coolant DODGE CALIBER SRT 2008 1.G User Guide

When additional coolant is needed to maintain the
proper level, it should be added to the coolant bottle. Do
not overfill.
Points To Remember
NOTE:When the vehicle is stopped after a few miles (a
few kilometers) of operation, you may observe vapor
coming from the front of the engine compartment. This is
normally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot coolant to
enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
²Do not overfill the coolant recovery bottle.
²Check coolant freeze point in the radiator and in the
coolant recovery bottle. If antifreeze needs to be
added, contents of coolant recovery bottle must also be
protected against freezing.
²If frequent coolant additions are required, or if the
level in the coolant recovery bottle does not drop when
the engine cools, the cooling system should be pres-
sure tested for leaks.
²Maintain coolant concentration at 50% HOAT engine
coolant (minimum) and distilled water for proper
corrosion protection of your engine which contains
aluminum components.
²Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
²Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean, also.
MAINTAINING YOUR VEHICLE 313
7

²Do not change the thermostat for summer or winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory coolant performance, poor gas
mileage, and increased emissions.
Hoses And Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling indicate deterioration of the rubber
Pay particular attention to the hoses nearest to high heat
sources such as the exhaust manifold. Inspect hose rout-
ing to be sure hoses do not touch any heat source or
moving component that may cause heat damage or
mechanical wear.
Insure nylon tubing in these areas has not melted or
collapsedInspect all hose connections such as clamps and cou-
plings to make sure the are secure and no leaks are
present.
Components should be replaced immediately if there is
any evidence of degradation that could cause failure.Fuel System Connections
Electronic Fuel Injection high pressure fuel systems are
designed with tubes and special connects, connections
and clamps which have unique material characteristics to
provide adequate sealing and resist attack by deterio-
rated gasoline.
You are urged to use only the manufactures-specified
tubes, connections and clamps, or their equivalent in
material and specification, in any fuel system servicing.
314 MAINTAINING YOUR VEHICLE

FLUIDS AND CAPACITIES
U.S. Metric
Fuel (Approximate)13.5 Gallons 51.0 Liters
Engine Oil-With Filter5.0 Quarts 4.7 Liters
Cooling System *
MopartAntifreeze/Coolant 5 Year/100,000 Miles Formula), or
equivalent.7.5 Quarts 7.1 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
MAINTAINING YOUR VEHICLE 333
7

FLUIDS, LUBRICANTS, AND GENUINE PARTS
Engine
Component Fluids, Lubricants and Genuine Parts
Engine Coolant MopartAntifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid Or-
ganic Additive Technology) or equivalent.
Engine Oil For best performance and maximum protection under all types of operating
conditions, the manufacturer only recommends full synthetic engine oils that
meet the requirements of DaimlerChrysler Material Standard MS-10725. The
manufacturer recommends the use of a full synthetic engine oil, such as Mo-
bil 1tSAE 0W-40 or equivalent. For additional information, refer to the ªEn-
gine Oil Selectionº and ªEngine Oil Viscosity (SAE Grade)º in the ªMainte-
nance Proceduresº section of this manual.
Engine Oil Filter Mopart04884899AB or equivalent.
Spark Plugs ZFR5AP (Gap 0.030º)
Fuel Selection Premium Unleaded 93 Octanerecommended.
334 MAINTAINING YOUR VEHICLE

²Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
²Check all lights and other electrical items for correct
operation.At Each Oil Change
²Change the engine oil filter.
²Inspect the brake hoses and lines.
²Check the Manual Transmission fluid level.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
340 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Perform Maintenance Every(Where time and mileage
are listed, follow the interval that occurs first.)
Maintenance Items Miles Kilometers or Months
Change the manual transmission fluid if using your
vehicle for any of the following: trailer towing, snow
plowing, heavy loading, taxi, police, delivery service
(commercial service), off-road, desert operation or
more then 50% of your driving is at sustained high
speeds during hot weather, above 90ÉF (32ÉC).48,000 80 000 48
Inspect and replace PCV valve if necessary.90,000 150 000 90
Flush and replace the engine coolant. 102,000 170 000 60
Replace the spark plugs.102,000 170 000 102
Replace Accessory Drive Belt(s). 120,000 200 000 120
342 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

ABS (Anti-Lock Brake System).............. 231
Adding Engine Coolant (Antifreeze).......... 311
Adding Fuel........................... 268
Adding Washer Fluid.................. 118,147
Additives, Fuel......................... 266
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 302
Air Conditioner Maintenance............... 304
Air Conditioning Controls................. 213
Air Conditioning, Operating Tips............ 218
Air Conditioning Refrigerant.............304,305
Air Conditioning System................213,304
Air Pressure, Tires....................... 247
Airbag................................ 44
Airbag Deployment....................... 52
Airbag Light.......................54,66,158
Airbag Maintenance....................... 53
Airbag, Side............................ 50
Airbag, Window (Side Curtain)............... 45
Alarm System (Security Alarm)............28,158Alignment and Balance................... 253
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 208
Antifreeze (Engine Coolant)...........310,333,334
Capacities........................... 333
Disposal............................ 312
Anti-Lock Brake System (ABS)............128,231
Anti-Theft Security Alarm (Theft Alarm)........ 28
Appearance Care........................ 318
Automatic Door Locks...................19,20
Ball Joints............................. 306
Battery............................... 302
Keyless Transmitter Replacement (RKE)....... 27
Belts, Drive............................ 299
Beverage Cooler........................ 148
Body Mechanism Lubrication............... 306
B-Pillar Location........................ 242
Brake Assist System...................... 130
356 INDEX

Brake Control System, Electronic............. 129
Brake Fluid............................ 335
Brake, Parking.......................... 228
Brake System........................230,315
Anti-Lock (ABS)....................128,231
Hoses.............................. 315
Master Cylinder....................... 316
Parking............................. 228
Warning Light........................ 161
Brakes.............................230,315
Break-In Recommendations, New Vehicle........ 65
Bulb Replacement....................... 327
Bulbs, Light............................ 327
Calibration, Compass..................... 178
Capacities, Antifreeze (Engine Coolant)........ 333
Capacities, Fluid........................ 333
Caps, Filler
Fuel................................ 268Oil (Engine).......................291,298
Car Washes............................ 319
Carbon Monoxide Warning................. 267
Cargo Area Cover....................... 143
Cargo Area Features...................... 141
Cargo Compartment
Light............................... 141
Luggage Carrier....................... 148
Cargo Light............................ 141
Cargo Load Floor........................ 144
Cargo Tie-Downs........................ 144
Carrier, Luggage........................ 148
Catalytic Converter...................... 300
Caution, Exhaust Gas...................... 65
CD (Compact Disc) Player...............181,188
CD (Compact Disc) Player Maintenance........ 211
Cellular Phone........................76,211
Center High Mounted Stop Light............ 332
Chains, Tire............................ 253
INDEX 357
10

Chart, Tire Sizing........................ 239
Check Engine Light (Malfunction Indicator
Light)................................ 293
Child Restraint.......................... 56
Child Restraint Tether Anchors............... 60
Child Restraint with Automatic Belts........... 59
Child Safety Locks........................ 21
Child Seat.............................. 63
Clean Air Gasoline....................... 264
Cleaning
Wheels............................. 320
Climate Control......................... 213
Clock........................180,183,190,203
Clutch............................... 316
Clutch Fluid........................... 316
Coin Holder........................... 140
Compact Disc (CD) Maintenance............. 211
Compass.............................. 178
Compass Calibration..................... 178Compass Variance....................... 176
Console.............................. 140
Contract, Service........................ 349
Cool Down, Turbo....................... 226
Coolant (Antifreeze)...................333,334
Cooler, Beverage........................ 148
Cooling System......................... 309
Adding Coolant (Antifreeze).............. 311
Coolant Level......................309,312
Disposal of Used Coolant................ 312
Drain, Flush, and Refill.................. 309
Inspection........................... 312
Points to Remember................. 311,313
Pressure Cap......................... 311
Selection of Coolant (Antifreeze)........... 310
Corrosion Protection..................... 318
Crankcase Emission Control System.......... 301
Cruise Light........................... 160
Cup Holder............................ 140
358 INDEX

Customer Assistance..................... 347
Data Recorder, Event...................... 54
Dealer Service.......................... 295
Defroster, Rear Window................... 147
Defroster, Windshield...................66,214
Delay (Intermittent) Wipers................. 117
Diagnostic System, Onboard................ 292
Dimmer Switch, Headlight................. 114
Disposal
Antifreeze (Engine Coolant)............... 312
Engine Oil........................... 299
Door Locks............................. 17
Door Locks, Automatic.................... 19
Door Opener, Garage..................... 122
Downshifting.......................... 227
Drive Belts............................ 299
Driver's Seat Back Tilt.................... 105Driving
On Slippery Surfaces.................... 234
Through Flowing, Rising, or Shallow Standing
Water................................ 235
Electric Remote Mirrors.................... 74
Electrical Power Outlets................... 138
Electronic Brake Control System............. 129
Brake Assist System.................... 130
Electronic Stability Program............... 131
Traction Control System................. 129
Electronic Speed Control (Cruise Control)....... 119
Electronic Stability Program (ESP)............ 131
Electronic Vehicle Information Center (EVIC).... 166
Emergency, In Case of
Jump Starting......................... 284
Towing............................. 287
Emission Control System Maintenance......293,338
Engine.............................65,291
INDEX 359
10