lock DODGE CALIBER 2006 1.G Manual PDF

TOWING A DISABLED VEHICLE
With Ignition Key
Automatic And Manual Transaxle
Front-wheel-drive vehicles must have the front wheels
elevated; all-wheel-drive vehicles must be hauled on a
flatbed truck.
All Transaxles
CAUTION!
If the vehicle being towed requires steering, the
ignition switch must be in the ACCESSORY posi-
tion, not in the LOCK position.
Do not attempt to use sling type equipment when
towing. When securing vehicle to flat bed truck, do not
attach to front or rear suspension components. Damage
to your vehicle may result from improper towing.
If it is necessary to use the accessories while being towed
(wipers, defrosters, etc.), the key must be in the ON
position, not the ACCESSORY position. Make certain the
transaxle remains in NEUTRAL.
Without The Ignition Key
Special care must be taken when the vehicle is towed
with the ignition in the LOCK position. A dolly should be
used under the front wheels if the rear wheels are raised.
Proper towing equipment is necessary to prevent dam-
age to the vehicle.
Battery power is required to release the brake/
transmission interlock system. There is a removable plug
in the right side of the shifter housing that allows you to
insert your finger to override the system.
Towing This Vehicle Behind Another Vehicle (Flat
Towing With All Four Wheels On The Ground)
CAUTION!
DO NOT flat tow this vehicle. Damage to the driv-
etrain will result.
238 WHAT TO DO IN EMERGENCIES

WARNING!
Fluid level should be checked on a level surface and
with the engine off to prevent injury from moving
parts and to insure accurate fluid level reading. Do
not overfill. Use only manufacturers recommended
power steering fluid.
If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
surfaces. Refer to Fluids, Lubricants, and Genuine Parts
for correct fluid types.
Front Suspension Ball Joints
There are two front suspension lower ball joints that are
permanently lubricated. Inspect these ball joints when-
ever under vehicle service is done. Damaged seals and
their corresponding potentially damaged ball joints must
be replaced.
Body Lubrication
Locks and all body pivot points, including such items as
seat tracks, doors, liftgate and hood hinges, should be
lubricated periodically to assure quiet, easy operation
and to protect against rust and wear. Prior to the appli-
cation of any lubricant, the parts concerned should be
wiped clean to remove dust and grit; after lubricating
excess oil and grease should be removed. Particular
attention should also be given to hood latching compo-
nents to insure proper function. When performing other
underhood services, the hood latch, release mechanism
and safety catch should be cleaned and lubricated.
The external lock cylinders should be lubricated twice a
year, preferably in the fall and spring. Apply a small
amount of a high quality lubricant such as MopartLock
Cylinder Lubricant directly into the lock cylinder.
Windshield Wiper Blades
Clean the rubber edges of the wiper blades and the
windshield periodically with a sponge or soft cloth and a
mild non abrasive cleaner or use the washer solvent. This
will remove accumulations of salt, waxes or road film
and help reduce streaking and smearing.
254 MAINTAINING YOUR VEHICLE

Operation of the wipers on dry glass for long periods may
cause deterioration of the wiper blades. Always use washer
fluid when using the wipers to remove salt or dirt from a
dry windshield. Avoid using the wiper blades to remove
frost or ice from the windshield. make sure that they are
not frozen to the glass before turning them on to avoid
damaging the blade. Keep the blade rubber out of contact
with petroleum products such as engine oil, gasoline, etc.
Windshield Wiper Blade Replacement
1. Lift the wiper arm away from the glass.
2. Push the release tab shown in the illustration and slide
the wiper blade assembly down along the arm. Gently
place the wiper arm on the windshield.
3. Install the new blade assembly onto the wiper arm tip
until it locks in place.
Windshield Washer Reservoir
The washer fluid reservoir is located in the rear of the
engine compartment on the right side and should be
checked for fluid level at regular intervals. Fill the
reservoir with windshield washer solvent (not radiator
antifreeze).
Exhaust System
The best protection against carbon monoxide entry into the
vehicle body is a properly maintained engine exhaust
system.
If you notice a change in the sound of the exhaust system,
or if exhaust fumes can be detected inside the vehicle, or
when the underside or rear of the vehicle is damaged;
have a competent technician inspect the complete ex-
haust system and adjacent body areas for broken, dam-
aged, deteriorated, or mispositioned parts. Open seams
or loose connections could permit exhaust fumes to seep
into the passenger compartment. In addition, inspect the
exhaust system each time the vehicle is raised for an oil
change or lubrication. Replace as required.
WARNING!
Exhaust gases can injure or kill. They contain carbon
monoxide (CO) which is colorless and odorless.
Breathing it can make you unconscious and can even-
tually poison you. To avoid breathing CO, refer to
Exhaust Gas in the Safety Tips section of this manual.
MAINTAINING YOUR VEHICLE 255
7

Cavity Cartridge
FuseMini
FuseDescription
1 40 Amp
GreenPower Top Feed
2 20 Amp
YellowAWD ECU Feed
3 10 Amp
RedCHMSL Brake Switch
Feed
4 10 Amp
RedIgnition Switch Feed
5 20 Amp
YellowTrailer Tow
6 10 Amp
RedIOD Sw/Pwr Mir/
Ocm Steering Cntrl
Sdar/Hfm
7 30 Amp
GreenIOD Sense1
8 30 Amp
GreenIOD Sense2
9 40 Amp
GreenPower SeatsCavity Cartridge
FuseMini
FuseDescription
10 20 Amp
YellowCCN Power Locks
11 15 Amp
Lt BluePower Outlet
12 20 Amp
YellowIgn Run/Acc Inverter
13 20 Amp
YellowPwr run/Acc Outlet
RR
14 10 Amp
RedIOD CCN/ Interior
Lighting
15 40 Amp
GreenRAD Fan Relay Bat-
tery Feed
16 15 Amp
Lt. BlueIGN Run/Acc Cigar
Ltr/Sunroof
17 10 Amp
RedIOD Feed Mod-Wcm
18 40 Amp
GreenASD Relay Contact
PWR Feed
19 20 Amp
YellowPWR Amp 1 & Amp
2 Feed
270 MAINTAINING YOUR VEHICLE

LIGHTS BULBS Ð Outside Bulb No.
Low Beam/High Beam Headlight............ H13
Front Park/Turn Signal/Side Marker Light. . . 3157AK
Front Fog Light.........................9145
Center High Mounted Stop Light
(CHMSL)...................... LEDAssembly
Rear Tail/Stop..........................3157
Rear Turn Signal......................3157AK
Backup Light.....................W16W (921)
License Light.......................... W5W
BULB REPLACEMENT
Headlights/Front Parking/Front Turn Signal
See your Authorized Dealer for replacement.
Fog Lights
1. Access lamp through the lower fascia cutout.
2. Rotate bulb and connector 1/4 turn counterclockwise.
3. Pull bulb off of connector.
Fog Light and Connector
MAINTAINING YOUR VEHICLE 273
7

2. Rotate the socket 1/4 turn counterclockwise. 3. Pull bulb from socket.
Center High-Mounted Stoplight
Light is an LED assembly. See your authorized dealer for
replacement.
Removing Socket from LampRemoving Bulb From Socket
MAINTAINING YOUR VEHICLE 277
7

ABS (Anti-Lock Brake System)............. 186
Adding Engine Coolant (Antifreeze)......... 257
Adding Fuel.......................... 214
Adding Washer Fluid..................82,102
Additives, Fuel........................ 212
Air Cleaner, Engine (Engine Air Cleaner Filter) . 251
Air Conditioner Maintenance.............. 253
Air Conditioning Controls................ 164
Air Conditioning, Operating Tips........... 168
Air Conditioning Refrigerant.............. 253
Air Conditioning System..............164,253
Air Pressure, Tires...................... 199
Airbag................................ 39
Airbag Deployment...................... 48
Airbag Light......................50,61,112
Airbag Maintenance...................... 50
Airbag, Side........................... 47
Alarm System (Security Alarm)..........24,112
Alignment and Balance.................. 205
All Wheel Drive (AWD).................. 183
Alterations/Modifications, Vehicle............ 6
Antenna, Satellite Radio.................. 161
Antifreeze (Engine Coolant).........256,278,279Capacities........................... 278
Disposal............................ 258
Anti-Lock Brake System (ABS)...........86,186
Anti-Theft Security Alarm (Theft Alarm)...... 24
Appearance Care....................... 265
Automatic Door Locks..................16,17
Automatic Transaxle...........9,174,176,229,263
Fluid Level Check..................... 263
Interlock System....................14,177
Overheating......................... 229
Selection Of Lubricant................. 263
Shifting............................ 177
Special Additives..................... 264
Autostick............................. 179
Ball Joints............................ 254
Battery............................... 251
Keyless Transmitter Replacement (RKE)..... 23
Belts, Drive........................... 249
Beverage Cooler........................ 103
Body Mechanism Lubrication.............. 254
B-Pillar Location....................... 194
Brake Assist System...................... 87
308 INDEX

Brake Fluid........................... 280
Brake, Parking......................... 183
Brake System.......................185,260
Anti-Lock (ABS)....................86,186
Hoses.............................. 261
Master Cylinder...................... 262
Parking............................ 183
Warning Light....................... 117
Brakes............................185,260
Brake/Transmission Interlock.............. 177
Break-In Recommendations, New Vehicle...... 59
Bulb Replacement...................272,273
Bulbs, Light........................... 272
Calibration, Compass.................... 127
Capacities, Antifreeze (Engine Coolant)...... 278
Capacities, Fluid....................... 278
Caps, Filler
Fuel............................... 214
Oil (Engine)......................241,247
Car Washes........................... 266
Carbon Monoxide Warning............... 213
Cargo Area Cover....................... 98Cargo Area Features..................... 96
Cargo Compartment
Light............................... 96
Luggage Carrier...................... 102
Cargo Light............................ 96
Cargo Load Floor....................... 99
Cargo Tie-Downs........................ 99
Carrier, Luggage....................... 102
Catalytic Converter..................... 249
Caution, Exhaust Gas..................... 60
CD (Compact Disc) Player..........129,136,147
CD (Compact Disc) Player Maintenance...... 163
Cellular Phone......................... 163
Center High Mounted Stop Light........... 277
Chains, Tire........................... 209
Changing A Flat Tire.................... 230
Chart, Tire Sizing....................... 191
Check Engine Light (Malfunction Indicator
Light)............................... 243
Child Restraint......................... 52
Child Restraint Tether Anchors............. 56
Child Restraint with Automatic Belts......... 55
Child Safety Locks....................... 18
INDEX 309
10

Child Seat............................. 57
Clean Air Gasoline...................... 211
Cleaning
Wheels............................. 267
Climate Control........................ 164
Clock.......................128,131,137,148
Clutch............................... 262
Clutch Fluid........................... 262
Coin Holder........................... 96
Compact Disc (CD) Maintenance........... 163
Compact Spare Tire..................... 201
Compass............................. 127
Compass Calibration.................... 127
Compass Variance...................... 125
Console............................... 96
Contract, Service....................... 302
Coolant (Antifreeze)..................278,279
Cooler, Beverage....................... 103
Cooling System........................ 256
Adding Coolant (Antifreeze)............. 257
Coolant Level.....................256,259
Disposal of Used Coolant............... 258
Drain, Flush, and Refill................. 256Inspection........................... 259
Points to Remember................258,259
Pressure Cap........................ 258
Selection of Coolant (Antifreeze).......... 256
Corrosion Protection.................... 265
Crankcase Emission Control System......... 250
Cruise Light........................... 115
Cup Holder............................ 96
Customer Assistance.................... 300
Data Recorder, Event..................... 50
Dealer Service......................... 244
Defroster, Rear Window.................. 102
Defroster, Windshield..................61,165
Delay (Intermittent) Wipers................ 82
Diagnostic System, Onboard............... 242
Dimmer Switch, Headlight................. 80
Disposal
Antifreeze (Engine Coolant)............. 258
Engine Oil.......................... 248
Door Locks............................ 14
Door Locks, Automatic................... 16
Downshifting.......................... 182
310 INDEX

Latches
Hood............................... 76
Lead Free Gasoline...................... 211
Life of Tires........................... 204
Liftgate (Sedan)......................... 26
Liftgate Window Wiper/Washer............ 101
Light Bulbs........................... 272
Lights..............................61,77
Airbag.........................50,61,112
Back-Up............................ 274
Brake Warning....................... 117
Bulb Replacement..................... 273
Cargo ............................... 96
Center Mounted Stop.................. 277
Daytime Running...................... 78
Dimmer Switch, Headlight............... 77
Electronic Stability Program (ESP) Indicator . . 88
Engine Temperature Warning............ 113
Fog ...........................79,116,273
Headlight Switch...................... 78
Headlights........................... 78
High Beam Indicator................... 117
Instrument Cluster..................... 78License............................. 276
Lights On Reminder.................... 79
Low Fuel........................... 112
Malfunction Indicator (Check Engine)...... 114
Map Reading......................... 77
Oil Pressure......................... 112
Rear Fog............................ 119
Seat Belt Reminder.................... 112
Security Alarm (Theft Alarm)............. 25
Theft Alarm (Security Alarm)............ 112
Traction Control....................... 88
Turn Signal...................77,79,116,274
Voltage............................. 112
Warning (Instrument Cluster Description) . . . 111
Loading Vehicle........................ 217
Tires ............................... 194
Locks
Child Protection....................... 18
Door............................... 14
Power Door.......................... 15
Steering Wheel........................ 13
Lubrication, Body....................... 254
Luggage Rack (Roof Rack)................ 102
314 INDEX