engine overheat DODGE CHARGER SRT 2018 User Guide
[x] Cancel search | Manufacturer: DODGE, Model Year: 2018, Model line: CHARGER SRT, Model: DODGE CHARGER SRT 2018Pages: 490, PDF Size: 5.08 MB
Page 318 of 490

CAUTION!
•Racing the engine or spinning the wheels may lead
to transmission overheating and failure. Allow the
engine to idle with the transmission in NEUTRAL
for at least one minute after every five rocking-
motion cycles. This will minimize overheating and
reduce the risk of transmission failure during pro-
longed efforts to free a stuck vehicle.
• When “rocking” a stuck vehicle by shifting between
DRIVE and REVERSE, do not spin the wheels faster
than 15 mph (24 km/h), or drivetrain damage may
result.
• Revving the engine or spinning the wheels too fast
may lead to transmission overheating and failure. It
can also damage the tires. Do not spin the wheels
above 30 mph (48 km/h) while in gear (no transmis-
sion shifting occurring).
316 IN CASE OF EMERGENCY
Page 339 of 490

Exhaust System
The best protection against carbon monoxide entry into the
vehicle body is a properly maintained engine exhaust
system.
If you notice a change in the sound of the exhaust system;
or if the exhaust fumes can be detected inside the vehicle;
or when the underside or rear of the vehicle is damaged;
have an authorized technician inspect the complete ex-
haust system and adjacent body areas for broken, dam-
aged, deteriorated, or mispositioned parts. Open seams or
loose connections could permit exhaust fumes to seep into
the passenger compartment. In addition, have the exhaust
system inspected each time the vehicle is raised for lubri-
cation or oil change. Replace as required.
WARNING!
•Exhaust gases can injure or kill. They contain carbon
monoxide (CO), which is colorless and odorless.
Breathing it can make you unconscious and can
eventually poison you. To avoid breathing CO, refer
to “Safety Tips” in “Safety” for further information.
(Continued)
WARNING! (Continued)
•A hot exhaust system can start a fire if you park over
materials that can burn. Such materials might be
grass or leaves coming into contact with your exhaust
system. Do not park or operate your vehicle in areas
where your exhaust system can contact anything that
can burn.
CAUTION!
•The catalytic converter requires the use of unleaded
fuel only. Leaded gasoline will destroy the effective-
ness of the catalyst as an emissions control device
and may seriously reduce engine performance and
cause serious damage to the engine.
• Damage to the catalytic converter can result if your
vehicle is not kept in proper operating condition. In
the event of engine malfunction, particularly involv-
ing engine misfire or other apparent loss of perfor-
mance, have your vehicle serviced promptly. Contin-
ued operation of your vehicle with a severe
malfunction could cause the converter to overheat,
resulting in possible damage to the converter and
vehicle.
8
SERVICING AND MAINTENANCE 337
Page 340 of 490

Under normal operating conditions, the catalytic converter
will not require maintenance. However, it is important to
keep the engine properly tuned to assure proper catalyst
operation and prevent possible catalyst damage.
NOTE:Intentional tampering with emissions control sys-
tems can result in civil penalties being assessed against
you.
In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe and
abnormal catalyst overheating. If this occurs, stop the
vehicle, turn off the engine and allow it to cool. Service,
including a tune-up to manufacturer’s specifications,
should be obtained immediately.
To minimize the possibility of catalytic converter damage:
• Do not shut off the engine or interrupt the ignition when
the transmission is in gear and the vehicle is in motion.
• Do not try to start the engine by pushing or towing the
vehicle.
• Do not idle the engine with any spark plug wires
disconnected or removed, such as when diagnostic
testing, or for prolonged periods during very rough idle
or malfunctioning operating conditions. NOTE:
Your vehicle’s exhaust system may be equipped
with an Electronic Exhaust Valve (EEV) system, if the
exhaust system is replaced with aftermarket products a
Malfunction Indicator Lamp (MIL) will illuminate.
Cooling System
WARNING!
• You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the hood,
do not open the hood until the radiator has had time
to cool. Never open a cooling system pressure cap
when the radiator or coolant bottle is hot.
• Keep hands, tools, clothing, and jewelry away from
the radiator cooling fan when the hood is raised. The
fan starts automatically and may start at any time,
whether the engine is running or not.
• When working near the radiator cooling fan, discon-
nect the fan motor lead or turn the ignition to the
OFF mode. The fan is temperature controlled and can
start at any time the ignition is in the ON mode.
338 SERVICING AND MAINTENANCE
Page 343 of 490

•Mix a minimum solution of 50% OAT engine coolant
that meets the requirements of FCA Material Standard
MS.90032 and distilled water. Use higher concentrations
(not to exceed 70%) if temperatures below 34°F ( 37°C)
are anticipated. Please contact an authorized dealer for
assistance.
• Use only high purity water such as distilled or deionized
water when mixing the water/engine coolant (anti-
freeze) solution. The use of lower quality water will
reduce the amount of corrosion protection in the engine
cooling system.
NOTE:
• It is the owner’s responsibility to maintain the proper
level of protection against freezing according to the
temperatures occurring in the area where the vehicle is
operated.
• Some vehicles require special tools to add coolant prop-
erly. Failure to fill these systems properly could lead to
severe internal engine damage. If any coolant is needed
to be added to the system, please contact a local autho-
rized dealer.
• Mixing engine coolant (antifreeze) types is not recom-
mended and can result in cooling system damage. If HOAT and OAT coolant are mixed in an emergency,
have a authorized dealer drain, flush, and refill with
OAT coolant (conforming to MS.90032) as soon as pos-
sible.
Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of engine
coolant (antifreeze), and to ensure that engine coolant
(antifreeze) will return to the radiator from the coolant
expansion bottle/recovery tank if so equipped.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
NOTE:
Be sure you do not mix the engine coolant system
pressure cap with the intercooler system pressure cap.
These caps are not interchangeable.
WARNING!
• Do not open hot engine cooling system. Never add
engine coolant (antifreeze) when the engine is over-
heated. Do not loosen or remove the cap to cool an
overheated engine. Heat causes pressure to build up
in the cooling system. To prevent scalding or injury,
(Continued)
8
SERVICING AND MAINTENANCE 341
Page 384 of 490

MMT In Gasoline
Methylcyclopentadienyl Manganese Tricarbonyl (MMT) is
a manganese-containing metallic additive that is blended
into some gasoline to increase octane. Gasoline blended
with MMT provides no performance advantage beyond
gasoline of the same octane number without MMT. Gaso-
line blended with MMT reduces spark plug life and
reduces emissions system performance in some vehicles.
The manufacturer recommends that gasoline without
MMT be used in your vehicle. The MMT content of
gasoline may not be indicated on the gasoline pump;
therefore, you should ask your gasoline retailer whether
the gasoline contains MMT. MMT is prohibited in Federal
and California reformulated gasoline.
Fuel System Cautions
CAUTION!
Follow these guidelines to maintain your vehicle’s
performance:
•The use of leaded gasoline is prohibited by Federal
law. Using leaded gasoline can impair engine perfor-
mance and damage the emissions control system.
(Continued)
CAUTION! (Continued)
•An out-of-tune engine or certain fuel or ignition
malfunctions can cause the catalytic converter to
overheat. If you notice a pungent burning odor or
some light smoke, your engine may be out of tune or
malfunctioning and may require immediate service.
Contact an authorized dealer for service assistance.
• The use of fuel additives, which are now being sold
as octane enhancers, is not recommended. Most of
these products contain high concentrations of metha-
nol. Fuel system damage or vehicle performance
problems resulting from the use of such fuels or
additives is not the responsibility of the manufac-
turer and may void or not be covered under the New
Vehicle Limited Warranty.
NOTE: Intentional tampering with the emissions control
system can result in civil penalties being assessed against
you.
382 TECHNICAL SPECIFICATIONS
Page 477 of 490

Corrosion Protection........................370
Cruise Control (Speed Control) ..............235, 238
Cruise Light .......................... .129, 130
Cupholders ...............................99
Customer Assistance ........................466
Cybersecurity ............................ .392
Daytime Running Lights ......................61
Dealer Service ............................ .329
Deck Lid Power Release ...........................87
Defroster, Windshield ........................205
Delay (Intermittent) Wipers ....................69
Diagnostic System, Onboard ...................131
Dimmer Switch Headlight ...............................61
Dipsticks Oil (Engine) ............................327
Power Steering ..........................234
Disposal Antifreeze (Engine Coolant) .................342
Disturb ................................. .460
Door Ajar ............................... .121
Door Ajar Light ............................121 Door Locks
Automatic ..............................41
Child-Protection Door Lock — Rear Doors .......41
Doors ....................................35
Drag And Drop Menu .......................391
Drive Modes ............................. .229
Driver ’s Seat Back Tilt ........................42
Driving Through Flowing, Rising, Or Shallow Standing
Water .................................276
Electric Brake Control System ..................137
Anti-Lock Brake System ....................136
Electronic Roll Mitigation ...............138, 145
Electric Remote Mirrors .......................58
Electronic Power Distribution Center (Fuses) .......290
Electronic Speed Control (Cruise Control) .........236
Electronic Stability Control (ESC) ...............139
Electronic Throttle Control Warning Light .........122
Emergency, In Case Of Freeing Vehicle When Stuck .................315
Hazar d
Warning Flasher ...................280
Jacking ............................... .346
Jump Starting ........................309, 310
Overheating ............................312
12
INDEX 475
Page 478 of 490

Emission Control System Maintenance............132
Engine ...............................325, 326
Air Cleaner ............................ .331
Block Heater ............................215
Break-In Recommendations .................216
Checking Oil Level .......................327
Compartment .......................... .326
Compartment Identification .................325
Coolant (Antifreeze) ...................339, 385
Cooling ...............................338
Exhaust Gas Caution ...................203, 383
Fails To Start ............................215
Flooded, Starting ........................ .215
Fuel Requirements ....................379, 384
Jump Starting ........................309, 310
Oil ............................329, 384, 385
Oil Filler Cap ........................325, 330
Oil Filter ...............................331
Oil Selection ............................384
Overheating ............................312
Starting ............................212, 213
Engine Oil Viscosity ........................ .330
Enhanced Accident Response Feature .........184, 318
Ethanol ................................. .381
Exhaust Gas Cautions ....................203, 383 Exhaust System
........................203, 337
Exterior Lighting ............................60
Exterior Lights ..........................60, 206
Filters Air Cleaner ............................ .331
Air Conditioning ..................... .79, 333
Engine Oil ..........................331, 385
Engine Oil Disposal .......................331
Flashers .................................280
Hazard Warning ........................ .280
Turn Signals ..................... .64,129,
206
Flash-To-Pass ..............................62
Flooded Engine Starting ..................... .215
Floor Console ..............................97
Fluid, Brake .......................... .385, 387
Fluid Capacities ............................384
Fluid Leaks ...............................207
Fluid Level Checks Brake .................................343
Cooling System ..........................339
Engine Oil ............................ .327
Power Steering ..........................234
Fluids And Lubricants .......................385
Fog Lights ................................64
476 INDEX
Page 482 of 490

Memory Feature (Memory Seats)..............42, 44
Memory Seat ............................42, 44
Memory Seats And Radio ...................42, 44
Methanol ............................... .381
Mirrors ..................................56
Electric Powered ..........................58
Electric Remote ...........................58
Heated .................................59
Outside ................................57
Rearview ............................56, 280
Vanity .................................59
Modifications/Alterations, Vehicle ................5
Monitor, Tire Pressure System ..................156
Mopar Parts ............................. .469
MP3 Control ............................. .447
Multi-Function Control Lever ...................61
Occupant Restraints ........................ .162
Octane Rating, Gasoline (Fuel) ..............379, 385
Oil Change Indicator ........................111
Reset .................................111
Oil, Engine ............................329, 385
Capacity ...............................384
Change Interval ........................ .329
Checking ............................. .327Dipstick
...............................327
Disposal ...............................331
Filter ............................. .331, 385
Filter Disposal .......................... .331
Materials Added To .......................330
Pressure Warning Light ....................122
Recommendation ........................ .384
Viscosity .......................... .330, 384
Oil Filter, Change ..........................331
Oil Filter, Selection ..........................331
Oil Pressure Light ..........................122
Onboard Diagnostic System ...................131
Operating Precautions .......................131
Operator Manual (Owner’s Manual) ...............5
Outside
Rearview Mirrors .....................57
Overheating, Engine ........................312
Owner’s Manual (Operator Manual) ...........5,470
Paddle Shifters ............................226
Paddle Shift Mode ..........................226
Paint Care ............................... .370
Panic Alarm ...............................20
Parking Brake ............................ .217
ParkSense System, Rear ..................... .259
Passing Light ..............................62
480 INDEX