headlamp DACIA SOLENZA 2004 User Guide

80
BATTERY - FRONT HEADLIGHTS
80 - 9
MEETING LIGHTS ADJUSTMENT (LOW BEAM)This is performed by acting upon the V screw
(vertically plane adjustment) or H (horizontally
p lane adjustment). By screwing, the lighting beam
is ”lowering” and by unscrewing is “ascending”. Check if the l ighted area is centered on the
vertical axis and if the optical separation at 15°
coincide with the headlamp lighting. An error of
1 cm is admissible. A lighting beam displaced towards left has
the aspect shown in (p icture a) and a lighting
beam displaced towards right has the aspect
shown in (picture b )
ROAD LIGHTS ADJUSTMENT (LONG BEAM)
Check the position to c oincide with the
adjustment pe rformed for low beam and with
the lighting beam distributed between the two
vertical lines on the panel
When checking the long beam, the lighting
center of t he ellipse, must be l ocated on t he
cross marking the screen center. If a m ajor de viation c ompared with t he low be am i s noticed, i t is re commended t he bul b
replacement, this one being in most of the cases, responsible for such defect.
Headlamps adjustment
H
V
figura a figura b
vnx.su

BATTERY - FRONT HEADLIGHTS
80
80 - 10
FOG P ROJECTORS ADJUSTMENT
The fog projectors adjustment is to be performed in the following conditions:
- the vehicle to be placed on a horizontal surface;
- the vehicle has not passengers inside the cockpit or weights in the trunk;
- the tires a re pressurized a t the manufacturer prescribed pressure.
Further on, proceed as follows:
Bring the vehicle at the working place.
Position the adjustment device (headlamp adjustment device –E) in front of an optical center
of a fog lamp. Switch on the fog projectors. Rotate the adjustment screw of the fog lamp (D), by means of
a scre wdriver ( A), so that a n adjustment of 2 % i s obtained and t he separation between t he
lighted area and the dark one from the adjustment device is l ocated under the marked line (G)
This adjustment is to be performed in the same way as for the meeting lights adjustment.
Bring the adjustment device in front of the optical center of the second fog lamp;
Perform the fog projector adjustment;
Switch off the fog projectors.
H eadlamps adjustment
G
E
A
vnx.su

80
BATTERY - FRONT HEADLIGHTS
80 - 11
Disconnect the (-) plug of the battery;
Dismount
the headlamp adjusting control from the turning lamp-headlamp assembly:
- pull backward the gasket of the headlamp adjustment corrector ( 1);
- detach from clips the protector (2) of the headlamp adjustment mechanism;
- loosen the locking nut ( 3);
- detach from clips the he adlamp adjustment control cable ( 4) from the headlamp
adjustment corrector and then from the fork (5);
Dismount the headlamp adjusting control from the other turning lamp-headlamp assembly .
Detach from clips the headlamp adjustment control cables and cut the attachment collars.
Dismount the headlamps adjustment control button.
Dismount the attachment nut of the headlamp adjustment control on the dashboard.
Dismount the bonnet opening control cable from the opening handle (see chapter 52).
Detach from clips, by means of a straight screwdriver, the cables passing bushing from the
cowl panel.
Remove the headlamps adjusting control cables from the cowl-passin g hole. Mark the mounting
position of the headlamps adjustment control cables.
REMOU NT I NG
Insert the headlamps adjusting control cables through the cowl-passing hole, observing the
existent position prior to dismounting.
Insert the bonnet opening control cable through the cables passing bushing.
DISMOUNTIN G1
2
V
56 34
Replacement of the headlamps mechanic adjustment control
vnx.su

BATTERY - FRONT HEADLIGHTS
80
80 - 12
Replacement of the headlamps mechanic adjustment control
Attach on the cowl panel, by means of clips, the cables passing bushing, ensuring the cockpit
co mpartment sealing against possible water drain along the cables passing bushing.
Mount the bonnet opening control cable in the opening handle (see chapter 52). Position the
headlamp s adjustment control on the dashboard.
Mount the attachment nut of the headlamps adjustment control on the dashboard.
Mo unt the headlamps adjustment control button and turn it in the position “3”.
Mount the headlamp adjustment control to a turning lamp-headlamp assembly :
-a ttach in clips by means of a straight screwdriver, the headlamp adjustment control cable
in fork (5) a n d t h en in the headlamp adjustment corrector;
- tighten initially the cable by hand till the fork ( 5) is in contact with support ( 6) so that fork
is remaining at max. 0.5 mm again st the support;
-block the headlamp adjustment cable by means of the nut ( 3);
-a ttach in clips the protector ( 2) o f t h e headlamp adjustment mechanism;
- position correctly the gasket of the headlamp adjustment corrector – the vertical adjustment
screw ( V) mu st come out through the gasket.
Mount the headlamp adjustment control of the other turning lamp-headlamp assembly.
Attach in the attachment points, by means of clips, the headlamps adjusting control cables,
replace and mount the attachment collars, observing the mounting position prior to the dismounting.
Keep a distance of approximate 40 mm
± 10 mm between the right cable and the cylinder
no .1 spark plug cable, in order to avoid the loses due to electric-magnetic induction.
Reconnect the battery ( -) term inal.
Switch on the headlamps and check the operation of the headlamps mechanic adjusting control.
The adju stment of the luminous spot dip of the headlamps in the downward sense of the vehicle
loading condition is to be performed by bringing the headlamps adjusting button in the “ 0” position
an d then in the desired condition.
REMA RK : The r equired tighteni ng moment of the attachment nut of th e headlamps
adju stment control on the dashboard: 2 Nm.
vnx.su

81
INSIDE AND REAR LIGHTING
81 - 5
Bulbs
BULBS
Headlamps High/low beam lights Bulb H4, 12V-60/55W Parking lights Bulb W5W, 12 V-5W
Front turning lamp Bulb PY21W, 12V-21W (colored)
F og projectors Halogen bulb H11, 12V-55W
Rear Parking, stop lights Bulb AB1, 12V-21/5W
lamps Turning lights Bulb PY21W, 12V-21W Rear fog lamp and reverse driving Bulb P21W 12V/21W
Rear side signalin g lamps Bulb WY5W 12V-5W
Ceiling lamp Bulb C5W, 12V-5W
License plate lamp Bulb W 5W, 12V-5W
Additional STOP lamp Bulb C21W, 12V/21W Sv8,5
Instrument panel Bulb12V, 2W (brown holder)
Bulb 12V, 1,2W (black holder)
Climate control panel Bulb 12V, 1,2 W
(black holder
vnx.su

89
ELECTRIC DIAGRAMS
89 - 8
Functional diagrams list index
Electric lighter
Alternator
Anti-theft system
Acoustic warning
Battery
Windscreen wiper timer
Injection computer (ECE)
Doors closing switch
Climate control panel
Hazard switch
Rear window defrosting switch
Left electric window switch
Right electric window switch
Turning signalling relay
Right rear door actuator
Left rear door actuator
Left front door actuator
Right front door actuator
Windscreen wiper-washer switch
Detona tion sensor
Atmospheric pressure sensor
RPM s ensor
Reverse driving contact
Handbrake contact
St op contact
Starte r
AC compressor clutch
Right rear lamp
Left rear lamp
Right fog headlight
Left fog headlight
Left front door contact
Right front parking lamp
Left front parking lamp
Cooling motor fan
Right rear loud speaker
Left rear loud speaker
Right front door loud speaker
Left front door loud speaker
Injector 1
Injector 2
Injector 3
Injector 4
Fuel lever transmitter and electric pump
Rear window defrosting
Electric left window actuator
Electric right window actuator
Oil pressure contact101
103
104
105
107
113
120
123
124
125
128
132
133
137
138
139
140
141
145
146
147
149
155
156
160
163
171
172
173
176
177
180
184
185
188
189
190
191
192
193
194
195
196
199
200
203
204
205
Code
Component denomination Code Component denomination209
212
213
221
222
224
225
226
227
231
234
236
238
242
244
247
255
256
261
262
267
268
272
319
320
321
326
333
371
462
503
584
597
639
649
654
700
756
778
857
887
899
927
101 6
109 1
114 0
115 6
120 2 Lights, turning lights and horn switch
Motor wi
ndscreen wiper
Ceiling lamp
Windscreen washing pump
Va l ve potentiometer
Power steering pressure controller
Diagnostic socket
Right headlamp
Left headlamp
Fog projectors control relay
Cooling motor fan control relay
Fuel pump control relay
Actuators relay
Downstream oxygen sensor
Injection water temperature sensor
DASHBOARD
Right front turning lamp
Left front turning lamp
Radio
Cooling motor fan and AC
Right side signalising lamp
Left side signalising lamp
Injection air temperature sensor
AC control panel
Cooling motor fan (for AC)
Motor fan resistance (for AC)
Speed limit indicator
Driver safety belt contact
Canister purging valve
License plate lamp
UCE decoder
AC compressor clutch control relay
Safety fuse box and engine compartment relays
STOP-S3 l amp
Step by step engine
Anti-starting bushing
Cooling blower low speed control relay
UCE airbag
Ignition coil
FLASH relay
Upstream oxygen sensor
Driver’s airbag
C hock sensor
Cockpit fuse box
I.C.P. braking system
V ehicle speed transducer
Cooling motor fan
AC pressure sensor (pressure controller)
vnx.su

89
ELECTRIC DIAGRAMS
89 - 19
INJECTOR 4
FU EL LEVEL TRANSMITTER AND ELECTRIC PUMP
REAR WINDOW DEFROSTING
ELECTRIC RIGHT WINDOW ACTUATOR
ELECTRIC LEFT WINDOW ACTUATOR
OIL PRESSUR E CONTAC T
LIGHTS, TU RNING LIGHTS, HORN SWITCH
WINDSCREEN WIPER MOTOR
CEIL ING LIGHT
WINDSCREEN WASHING PUMP
VALVE POTENTIOMETER
POWER ST EERING PRESSURE CONTROLLER
DIAGNOSTIC SOCKET
RIGHT HEADLAMP
LEFT HEADLAMP
FOG PROJ ECTORS C ONTROL R ELAY
DOWNSTREAM OXYGEN SENSOR
WA T E R T E MPERATURE SENSOR
INST RUMENT PANEL
RIGHT FRONT TURNING LAMP
LEFT FRONT TU RNING LAMP
RADIO
E NGINE COOLING FAN (for vehicles with AC)
RIGHT FRONT SIDE SIGNALING LAMP
LEFT FRONT SIDE SIGNALING LAMP
INJECTION AIR TEM PERATURE SENSOR
CLIMATE CONTROL PANEL W ITH AC
CLIMATE CONTROL BLOW ER (for AC vehicle equipment)
CLIMATE CONTROL FAN RESISTANCE ( for vehicles with AC)
SPEED LIMIT INDICATOR
DRIVER SAFETY BELT CONTACT
CANISTER PURGING VALVE
LICENSE PLATE LAMP
UCE DECODER
FUSE BOX AND ENGINE RELAYS (for vehicles without AC)
FUSE BOX AND ENGINE RELAYS (for vehicles with AC)
STOP -S3 LAMP (in aileron)
STEP-BY-ST EP ENGINE
ANTI-STARTING BUSHING
U.C.E. AIRBAG
I GNITION COIL
FLASH RELAY
UPSTREAM OXYGEN SENSOR
DRIVER’S AIRBAG
CHOCK SENSOR
COCKPIT FUSE BOX
196
199
200
203
204
205
209
212
213
221
222
224
225
226
227
231
242
244
247
255
256
261
262
267
268
272
319
320
321
326
333
371
462
503
597
597
639
649
654
756
778
857
887
899
927
1016 89-125
89-175
89-179
89-150
89-150
89-126
89-151
89-152
89-152
89-153
89-126
89-127
89-153
89-154
89-154
89-178
89-127
89-128
89-155
89-157
89-157
89-158
89-128
89-159
89-159
89-129
89-160
89-161
89-129
89-162
89-176
87-130
89-179
89-163
89-131
89-133
89-179
89-135
89-164
89-164
89-135
89-165
89-136
89-165
89-136
89-166

Index in connectors and couplings
vnx.su

89
ELECTRIC DIAGRAMS
89 - 62
FRONT WIRING – DASHBOARDX412
03
RIGHT HEADLAMP
LEFT HEADLAMP
10.6 MBM ASS
20.6 CPDRIGHT MEETI NG HEADLIGHTS
PROTECTED > OUTLET FUSE F09
30.6 RPDRIGHT ROAD LIGHTS
PROTECTED > OUTLET FUSE F11
Destination BA
N1
MB 2
X 3
RPD
CD8F
CPD
X
226
10.6MBMASS
20.6 CPGLEFT MEETING HEADLIGHTS
PROTECTED > OUTLET FUSE F08
30.6 RPGLEFT ROAD LIGHTS
PROTECTED > OUTLET F10
Destination BA
N1
MB 2
X3
RPG
CD8F
CPG
X
227
Wires functions in connectors and couplings
vnx.su

89
ELECTRIC DIAGRAMS
89 - 78
FRONT WIRING – DASHBOARDX412
03
LEFT FRONT BODY ELECTRIC MASS
1 5.0 MB MASS > FRONT SIDE SIGNALIZING L AMP
LEFT/RIGHT , WINDSCREEN WIPER PUM P, WINDSCREEN
WIPER MOTOR , CLIM ATE CONTROL FAN (PINS 14 and 1 5)
Position Section Destination
LEFT FRONT BODY ELECTRIC MASS
MB
NMB
1 2.0 MB MASS > RIGHT HEADLAMP, RIGHT FRONT PARKING LIGHT ,
FRONT RIGHT TURNING LAMP
1 2.0 MB MASS > LEFT HEADLAM P, LEFT FRONT PARKING LAMP,
FRONT LEFT TURNING LAMP
Position Section Destination
MB
N
NMB

Wires functions in connectors and couplings
vnx.su

89
ELECTRIC DIAGRAMS
89 - 8
Electric components index
Electric lighter
Alternator
Anti-theft system
Acoustic warning
Battery
Injection computer (ECE)
Doors closing switch
Climate control panel
Hazard switch
Rear window defrosting switch
Left electric window switch
Right electric window switch
Right rear door actuator
Left rear door actuator
Left front door actuator
Right front door actuator
Windscreen wiper-washer switch
Detona tion sensor
Atmospheric pressure sensor
RPM sensor
Reverse driving contact
Handbrake contact
St op contact
Starte r
AC compressor clutch
Right rear lamp
Left rear lamp
Right fog projector
Left fog projector
Left front door contact
Right front parking lamp
Left front parking lamp
Cooling motor fan
Right rear speaker
Left rear speaker
Right front door speaker
Left front door speaker
Injector 1
Injector 2
Injector 3
Injector 4
Rear window defrosting
Electric left window actuator
Electric right window actuator
Oil pressure contact101
103
104
105
107
120
123
124
125
128
132
133
138
139
140
141
145
146
147
149
155
156
160
163
171
172
173
176
177
180
184
185
188
189
190
191
192
193
194
195
196
200
203
204
205
CODE
COMPONENT DENOMINATION CODE COMPONENT DENOMINATION209
212
213
221
222
224
225
226
227
231
234
236
238
242
244
247
255
256
261
262
267
268
272
319
320
321
371
462
584
597
639
645
649
700
756
778
833
887
899
927
957
101 6
109 1
114 0
115 6
120 2 Lights, turning lights and horn switch
Windscreen wiper motor
Ceiling lamp
Windscreen washing pump
Va l
ve potentiometer
Power steering pressure controller
Diagnostic socket
Right headlamp
Left headlamp
Fog projectors control relay
Cooling motor fan control relay
Fuel pump control relay
Actuators relay
Downstream oxygen sensor
Injection water temperature sensor
Instrument panel
Right front turning lamp
Left front turning lamp
Radio
Cooling motor fan a nd air conditioning
Right side signalising lamp
Left side signalising lamp
Injection air temperature sensor
Climate control with AC panel
Cooling motor fan (for AC)
Motor fan resistance (for AC)
Canister purging valve
License plate lamp
AC compressor clutch control relay
Safety fuse box and engine compartment relays
STOP-S3 l amp
Cockpit UCE
Step by step engine
Cooling blower low speed control relay
UCE airbag
Ignition coil
Fuel level transmitter and electric pump
Upstream oxygen sensor
Driver airbag
C hock sensor
Anti-starting bushing
Cockpit fuse box
I.C.P. braking system
V ehicle speed transducer
Climate control blower (fan)
AC pressure sensor (pressure controller)
vnx.su