filter)
Checking components
2

81-282
-


battery
-

a

ir / passenger compartment filter
-

o

il filter
-

p

article filter
-

b

rake pads / discs
Changing bulbs
3

03-315
-

front
-

rear
Platform cab
Changing rear lamp bulbs 3
15
Dimension 3 31 12V battery

3
21-325
Opening the bonnet
2
76
Under the bonnet 2 77
Engines 3 32-336
AdBlue® 28 3-286Weights
33
2-336
Load reduction, economy mode
2
70
Engine compartment
fuses
3
16 -317, 320
Over view

265
Jumpy _en_Chap07_info-pratiques_ed01-2016
Fuel tank
Opening
If your vehicle is fitted with Stop & Start,
never refuel with the engine in STOP
mode; you must switch off the ignition
using the key, or the START/STOP
button if your vehicle has Keyless Entry
and Starting.
F

Y

ou must switch off the engine.
F

I

f your vehicle has Keyless Entry and
Starting, unlock the vehicle.
F

O

pen the filler flap.
Refuelling
Additions of fuel must be of at least 8 litres to
be registered by the fuel gauge.
Opening the filler cap may result in an inrush of
air. This vacuum is entirely normal and results
from the sealing of the fuel system.
F

R
emove the filler cap by unscrewing it,
then place it on the carrier located on the
filler flap.
F

I
ntroduce the nozzle and push it in fully
(pushing on the metal non-return valve A ).
F

F
ill the tank. Do not continue past the third
cut-off of the nozzle, as this may cause
malfunctions.
F

R
efit the filler cap turning it to the right.
F

P
ush the filler flap to close it (your vehicle
must be unlocked).
F

T
ake care to select the pump that delivers
the correct fuel type for your vehicle's
engine (reminder on a label on the inside of
the filler flap).
Capacity of the tank: approximately 69
litres.
F
I
f your vehicle has a conventional key,
introduce the key into the filler cap, then
turn it to the left.
7
Practical information

267
Jumpy _en_Chap07_info-pratiques_ed01-2016
Fuel used for Diesel
engines
The Diesel engines are compatible with
biofuels that conform to current and future
European standards and and can be obtained
from filling stations:The use of B20 or B30 fuel
meeting standard EN16709
is possible in your Diesel
engine. However, this use,
even occasional, requires
strict application of the special
servicing conditions referred to
as "Arduous conditions".
For more information, contact a
CITROËN dealer or a qualified
workshop.
It is still possible to use a fuel can to fill
the tank but this must be done slowly.
In order to ensure a good flow of fuel,
do not place the nozzle of the fuel can
in direct contact with the flap of the
misfuel prevention device.
Travelling abroad
As Diesel fuel pump nozzles may be different
in other countries, the presence of the misfuel
prevention device may make refuelling
impossible.
Before travelling abroad, we recommend that
you check with the CITROËN dealer network,
whether your vehicle is suitable for the fuel
pumps in the country in which you want to
travel.
The use of any other type of (bio)
fuel (vegetable or animal oils, pure
or diluted, domestic fuel...) is strictly
prohibited (risk of damage to the engine
and fuel system).
The only Diesel additives authorised for
use are those that meet the B715000
standard.
-

D
iesel fuel that meets
standard EN590 mixed with
a biofuel that meets standard
EN14214 (possibly containing
up to 7 % Fatty Acid Methyl
Ester),
-

D
iesel fuel that meets
standard EN16734 mixed with
a biofuel that meets standard
EN14214 (possibly containing
up to 10 % Fatty Acid Methyl
Ester),
-

P
araffinic Diesel fuel that
meets standard EN15940
mixed with a biofuel that
meets standard EN14214
(possibly containing up to 7 %
Fatty Acid Methyl Ester).
7
Practical information

277
Jumpy _en_Chap07_info-pratiques_ed01-2016
* According to engine.
Diesel engine
1. Screenwash and headlamp wash reservoir.
2. Coolant header tank.
3.
E

ngine oil filler cap.
4.
E

ngine oil dipstick.
5.
P

riming pump*.
6.
B

rake fluid filler cap.
7.
B

attery.
8.
R

emote earth point ("-" terminal).
9.
F

usebox.
10.
P

ower steering fluid reservoir.
11.
A

ir filter. This engine is shown as an example. The locations of the engine oil dipstick and filler cap may vary.
The Diesel fuel system operates under
high pressure:
-

N
ever carry out any work on this
system yourself.
-

H
Di engines make use of advanced
technology.
All maintenance and repairs require
specially trained staff, which only a
CITROËN dealer can provide.
7
Practical information

327
Jumpy _en_Chap08_En-cas-de-panne_ed01-2016
On vehicles fitted with Diesel engines, the fuel
system must be primed if you run out of fuel.
For all versions other than BlueHDi, refer to the
corresponding engine compartment view.
Running out of fuel (Diesel)
For more information on Diesel misfuel
prevention, refer to the corresponding
section. F
A dd at least five litres of Diesel fuel to
the
tank.
F

O
pen the bonnet.
F

I
f necessary, unclip the styling cover for
access to the priming pump.
F

S
queeze and release the priming pump
repeatedly until resistance is felt (there
may be resistance at the first press).
F

O
perate the starter to start the engine
(if the engine does not start at the first
attempt, wait around 15 seconds before
trying again).
F

I
f the engine does not start after a few
attempts, operate the priming pump again
then start the engine.
F

R
efit the styling cover and clip it in place.
F

C
lose the bonnet.
1.6 HDi engine
(except BlueHDi)
If the engine does not start first time,
don't keep trying but start the procedure
again from the beginning.
BlueHDi engine
F Fill the fuel tank with at least five litres of Diesel.
F

S
witch on the ignition (without starting the
engine).
F

W
ait around 6 seconds and switch off the
ignition.
F

R
epeat the operation 10 times.
F

O
perate the starter to run the engine.
Other engines
F Add at least five litres of Diesel fuel to the tank.
F

O
pen the bonnet.
F

I
f necessary, unclip the styling cover for
access to the priming pump.
F

S
queeze and release the priming pump
repeatedly until resistance is felt (there
may be resistance at the first press).
F

O
perate the starter to start the engine
(if the engine does not start at the first
attempt, wait around 15 seconds before
trying again).
F

I
f the engine does not start after a few
attempts, operate the priming pump again
then start the engine.
F

R
efit the styling cover and clip it in place.
F

C
lose the bonnet.
8
In the event of a breakdown

509
Jumpy_en_Chap11_index-alpha_ed01-2016
Kit, puncture repair .......................................29 0
Kit, temporary puncture repair ............. 2 89, 290Maintenance, routine ......................................
12
M arkings, identification .................................3
37
Mat
.......

................................................. 119, 202
Memorising a speed

.....................................2

24
Menu
................... 3

52, 354, 356, 358, 360, 362,
370, 372, 374, 378, 384, 386, 388, 390, 392, 400, 402, 404, 412, 414, 416, 434, 440, 442,
444, 446, 448, 456, 458, 460, 468, 470, 472
Menu, main
..............................

.....................487
Menus (audio)

..............................
........ 345, 433
Messages
...............................

...............410 , 4 6 6
Messages, quick
................................... 4

11, 467
Mirror, rear view

............................................14

5
Mirrors, door ..................133, 134, 143, 144, 252
Mirror, vanity
..............................

...................11 9
Misfuel prevention
...............................

..........266
Moduwork ...................................................... 10 6
Mountings, Isofix
...............................

....186, 190
MP3 CD

................
.........................................494
Labels
................

...................................... 11, 11 6
Labels, identification
..................................... 3

37
Ladder
...............

............................................ 272
Lane Departure Warning System (LDWS)

............................2
9, 248, 249
Level, brake fluid

........................................... 2

79
Level, Diesel additive
............................2

80, 281
Level, engine coolant

.............................. 3
1, 279
Level, engine oil

...............................
.......34, 278
Level, headlamp wash
..........................1

58, 280
Level, power steering fluid

............................2

79
Levels and checks

..............................
..27 7-2 8 0
Level, screenwash fluid

........................1
58, 280
Lighting
................

....................................30, 146
Lighting, cornering
...............................

.........152
Lighting dimmer

..............................
................39
Lighting, guide-me home

..............................15

0
Lighting, welcome

......................................... 1

51
Loading
..............................

..................... 12, 273
Loading area fittings
..................................... 12

2
Load reduction mode
.................................... 2

70
Load restraint
................................................ 12

2
Localised Assistance Call
............................. 33

8
Locating your vehicle

................................5
2, 67
Locking
.................................... 5

0, 55, 57, 64, 71
Locking from the inside

.............................7
2, 73
Low fuel level

..............................
............20, 265
Lumbar
...............................

...........................10 0
L
M
Navigation ............3 52, 354, 356, 358, 360, 362
Navigation, connected .................. 3 70, 372, 374
Net, cargo...................................................... 10 6
Net, high load retaining

.................................12

3
Number plate lamps
.............................. 31

1, 314
N
Oil change .....................................................278
Oil consumption ............................................ 2
78
Oil, engine

...............................
......................278
On-board tools
...................................... 2

87, 289
Opening the bonnet

...................................... 2

76
Opening the boot

..............................
.. 47, 59, 94
Opening the doors

.......4
7, 59, 74, 78 - 81, 83, 93
Opening to 90/180/235°

..................................92
O

pening to 180°
...............................
...............91
Pads, brake
................................................... 28

2
Paint colour code

.......................................... 3

37
Parking brake

..................................1
8, 205, 282
Parking sensors, audible and visual
.................................................... 25

6
Parking sensors, front

...................................25

6
Parking sensors, rear............................255, 256
Plates, identification ...................................... 337
Platform cab
.......................................... 3

15, 332
Player, Apple
® .............................. 3 99, 455, 495
Player, MP3 CD ............................... ..............494
Player, USB

.................................. 3
98, 454, 492
Port, USB

............................. 1
22, 398, 454, 492
Pressures, tyres
................... 2

90, 295, 302, 337
Pre-tensioning seat belts

.............................. 16

9
Priming pump
...............................

.................327
Priming the fuel system

................................ 3

27
Profiles
.................................................. 4

18, 474
Protecting children

......................... 17

1, 174 -176 ,
182, 187, 188, 190, 193
Puncture
................

........................................ 290
O
P
.
Alphabetical index