belt DACIA SOLENZA 2004 Owner's Guide

SECURITY ELEMENTS
59
59 - 2
Rear safety belts
4
3 2
132 1
4
TIGHTENING MOMENTS(daNm)
Rear safety belt attachment scre w 2.7
DISMOUNTING
Di
smount t he t wo attachment screws of
the bench backre st. Sw ing over the bench backrest.
Di smount:
-r ear plate and its supports (see
chapter 74);
-belt attachment screws ( 2) and (3) o n
the side fra me lining. P
lace back t he bench backrest i n normal
position.
Sw ing over its supports the bench seat.
Dism oun t t he re a r b e lt attachment
screws ( 4) on the central floor.
REMOUNTING
Perform the dismounting operations in
the reverse order. The require d tightening moment of the
rear belt attachment screws is of 2,7 daNm.
vnx.su

62
AIR CONDITIONING
62- 12
Compressor
FUN CTION
The compressor is suction the vapors com-
ing from evaporator at low temperature and
pressure, compress them and transmit the gas
at high temperature and pressure towards con-
denser. The refrigerant fluid in entering in condenser
in vapors condition, at high temperature and
pressure, where, by condensing, is transmittin g
in the external environment the abstracted heat.
At condenser exit, the refrigerant fluid is in
liquid condition, at high pressure and tempera-
ture.
DISMOUNTIN G
Drain the refrigerant c ircuit t o a charging
station.
Disconnect the battery.
Disconnect the supply wiring connector of
the compressor clutch.
Dismount the screw of attachment clamp
of the refrigerant pipes on compressor.
Cover the open piping with protectors.
Dismount the compressor-driving belt.
Dismount the four compressor attachment
screws.
Extract the compressor.
REMOU NT I NG
In case compressor is replaced, this one is
delivered filled with oil. Position the compressor with the filling cap
upwards. Mount the compressor attachment screws.
Tighten the compressor attachment screws
to the required moment of 2,1 daNm.
Remount the two refrigerant pipes and
tighten t he attachment clamp screw to the re-
quired moment of 1,2 daNm.
Mount the compressor -driving belt and ten-
sion it by acting upon the screw ( 1) according
to the method descri bed in chapter 07 “ Ac-
cessories belts tensioning”.
The tensioning values are :
150 - 155 Hz - compressor belt;
214 – 230 Hz – DA pump/compressor belt.
Connect the supply wire connector of the
compressor clutch. Vacuum and fill the circuit with refrigerant
fluid HFC 134a , by means of the charging sta-
tion (see chapter 62 “Draining – Filling unit
refrigerant circuit” ).
REMARK :
Before mounting c heck t he condition
of t he gaskets and lubri cate them wi th
compressor oil PAG SP 10.
vnx.su

71
CARRIAGE BODY INSIDE TRIMS
71 - 3
Middle pillar trim
DISMOUNTING
Move the front seat to e nable opera tor
access to the front pillar. Dismount:
- partially the front/re ar door ga skets
(in the contact are as with middle pi llar tri m);
- attachment screws (2) and (5) of the
front belt on the middle pillar at upper part,
consequently, at lower part;
- attachment screws (3) and (4) of the
middle pillar tri m on the side frame lining.
Release the middle pillar tri m (1).
REMOUNTING
Perform the dismounting ope rations in
the reverse order.
The tightening moment of the be lt attach-
ment screws is of 2,7 daNm, and the one of
the attachment screws of the middle pillar
trim is of 0,12 daNm.
vnx.su

CARRIAGE BODY INSIDE TRIMS
71
71 - 4
Rear quarter panel trim
DISMOUNTING
Dismount:
- rear quart er panel ornament;
- partially the rear door sealing gasket in the contact area with the rear quarter panel
trim; - rear table;
- table support ( see chapter 74);
- attachment screw (2) of the rear belt on the upper pa rt;
- attachment screws (4) and (5) of the rear quart er pa nel trim to t he side frame l ining.
Detach from clips the rear quarter pa nel trim (1).
REMOUNTING
Perform the dismounting operations in the reverse order.
The tightening moment of the belt attachment screw is of 2,7 daNm.
vnx.su

CARRIAGE BODY INSIDE TRIMS
71
71 - 8
1 – cockpit carpe t
2 – clip
DISMOUNTING
Di
smount :
- front seats ( see chapter 78 );
- rear bench seat (see chapter 78);
- front seat belts lockers ( see chap-
ter 59 )
- centra l console ( see chapter 58);
- distributor of the air ventilation/cli-
mate maintenance RACV (see chapter 61 );
- front safety belts at lower part;
- accelera tion pedal limiter.
D etach from clips the cockpit carpet ( 1).
REMOUNTING
Perform the dismounting opera tions in the
reverse order.
The clips attaching is to be performed with
a maximum forc e of 3 daN.
Cockpit carpet
1
2
vnx.su

83
INSTRUMENT PANEL
83 - 3 Con
nector D (gray)
Pin Denomination 1. Mass
2. Free
3. Free
4. Free
5. Water temperature alert
6. Oil pressure alert
7. Battery charging indicator
8. Fog lamp indicator
9. Fog projectors indicator
10. Right turning indicator
C
onnector C (black)
Pin Denomination 1. Free
2. Free
3. Free
4. Handbrake indicator / ICP braking
system
5. Free
6. Anti-starting indicator
7. – Fuel level transmitter
8. Fuel level signal
9. Free
10. + Battery
Connector A (white)
Pin Denomination 1. Left turning indicator
2. Meeting lights indicator
3. Road lights indicator
4. Rear windscreen defrosting indicator
5. Free
6. Free
7. Free
8. + Parking lights
9. Water temperature indicator
10. Free
Connectors disposal
Connector B (brown)
Pin Denomination 1. Vehicle speed signal
2. Engine RPM signal
3. Free
4. Free
5. + After contact
6. Driver safety belt indicator
7. OBD indicator
8. Free
9. Free
10. + After contact
vnx.su

89
ELECTRIC DIAGRAMS
89 - 6
Functional diagrams list
DOORS CENTRAL LOCKING
ANTI-STARTING
SPEED LIMIT INDICATOR
ELECTRIC LIGHTER
CLIMATE CONTROL
CLIMATE CONTROL AND AIR CONDITION
CEILING LAMP
FRO NT WINDOWS ELECTRIC CONTROL
RADIO
STARTING CIRCUIT
E NGINE COOLING FAN
ELECTRONIC INJECTION
CHARGING CIRCUIT
REAR WIRING MASS
FRONT WIRING/ DASHBOARD MASS
BATTERY/CARRIAGE BODY MASS
FOG PROJECTORS WIRING MASS
HATCHB ACK WIRI NG MASS
E NGINE WIRING MASS
COCKPIT FUSE BOX
E NGINE FUSE BOX AND RELAY
HANDBRAKE INDICATOR / BRAKING SYSTEM FAILURE
FUEL LEVER INDICATOR
OIL PRESS URE INDICATOR
DIAGNOSTIC SOCKET
DASHB OAR D
ALER T TEMPERATU RE INDICATOR FOR COOLING FLUID
WA TER TEMPERATURE COOLING FLUID INDICATOR
SPEED INDICATOR
DRIVER’S AIRBAG
DRIVER SAFETY BELTS INDICATOR
ACOUSTIC WAR NING
REAR WINDOW DEFROSTING
ELECT RIC D IAGRAM S DE NOM INATION DI AGRAM NUM B E R
1
2
3
4
5
6
7
8
9-10
11
12-13
14-15-16-17-18-19-20-21
22
23-24
25-26-27-28-29-30-31-32-
33-34-35-36
37
38
39
40-41-42-43
44-45-46-47-48-49-50-51-
52-53-54-55-56-57-58-59
60-61-62-63
64
65-66
67
68-69
70-71-72-73-74
75
76
77-78
79
80
81
82
vnx.su

89
ELECTRIC DIAGRAMS
89 - 8
Functional diagrams list index
Electric lighter
Alternator
Anti-theft system
Acoustic warning
Battery
Windscreen wiper timer
Injection computer (ECE)
Doors closing switch
Climate control panel
Hazard switch
Rear window defrosting switch
Left electric window switch
Right electric window switch
Turning signalling relay
Right rear door actuator
Left rear door actuator
Left front door actuator
Right front door actuator
Windscreen wiper-washer switch
Detona tion sensor
Atmospheric pressure sensor
RPM s ensor
Reverse driving contact
Handbrake contact
St op contact
Starte r
AC compressor clutch
Right rear lamp
Left rear lamp
Right fog headlight
Left fog headlight
Left front door contact
Right front parking lamp
Left front parking lamp
Cooling motor fan
Right rear loud speaker
Left rear loud speaker
Right front door loud speaker
Left front door loud speaker
Injector 1
Injector 2
Injector 3
Injector 4
Fuel lever transmitter and electric pump
Rear window defrosting
Electric left window actuator
Electric right window actuator
Oil pressure contact101
103
104
105
107
113
120
123
124
125
128
132
133
137
138
139
140
141
145
146
147
149
155
156
160
163
171
172
173
176
177
180
184
185
188
189
190
191
192
193
194
195
196
199
200
203
204
205
Code
Component denomination Code Component denomination209
212
213
221
222
224
225
226
227
231
234
236
238
242
244
247
255
256
261
262
267
268
272
319
320
321
326
333
371
462
503
584
597
639
649
654
700
756
778
857
887
899
927
101 6
109 1
114 0
115 6
120 2 Lights, turning lights and horn switch
Motor wi
ndscreen wiper
Ceiling lamp
Windscreen washing pump
Va l ve potentiometer
Power steering pressure controller
Diagnostic socket
Right headlamp
Left headlamp
Fog projectors control relay
Cooling motor fan control relay
Fuel pump control relay
Actuators relay
Downstream oxygen sensor
Injection water temperature sensor
DASHBOARD
Right front turning lamp
Left front turning lamp
Radio
Cooling motor fan and AC
Right side signalising lamp
Left side signalising lamp
Injection air temperature sensor
AC control panel
Cooling motor fan (for AC)
Motor fan resistance (for AC)
Speed limit indicator
Driver safety belt contact
Canister purging valve
License plate lamp
UCE decoder
AC compressor clutch control relay
Safety fuse box and engine compartment relays
STOP-S3 l amp
Step by step engine
Anti-starting bushing
Cooling blower low speed control relay
UCE airbag
Ignition coil
FLASH relay
Upstream oxygen sensor
Driver’s airbag
C hock sensor
Cockpit fuse box
I.C.P. braking system
V ehicle speed transducer
Cooling motor fan
AC pressure sensor (pressure controller)
vnx.su

89
ELECTRIC DIAGRAMS
89 - 11
Electric components location on the vehicle
In ject or 1
Inject or 2
Inject or 3
Inje ctor 4
Atmospheric pressure sensor
Detonation sensor
Starter
In jection air temperature sensor
Valve potentiometer
Upstream oxygen sensor
Step-by step engine
Alternator
Ignition c oil
Canister purging valve
AC pressure sensor (pressure controller)
Pressure controller DA
AC compressor clutch
Upstream oxygen sensor
Cooling motor fan and AC
Cooling engine fan resistance for AC
Oil pressure contact
Injec tion computer
RPM sensor
In jection water temperature sensor
Reverse driving contact
Fuse box and engine relays
Vehicle speed transducer
I CP brake system
Chock sensor
Windscreen wiper motor
Windscreen washing motor
Speed limit ind icator
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32Turning lights relay
Front door contact
Windscreen wiper timer
Left fron t door actuator
Le ft elec tric window actuator
Left fr ont door loud speaker
Cockpit fuse box
UCE d ecoder
FLASH relay
Rear window defrosting switch
Anti-starting bushing
STOP contact
Radio
Doors locking switch
Li ghter
Hazard switch
Climate control panel
Electr ic right window switch
Electr ic left window switch
UCE airbag
Diagnostic socket
Handbrake contact
Safety belt contact
Driver’s airbag
Right front door loud speaker
Electr ic right window actuator
Right front door actuator
Right rear door actuator
Right rear loud speaker
STOP-S3 lamp
Fuel level transmitter and electric pump
Left rear door loud speaker
Left r ear door actuator
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
No. Denomination
No.Denomination
vnx.su

89
ELECTRIC DIAGRAMS
89 - 19
INJECTOR 4
FU EL LEVEL TRANSMITTER AND ELECTRIC PUMP
REAR WINDOW DEFROSTING
ELECTRIC RIGHT WINDOW ACTUATOR
ELECTRIC LEFT WINDOW ACTUATOR
OIL PRESSUR E CONTAC T
LIGHTS, TU RNING LIGHTS, HORN SWITCH
WINDSCREEN WIPER MOTOR
CEIL ING LIGHT
WINDSCREEN WASHING PUMP
VALVE POTENTIOMETER
POWER ST EERING PRESSURE CONTROLLER
DIAGNOSTIC SOCKET
RIGHT HEADLAMP
LEFT HEADLAMP
FOG PROJ ECTORS C ONTROL R ELAY
DOWNSTREAM OXYGEN SENSOR
WA T E R T E MPERATURE SENSOR
INST RUMENT PANEL
RIGHT FRONT TURNING LAMP
LEFT FRONT TU RNING LAMP
RADIO
E NGINE COOLING FAN (for vehicles with AC)
RIGHT FRONT SIDE SIGNALING LAMP
LEFT FRONT SIDE SIGNALING LAMP
INJECTION AIR TEM PERATURE SENSOR
CLIMATE CONTROL PANEL W ITH AC
CLIMATE CONTROL BLOW ER (for AC vehicle equipment)
CLIMATE CONTROL FAN RESISTANCE ( for vehicles with AC)
SPEED LIMIT INDICATOR
DRIVER SAFETY BELT CONTACT
CANISTER PURGING VALVE
LICENSE PLATE LAMP
UCE DECODER
FUSE BOX AND ENGINE RELAYS (for vehicles without AC)
FUSE BOX AND ENGINE RELAYS (for vehicles with AC)
STOP -S3 LAMP (in aileron)
STEP-BY-ST EP ENGINE
ANTI-STARTING BUSHING
U.C.E. AIRBAG
I GNITION COIL
FLASH RELAY
UPSTREAM OXYGEN SENSOR
DRIVER’S AIRBAG
CHOCK SENSOR
COCKPIT FUSE BOX
196
199
200
203
204
205
209
212
213
221
222
224
225
226
227
231
242
244
247
255
256
261
262
267
268
272
319
320
321
326
333
371
462
503
597
597
639
649
654
756
778
857
887
899
927
1016 89-125
89-175
89-179
89-150
89-150
89-126
89-151
89-152
89-152
89-153
89-126
89-127
89-153
89-154
89-154
89-178
89-127
89-128
89-155
89-157
89-157
89-158
89-128
89-159
89-159
89-129
89-160
89-161
89-129
89-162
89-176
87-130
89-179
89-163
89-131
89-133
89-179
89-135
89-164
89-164
89-135
89-165
89-136
89-165
89-136
89-166

Index in connectors and couplings
vnx.su