diagram DAEWOO MATIZ 2003 Service Owner's Manual

DAEWOO M-150 BL2
SECTION 8A
SEAT BELTS
CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a
tool or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable
will help prevent personal injury and damage to the vehicle. The ignition must also be in B unless otherwise
noted.
TABLE OF CONTENTS
Description and Operation 8A-2. . . . . . . . . . . . . . . . . .
Driver Seat Belt Warning 8A-2. . . . . . . . . . . . . . . . . . .
Three-Point Pretensioner Front Seat Belt
(W/EUROPE Only) 8A-2. . . . . . . . . . . . . . . . . . . . . .
Three-Point WLR Front Seat Belt 8A-2. . . . . . . . . . . .
Three-Point ELR Front Seat Belt 8A-2. . . . . . . . . . . .
Three-Point ELR Rear Outboard Seat Belt 8A-2. . . .
Two-Point Lap Rear Center Seat Belt 8A-2. . . . . . . .
Operational and Functional Checks 8A-2. . . . . . . . . .
Component Locator 8A-3. . . . . . . . . . . . . . . . . . . . . . . .
Front and Rear Seat Belt 8A-3. . . . . . . . . . . . . . . . . . .
Diagnostic Information and Procedures 8A-4. . . . .
Seat Belt Warning Lamp is Inoperative 8A-4. . . . . . . Repair Instructions 8A-5. . . . . . . . . . . . . . . . . . . . . . . . .
On-Vehicle Service 8A-5. . . . . . . . . . . . . . . . . . . . . . . . . .
Three-Point WLR/ELR Front Seat Belt 8A-5. . . . . . .
Three-Point Pretensioner Front Seat Belt
(W/EUROPE Only) 8A-6. . . . . . . . . . . . . . . . . . . . . .
Front Seat Belt Buckle 8A-8. . . . . . . . . . . . . . . . . . . . .
Three–Point ELR Rear Outboard Seat Belt 8A-8. . .
Two-Point Lap Rear Center Seat Belt 8A-10. . . . . . .
Specifications 8A-11. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fastener Tightening Specifications 8A-11. . . . . . . . . .
Schematic and Routing Diagrams 8A-12. . . . . . . . . .
Driver Seat Belt Warning 8A-12. . . . . . . . . . . . . . . . . .

8A –12 SEAT BELTS
DAEWOO M-150 BL2
SCHEMATIC AND ROUTING DIAGRAMS
DRIVER SEAT BELT WARNING
D1AA201A

8B–2 SUPPLEMENTAL INFLATABLE RESTRAINTS (SIR)
DAEWOO M-150 BL2
Diagnostic Illustration 8 8B-65. . . . . . . . . . . . . . . . . . .
Diagnostic Illustration 9 8B-65. . . . . . . . . . . . . . . . . . .
Diagnostic Illustration 10 8B-66. . . . . . . . . . . . . . . . . .
Diagnostic Illustration 11 8B-66. . . . . . . . . . . . . . . . . . .
Diagnostic Illustration 12 8B-66. . . . . . . . . . . . . . . . . .
Diagnostic Illustration 13 8B-66. . . . . . . . . . . . . . . . . .
Diagnostic Illustration 14 8B-67. . . . . . . . . . . . . . . . . .
Diagnostic Illustration 15 8B-67. . . . . . . . . . . . . . . . . .
Diagnostic Illustration 16 8B-67. . . . . . . . . . . . . . . . . .
Diagnostic Illustration 17 8B-67. . . . . . . . . . . . . . . . . .
Diagnostic Illustration 18 8B-68. . . . . . . . . . . . . . . . . .
Diagnostic Illustration 19 8B-68. . . . . . . . . . . . . . . . . .
Diagnostic Illustration 20 8B-68. . . . . . . . . . . . . . . . . .
Diagnostic Illustration 21 8B-68. . . . . . . . . . . . . . . . . .
Repair Instructions 8B-69. . . . . . . . . . . . . . . . . . . . . . . .
On-Vehicle Service 8B-69. . . . . . . . . . . . . . . . . . . . . . . . . Driver Airbag Module 8B-69. . . . . . . . . . . . . . . . . . . . .
Clock Spring 8B-70. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Passenger Airbag Module 8B-71. . . . . . . . . . . . . . . . .
Sensing and Diagnostic Module (SDM) 8B-72. . . . . .
Airbag Module Deployment (In Vehicle) 8B-74. . . . . .
Airbag Module Deployment (Outside
of Vehicle) 8B-76. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Deployed Airbag Module Disposal Procedure 8B-76
Specifications 8B-78. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fastener Tightening Specifications 8B-78. . . . . . . . . .
Special Tools and Equipment 8B-78. . . . . . . . . . . . . .
Special Tools Table 8B-78. . . . . . . . . . . . . . . . . . . . . . .
Schematic and Routing Diagrams 8B-79. . . . . . . . . .
Supplemental Inflatable Restraints (SIR)
Electrical Schematic 8B-79. . . . . . . . . . . . . . . . . . . .

SUPPLEMENTAL INFLATABLE RESTRAINTS (SIR) 8B–79
DAEWOO M-150 BL2
SCHEMATIC AND ROUTING DIAGRAMS
SUPPLEMENTAL INFLATABLE RESTRAINTS (SIR)
ELECTRICAL SCHEMATIC
D1AB201B

DAEWOO M-150 BL2
SECTION 9A
BODY WIRING SYSTEM
CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a
tool or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable
will help prevent personal injury and damage to the vehicle. The ignition must also be in B unless otherwise
noted.
TABLE OF CONTENTS
Description and Operation 9A-2. . . . . . . . . . . . . . . . . .
How to Read Electrical Wiring Diagram 9A-2. . . . . . .
How to Check Terminal Number of Connector 9A-4.
Special Tools and Equipment 9A-5. . . . . . . . . . . . . . .
Special Tools Table 9A-5. . . . . . . . . . . . . . . . . . . . . . . .
Schematic and Routing Diagrams 9A-6. . . . . . . . . . .
Wire Color Chart 9A-6. . . . . . . . . . . . . . . . . . . . . . . . . .
Power Distribution Schematic 9A-7. . . . . . . . . . . . . . .
Relay & Fuse Box Locator (Engine Room) 9A-8. . . .
Fuse Box Locator
(Passenger Compartment) 9A-9. . . . . . . . . . . . . . . . Fuse Chart 9A-10. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Harness Routing 9A-11. . . . . . . . . . . . . . . . . . . .
Engine Harness Routing 9A-12. . . . . . . . . . . . . . . . . . .
Instrument Harness Routing 9A-14. . . . . . . . . . . . . . .
Airbag Harness Routing 9A-16. . . . . . . . . . . . . . . . . . .
Body Harness Routing 9A-17. . . . . . . . . . . . . . . . . . . .
Front Door Harness Routing 9A-19. . . . . . . . . . . . . . .
Rear Door Harness Routing 9A-20. . . . . . . . . . . . . . . .
Tailgate Harness Routing 9A-21. . . . . . . . . . . . . . . . . .

9A – 2 BODY WIRING SYSTEM
DAEWOO M-150 BL2
DESCRIPTION AND OPERATION
HOW TO READ ELECTRICAL WIRING DIAGRAM
D111001A

BODY WIRING SYSTEM 9A–3
DAEWOO M-150 BL2
Contents of Electrical Wiring Diagram
PositionExplanation
A
–The box above the fuse box: Power supply lines
–Power supply lines: 30, 15, 15A, Ka, 58, 50
–Refer to “Circuit Identification Symbol” in this section for more details.
B
–Ef10 or F3: Fuse Number

Ef10: Fuse No 10 in the engine room fuse box

F3: Fuse No 3 in the passenger room fuse box
–40A: Fuse Capacity
–Refer to “Relay Box Locator” and “Fuse Box Locator” in this section.
C
–Connector
–Connector No C202, terminal No 10
–Refer to “How to Check Terminal Number of Connect” in this section
D–Internal circuit of component (Relay)
(Component Name, Terminal Number)
E–Internal circuit of component (Switch)
(Terminal Number)
F–Wiring Harness Color
–Refer to “Wire Color Chart” in this section
G
–Ground line.
–G402: Ground Position
–In case of the ground numberless, this means the body ground.
Circuit Identification Symbol
Identification SymbolMeaning
CConnector
EfFuse in engine room fuse box
FFuse in passenger compartment fuse box
GGround

9A–6 BODY WIRING SYSTEM
DAEWOO M-150 BL2
SCHEMATIC AND ROUTING DIAGRAMS
WIRE COLOR CHART
Wire ColorAbbreviation On Schematic
GreenDK GRN
BlueDK BLU
BrownBRN
OrangeORN
YellowYEL
GreyGRY
RedRED
BlackBLK
WhiteWHT
PurplePPL
Wires With Tracers
Wire ColorAbbreviation On Schematic
Red with White TracerRED/WHT

DAEWOO M-150 BL2
SECTION 9B
LIGHTING SYSTEMS
CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a
tool or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable
will help prevent personal injury and damage to the vehicle. The ignition must also be in B unless otherwise
noted.
TABLE OF CONTENTS
Description and Operation 9B-2. . . . . . . . . . . . . . . . . .
Headlamps and Parking Lamps 9B-2. . . . . . . . . . . . .
Front Turn Signal Lamps 9B-2. . . . . . . . . . . . . . . . . . .
Rear Fog Lamp 9B-2. . . . . . . . . . . . . . . . . . . . . . . . . . .
Taillamps 9B-2. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
License Plate Lamp 9B-2. . . . . . . . . . . . . . . . . . . . . . . .
Interior Courtesy Lamp 9B-2. . . . . . . . . . . . . . . . . . . . .
Backup Lamp(s) 9B-2. . . . . . . . . . . . . . . . . . . . . . . . . . .
Daytime Running Lamps (DRL)
(W/Europe Only) 9B-2. . . . . . . . . . . . . . . . . . . . . . . .
Diagnostic Information and Procedures 9B-3. . . . .
Headlamps 9B-3. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Turn Signal Lamps and Hazard Lamps 9B-4. . . . . . .
Stoplamps and Interior Courtesy Lamp 9B-5. . . . . . .
Rear Fog Lamp 9B-6. . . . . . . . . . . . . . . . . . . . . . . . . . .
Repair Instructions 9B-7. . . . . . . . . . . . . . . . . . . . . . . . .
Headlamps 9B-7. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Turn Signal Lamps 9B-8. . . . . . . . . . . . . . . . . . . . . . . .
Side Turn Signal Lamps 9B-8. . . . . . . . . . . . . . . . . . . .
Taillamps Assembly 9B-9. . . . . . . . . . . . . . . . . . . . . . . .
Front Fog Lamp 9B-9. . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Fog/Backup Lamp(s) 9B-10. . . . . . . . . . . . . . . . .
Center High-Mounted Stoplamp 9B-11. . . . . . . . . . . . CHMSL Mounting Bracket 9B-12. . . . . . . . . . . . . . . . .
License Plate Lamps 9B-12. . . . . . . . . . . . . . . . . . . . . .
Door Jamb Switch 9B-13. . . . . . . . . . . . . . . . . . . . . . . .
Interior Courtesy Lamp 9B-13. . . . . . . . . . . . . . . . . . . .
Daytime Running Lamp Module
(W/Europe Only) 9B-14. . . . . . . . . . . . . . . . . . . . . . .
Ashtray Lamp 9B-14. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Luggage Room Lamp 9B-15. . . . . . . . . . . . . . . . . . . . .
Specifications 9B-16. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bulb Usage Chart 9B-16. . . . . . . . . . . . . . . . . . . . . . . .
Schematic and Routing Diagrams 9B-17. . . . . . . . . .
Backup Lamp(s) Circuit 9B-17. . . . . . . . . . . . . . . . . . .
Headlamps Circuit 9B-18. . . . . . . . . . . . . . . . . . . . . . . .
Headlamp Leveling Circuit 9B-19. . . . . . . . . . . . . . . . .
Tail and Licence Plate Lamps Circuit 9B-20. . . . . . . .
Stoplamps Circuit 9B-21. . . . . . . . . . . . . . . . . . . . . . . .
Turn and Hazard Lamps Circuit 9B-22. . . . . . . . . . . .
Interior Courtesy Lamp Circuit 9B-23. . . . . . . . . . . . . .
Front Fog Lamp Circuit 9B-24. . . . . . . . . . . . . . . . . . . .
Rear Fog Lamp Circuit 9B-25. . . . . . . . . . . . . . . . . . . .
Dimmer Control Circuit (Except W/Europe) 9B-26. .
Daytime Running Lamps Circuit
(W/Europe Only) 9B-27. . . . . . . . . . . . . . . . . . . . . . .

LIGHTING SYSTEMS 9B–17
DAEWOO M-150 BL2
SCHEMATIC AND ROUTING DIAGRAMS
BACKUP LAMP(S) CIRCUIT
D19D201B