tires DODGE DART 2016 PF / 1.G Service Manual

NOTE:For 1.4L Turbo automatic (DDCT) transmission:
Shifts between DRIVE and REVERSE can only be
achieved at wheel speeds of approximately 6 mph
(10 km/h) or less.
CAUTION!
Racing the engine or spinning the wheels may lead to
transmission overheating and failure. Allow the en-
gine to idle with the transmission in NEUTRAL for at
least one minute after every five rocking-motion
cycles. This will minimize overheating and reduce
the risk of clutch or transmission failure during
prolonged efforts to free a stuck vehicle. NOTE:
Push the ESC Off switch, to place the Electronic
Stability Control (ESC) system in “partial off” mode,
before rocking the vehicle. Refer to “Electronic Brake
Control” in “Starting And Operating” for further infor-
mation. Once the vehicle has been freed, push the ESC
Off switch again to restore ESC Onmode.CAUTION!
•When “rocking” a stuck vehicle by shifting be-
tween DRIVE/2nd gear and REVERSE, do not spin
the wheels faster than 15 mph (24 km/h), or drive-
train damage may result.
• Revving the engine or spinning the wheels too fast
may lead to transmission overheating and failure.
It can also damage the tires. Do not spin the wheels
above 30 mph (48 km/h) while in gear (no trans-
mission shifting occurring).
560 WHAT TO DO IN EMERGENCIES

WARNING!
Fast spinning tires can be dangerous. Forces gener-
ated by excessive wheel speeds may cause damage, or
even failure, of the axle and tires. A tire could
explode and injure someone. Do not spin your vehi-
cle’s wheels faster than 30 mph (48 km/h) or for
longer than 30 seconds continuously without stop-
ping when you are stuck and do not let anyone near
a spinning wheel, no matter what the speed.
SHIFT LEVER OVERRIDE
If a malfunction occurs and the shift lever cannot be
moved out of the PARK position, you can use the
following procedure to temporarily move the shift lever:
1. Turn the engine OFF.
2. Firmly apply the parking brake.3. Remove the rubber storage tray liner from the center
console, then lift up the front of the shift lever bezel,
carefully disengage the bezel from the shift lever
housing, and slide it up to the top of the shift lever.
4. Press and maintain firm pressure on the brake pedal.
Shift Lever Bezel
6
WHAT TO DO IN EMERGENCIES 561

MAINTAINING YOUR VEHICLE
CONTENTS
ENGINE COMPARTMENT — 1.4L TURBO . . . .571
 ENGINE COMPARTMENT — 2.0L ..........572
 ENGINE COMPARTMENT — 2.4L ..........573
 ONBOARD DIAGNOSTIC SYSTEM — OBD II . .574
▫ Loose Fuel Filler Cap Message ............574
 EMISSIONS INSPECTION AND MAINTENANCE
PROGRAMS ......................... .575
 REPLACEMENT PARTS ..................576
 DEALER SERVICE ..................... .577
 MAINTENANCE PROCEDURES ...........577▫
Engine Oil ......................... .578
▫ Engine Oil Filter ..................... .581
▫ Engine Air Cleaner Filter ................582
▫ Tires ............................. .583
▫ Maintenance-Free Battery ...............583
▫ Air Conditioner Maintenance .............584
▫ A/C Air Filter ...................... .585
▫ Body Lubrication .....................587
▫ Windshield Wiper Blades ...............588
▫ Adding Washer Fluid ..................588
7

Tires
Checking For Tire Wear
Once a month, check the tire inflation pressures and look
for unusual wear or damage. Rotate at the first sign of
irregular wear, even if it occurs before the oil indicator
system turns on.
Maintenance-Free Battery
Your vehicle is equipped with a maintenance-free battery.
You will never have to add water, nor is periodic main-
tenance required.
WARNING!
•Battery fluid is a corrosive acid solution and can
burn or even blind you. Do not allow battery fluid
to contact your eyes, skin, or clothing. Do not lean
over a battery when attaching clamps. If acid
(Continued)
WARNING! (Continued)
splashes in eyes or on skin, flush the area imme-
diately with large amounts of water. Refer to
“Jump-Starting Procedures” in “What To Do In
Emergencies” for further information.
• Battery gas is flammable and explosive. Keep
flame or sparks away from the battery. Do not use
a booster battery or any other booster source with
an output greater than 12 Volts. Do not allow cable
clamps to touch each other.
• Battery posts, terminals, and related accessories
contain lead and lead compounds. Wash hands
after handling.
• The battery in this vehicle has a vent hose that
should not be disconnected and should only be
replaced with a battery of the same type (vented).
7
MAINTAINING YOUR VEHICLE 583

Once A Month Or Before A Long Trip:
•Check engine oil level.
• Check windshield washer fluid level.
• Check the tire inflation pressures and look for unusual
wear or damage.
• Check the fluid levels of the coolant reservoir, and
brake master cylinder as needed.
• Check function of all interior and exterior lights.
Required Maintenance
Refer to the Maintenance Schedules on the following
pages for required maintenance.
At Every Oil Change Interval As Indicated By Oil
Change Indicator System:
•Change engine oil and filter.
• Rotate the tires. Rotate at the first sign of irregu-
lar wear, even if it occurs before the oil indicator
system turns on.
• Inspect battery and clean and tighten terminals as
required.
• Inspect brake pads, shoes, rotors, drums, hoses
and park brake.
• Inspect engine cooling system protection and
hoses.
• Inspect exhaust system.
• Inspect engine air cleaner if using in dusty or
off-road conditions. 8
MAINTENANCE SCHEDULES 629

Call toll free at:
•1-800-890-4038 (U.S.)
• 1-800-387-1143 (Canada)
Or
Visit us on the Worldwide Web at:
• www.techauthority.com
DEPARTMENT OF TRANSPORTATION UNIFORM
TIRE QUALITY GRADES
The following tire grading categories were established by
the National Highway Traffic Safety Administration. The
specific grade rating assigned by the tire’s manufacturer
in each category is shown on the sidewall of the tires on
your vehicle.
All passenger vehicle tires must conform to Federal
safety requirements in addition to these grades.
Treadwear
The Treadwear grade is a comparative rating, based on
the wear rate of the tire when tested under controlled
conditions on a specified government test course. For
example, a tire graded 150 would wear one and one-half
times as well on the government course as a tire graded
100. The relative performance of tires depends upon the
actual conditions of their use, however, and may depart
significantly from the norm due to variations in driving
habits, service practices, and differences in road charac-
teristics and climate.
Traction Grades
The Traction grades, from highest to lowest, are AA, A, B,
and C. These grades represent the tire’s ability to stop on
wet pavement, as measured under controlled conditions on
specified government test surfaces of asphalt and concrete.
A tire marked C may have poor traction performance.9
IF YOU NEED CONSUMER ASSISTANCE 643

WARNING!
The traction grade assigned to this tire is based on
straight-ahead braking traction tests, and does not
include acceleration, cornering, hydroplaning, or
peak traction characteristics.
Temperature Grades
The temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation of heat
and its ability to dissipate heat, when tested under
controlled conditions on a specified indoor laboratory
test wheel. Sustained high temperature can cause the
material of the tire to degenerate and reduce tire life, andexcessive temperature can lead to sudden tire failure. The
grade C corresponds to a level of performance, which all
passenger vehicle tires must meet under the Federal
Motor Vehicle Safety Standard No. 109. Grades B and A
represent higher levels of performance on the laboratory
test wheel, than the minimum required by law.
WARNING!
The temperature grade for this tire is established for
a tire that is properly inflated and not overloaded.
Excessive speed, under-inflation, or excessive load-
ing, either separately or in combination, can cause
heat buildup and possible tire failure.
644 IF YOU NEED CONSUMER ASSISTANCE

About Your Brakes....................... .454
Adding Engine Coolant (Antifreeze) ............593
Adding Fuel ............................ .509
Adding Washer Fluid ..................... .588
Additives, Fuel .......................... .507
Adjust Down .............................. .220
Forward ............................. .220
Rearward ............................ .220
Up ................................ .220
AirBag.............................. .62, 63
Advance Front Air Bag ...............63, 64, 65
Air Bag Operation .......................65
Air Bag Warning Light ..................66, 84
Driver Knee Air Bag ......................76
Enhanced Accident Response ................83
Event Data Recorder (EDR) .................86
FrontAirBag......................62, 63, 66
Front Passenger Knee Air Bag ...............76If A Deployment Occurs
...................82
Knee Impact Bolsters .....................76
Maintaining Your Air Bag System ............85
Transporting Pets ...................... .107
Air Bag Deployment ........................62
Air Bag Light ..................... .84, 110, 307
Air Bag Maintenance .......................85
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . .582
Air Conditioner Maintenance .................584
Air Conditioning ......................... .394
Air Conditioning Controls ...................394
Air Conditioning Filter ..................409, 585
Air Conditioning, Operating Tips ..............408
Air Conditioning Refrigerant ..............584, 585
Air Conditioning System .............394, 406, 584
Air Pressure, Tires ........................ .482
Alarm Arm The System ........................20
Rearming The System .....................20
646 INDEX

Jack Location........................... .544
Jack Operation ....................... .544, 547
Jump Starting ........................... .555
Key Fob Arm The Alarm .........................20
Keyless Entry ...........................37
Lock The Doors ...................... .25, 35
Panic Alarm ........................ .22, 26
Programming Additional Key Fobs ...........26
Programming Additional Transmitters .........26
Remote Keyless Entry (RKE) ................23
Unlatch The Trunk .......................26
Unlock The Doors .......................24
Key-In Reminder ..........................16
Keyless Enter-N-Go .....................37, 416
Enter The Trunk ..................... .26, 37
KeyFob...............................37
Lock The Vehicle’s Doors .............25, 35, 37 Passive Entry
...........................37
Passive Entry Programming .................37
Remote Control .........................37
Unlock From The Driver’s Side ............24, 37
Unlock From The Passenger Side ..........24, 37
Keyless Entry System .......................23
Keyless Go ...............................13
Key, Programming .........................19
Key, Replacement ..........................19
Keys ...................................12
Key, Sentry (Immobilizer) ....................18
Lane Change And Turn Signals ...............239
Lane Change Assist ....................... .240
Lap/Shoulder Belts .........................52
Latches ................................113
Lead Free Gasoline ....................... .504
Leaks, Fluid .............................113
Life Of Tires ............................ .491
10
INDEX 655

Vanity Mirror......................... .124
Warning (Instrument Cluster Description) . . .311, 326
Loading Vehicle ...................... .512, 514
Capacities ........................... .514
Tires ............................... .476
Locks ..................................33
Automatic Door .........................35
Auto Unlock ...........................36
Child Protection .........................36
Door .................................33
Power Door ............................35
Lubrication, Body ........................ .587
Lug Nuts .............................. .532
Maintenance Free Battery ....................583
Maintenance Procedures ....................577
Maintenance Schedule ..................... .628
Malfunction Indicator Light (Check Engine) . . .316, 575
Manual, Service ......................... .642Manual Transmission
...................421, 601
Fluid Level Check ...................... .601
Frequency Of Fluid Change ................601
Lubricant Selection ..................... .601
Shift Speeds .......................... .422
Master Cylinder (Brakes) ....................597
Methanol .............................. .506
Mini-Trip Computer ...................... .334
Mirrors ............................... .121
Automatic Dimming .....................121
Electric Powered ....................... .123
Electric Remote ........................ .123
Exterior Folding ....................... .123
Heated .............................. .124
Outside ............................. .122
Rearview ............................ .121
Vanity .............................. .124
Modifications/Alterations, Vehicle ...............7
Monitor, Tire Pressure System ................495
10
INDEX 657