fuel pressure DODGE CARAVAN 2008 5.G User Guide

²Do not change the thermostat for summer or winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory coolant performance, poor gas
mileage, and increased emissions.
HOSES AND VACUUM/VAPOR HARNESSES
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling indicate deterioration of the rubber.
Pay particular attention to those hoses nearest to high
heat sources such as the exhaust manifold. Inspect hose
routing to be sure hoses do not come in contact with any
heat source or moving component which may cause heat
damage or mechanical wear.
Ensure nylon tubing in these areas has not melted or
collapsed.Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
Components should be replaced immediately if there is
any evidence of wear or damage that could cause failure.FUEL SYSTEM CONNECTIONS
The Electronic Fuel Injection high-pressure fuel system's
hoses and quick connect fittings have unique material
characteristics that provide adequate sealing and resist
attack by deteriorated gasoline.
You are urged to use only the manufacture specified
hoses with quick connect fittings, or their equivalent in
material and specification, in any fuel system servicing. It
is mandatory to replace any damaged hoses or quick
connect fittings that have been removed during service.
Care should be taken in installing quick connect fittings
to ensure they are properly installed and fully connected.
See your authorized dealer for service.
MAINTAINING YOUR VEHICLE 461
7

NOTE:
²The oil change indicator message will not monitor the
time since the last oil change. Change your vehicle's
oil if it has been six months since your last oil change
even if the oil change indicator message is NOT
illuminated.
²Change your engine oil more often if you drive your
vehicle off-road for an extended period of time.
²Under no circumstances should oil change intervals
exceed 6,000 mi (10 000 km) or six months, whichever
comes first.
Your authorized dealer will reset the oil change indicator
message after completing the scheduled oil change. If this
scheduled oil change is performed by someone other
than your dealer, the message can be reset by referring to
the steps described under ªOil Change Requiredº in ªUse
Factory Settingsº of the EVIC section in this manual orunder ªOdometer/Trip Odometerº in the ªInstrument
Cluster Descriptions section of this manual.
At Each Stop For Fuel
²Check the engine oil level about five minutes after a
fully warmed engine is shut off. Checking the oil level
while the vehicle is on level ground will improve the
accuracy of the oil level reading. Add oil only when
the level is at or below the ADD, SAFE or MIN mark.
²Check the windshield washer solvent and add if
required.
Once A Month
²Check tire pressure and look for unusual wear or
damage.
²Inspect the battery and clean and tighten the terminals
as required.
MAINTENANCE SCHEDULES 491
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Adding Engine Coolant (Antifreeze).......... 458
Adding Fuel........................... 382
Adding Washer Fluid..................... 455
Additives, Fuel......................... 380
Adjustable Pedals....................... 177
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 445
Air Conditioner Maintenance............... 450
Air Conditioning........................ 301
Air Conditioning Controls................. 301
Air Conditioning Filter.................320,451
Air Conditioning, Operating Tips............ 319
Air Conditioning, Rear Zone.............307,314
Air Conditioning Refrigerant............... 450
Air Conditioning System.............301,309,450
Air Conditioning System, Zone Control........ 305
Air Pressure, Tires....................... 358
Airbag..............................66,74
Airbag Deployment....................... 75
Airbag Light...................67,73,77,94,233Airbag Maintenance....................... 76
Airbag, Side........................68,72,74
Airbag, Window (Side Curtain)...........70,72,74
Alarm Light........................... 233
Alarm (Security Alarm).................... 18
Alignment and Balance................... 366
Alterations/Modifications, Vehicle............. 7
Antenna, Satellite Radio................... 288
Antifreeze (Engine Coolant)...........457,458,486
Disposal............................ 459
Anti-Lock Brake System (ABS).............. 338
Anti-Lock Warning Light...............227,339
Anti-Theft System........................ 18
Appearance Care........................ 467
Ashtray............................... 201
Assistance Towing....................... 117
Audio Systems (Radio).................280,283
Auto Down Power Windows................ 39
Auto Up Power Windows................40,194
508 INDEX

Brakes.............................337,462
Brake/Transmission Interlock............... 328
Break-In Recommendations, New Vehicle........ 93
Bulb Replacement....................... 482
Bulbs, Light............................ 481
Calibration, Compass..................240,246
Capacities, Fluid........................ 486
Caps, Filler
Fuel................................ 382
Oil (Engine).......................434,443
Radiator (Coolant Pressure)............... 458
Car Washes............................ 468
Carbon Monoxide Warning................. 381
Cargo Compartment
Luggage Carrier....................... 215
Cargo (Vehicle Loading)................... 214
Catalytic Converter...................... 446
Caution, Exhaust Gas.................51,95,381CD (Compact Disc) Player...............280,283
CD (Compact Disc) Player Maintenance........ 300
Cellular Phone.................104,283,284,299
Center High Mounted Stop Light............ 485
Chains, Tire............................ 367
Changing A Flat Tire..................... 412
Chart, Tire Sizing........................ 350
Check Engine Light
(Malfunction Indicator Light).............232,438
Child Restraint........................81,83
Child Restraint Tether Anchors............... 86
Child Safety Locks........................ 46
Child Seat.............................. 88
Clean Air Gasoline....................... 378
Cleaning
Wheels............................. 470
Climate Control......................... 301
Clock........................254,269,281,285
Coat Hook............................ 214
510 INDEX

License............................. 485
Lights On Reminder.................... 165
Low Fuel............................ 234
Malfunction Indicator (Check Engine)........ 232
Oil Pressure.......................... 233
Park.............................162,483
Passing............................. 170
Reading............................. 183
Rear Servicing........................ 484
Rear Tail............................ 484
Seat Belt Reminder..................... 233
Security Alarm (Theft Alarm).............. 233
Service...........................481,482
Service Engine Soon (Malfunction Indicator) . . . 232
Side Marker.......................... 484
Theft Alarm (Security Alarm).............. 233
Turn Signal.....................166,483,484
Voltage............................. 234
Warning (Instrument Cluster Description)..... 226Load Leveling System.................... 218
Loading Vehicle...................214,388,391
Capacities........................... 391
Tires ............................... 353
Locks
Door................................ 31
Lower Anchors and Tether for CHildren (LATCH)... 86
Lubrication, Body....................... 454
Luggage Rack (Roof Rack)................. 215
Lumbar Support........................ 137
Maintenance Free Battery.................. 448
Maintenance Procedures................... 441
Maintenance Schedule.................... 490
Maintenance, Sunroof..................... 195
Malfunction Indicator Light (Check Engine) . . 232,438
Manual, Service......................... 504
Map/Reading Lights..................... 183
Memory Feature (Memory Seat)............. 155
518 INDEX