instrument panel DACIA SUPERNOVA 2004 Owner's Manual

83
INSTRUMENT PANEL
OIL PRESSURE WARNING LIGHT STILL ON
AFTER ENGINE STARTING
Check the oil pressure
The pressure is correct.
Replace the oil pressure switch. The pressure is not correct.
There is a failure in the oil circuit.
OIL PRESSURE WARNING LIGHT IS NOT ON
WHEN CONTACT SWITCH ON
Place the wire from the oil pressure switch to the ground.
Wa r ning light is not on.
Check if the bulb is not burnt.
Warning light is on. Replace the oil pressure
switch.
Burnt bulb. Replace it. Bulb is not burnt . Check the bulb
supply wiring and fix it.
FUEL LEVEL INDICATOR
SHOWING ALWAYS FULL
Disconnect the connection wire t o the probe.
The indicator comes back
to zero. Re place the probe. The indicator
does not come to zero.Is there
any ground short-circuit of the connection
wi re to the probe?
Yes. Fix the wiring layout. No. Replace the indicator.
83-7
DIAGNOSTIC
vnx.su

83
INSTRUMENT PANEL
83-8
FUEL LEVEL INDICATOR NOT SHOWING CORRECTLY
Disconnect the connection wire to the probe
Yes, Fix the
wire layout. The indicator does not come to zero. Is
there a gro
un d sh ort - c i rc ui t of t he
connection wire to the probe ? The indicator comes back to
zero.
Place a t ground, the wire connection
to the probe.
N
o. The indicator is defect.
The indicator is showing
full.Replace the probe. The indicator does not show full; the probe
wi
re is not connected or broken.
FUEL LEVEL INDICATOR NOT WORKING
Place at ground the connection wire to the probe.
The indicator is working. Replace the
probe. The indicator does not work.
Check the indicator supply and ground.
If correct, place at ground the
connection wire to the probe.N
ot correct. Re pair the ground or probe
supply wiring .
Indicator does not work. Fix the wiring between
the probe and indicator.
DIAGNOSTIC
vnx.su

83
INSTRUMENT PANEL
83-10
FUEL LEVEL TRANSMITTER REPLACEMENT
DISMOUNTING
Disconnect the battery.
Dismount the fuel tank-visiting cap, by acting upon the attachment screws.
Disconnect the transmitter connector from the rear wiring / fuel tank cap.
D etach the clips of the hoses connected to the fuel tank cap.
Rotate the probe attachment flange from right to left, by about 1/3 rotation, until it is released
from the attachment shoulders.
Pull out the assembly fuel tank cap-fuel pump-level transmitter;
Dismount the attachment screws of the fuel level transmitter.
REMOUNTING
Perform in the reverse order the dismounting operations, checking carefully the condition of
the tank cap-sealing gasket.
ELECTRIC TESTS – FUEL LEVEL TRANSMITTER
PO SITION OF THE FUEL LEVEL R
INDICATOR ON INSTRUMENT PANEL transmitter
(W)
4/4 7+/-15 %
3/4 50+/- 5 %
1/2 97+/- 5 %
1/4 162+/- 3 %
0 280+/- 3 %
minimal level warning -
FUEL LEVEL TRANSMITTER
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 11
39HANDBRAKE INDICATOR AND BRAKING SYSTEM FAILURE S S S
40 FUEL LEVEL INDICATOR CIRCUIT S S S
41 OIL PRESSURE INDICATOR CIRCUIT S S S
42 DIAG NOSTIC SOCKET S S S
43 INSTRUMENT PANEL AE1 S
44 INSTRUMENT PANEL AE2, AE3 S S
45 WA TER TEMPERATURE INDICATOR CIRCUIT S S S
46 BRAKE PADS WEAR INDICATOR CIRCUIT S S S
47 VEHICLE SPEED S S S
48 SOUND W ARNING S S S
49 REAR WINDOW DEFROSTING S S S
50 WINDSCREEN WIPER-WASHING S S S
51 REAR FOG LAMP S S S
52 FOG HEADLIGHTS AE2, AE3 S S
53 MEETING LIGHTS S S S
54 REVERSE DRIVING LIGHTS S S S
55 PA R K I N G LIGHTS S S S
56 ROAD LIGHTS S S S
57 STOP LIGHTS AE1, AE2 S S
58 STOP LIGHTS AE2(aileron) O
59 STOP LIGH TS AE2(CA), AE3 O S
60 TURNING AND HAZARD LIGHTS AE1 S
61 TURNING AND HAZARD LIGHTS AE2, AE3 S S
Note : these electr ic diagrams are valid for vehicle manufactured until 01.06.2001; AE1
( Confort), AE2 (Rapsodie), AE3 (Clima) represent equipping levels of the vehicle.
FUNCTIONAL DIAGRAMS LIST
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 12
(until 01.06.2001)
21
101
102
103
104
105
107
113
120
121
122
123
124
125
128
137
138
139
140
141
145
146
147
149
155
156
160
163
165
168
171
172
173
175
176
177
180
181
184
185
188
189
190Right signalling anti-return diode
Electric lighter
Ashtr a y
Alternator
Anti-theft system
Acoustic alarm
Battery
Windscreen wiper timer
Injection computer (UCE)
Fog lights switch
Fog headlights switch
Door closing switch
Climate blower switch
Hazard switch
Rear window defrosting switch
Turning signalling relay
Right rear door actuator
Left rear door actuator
Left front door actuator
Right front door actuator
Windscreen wiper-washer switch
Detona tion sensor
Atmospheric pressure sensor
RPM s
ensor
Reverse driving contact
Handbrake contact
St op contact
Starte r
Trunk lighting lamp
Documents compartment lighting lamp
AC compressor clutch
Right rear lamp
Left rear lamp
Left fog lamp
Right fog headlight
Left fog headlight
Left front door contact
Right front door contact
Right front parking lamp
Left front parking lamp
Cooling motor fan
Right rear loud speaker
Left rear loud speakerRight front brake pad
Left front brake pad
Windscreen washing pump
Va l ve potentiometer
Diagnostic socket
Right headlamp
Left headlamp
Fog lamps relay
Fog headlights control relay
Cooling motor fan control relay
Fuel pump control relay
Actuators relay
Injection water temperature sensor
Instrument panel
V ehicle speed transducer
Right front turning lamp
Left front turning lamp
Cockpit fuse and relays box
Radio
Cooling motor fan and AC
Right side signalling lamp
Left side signalling lamp
Injection air temperature sensor
Rear window defrosting timer
Climate control lighting
AC starting button
Motor fan resistance ( f or AC)
Left front ceiling lamp
Right front ceiling lamp
Canister purging valve
UCE anti-intrusion
Engine hood contact
Siren
Vo l u metric sensor
AC relay ( on board)
UCE decoder
Hatchback contact
AC compressor clutch control relay
Engine compartment fuse and relays box
Climate control blower
STOP-S3 l amp
St ep-by-step engine
Anti-starting bushing
216
217
221
222
225
226
227
230
231
234
236
238
244
247
250
255
256
260
261
262
267
268
272
294
298
319
321
328
329
371
427
438
442
454
474
503
560
584
597
600
639
649
654
CODE COMPONENT DENOMINATIONCODE COMPONENT DENOMINATION
ELECTRIC COMPONENTS INDEX
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 18
( until 01.06.2001)
The cockpit fuse box is placed left side under dashboard, being attached on the interior side
of the door(1). To access the fuses, turn the knob (2), then open up the door towards exterior.
The fuses are protecting the following electric circuits:
FUSE
NUMB ER FUSE
TYPE PROTECTED C IRCUIT
Clock, radio, STOP contact, climate blower relay control
Reverse driving contact
UCE decoder, speed transducer, instrument panel supply, diagnostic
socket, AC starting button, UCE anti-intrusion
Hazard and turning signaling lights
Front/rear parking lights, lighting: switches, instrume nt panel, climate
control, documents compartment, lighter, ashtray, radio.
Lighter, clock, instrument panel ( anti-starting indic ator), front right
ceiling lamp, UCE anti-intrusion, anti-intrusion indicator, diagnostic socket.
Windscreen wiper-washing switch, windscreen wiper timer
Rear window defrosting
Climate blower
Left fo g lamp
F01
F02
F03
F04
F05
F06
F07
F08
F09
F10 15A
5A
15A
7,5A
5A
15A
15A
20A
15A
5A
1
2
COCKPIT FUSE BOX
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 25
196 INJECTOR 489-106
199 FU EL LEVEL TRANSMITTER AND ELECTRIC PUMP 89-146
200 REAR WINDOW DEFROSTING 89-149
205 OIL PRESSUR E CONTAC T 89-98
209 CLIGHTS, TURNING LIGHTS, HORN SWITCH 89-114
210 ELECTRONIC CLOC K 89-128
212 WINDSCREEN WIPER MOTOR 89-112
216 RIGHT FRONT BRAKE PAD 89-127
217 LEFT FRONT BRAKE PAD 89-127
221 WINDSCREEN WASHING PUMP 89-125
222 VALVE POTENTIOMETER 89-104
225 DIAGNOSTIC SOCKET 89-135
226 RIGHT HEADLAMP 89-125
227 LEFT HEADLAMP 89-125
244 WATER TEMPERATURE SENSOR 89-99
247 INSTRUMENT PANEL 89-135
250 SPEED TRANSDUC ER 89-117
255 RIGHT FRONT TURNING LAMP 89-126
256 LEFT FRONT TURNING LAMP 89-126
260 COCKPIT FUSE AND RELAYS BOX 89-119
261 R ADIO 89-128
262 COOLING MOTOR FAN (for vehicles with AC) 89-107
267 RIGHT SIDE SIGNALING LAMP 89-126
268 LEFT SIDE SIGNALING LAMP 89-127
272 INJECTION AIR TEMPERATURE SENSOR 89-103
298 CLIMATE CONTROL LIGHTING 89-131
319 AC STARTING BUTTON 89-131
321 MOTOR FAN RESISTANCE ( for vehicles with AC) 89-108
328 LEFT FRONT CEILING LAMP 89-149
329 RIGHT FRONT CEILING LAMP 89-149
371 CANISTER PURGING VALVE 89-101
427 UCE ANT I-INTRUSION 89-143
438 ENGINE HOOD CONTACT 89-118
442 SIREN 89-118
454 RIGHT VOLUMETRIC SENSOR(Rx) 89-142
454 LEFT VOLUMETRIC SENSOR (Tx) 89-142
474 AC R ELAY (on board) 89-129
503 UCE DECODER 89-115
560 HATCHBAC K C ONTACT 89-146
597 ENGINE RELAYS AND FUSE BOX ( for vehicles without AC) 89-94
597 ENGINE RELAYS AND FUSE BOX ( for vehicles with AC) 89-96
600 CLIMATE CONTROL B LOWER 89-130
639 STOP-S3 LAMP (on roof) 89-150
639 STOP[ -S3 LAMP (in aileron) 89-150
649 STEP-BY-STEP ENGINE 89-103
654 ANTI-STARTING BUSHING 89-116
778 IGNITION COIL 89-100
857 FLASH RELAY 89-116
887 SUPSTREAM OXYGEN SENSOR 89-100
927 CHOCK SENSOR 89-102
993 ANTI-INTRUSION INDICATOR LED 89-142
WIRE FUNCTIONS INDEX IN CONNECTORS AND COUPLINGS
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 73
DIAGNOSI
S SOCKET
INSTRUMENT PANEL
DASHBOARD WIRINGB41 01
10 ,35 AP15+ AFTER PROTECTED CONTACT > FUSE OUTLET F03
40,35MM ASS
50 ,35 N ELECTRONIC MASS
70 ,35 HK DIAGNOSIS SIGNAL – LINE K
15 0, 35HL DIAGNOSIS SIGNAL – LINE L
16 0, 35BP3 + PROTECTED BATTERY > FUSE OUTLET F15
PositionSectioning Destination
NO
R X
8 7 6 5 4 3 2 1
HK N M AP15
16 15 14 13 12 11 10 9
BP3 HL
X N N G
225
1
20,35 15A REAR WINDOW DEFROSTING INDICA TOR – CONTROL
30 ,35 H7 RPM-METER SIGNAL > INJECTION COMPUTER
40 ,35 42A SIGNAL+W ATER TEMPERA TURE
50 ,35 28A CONTROL - OIL PRESSURE INDICA TOR
60 ,35 31A CONTROL - WATER PRESSURE INDICA TOR
70 ,35 64C LEFT TURNING LIGHTS CONTROL
80,35MM ASS
80 ,35 M SHUNT > M ASS
90 ,35 64F CONTROL + HAZARD INDICA TO R
10 0, 5M SHUNT > MASS
10 0, 5M SHUNT > MASS
PositionSectioning Destination
BA
1
09876 54 3 21
M64FM 64C 3 1 A 2 8 A 42A H7 15A
XXXXX XN
N N
N 247
X
CO NNECTORS AND CONNECTIONS WIRES FUNCTION
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 75
DASHBOARD WIRINGB4101
10 .6 2JD + ALTERNATOR EXCITA TION > INSTRUMENT PANEL
20 .35 47A - FUEL LEVEL WARNING SIGNAL
30 ,35 41A SIGNAL + FUEL LEVEL TRANSMITTER
4
5
6
7
8
PositionSectioning Destination
87 65 4321
41A 47A2JD 247 BA
XX X
CO
NNECTORS AND CONNECTIONS WIRES FUNCTION
vnx.su

89A
ELECTRICAL DIAGRAMS
89A - 92
DASH
BOARD WIRING CONNECTION
CONNECTIONSB41
01
Position Sectioning Destination
A1 0,35 64D RIGHT TURNING LIGHTS CONTROL
> INDICATOR
A2 0,35 31A INSTRUME NT PANEL > WATER TEMPERATURE WARNING
A3 0,35 28A INSTRUMENT PANEL > OIL PRESSURE W ARNING
A4
A5 0,35 42A SIGNAL + WATER TEMPERA TURE
A6 0,35 H7 RPM-METER SIGNAL
A7 0,35 15A REAR WINDOW DEFROSTING INDICATOR-CONTROL
B1 0,75 AP10 + AFTER PROTECTED CONT ACT
B2 0,35 RPD PROTECTED RIGHT HIGH BEAM > INDICATO R
B3 0,35 64DRIGHT TURNING LIGHTS CONTROL > INDICATOR
B4 0,35 38AS
AIR-CONDITIONING COMPRESSOR CONNECTION SIGNA L > RELAY
B5 0,35 H1ICP HANDBRAKE INDICATOR-CONTROL
B6 0,35 H12BRAKE PADS WEAR INDICA TOR-CONTROL
B7 0,62 JD + ALTERNATOR EXCITA TION > INSTRUMENT PANEL
C1 0,35 47A - FUEL MINIMAL LEVEL WARNING
C2 0,35 41A SIGNAL + FUEL LEVEL TRANSMITTER
C3 0,35 3FHI NJECTION FAILURE INDICATOR-CONTROL
C4 0 , 35 80T A N TI-STARTING IN DICATOR-CONTROL
C5 0,35 HKDIAGNOSIS SIGNAL LINE K
C6 0,35 HLDIAGNOSIS SIGNAL LINE L
C7 0 , 35 MMASS
MA
76 5 32 1
C
B
A
R 107
M HL HK 8 0T 3FH 41A 47A
2JD H1 2 H1 38AS 64D RPD AP10
15A H7 42A 2 8 A 3 1 A 6 4 D
N X X X X X X
XX X X X X R-G
X X X X X X
CO NNECTORS AND CONNECTIONS WIRES FUNCTION
vnx.su