lights DODGE CARAVAN 2011 Service Manual

Cleaning Headlights
Your vehicle has plastic headlights that are lightweight
and less susceptible to stone breakage than glass head-
lights.
Plastic is not as scratch resistant as glass and therefore
different lens cleaning procedures must be followed.
To minimize the possibility of scratching the lenses and
reducing light output, avoid wiping with a dry cloth. To
remove road dirt, wash with a mild soap solution fol-
lowed by rinsing.
Do not use abrasive cleaning components, solvents, steel
wool or other aggressive material to clean the lenses.
Glass Surfaces
All glass surfaces should be cleaned on a regular basis
with MOPARGlass Cleaner or equivalent or any com-
mercial household-type glass cleaner. Never use an abra-
sive type cleaner. Use caution when cleaning the inside rear window equipped with electric defrosters or the
right rear quarter window equipped with the radio
antenna. Do not use scrapers or other sharp instruments
that may scratch the elements.
When cleaning the rearview mirror, spray cleaner on the
towel or rag that you are using. Do not spray cleaner
directly on the mirror.
Cleaning Plastic Instrument Cluster Lenses
The lenses in front of the instruments in this vehicle are
molded in clear plastic. When cleaning the lenses, care
must be taken to avoid scratching the plastic.
1. Clean with a wet soft rag. A mild soap solution may be
used, but do not use high alcohol content or abrasive
cleaners. If soap is used, wipe clean with a clean damp
rag.
2. Dry with a soft cloth.
498 MAINTAINING YOUR VEHICLE
ProCarManuals.com

•Under no circumstances should oil change intervals
exceed 8,000 miles (13 000 km) or six months, which-
ever comes first.
Your authorized dealer will reset the oil change indicator
message after completing the scheduled oil change. If a
scheduled oil change is performed by someone other
than your authorized dealer, the message can be reset by
referring to the steps described under “Electronic Vehicle
Information Center (EVIC)/Oil Change Required” in
“Understanding Your Instrument Panel” or under “In-
strument Cluster Description/Odometer/Trip Odom-
eter” in “Understanding Your Instrument Panel” for
further information.
At Each Stop For Fuel
•Check the engine oil level about five minutes after a
fully warmed engine is shut OFF. Checking the oil
level while the vehicle is on level ground will improve the accuracy of the oil level reading. Add oil only
when the level is at or below the ADD, SAFE or MIN
mark.
•Check the windshield washer solvent and add if
required.
Once A Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of the coolant reservoir, the
brake master cylinder, the power steering and the
transmission and add as needed.
•Check all lights and other electrical items for correct
operation.
8
M A I
N T
E
N A
N CE
S
C
H E
D
U L
E
SMAINTENANCE SCHEDULES 517
ProCarManuals.com

Adding Engine Coolant (Antifreeze).......... 486
Adding Fuel ........................... 416
Adding Washer Fluid ..................... 483
Additives, Fuel ......................... 410
Adjustable Pedals ....................... 177
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 475
Air Conditioner Maintenance ............... 479
Air Conditioning ........................ 321
Air Conditioning Controls ................. 321
Air Conditioning Filter .................345,480
Air Conditioning Refrigerant ............... 479
Air Conditioning System .............321,333,479
Air Conditioning System, Zone Control ........ 325
Air Conditioning, Operating Tips ............ 344
Air Conditioning, Rear Zone .............330,340
Air Pressure, Tires ....................... 387
Airbag .............................. 72,81
Airbag Deployment ....................... 83
Airbag Light .................... 79,85,102,257Airbag Maintenance
....................... 84
Airbag, Side ........................ 76,78,81
Airbag, Window (Side Curtain) ...........77,78,81
Alarm (Security Alarm) .................... 17
Alarm Light ........................... 257
Alterations/Modifications, Vehicle ............. 7
Antenna, Satellite Radio ................... 307
Anti-Lock Warning Light .................. 252
Anti-Theft System ........................ 17
Antifreeze (Engine Coolant) ..............485,511
Disposal ........................... 488
Appearance Care ........................ 494
Ashtray ............................... 217
Auto Down Power Windows ................ 40
Auto Up Power Windows .................. 40
Automatic Dimming Mirror ................ 114
Automatic Door Locks ..................... 35
Automatic Headlights .................... 165
Automatic Temperature Control (ATC) ......... 333
540 INDEX
ProCarManuals.com

Universal Consumer Interface (UCI)....... 310
Conserving Fuel ........................ 274
Console .............................. 224
Console, Floor .......................... 224
Console, Overhead ....................... 193
Console, Removable ...................... 229
Contract, Service ........................ 533
Coolant Pressure Cap (Radiator Cap) .......... 487
Cooling System ......................... 484
Adding Coolant (Antifreeze) ............. 486
Coolant Capacity ..................... 511
Coolant Level .................... 484,488
Disposal of Used Coolant ............... 488
Drain, Flush, and Refill ................ 485
Inspection .......................... 488
Points to Remember .................. 488
Pressure Cap ........................ 487
Radiator Cap ....................... 487
Selection of Coolant (Antifreeze) ....485,511,512 Cupholders
......................... 213,499
Customer Assistance ..................... 531
Data Recorder, Event ...................... 86
Daytime Running Lights ................... 167
Dealer Service .......................... 471
Defroster, Rear Window ................... 233
Defroster, Windshield .................. 103,338
Diagnostic System, Onboard ................ 468
Dimmer Control ........................ 167
Dipsticks Automatic Transaxle .................. 493
Oil (Engine) ........................ 472
Power Steering ...................... 366
Disabled Vehicle Towing ................... 462
Disposal Antifreeze (Engine Coolant) ............. 488
Engine Oil ......................... 474
Door Locks ............................. 32
10
INDEX 543
ProCarManuals.com

Oil Change Interval................... 473
Oil Disposal ........................ 474
Oil Filler Cap ....................... 474
Oil Filter Disposal .................... 474
Oil Selection ..................... 473,511
Oil Synthetic ........................ 474
Overheating ........................ 438
Starting ........................... 351
Temperature Gauge ................... 259
Enhanced Accident Response Feature .......... 82
Entry System, Illuminated .................. 19
Ethanol ............................... 409
Event Data Recorder ...................... 86
Exhaust Gas Caution ................53,101,412
Exhaust System ...................... 101,476
Express Down Windows ................... 22
Extender, Seat Belt ........................ 72
Exterior Folding Mirrors ................... 115
Exterior Lights .......................... 104 Fabric Care
............................ 497
Filler Location Fuel ...................... 256
Filters Air Cleaner ......................... 475
Air Conditioning .................. 345,480
Engine Oil ....................... 475,512
Engine Oil Disposal ................... 474
Flash-To-Pass ........................... 170
Flashers Hazard Warning ..................... 438
Turn Signal ................ 104,249,508,509
Flat Tire Stowage ........................ 453
Flexible Fuel Vehicles Cruising Range ...................... 415
Engine Oil ......................... 415
Fuel Requirements ................. 412,414
Maintenance ........................ 416
Replacement Parts .................... 416
Starting ........................... 415
10
INDEX 545
ProCarManuals.com

Flooded Engine Starting................... 352
Floor Console .......................... 224
Fluid Capacities ......................... 511
Fluid Leaks ............................ 105
Fluid Level Checks Automatic Transaxle .................. 493
Brake ............................. 490
Power Steering ...................... 366
Fluids ................................ 512
Fluids, Lubricants and Genuine Parts .......... 512
Fog Light Service ........................ 508
Fog Lights ....................... 167,249,508
Fold in Floor (Stow \bn Go) Seating........... 139
Freeing A Stuck Vehicle ................... 460
Fuel ................................. 408
Adding ........................... 416
Additives .......................... 410
Clean Air .......................... 408
Conserving ......................... 274 Economy Mode
...................... 356
Ethanol ........................... 409
Filler Cap (Gas Cap) ...............256,416
Filler Door (Gas Cap) .................. 256
Gasoline ........................... 408
Gauge ............................ 256
Light .......................... 260,270
Materials Added ..................... 410
Methanol .......................... 409
Octane Rating ....................... 512
Requirements .................... 408,511
Saver Mode ........................ 274
Tank Capacity ....................... 511
Fuel Optimizer ......................... 274
Fuel Saver ............................. 274
Fuel, Flexible ........................... 412
Fueling ............................... 416
Fuses ................................ 499
546 INDEX
ProCarManuals.com

Garage Door Opener (HomeLink®)........... 197
Gas Cap (Fuel Filler Cap) ............416,418,468
Gasoline (Fuel) ......................... 408
Conserving ......................... 274
Gasoline, Clean Air ...................... 408
Gasoline, Reformulated ................... 408
Gauges Coolant Temperature .................. 259
Fuel .............................. 256
Speedometer ........................ 256
Tachometer ......................... 249
Gear Select Lever Override ................. 461
Gearshift .............................. 358
General Information .................. 17,28,407
Glass Cleaning .......................... 498
Gross Axle Weight Rating ...............419,422
Gross Vehicle Weight Rating .............419,422
Hands-Free Phone (Uconnect™) ............. 127Hazard
Driving Through Flowing, Rising, or Shallow
Standing Water ...................... 363
Hazard Warning Flasher ................... 438
Head Restraints ......................... 135
Headlights Bulb Replacement .................... 507
Cleaning ........................... 498
Lights On Reminder .................. 166
Passing ............................ 170
Replacing .......................... 507
Time Delay ......................... 166
Washers ........................... 166
Heated Mirrors ......................... 116
Heated Seats ........................... 130
Heater ............................... 321
Heater, Engine Block ..................... 353
High Beam/Low Beam Select (Dimmer) Switch . . 170
10
INDEX 547
ProCarManuals.com

HitchesTrailer Towing ....................... 426
HomeLink® (Garage Door Opener) Transmitter . . 197
Hood Release .......................... 163
Hook, Coat ............................ 223
Ignition ............................... 13
Key ............................. 12,13
Ignition Key Removal ..................... 13
Illuminated Entry ........................ 19
Immobilizer (Sentry Key) ................... 15
Infant Restraint ........................ 87,88
Information Center, Vehicle ................. 265
Inside Rearview Mirror .................... 113
Instrument Cluster .................... 247,249
Instrument Panel and Controls .............. 246
Instrument Panel Cover ................... 497
Instrument Panel Lens Cleaning ............. 498
Integrated Power Module (Fuses) ............ 499Interior Appearance Care
.................. 497
Interior Lights .......................... 167
Introduction ............................. 4
Jack Location ........................... 440
Jack Operation .......................... 439
Jump Starting .......................... 456
Key-In Reminder ......................... 15
Key, Programming ........................ 17
Key, Replacement ........................ 16
Key, Sentry (Immobilizer) ................... 15
Keyless Entry System ...................... 20
Keys ................................. 12
Lane Change Assist ...................... 170
Lap/Shoulder Belts ....................... 57
LATCH (Lower Anchors and Tether for CHildren).. 91
Latches ............................... 104
548 INDEX
ProCarManuals.com

Hood............................. 163
Lead Free Gasoline ...................... 408
Leaks, Fluid ........................... 105
Life of Tires ............................ 393
Liftgate ................................ 49
Light Bulbs ............................ 104
Lights ............................. 104,165
Airbag ..................... 79,85,102,257
Alarm ............................ 257
Anti-Lock .......................... 252
Automatic Headlights ................. 165
Back-Up ........................... 509
Battery Saver ....................... 171
Brake Assist Warning .................. 375
Brake Warning ...................... 257
Bulb Replacement .................... 507
Center Mounted Stop .................. 510
Daytime Running .................... 167
Dimmer Switch, Headlight .............. 167 Electronic Stability Program (ESP) Indicator . . 375
Engine Temperature Warning
............ 261
Exterior ........................... 104
Fog ......................... 167,249,508
Hazard Warning Flasher ............... 438
Headlights ......................... 507
Headlights On Reminder ............... 166
High Beam Indicator .................. 249
High Beam/Low Beam Select ............ 170
Illuminated Entry ..................... 19
Interior ............................ 167
License ............................ 510
Lights On Reminder .................. 166
Low Fuel ....................... 260,270
Malfunction Indicator (Check Engine) ...... 254
Oil Pressure ........................ 261
Park .............................. 508
Passing ............................ 170
Reading ........................... 194
10
INDEX 549
ProCarManuals.com

Rear Servicing....................... 509
Rear Tail ........................... 509
Seat Belt Reminder ................... 259
Security Alarm (Theft Alarm) ............ 257
Service ............................ 507
Service Engine Soon (Malfunction Indicator). . 254
Side Marker ........................ 509
Theft Alarm (Security Alarm) ............ 257
Tire Pressure Monitoring (TPMS) ......... 253
Traction Control ..................... 375
Turn Signal ................... 104,508,509
Voltage ............................ 260
Warning (Instrument Cluster Description) . . . 249
Load Leveling System .................... 234
Loading Vehicle ................... 224,418,421
Capacities .......................... 421
Tires .............................. 382
Locks Automatic Door ...................... 35 Door
.............................. 32
Lower Anchors and Tether for CHildren (LATCH).. 91
Lubrication, Body ....................... 482
Luggage Rack (Roof Rack) ................. 234
Maintenance Free Battery .................. 478
Maintenance Procedures ................... 471
Maintenance Schedule .................... 516
Maintenance, Sunroof ..................... 206
Malfunction Indicator Light (Check Engine) . . 254,469
Manual, Service ......................... 535
Map/Reading Lights ..................... 194
Memory Feature (Memory Seat) ............. 159
Memory Seat ........................ 1 16,159
Methanol ............................. 409
Mini-Trip Computer ................... 262,276
Mirrors ............................... 113
Automatic Dimming .................. 114
Electric Remote ...................... 115
550 INDEX
ProCarManuals.com