airbag DACIA SOLENZA 2004 Owner's Guide

88
WIRING
88 - 23
Diagnostic – Failure locating tree
Ensure t hat not CL IP tester i s the failure cause – try its communication with some ot her
vehicle UCE airbag. If CLIP tester is not the failure cause and the dialogue is not established
with no other computer of the same vehicle, it is possible that another damaged computer is
perturbing the diagnostic lines L and K.
Proceed by consecutive disconnection for damaged computer locating.
Check the battery voltage and perform the necessary interve ntions in order to obtain an
adequate vol tage, with the value between 10.5 volts and 15 volts.
Check the presence and condition of the supply fuse of UCE airbag.
Check the correct connection of the computer connector and the cables condition.
Check the computer correct supplying: -Disconnect UCE airbag then connect the 30 pins adapter B40.
- Check and ensure voltage presence be tween plugs marked mass and +DC (+ after
contact)
Check the correct supplying of the diagnostic socket: -supply + permanent at pin 16
- mass at pin 5
Check the continuity and insulation of the connection lines diagnostic socket / UCE airbag:
- plug 23 of UCE airba g pin 15 diagnostic socket (line L)
- plug 9 of UCE a irbag pin 7 di agnostic socket (line K)
If dialogue is not established after these checking, replace UCE airbag (see c hapter “UCE
airbag replacement) .
Missing dialog with the airbag computer.
ALP1
RECOMMENDATIONSCharacteristics : nothing to notice
AFTER
INTERVENTION After communication establishing, treat the possible declared failures.
vnx.su

89
ELECTRIC DIAGRAMS
89 - 2
The fuse box from the engine compartment is presented in Chapter 9, that contains information
about its location on the vehicle and the functional purpose of the relays and fuse placed on it.
The functional codes of the wires are detailed explained in Chapter 12. FUNCTIONAL DIAGRAMS INTERPRETATION
The functional diagram information included in Chapter 7 are to be i nterpreted taking i nto
consideration the explanation referring to the following example:
1= vehicle class
2= manufacturing year
3= functional electric diagram denomination
4= equipment differentiation criteria for identifying the functional electric diagram ˙
5= electric connector colour ˝
6= connector graphical representation
7= electric component index number
8= number of the fuse box on which the relay or safety fuse is m ounted
9= safety fuse identification on fuse box
10 = safety fuse value
11 = identification of wiring joints
12 = electric mass identification
13 = electric connection colour between wiring ˝
14 = electric connection identification
15 = electric connection graphical representation
16 = symbol, pages containing functional diagrams
17 = wire function code
18 = wire colour ˝
19 = functional diagram number
OBSERVATION:
1. The area ( 4) specifies the differentiating elements serving to the various functional diagrams
identification, considering the following symbols:
ABCO01 = driver’s airbag
CA = climate maintenance with air conditioning
CHAUFO = climate maintenance without air conditioning
CPE = Electric locking/unlock ing doors control
DA = assisted power steering
E0, E1, E2 = levels of equipment
LV E = front windows electric control
___ ___________________________________________________________________________
General
vnx.su

89
ELECTRIC DIAGRAMS
89 - 6
Functional diagrams list
DOORS CENTRAL LOCKING
ANTI-STARTING
SPEED LIMIT INDICATOR
ELECTRIC LIGHTER
CLIMATE CONTROL
CLIMATE CONTROL AND AIR CONDITION
CEILING LAMP
FRO NT WINDOWS ELECTRIC CONTROL
RADIO
STARTING CIRCUIT
E NGINE COOLING FAN
ELECTRONIC INJECTION
CHARGING CIRCUIT
REAR WIRING MASS
FRONT WIRING/ DASHBOARD MASS
BATTERY/CARRIAGE BODY MASS
FOG PROJECTORS WIRING MASS
HATCHB ACK WIRI NG MASS
E NGINE WIRING MASS
COCKPIT FUSE BOX
E NGINE FUSE BOX AND RELAY
HANDBRAKE INDICATOR / BRAKING SYSTEM FAILURE
FUEL LEVER INDICATOR
OIL PRESS URE INDICATOR
DIAGNOSTIC SOCKET
DASHB OAR D
ALER T TEMPERATU RE INDICATOR FOR COOLING FLUID
WA TER TEMPERATURE COOLING FLUID INDICATOR
SPEED INDICATOR
DRIVER’S AIRBAG
DRIVER SAFETY BELTS INDICATOR
ACOUSTIC WAR NING
REAR WINDOW DEFROSTING
ELECT RIC D IAGRAM S DE NOM INATION DI AGRAM NUM B E R
1
2
3
4
5
6
7
8
9-10
11
12-13
14-15-16-17-18-19-20-21
22
23-24
25-26-27-28-29-30-31-32-
33-34-35-36
37
38
39
40-41-42-43
44-45-46-47-48-49-50-51-
52-53-54-55-56-57-58-59
60-61-62-63
64
65-66
67
68-69
70-71-72-73-74
75
76
77-78
79
80
81
82
vnx.su

89
ELECTRIC DIAGRAMS
89 - 8
Functional diagrams list index
Electric lighter
Alternator
Anti-theft system
Acoustic warning
Battery
Windscreen wiper timer
Injection computer (ECE)
Doors closing switch
Climate control panel
Hazard switch
Rear window defrosting switch
Left electric window switch
Right electric window switch
Turning signalling relay
Right rear door actuator
Left rear door actuator
Left front door actuator
Right front door actuator
Windscreen wiper-washer switch
Detona tion sensor
Atmospheric pressure sensor
RPM s ensor
Reverse driving contact
Handbrake contact
St op contact
Starte r
AC compressor clutch
Right rear lamp
Left rear lamp
Right fog headlight
Left fog headlight
Left front door contact
Right front parking lamp
Left front parking lamp
Cooling motor fan
Right rear loud speaker
Left rear loud speaker
Right front door loud speaker
Left front door loud speaker
Injector 1
Injector 2
Injector 3
Injector 4
Fuel lever transmitter and electric pump
Rear window defrosting
Electric left window actuator
Electric right window actuator
Oil pressure contact101
103
104
105
107
113
120
123
124
125
128
132
133
137
138
139
140
141
145
146
147
149
155
156
160
163
171
172
173
176
177
180
184
185
188
189
190
191
192
193
194
195
196
199
200
203
204
205
Code
Component denomination Code Component denomination209
212
213
221
222
224
225
226
227
231
234
236
238
242
244
247
255
256
261
262
267
268
272
319
320
321
326
333
371
462
503
584
597
639
649
654
700
756
778
857
887
899
927
101 6
109 1
114 0
115 6
120 2 Lights, turning lights and horn switch
Motor wi
ndscreen wiper
Ceiling lamp
Windscreen washing pump
Va l ve potentiometer
Power steering pressure controller
Diagnostic socket
Right headlamp
Left headlamp
Fog projectors control relay
Cooling motor fan control relay
Fuel pump control relay
Actuators relay
Downstream oxygen sensor
Injection water temperature sensor
DASHBOARD
Right front turning lamp
Left front turning lamp
Radio
Cooling motor fan and AC
Right side signalising lamp
Left side signalising lamp
Injection air temperature sensor
AC control panel
Cooling motor fan (for AC)
Motor fan resistance (for AC)
Speed limit indicator
Driver safety belt contact
Canister purging valve
License plate lamp
UCE decoder
AC compressor clutch control relay
Safety fuse box and engine compartment relays
STOP-S3 l amp
Step by step engine
Anti-starting bushing
Cooling blower low speed control relay
UCE airbag
Ignition coil
FLASH relay
Upstream oxygen sensor
Driver’s airbag
C hock sensor
Cockpit fuse box
I.C.P. braking system
V ehicle speed transducer
Cooling motor fan
AC pressure sensor (pressure controller)
vnx.su

89
ELECTRIC DIAGRAMS
89 - 11
Electric components location on the vehicle
In ject or 1
Inject or 2
Inject or 3
Inje ctor 4
Atmospheric pressure sensor
Detonation sensor
Starter
In jection air temperature sensor
Valve potentiometer
Upstream oxygen sensor
Step-by step engine
Alternator
Ignition c oil
Canister purging valve
AC pressure sensor (pressure controller)
Pressure controller DA
AC compressor clutch
Upstream oxygen sensor
Cooling motor fan and AC
Cooling engine fan resistance for AC
Oil pressure contact
Injec tion computer
RPM sensor
In jection water temperature sensor
Reverse driving contact
Fuse box and engine relays
Vehicle speed transducer
I CP brake system
Chock sensor
Windscreen wiper motor
Windscreen washing motor
Speed limit ind icator
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32Turning lights relay
Front door contact
Windscreen wiper timer
Left fron t door actuator
Le ft elec tric window actuator
Left fr ont door loud speaker
Cockpit fuse box
UCE d ecoder
FLASH relay
Rear window defrosting switch
Anti-starting bushing
STOP contact
Radio
Doors locking switch
Li ghter
Hazard switch
Climate control panel
Electr ic right window switch
Electr ic left window switch
UCE airbag
Diagnostic socket
Handbrake contact
Safety belt contact
Driver’s airbag
Right front door loud speaker
Electr ic right window actuator
Right front door actuator
Right rear door actuator
Right rear loud speaker
STOP-S3 lamp
Fuel level transmitter and electric pump
Left rear door loud speaker
Left r ear door actuator
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
No. Denomination
No.Denomination
vnx.su

89
ELECTRIC DIAGRAMS
89 - 14
Cockpit fuse box
The cockpit fuse box is placed in driving post left side, being attached on the dashboard lateral
side.
The fuses are protecting the following electric components and circuits:
Diagnostic socket, ceiling light, windscreen wiper motor (fix point
stopping), FLASH relay (+C)
UCE decoder, anti-starting bushing, rad io, instrument panel, climate
control panel (+C)
U.C.E. decoder, diagnostic socket, instrument panel, climate control
panel, speed limit indicator, contact STOP (+DC)
U.C.E. injection, U.C.E. airbag fuel pump relay/ ignition coil (+DC)
Reverse driving contact(+DC)
Windscreen wiper switch, windscreen wiper timer.
Left mee ting lights, instrument panel (indicator)
Right meeting lights
F02
F03
F04
F05
F06
F07
F08
F09

FUSE
NUMBERFUS E
TYPE P
ROTECTED CIRCU IT
10A
25A
15A
15A
5A
10A
10A
10A
vnx.su

89
ELECTRIC DIAGRAMS
89 - 19
INJECTOR 4
FU EL LEVEL TRANSMITTER AND ELECTRIC PUMP
REAR WINDOW DEFROSTING
ELECTRIC RIGHT WINDOW ACTUATOR
ELECTRIC LEFT WINDOW ACTUATOR
OIL PRESSUR E CONTAC T
LIGHTS, TU RNING LIGHTS, HORN SWITCH
WINDSCREEN WIPER MOTOR
CEIL ING LIGHT
WINDSCREEN WASHING PUMP
VALVE POTENTIOMETER
POWER ST EERING PRESSURE CONTROLLER
DIAGNOSTIC SOCKET
RIGHT HEADLAMP
LEFT HEADLAMP
FOG PROJ ECTORS C ONTROL R ELAY
DOWNSTREAM OXYGEN SENSOR
WA T E R T E MPERATURE SENSOR
INST RUMENT PANEL
RIGHT FRONT TURNING LAMP
LEFT FRONT TU RNING LAMP
RADIO
E NGINE COOLING FAN (for vehicles with AC)
RIGHT FRONT SIDE SIGNALING LAMP
LEFT FRONT SIDE SIGNALING LAMP
INJECTION AIR TEM PERATURE SENSOR
CLIMATE CONTROL PANEL W ITH AC
CLIMATE CONTROL BLOW ER (for AC vehicle equipment)
CLIMATE CONTROL FAN RESISTANCE ( for vehicles with AC)
SPEED LIMIT INDICATOR
DRIVER SAFETY BELT CONTACT
CANISTER PURGING VALVE
LICENSE PLATE LAMP
UCE DECODER
FUSE BOX AND ENGINE RELAYS (for vehicles without AC)
FUSE BOX AND ENGINE RELAYS (for vehicles with AC)
STOP -S3 LAMP (in aileron)
STEP-BY-ST EP ENGINE
ANTI-STARTING BUSHING
U.C.E. AIRBAG
I GNITION COIL
FLASH RELAY
UPSTREAM OXYGEN SENSOR
DRIVER’S AIRBAG
CHOCK SENSOR
COCKPIT FUSE BOX
196
199
200
203
204
205
209
212
213
221
222
224
225
226
227
231
242
244
247
255
256
261
262
267
268
272
319
320
321
326
333
371
462
503
597
597
639
649
654
756
778
857
887
899
927
1016 89-125
89-175
89-179
89-150
89-150
89-126
89-151
89-152
89-152
89-153
89-126
89-127
89-153
89-154
89-154
89-178
89-127
89-128
89-155
89-157
89-157
89-158
89-128
89-159
89-159
89-129
89-160
89-161
89-129
89-162
89-176
87-130
89-179
89-163
89-131
89-133
89-179
89-135
89-164
89-164
89-135
89-165
89-136
89-165
89-136
89-166

Index in connectors and couplings
vnx.su

89
ELECTRIC DIAGRAMS
89 - 63
FRONT WIRING – DASHBOARDX412
03
INSTRUMENT PANEL
*- for EURO 2000
1 0.35 64C CONTROL LEFT TURNING LIGHTS
2 0.35 CPG PROTECTE D LEFT MEETING HEADLIGHTS > INDICA TO R
3 0.35 RPG PROTECTED LEFT ROAD LIGHTS > INDICA TOR
4 0.35 15A CONTROL – REAR WINDOW DEFROSTING INDICA TOR
6 0.35 129A CONTROL- AIRBAG FAILURE INDICA TO R
8 0.35 LPG + LEFT PARKING LIGHTS > OUTL ET FUSE F14
9 0.35 42A SIGNAL + W ATER TEMPERA TURE
PositionSection Destination
1 0.35 47F VEHICLE SPEED
SIGNAL
2 0.35 H7 RPM SIGNAL > INJECTION COM PUTER
5 0.6 AP43 + AFTER PROTECTED CONTACT > OUTLET FUSE F04
6 0.35
60DVDRIVER SAFETY BEL T INDICA TOR MASS
7* 0.353F H CONTROL - ANTI-POLLUTION FAILURE INDICA TOR
10 0. 6 AP43 + AFTER PROTECTED CONTACT > OUTLET FUSE F04
PositionSection Destination
129A
X
Wires functions in connectors and couplings
vnx.su

89
ELECTRIC DIAGRAMS
89 - 72
FRONT WIRING – DASHBOARDX41203
ANTI-STARTING BUSHING
20F MK BP12 80X
GR
654
1 2 3 4
X N R X
Position Section Destination
10.35 20F SIGNAL RADIO RECEIV ER - FREQUENCY
20.35 M KMASS
30 .35 BP12 PROTECTED BATTERY > OUTLET FUSE F03
40 .35 80X SIGNAL WAY ANTI-ST ARTING RECEIVER (TR)
U.C.E. AIRBAG
Position Section Destination
50
.6 AP29 +AFTER PROTECTED CONTACT > EXIT FUSE F05
60.6 NAP MASS
70 .35 129A CONTROL-AIRBAG FAILURE INDICA TO R
90 .35 HK SIGNAL DIAGNOSTIC LINE K
10 0. 6 129 FSIGNAL + DRIVER’S AIRBAG
11 0. 6 129GS IGNAL - DRIVER’S AIRBAG
20 0. 6 NAP MASS
23 0. 35HLSIGNAL DIAGNOSTIC LINE L
NAP
NAP

Wires functions in connectors and couplings
vnx.su

89
ELECTRIC DIAGRAMS
89 - 73
FLASH RELAY
NO
857
VI
R
R
R
54 3
64C 6 4 D B P 1 1
619 BP11
X X
72 880B D
Position Section Destination
10
.6 BP11 + PROTECTED BA TTERY > SHUNT
20 .6 80BD FLASH RELAY CONTROL
30 .6 BP11 + PROTECTED BATTERY > OUT LET FUSE F02
30 .6 BP11 + PROTECTED BA TTERY > SHUNT
40 .6 64D RIGHT TURNI NG LIGHTS CONTROL
50 .6 64C LEFT TURNING LIGHTS CONTROL
FRONT WIRING – DASHBOARDX412
03
DRIVER’S AIRBAG
Position Section Destination
10.6 129F SIGNAL + DRIVER’S AIRBAG
20 .6 129G SIGNAL – DRIVER’S AIRBAG
899
2 1
129G 129F
X X
Wires functions in connectors and couplings
vnx.su