fuel DODGE CALIBER SRT 2008 1.G Owner's Guide

Fuel Filter
A plugged fuel filter can cause hard starting or limit the
speed at which a vehicle can be driven. Should an
excessive amount of dirt accumulate in the fuel tank,
frequent filter replacement may be necessary. The fuel
filters are located inside the fuel tank. See your dealer for
service.
Air Cleaner Element (Filter)
Replace the filter at the intervals shown in the ªMainte-
nance Schedule.º Refer to Section 8 of this manual.
NOTE:For vehicles with a Turbo engine, a small
amount of oil accumulation in the air cleaner box is
normal. The amount will depend on driving style. The air
cleaner box should be cleaned out and a new make-up-
air filter element should be installed during the normal
air filter maintenance procedure.
WARNING!
The air cleaner can provide a measure of protection
in the case of engine backfire. Do not remove the air
cleaner unless such removal is necessary for repair or
maintenance. Make sure that no one is near the
engine compartment before starting the vehicle with
the air cleaner removed. Failure to do so can result in
serious personal injury.
Maintenance-Free Battery
You will never have to add water, nor is periodic main-
tenance required.
302 MAINTAINING YOUR VEHICLE

²Do not change the thermostat for summer or winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory coolant performance, poor gas
mileage, and increased emissions.
Hoses And Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling indicate deterioration of the rubber
Pay particular attention to the hoses nearest to high heat
sources such as the exhaust manifold. Inspect hose rout-
ing to be sure hoses do not touch any heat source or
moving component that may cause heat damage or
mechanical wear.
Insure nylon tubing in these areas has not melted or
collapsedInspect all hose connections such as clamps and cou-
plings to make sure the are secure and no leaks are
present.
Components should be replaced immediately if there is
any evidence of degradation that could cause failure.Fuel System Connections
Electronic Fuel Injection high pressure fuel systems are
designed with tubes and special connects, connections
and clamps which have unique material characteristics to
provide adequate sealing and resist attack by deterio-
rated gasoline.
You are urged to use only the manufactures-specified
tubes, connections and clamps, or their equivalent in
material and specification, in any fuel system servicing.
314 MAINTAINING YOUR VEHICLE

FLUIDS AND CAPACITIES
U.S. Metric
Fuel (Approximate)13.5 Gallons 51.0 Liters
Engine Oil-With Filter5.0 Quarts 4.7 Liters
Cooling System *
MopartAntifreeze/Coolant 5 Year/100,000 Miles Formula), or
equivalent.7.5 Quarts 7.1 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
MAINTAINING YOUR VEHICLE 333
7

FLUIDS, LUBRICANTS, AND GENUINE PARTS
Engine
Component Fluids, Lubricants and Genuine Parts
Engine Coolant MopartAntifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid Or-
ganic Additive Technology) or equivalent.
Engine Oil For best performance and maximum protection under all types of operating
conditions, the manufacturer only recommends full synthetic engine oils that
meet the requirements of DaimlerChrysler Material Standard MS-10725. The
manufacturer recommends the use of a full synthetic engine oil, such as Mo-
bil 1tSAE 0W-40 or equivalent. For additional information, refer to the ªEn-
gine Oil Selectionº and ªEngine Oil Viscosity (SAE Grade)º in the ªMainte-
nance Proceduresº section of this manual.
Engine Oil Filter Mopart04884899AB or equivalent.
Spark Plugs ZFR5AP (Gap 0.030º)
Fuel Selection Premium Unleaded 93 Octanerecommended.
334 MAINTAINING YOUR VEHICLE

if it has been 6 months since your last oil change even
if the oil change indicator message is NOT illumi-
nated.
²Change your engine oil more often if you drive your
vehicle off-road for an extended period of time.
²Under no circumstances should oil change intervals
exceed 6,000 miles (10,000 km) or 6 months, whichever
comes first.
Your dealer will reset the oil change indicator message
after completing the scheduled oil change. If this sched-
uled oil change is performed by someone other than your
dealer the message can be reset by referring to the steps
described under ªOil Change Requiredº in ªUse Factory
Settingsº of the EVIC section in this manual or under
ªOdometer/Trip Odometerº in the ªInstrument Cluster
Descriptions section of this manual.At Each Stop for Fuel
²Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
²Check the windshield washer solvent and add if
required.
Once a Month
²Check tire pressure and look for unusual wear or
damage.
²Inspect the battery and clean and tighten the terminals
as required.
MAINTENANCE SCHEDULES 339
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

ABS (Anti-Lock Brake System).............. 231
Adding Engine Coolant (Antifreeze).......... 311
Adding Fuel........................... 268
Adding Washer Fluid.................. 118,147
Additives, Fuel......................... 266
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 302
Air Conditioner Maintenance............... 304
Air Conditioning Controls................. 213
Air Conditioning, Operating Tips............ 218
Air Conditioning Refrigerant.............304,305
Air Conditioning System................213,304
Air Pressure, Tires....................... 247
Airbag................................ 44
Airbag Deployment....................... 52
Airbag Light.......................54,66,158
Airbag Maintenance....................... 53
Airbag, Side............................ 50
Airbag, Window (Side Curtain)............... 45
Alarm System (Security Alarm)............28,158Alignment and Balance................... 253
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 208
Antifreeze (Engine Coolant)...........310,333,334
Capacities........................... 333
Disposal............................ 312
Anti-Lock Brake System (ABS)............128,231
Anti-Theft Security Alarm (Theft Alarm)........ 28
Appearance Care........................ 318
Automatic Door Locks...................19,20
Ball Joints............................. 306
Battery............................... 302
Keyless Transmitter Replacement (RKE)....... 27
Belts, Drive............................ 299
Beverage Cooler........................ 148
Body Mechanism Lubrication............... 306
B-Pillar Location........................ 242
Brake Assist System...................... 130
356 INDEX

Brake Control System, Electronic............. 129
Brake Fluid............................ 335
Brake, Parking.......................... 228
Brake System........................230,315
Anti-Lock (ABS)....................128,231
Hoses.............................. 315
Master Cylinder....................... 316
Parking............................. 228
Warning Light........................ 161
Brakes.............................230,315
Break-In Recommendations, New Vehicle........ 65
Bulb Replacement....................... 327
Bulbs, Light............................ 327
Calibration, Compass..................... 178
Capacities, Antifreeze (Engine Coolant)........ 333
Capacities, Fluid........................ 333
Caps, Filler
Fuel................................ 268Oil (Engine).......................291,298
Car Washes............................ 319
Carbon Monoxide Warning................. 267
Cargo Area Cover....................... 143
Cargo Area Features...................... 141
Cargo Compartment
Light............................... 141
Luggage Carrier....................... 148
Cargo Light............................ 141
Cargo Load Floor........................ 144
Cargo Tie-Downs........................ 144
Carrier, Luggage........................ 148
Catalytic Converter...................... 300
Caution, Exhaust Gas...................... 65
CD (Compact Disc) Player...............181,188
CD (Compact Disc) Player Maintenance........ 211
Cellular Phone........................76,211
Center High Mounted Stop Light............ 332
Chains, Tire............................ 253
INDEX 357
10

Break-In Recommendations................ 65
Checking Oil Level..................... 296
Cooling............................. 309
Exhaust Gas Caution.................... 267
Fuel Requirements..................... 264
Jump Starting......................... 284
Oil ...........................296,333,334
Oil Change Interval.................... 297
Oil Filler Cap......................291,298
Oil Filter............................ 334
Oil Selection.......................... 297
Operation............................ 65
Overheating.......................... 274
Temperature Gauge..................... 157
Enhanced Accident Response Feature.......... 53
Ethanol............................... 265
Event Data Recorder...................... 54
Exhaust Gas Caution..............31,65,267,308
Exhaust System......................... 308Filler Location Fuel...................... 157
Filters
Air Cleaner.......................... 302
Engine Fuel.......................... 302
Engine Oil........................299,334
Flashers.............................. 274
Hazard Warning....................... 274
Turn Signal.......................... 328
Flooded Engine Starting................... 225
Fluid, Brake........................... 335
Fluid Capacities......................... 333
Fluid Leaks............................. 67
Fluids................................ 334
Fluids, Lubricants and Genuine Parts.......... 334
Fog Lights....................... 113,162,328
Folding Rear Seat........................ 107
Folding Rear Seat (Sedan).................. 107
Freeing A Stuck Vehicle................... 286
Fuel..............................264,334
360 INDEX

Adding............................. 268
Additives............................ 266
Capacity............................ 333
Clean Air............................ 264
Ethanol............................. 265
Filler Cap (Gas Cap).................157,268
Filler Door (Gas Cap)................... 157
Filter............................... 302
Gasoline............................ 264
Gauge.............................. 157
Hoses.............................. 314
Light............................... 158
Materials Added....................... 266
Methanol............................ 265
Octane Rating........................ 264
Requirements......................... 264
System Hoses......................... 314
Tank Capacity........................ 333
Fuel System Caution..................... 270Fueling............................... 268
Fuses................................ 323
Garage Door Opener (HomeLinkt) ........... 122
Gas Cap (Fuel Filler Cap)............268,269,293
Gasoline, Clean Air...................... 264
Gasoline (Fuel).......................264,333
Gasoline, Reformulated................... 264
Gauges
Coolant Temperature.................... 157
Fuel................................ 157
Odometer........................... 159
Tachometer.......................... 158
General Information.................16,103,263
General Maintenance..................... 296
Glass Cleaning.......................... 322
Glove Compartment...................... 148
Gross Vehicle Weight Rating................ 270
INDEX 361
10

Key-In Reminder......................... 12
Keyless Entry System (Sedan)................ 22
Keys................................. 12
Lane Change and Turn Signals...........162,328
Lap/Shoulder Belts....................... 33
Latches
Hood............................... 109
Lead Free Gasoline...................... 264
Life of Tires............................ 251
Liftgate (Sedan).......................... 29
Liftgate Window Wiper/Washer............. 146
Light Bulbs............................ 327
Lights..............................67,110
Airbag..........................54,66,158
Back-Up............................. 328
Brake Warning........................ 161
Bulb Replacement...................... 327
Cargo .............................. 141Center Mounted Stop................... 332
Daytime Running...................... 115
Dimmer Switch, Headlight................ 111
Electronic Stability Program (ESP)
Indicator...........................131,133
Engine Temperature Warning.............. 159
Fog .......................... 113,162,328
Headlight Switch...................... 111
Headlights........................... 111
High Beam Indicator.................... 165
Instrument Cluster..................... 111
License............................. 331
Lights On Reminder.................... 112
Low Fuel............................ 158
Malfunction Indicator (Check Engine)........ 164
Map Reading......................... 110
Oil Pressure.......................... 159
Seat Belt Reminder..................... 158
Security Alarm (Theft Alarm).............. 29
INDEX 363
10