ESP DODGE CHARGER 2006 6.G Service Manual

SCHEDULE“A”
Miles 6,000 12,000 18,000 24,000 30,000 36,000
(Kilometers) (10 000) (20 000) (30 000) (40 000) (50 000) (60 000)
[Months] [6] [12] [18] [24] [30] [36]
Change engine oil and engine oil filter. XXXXXX
Inspect theair cleaner filterand replace if re-
quired.*X XXX X
Replace theair cleaner filter.X
Replace thespark plugs.5.7L Engine. X
Inspect the front and rear brake linings and
rotors.XX
Replace the air conditioning filter. X X X
Rotate the tires. XXXXXX
SCHEDULE“A”339
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 42,000 48,000 54,000 60,000 66,000 72,000
(Kilometers) (70 000) (80 000) (90 000) (100 000) (110 000) (120 000)
[Months] [42] [48] [54] [60] [66] [72]
Change engine oil and engine oil filter. X X X X X X
Inspect theair cleaner filterand replace if
required.*XXX XX
Replace theair cleaner filter.X
Inspect the front and rear brake linings and
rotors.XX
Replace thespark plugs.5.7L Engine. X
Check and Inspect the accessory drive belt
and tensioner. Replace if required.X
Flush and replace engine coolant at 60 months
if not done at 102,000 miles.X
Check and replace, if necessary, thePCV
valve.*X
Replace the air conditioning filter. X X X
Rotate the tires. X X X X X X
340 SCHEDULE“A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 78,000 84,000 90,000 96,000 102,000
(Kilometers) (130 000) (140 000) (150 000) (160 000) (170 000)
[Months] [78] [84] [90] [96] [102]
Change engine oil and engine oil filter. X X X X X
Inspect theair cleaner filterand replace if re-
quired.*XX XX
Replace theair cleaner filter.X
Inspect the front and rear brake linings and rotors. X
Check and Inspect the accessory drive belt and ten-
sioner. Replace if required.X
Replace thespark plugs.2.7L, 3.5L Engines. X
Replace thespark plugs.5.7L Engine. X
Check and replace, if necessary, thePCV valve.*‡X
Replace theengine timing belt.3.5L Engine. X
Flush and replace the engine coolant at 102,000
miles if not done at 60 months.X
Replace the air conditioning filter. X X
Rotate the tires. X X X X X
SCHEDULE“A”341
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 108,000 114,000 120,000
(Kilometers) (180 000) (190 000) (200 000)
[Months] [108] [114] [120]
Change engine oil and engine oil filter. X X X
Inspect theair cleaner filterand replace if required.* X X
Replace theair cleaner filter.X
Inspect the front and rear brake linings and rotors. X
Replace thespark plugs.5.7L Engine. X
Check and replace, if necessary, thePCV valve.*X
Replace the air conditioning filter. X X
Flush and replace the engine coolant at 120 months, if not re-
placed at 102,000 miles.X
Rotate the tires. X X X
* This maintenance is recommended by the manufacturer
to the owner but is not required to maintain the emis-
sions warranty.
‡This maintenance is not required if previously replaced.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
WARNING!
You can be badly injured working on or around a
motor vehicle. Do only that service work for which
you have the knowledge and the right equipment. If
you have any doubt about your ability to perform a
service job, take your vehicle to a competent mechanic.
342 SCHEDULE“A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Service Contract
You may have purchased a service contract for your
vehicle to help protect you from the high cost of unex-
pected repairs after your manufacturer’s new vehicle
limited warranty expires. The manufacturer stands be-
hind only the manufacturer’s Service Contracts. If you
purchased a manufacturer’s Service Contract, you will
receive Plan Provisions and an Owner Identification Card
in the mail within three weeks of your vehicle delivery
date. If you have any questions about your service
contract, call the manufacturer’s Service Contract Na-
tional Customer Hotline at 1-800-521-9922.
The manufacturer will not stand behind any service
contract that is not the manufacturer’s Service Contract. It
is not responsible for any service contract other than the
manufacturer’s Service Contract. If you purchased a
service contract that is not a manufacturer’s Service
Contract, and you require service after your manufactur-
er’s new vehicle limited warranty expires, please refer to
your contract documents, and contact the person listed in
those documents.We appreciate that you have made a major investment
when you purchased your new vehicle. Your dealer has
also made a major investment in facilities, tools, and
training to assure that you are absolutely delighted with
your ownership experience. You’ll be pleased with their
sincere efforts to resolve any warranty issues or related
concerns.
WARRANTY INFORMATION (U.S. Vehicles Only)
See the Warranty Information Booklet for the terms and
provisions of DaimlerChrysler’s warranties applicable to
this vehicle.
MOPAR PARTS
Moparfluids, lubricants, parts, and accessories are
available from your dealer. They will help you keep your
vehicle operating at its best.
346 IF YOU NEED CONSUMER ASSISTANCE

grade C corresponds to a level of performance which all
passenger car tires must meet under the Federal Motor
Vehicle Safety Standard No. 109. Grades B and A repre-
sent higher levels of performance on the laboratory test
wheel than the minimum required by law.
WARNING!
The temperature grade for this tire is established for
a tire that is properly inflated and not overloaded.
Excessive speed, underinflation, or excessive load-
ing, either separately or in combination, can cause
heat buildup and possible tire failure.
350 IF YOU NEED CONSUMER ASSISTANCE

Compass Variance...................... 147
Computer, Trip/Travel................... 144
Console.............................. 127
Console, Floor......................... 127
Console, Overhead...................... 114
Contract, Service....................... 346
Coolant Pressure Cap.................... 301
Cooling System........................ 298
Adding Coolant (Antifreeze)............. 300
Coolant Capacity..................... 323
Coolant Level.....................299,301
Disposal of Used Coolant............... 301
Drain, Flush, and Refill................. 299
Inspection........................... 301
Points to Remember................... 302
Pressure Cap........................ 301
Radiator Cap........................ 301
Selection of Coolant (Antifreeze)....299,323,324
Cruise Control (Speed Control)............. 111
Cup Holder........................125,310
Customer Assistance.................... 344
Data Recorder, Event..................... 50Dealer Service......................... 284
Defroster, Rear Window.................. 182
Defroster, Windshield...............60,183,188
Delay (Intermittent) Wipers............... 105
Diagnostic System, Onboard............... 282
Dimmer Switch, Headlight................ 103
Disposal
Antifreeze (Engine Coolant)............. 301
Door Locks............................ 16
Door Locks, Automatic................... 17
Door Opener, Garage.................... 115
Drive Belts............................ 290
Driving
On Slippery Surfaces.................. 272
DVD Player (Video Entertainment System).... 176
Electric Remote Mirrors................... 69
Electrical Power Outlets.................. 123
Electronic Speed Control (Cruise Control)..... 111
Electronic Stability Program (ESP).......... 109
Electronic Vehicle Information Center (EVIC) . . 142
Emergency, In Case of
Freeing Vehicle When Stuck............. 273
354 INDEX

Hazard Warning Flasher................ 262
Jacking............................. 263
Jump Starting........................ 270
Overheating......................... 262
Towing............................. 274
Emission Control System Maintenance....283,328
Engine.........................279,280,281
Air Cleaner.......................... 291
Air Cleaner Filter..................... 290
Block Heater......................... 198
Break-In Recommendations............... 59
Checking Oil Level.................285,286
Compartment..................279,280,281
Coolant (Antifreeze)................299,324
Cooling............................ 298
Exhaust Gas Caution................59,244
Fails to Start......................... 197
Fuel Requirements.................241,323
Oil ..........................285,323,324
Oil Change Interval................... 287
Oil Selection......................287,323
Oil Synthetic......................... 289
Overheating......................... 262Temperature Gauge................... 135
Enhanced Accident Response Feature......... 49
Event Data Recorder..................... 50
Exhaust Gas Caution...............59,244,298
Exhaust System........................ 297
Exterior Folding Mirrors.................. 68
Filters
Air Cleaner.......................... 290
Air Conditioning..................190,295
Engine Fuel......................... 291
Engine Oil.......................290,324
Engine Oil Disposal................... 289
Flashers
Hazard Warning...................... 262
Turn Signal.......................... 136
Flash-To-Pass.......................... 103
Flat Tire Changing...................... 263
Floor Console.......................... 127
Fluid Capacities........................ 323
Fluid Leaks............................ 61
Fluid Level Checks
Brake.............................. 304
INDEX 355
10