wiper fluid DAEWOO MATIZ 2003 Service Repair Manual

GENERAL ENGINE INFORMATION 1A–3
DAEWOO M-150 BL2
COMPONENT LOCATOR
ENGINE COMPARTMENT (TYPICAL)
(Left–Hand Drive Shown, Right–Hand Drive Similar)
D102A401
1 Power Steering Oil Reservoir
2 Coolant Reservoir
3 Canister
4 Canister Solenoid
5 Manifold Absolute Pressure (MAP) Sensor
6 Intake Manifold
7 Ignition Coil
8 Idle Air Control (IAC) Valve
9 Throttle Position (TP) Sensor
10 Throttle Body
11 Brake Fluid Reservoir
12 Wiper Motor13 Battery
14 Fuse Box
15 Air Cleaner Housing
16 Resonator
17 PCV Hose
18 Distributor
19 Exhaust Manifold
20 Snorkel
21 Engine
22 Washer Fluid Reservoir
23 Oil Level Gauge
24 Oil Filler Cap

1A–4 GENERAL ENGINE INFORMATION
DAEWOO M-150 BL2
ENGINE COMPARTMENT (EURO III)
(Left–Hand Drive Shown, Right–Hand Drive Similar)
MAA1A010
1 Power Steering Oil Reservoir
2 Coolant Reservoir
3 Canister Purge Solenoid
4 Manifold Absolute Pressure (MAP) Sensor
5 Intake Manifold
6 Throttle Position (TP) Sensor
7 Throttle Body
8 Idle Air Control (IAC) Valve
9 Brake Fluid Reservoir
10 Wiper Motor11 Battery
12 Fuse Box
13 Air Cleaner Housing
14 Resonator
15 Electronic Ignition System Ignition Coil
16 Exhaust Manifold
17 Snorkel
18 Engine
20 Washer Fluid Reservoir
19 Oil Level Gauge
21 Oil Filler Cap

9D – 2 WIPERS/WASHER SYSTEMS
DAEWOO M-150 BL2
DESCRIPTION AND OPERATION
WINDSHIELD WIPER SYSTEM
The windshield wiper system consists of a wiper motor,
a linkage, a wiper arm and a blade, and a wiper/washer
switch. The windshield wiper circuit incorporates a self-
parking device which consists of a worm gear and a cam
plate in order to keep the circuit engage temporarily
when the switch is turned off. The wiper system is driven
by a permanent magnet-type motor. The windshield wip-
er motor is mounted on the dash panel and is directly
connected to the windshield wiper linkage.
The windshield wiper motor has two speeds, LOW and
HIGH, and also has intermittent wiper capability. The
wiper switch is an integral part of the wiper/washer
switch. Windshield wiper operation is actuated through
the lever on the right side of the steering column.
WINDSHIELD WASHER SYSTEM
The windshield washer system is equipped with a wash-
er fluid reservoir, a washer fluid pump, hoses, nozzles,and a wiper/washer switch. The windshield washer res-
ervoir is mounted inner the front right wheel well splash
shield. Attached to the reservoir is a washer pump,
which pumps fluid through the hoses to the two nozzles
mounted on the cowl panel. The washer switch is an in-
tegral part of the wiper/washer switch. Windshield wash-
er operation is actuated through the lever on the right
side of the steering column.
REAR WIPER/WASHER SYSTEM
The rear wiper/washer system is equipped with the high
grade vehicle. The rear wiper and the washer are one
assembly. The rear washer is installed to the rear wiper.
The rear wiper/washer switch is same with the wind-
shield wiper. Push the switch to one position forward
and the rear wiper operate slowly. And push more the
switch forward and the rear wiper/washer system oper-
ate.

WIPERS/WASHER SYSTEMS 9D–11
DAEWOO M-150 BL2
D19D537A
3. Raise and suitably support the vehicle.
4. Remove the front RH wheelhouse splash shield.

Remove the screws (1).

Remove the clips (2).

Remove the wheelhouse splash shield (3).
D109D538
5. Remove the washer reservoir assembly.

Drain the washer fluid.

Disconnect the washer hose connector (1).

Disconnect the washer pump electrical connector
(2).

Remove the bolts (3).

Remove the washer reservoir assembly (4).
D109D539
Installation Procedure
1. Install the washer reservoir assembly with the bolts.
2. Connect the washer pump electrical connector.
3. Connect the washer hose connector.
4. Install the front RH wheelhouse splash shield with the
screws and the clips.
5. Lower the vehicle.
6. Install the washer reservoir with the bolt.
7. Connect the negative battery cable.
D109D540
WASHER PUMP
Removal Procedure
1. Disconnect the negative battery cable.
2. Remove the washer reservoir assembly. Refer to
“Washer Reservoir” in this section.
3. Drain the washer fluid.
4. Remove the wiper motor from the washer reservoir
assembly.
a. Washer pump.